1. Manuals
  2. Brands
  3. Cobalt Boats Manuals
  4. Boat
  5. 200
  6. Owner's manual

Cobalt Boats 200 Owner's Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

200
COBALT BOATS
Owner's Manual

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 200 and is the answer not in the manual?

Questions and answers

Matt
March 22, 2025

Controls on the toilet?

0

Subscribe to Our Youtube Channel

Related Manuals for Cobalt Boats 200

Summary of Contents for Cobalt Boats 200

  • Page 1 COBALT BOATS Owner’s Manual...
  • Page 2 We Wish You Safe and Happy Boating! Your Cobalt boat was built to meet or exceed all applicable boat building standards at the time of manufacture. Your Cobalt boat was inspected and certified prior to introduction, and periodic inspections of this model are conducted in-plant to ensure continued compliance.

  • Page 3: Table Of Contents

    ABLE OF ONTENTS 200 Owner’s Manual GENERAL INFORMATION WELCOME....................1-1 CERTIFICATE OF LIMITED WARRANTY ..........1-2 INTRODUCTION..................1-4 Intended Use ..................1-4 Craft Design Category................ 1-4 OWNER RESPONSIBILITY/WARRANTY PROCEDURE ....... 1-5 Before Operating ................1-5 Warranty Service Requirements ............1-5 Extended Service Agreement.............
  • Page 4 Fueling ....................3-2 LAUNCHING .................... 3-5 Launching Checklist ................3-5 On the Water..................3-5 Boarding ..................... 3-5 Loading ....................3-5 Shipshape ..................3-5 GETTING UNDERWAY ................3-6 Before Starting Checklist..............3-6 Handling Dock and Mooring Lines ............. 3-7 200 Owner’s Manual...

  • Page 5: Able Of

    MOTOR BOX ASSEMBLY ..............3-38 TOOL KIT - OPTIONAL ................. 3-39 FLAGPOLE WITH FLAG - OPTIONAL ..........3-39 SYSTEMS INTRODUCTION..................4-1 ELECTRICAL WIRING HARNESS ............4-2 FUEL ROUTING ..................4-3 FIRE SUPPRESSION EQUIPMENT............4-4 ELECTRICAL SYSTEM ................4-4 200 Owner’s Manual...
  • Page 6 Salt Water ..................5-8 CANVAS ....................5-9 Cleaning Canvas ................5-9 Special Cleaning Problems ..............5-9 OTHER CANVAS COMPONENTS ............5-10 Clear Vinyl “Isinglass” ..............5-10 Zippers ..................... 5-10 Snap Fasteners ................5-10 WINDSHIELD..................5-10 BILGE..................... 5-10 MARINE GROWTH................5-10 200 Owner’s Manual...
  • Page 7 During Operation ................7-2 Returning to Port ................7-2 Stopping the Engines ................. 7-2 After Boating..................7-2 SERVICE LOG ..................7-3 FUEL LOG ....................7-4 FLOAT PLAN ................... 7-5 BOAT INFORMATION ................7-6 WARRANTY TRANSFER FORM............. 7-7 200 Owner’s Manual...
  • Page 8 COBAL T BOWRIDER NOTES 200 Owner’s Manual...

  • Page 9: 200 Owner's Manual

    ECTION 200 Owner’s Manual ENERAL NFORMATION WELCOME Dear New Cobalt Owner, From all of us at the factory and from your authorized Cobalt dealer, thank you for purchasing a Cobalt boat. We greatly appreciate your business and look forward to a long and enjoyable relationship with you as part of the Cobalt family.

  • Page 10: Certificate Of Limited Warranty

    ECTION CERTIFICATE OF LIMITED WARRANTY Subject to the terms and conditions in this warranty, Cobalt Boats, LLC, a Delaware limited liability corporation doing business as Cobalt Boats (“Cobalt”), warrants to the original retail purchaser (and any subsequent owner) of a new Cobalt boat purchased from an authorized Cobalt dealer for personal, non-racing and non-commercial use (“Owner”), as follows:...
  • Page 11 Service Agreement is administered by a third party. For more information regarding this coverage and obtaining service, refer to the Extended Service Agreement booklet in your boat bag. All warranties, Cobalt and Extended Service are transferable and transfer fees are applicable. 200 Owner’s Manual...

  • Page 12: Introduction

    13' 1.44" (4 m) and above, and is largely self-sufficient. Abnormal conditions such as hurricanes are excluded. Such conditions may be encountered on extended voyages, for example across oceans, or inshore when unsheltered from the wind and waves for several hundred nautical miles. 200 Owner’s Manual...

  • Page 13: Owner Responsibility/Warranty Procedure

    Any claims waters, in estuaries and in coastal waters in against Cobalt Boats without prior approval from moderate weather conditions. Cobalt Boats on repairs completed by an unauthorized dealership may be denied.

  • Page 14: Certifications

    ECTION CERTIFICATIONS FEATURES/CONSTRUCTION NMMA Amenities Cobalt Boats is a member of the National Marine Your Cobalt boat incorporates classic styling with Manufacturers Association (NMMA). This the long, clean lines that have defined Cobalt independent organization’s members include boat, design for over 40 years.

  • Page 15: Warning Labels

    PROLONGED EXPOSURE TO CO WILL CAUSE BRAIN STORAGE PURPOSES ONLY. DAMAGE OR DEATH. Extended Swim Platform Extended Swim Platform COBALT BOATS “MEET U.S. EPA EVAP STANDARDS USING CERTIFIED COMPONENTS” Hydraulic Swim Platform Helm (U.S. Only) WARNING AVOID OBSTRUCTION OF NAVIGATION LIGHTS AND POSSIBLE COLLISION.
  • Page 16 USE BOTH TURN LOCKS TO SECURE DOOR. Walk-Through Door/Windshield CAUTION FOOT CAN SLIP THROUGH RUNG CAUSING BODILY INJURY, CLOSE CABIN DOOR BEFORE USING FORE DECK LADDER Companionway Area Helm Helm (California Only) Engine Compartment (actual capacity varies by model) COB_0019_A 200 Owner’s Manual...

  • Page 17: Publications

    It is located in full view of the onboard systems and equipment furnished by helm. suppliers other than Cobalt Boats. Please refer to CAPSIZE – To turn over. these manufacturer’s manuals for additional operation and maintenance instructions not CAST-OFF –...
  • Page 18 TRANSOM – The transverse beam across the NMMA – National Marine Manufacturers stern. Association. TRIM – Fore to aft and side to side balance of the boat when loaded. 200 Owner’s Manual...
  • Page 19 WAKE – The waves that a boat leaves behind when moving through the water. WATERWAY – A navigable body of water. WINDLASS – An electric winch to raise the anchor. 200 Owner’s Manual...

  • Page 20: Symbols

    Use Water Caution Hour Meter STOP Engine Engine Fuel Grease Height Holding Horn Stop Tank Above Water Tank Ignition Overall Lift Light Navigation Tank Switch Length Point Lights Trim Water Windshield Safety Alert Tabs Tank Wipers Symbol COB_0030_A 200 Owner’s Manual...

  • Page 21: Specifications

    Bridge Clearance w/Arch or Tower 7' 7'' (2.31 m) Draft, Drive Up 24'' (0.61 m) Draft, Drive Down 36'' (0.92 m) Dry Weight 3850 lbs (1746 kg) Boat Certified Capacity 12 persons Boat Certified Capacity w/Gear 1650 lbs (748 kg) 200 Owner’s Manual...

  • Page 22: Layout

    16. Anchor Light Storage 17. Ice Chest/Removable 18. Optional Dinette Table Mount 19. Glove Box/Stereo/12V Outlet 20. Storage/Dockline 21. Ski Locker 22. Fuel Tank/Access 23. Air Compressor/Storage 24. Optional Transom Tilt Switch 25. Optional Stereo Remote COB_0319_A 200 Owner’s Manual...

  • Page 23: Propeller Application Chart

    481406 3885842 VOLVO V8-225 2.32 2.32 VOLVO 5.0 GXi & GXiC 1.60 1.79 21 pitch 3 Blade 480341 VOLVO 5.0 GXi & GXiC 1.95 2.32 FH5’s 481405 3851495 VOLVO V8-270 VOLVO V8-300 FH5’s 481405 3851495 VOLVO V8-320 200 Owner’s Manual...

  • Page 24: Alphabetical Index

    Certificate of Limited Warranty ... . . 1-2 200....... . . 1-13 Certifications.
  • Page 25 If You Sell Your Cobalt Boat ....1-5 Operation Checklist ..... 2-4 200 Owner’s Manual...
  • Page 26 Using Lifting Slings..... . 6-4 Sea Grass Floor Covering Cleaning Ventilation System ..... . 2-3 200 Owner’s Manual...
  • Page 27 Windshield ......5-10 Zippers......5-10 200 Owner’s Manual...
  • Page 28 COBAL T BOWRIDER ECTION NOTES 200 Owner’s Manual...

  • Page 29: Owner/Operator Responsibilities

    ECTION 200 Owner’s Manual ESPONSIBILITIES AND AFETY Your safety, the safety of your passengers, and While operating the boat, the owner/operator is other boaters are among your responsibilities as responsible for: operator of this boat. Your boat must be in •...

  • Page 30: Required Safety Equipment

    Fire Extinguisher All inboard/outboard boats must carry an appropriate portable marine type fire extinguisher in operable condition and accessible location. Your Cobalt boat is equipped with a portable fire extinguisher and may have a fixed system fire extinguisher. 200 Owner’s Manual...

  • Page 31: Recommended Spare Parts

    • Canadian Power and Sail Squadrons the engine compartment. When activated, the • Yacht Clubs blowers exhaust dangerous fumes and intake fresh air through vents. Operate the blowers for at least four minutes before starting the engines. 200 Owner’s Manual...

  • Page 32: Electrical Systems

    While operating your boat, frequently check that the control and steering systems continue to operate smoothly. Monitor your gauges for signs of abnormal behavior. Beware of any excessive vibration. Refer to Section 3, Before Starting Checklist. 200 Owner’s Manual...

  • Page 33: Environmental Considerations

    This label must stay affixed to the boat if it is operated in California. The label identifies your boat is equipped with a California Certified Engine. The label is positioned so it will be at the leading or trailing edge of the state registration numbers. 200 Owner’s Manual...
  • Page 34 There is a tremendous drain on our fishery waste discharge. resources. Over-fishing and pollution have strained the fish population. Do your part by keeping only what you will eat and practice catch-and-release. 200 Owner’s Manual...

  • Page 35: Components, Maintenance And Repairs

    A fire extinguishers are normally an option on most maintenance log is helpful when requesting Cobalt boats). If you are in question of whether your warranty service using the extended warranty boat is equipped with fixed fire extinguishers, coverage.
  • Page 36 If you experience a propulsion, steering or control failure, immediately turn off the engines. Release the anchor to prevent drifting. Try to determine the failure and repair, if possible. Otherwise, call or signal for assistance. 200 Owner’s Manual...

  • Page 37: Lifesaving Equipment

    Federal law requires at least one Type I, II, III or V TYPE III Personal Flotation Device (PFD) for each person FLOTATION AIDS onboard or being towed, and at least one Type IV KC-0042C throwable PFD in the boat. 200 Owner’s Manual...
  • Page 38 • A Type V PFD must be worn to be counted toward the minimum carriage requirements. • Special PFDs are available for skiing and other water sports. These PFDs are constructed with materials suitable for high impact falls. 200 Owner’s Manual...
  • Page 39 Radar Reflectors Radar reflectors allow you to be seen by other vessels’ radar within your area. Mount the reflector as high as possible on the radar arch. 200 Owner’s Manual...

  • Page 40: Safety

    Indicates a hazardous situation which, if Seating not avoided, will result in death or Keep your passengers seated in seats. The boat’s serious injury. bow, gunwale, transom platform and seat backs are not intended for use as seats while underway. 200 Owner’s Manual...
  • Page 41 • Stow gear below deck and batten down equipment on deck. • Reduce speed and head for a safe place that you can easily reach. If you lose power, keep the boat headed into the waves by using the anchor. 200 Owner’s Manual...
  • Page 42 Federal and state law prohibit blast from your horn or whistle once every minute. operating a boat under the influence of Additionally, have passengers wear PFDs and alcohol and other drugs. These observe for oncoming vessels. regulations are actively enforced. 200 Owner’s Manual...
  • Page 43 Seek medical attention if transom platform while engines are running. necessary. Ventilation Your Cobalt boat may be equipped with carbon monoxide (CO) detector(s), if your boat is a cabin type or built with an enclosed changing area. 200 Owner’s Manual...
  • Page 44 Operating with high bow angle. Exhausts traveling along obstruction. Exhausts from other vessels in confined areas. Operating at slow speed or while dead in the water. Operating with canvas tops and side curtains in place without ventilation. COB_0033_A 200 Owner’s Manual...
  • Page 45 Road” for both federal and state waterways; you must stop if signaled to do so by enforcement Noise limits are regulated in many areas. Be sure officers, and permit to be boarded as asked. to follow regulations and be courteous. 200 Owner’s Manual...

  • Page 46: Water Sports Safety

    • Do not use any fuel burning appliances with a liability arising from such assistance. transom exhaust port when swimming from the stern swim platform. DANGER Avoid injury or death. DO NOT practice unsafe water sports. 200 Owner’s Manual...
  • Page 47 • Do not water sport in shallow water or at night. which can result in serious injury or death are not considered water sports. Cobalt Boats does not • Do not jump from a moving boat. promote unsafe boating risks or jeopardizing any •...

  • Page 48: Safety Alert From August 28, 2001

    In general, boats with less maneuverability have right-of-way over more agile craft. You must stay clear of the vessel with right-of-way and pass to his stern. 200 Owner’s Manual...
  • Page 49 12 O'CLOCK STAND-ON (PRIVILEGED) VESSEL HONK HONK HONK HONK HONK HONK DANGER ZONE GIVE-WAY (BURDENED) VESSEL PASSING PASSING MEETING PORT TO STARBOARD TO HEAD TO PORT STARBOARD HEAD COB_0034_A 4 O'CLOCK COB_0005_A 200 Owner’s Manual...

  • Page 50: Aids To Navigation

    Buoys with unique light-flashing characteristics are identified on nautical charts with the specific Protect your night vision by avoiding bright lights flashing pattern. and have a passenger, if possible, help keep watch for other boats, water hazards and aids to navigation. 200 Owner’s Manual...
  • Page 51 Regulatory markers are white with orange geometric shapes and also have orange bands near the top and at the water line of the buoy. You must obey regulatory markers (see below). CONTROLLED DANGER BOATS INFORMATION AREA KEEP OUT KC-1903 200 Owner’s Manual...
  • Page 52 Quick Flashing Flashing Occulting Starboard Side Even Numbers Daymark Nun Buoy Lighted Buoy KC-1909 WHITE LIGHT ONLY MORSE CODE Mo (A) Safe Water Aids Marking Mid-Channels and Fairways (No Numbers–May be Lettered) Spherical Buoy Daymark Lighted KC-1910 200 Owner’s Manual...
  • Page 53 RED and GREEN horizontally striped buoys. A RED band at the top means the preferred channel is to the left of the buoy; a GREEN top band means the preferred channel is to the right of the buoy. 200 Owner’s Manual...
  • Page 54 They are similar to lighted BLACK-STRIPED buoys, except they are usually higher and on more WHITE BUOY stable platforms to increase visibility. Most minor KC-1902 lights are part of a series to mark a channel, river or harbor. 200 Owner’s Manual...
  • Page 55 RIGHT OF RANGE LINE ON RANGE LINE COB_0038_A Lighthouses Lighthouses can be found at harbor entrances, prominent headlands, isolated danger areas and along the coast. These striped or patterned structures have unique flashing characteristics to help identify them. KC-0443C 200 Owner’s Manual...
  • Page 56 Boaters must also recognize the flag designs which indicate that skin divers are present and keep well clear of the area. KC-0250C Watch for swimmers. Swimming areas may not be marked. Steer clear from the area and remain alert. 200 Owner’s Manual...

  • Page 57: Operating Information

    ECTION 200 Owner’s Manual PERATING NFORMATION FIRST-TIME OPERATION This section is not intended to provide complete training on all aspects of boat operation. We strongly recommend that all operators of this WARNING Cobalt boat seek additional training on boat Avoid injury or death. Improper handling and safety.

  • Page 58: Fuel

    Operate the type of discharge, trash or blowers for at least four minutes. DO litter into our waterways. NOT store rags used to wipe up fuel or solvent spills in the boat. Dispose of rags properly ashore. 200 Owner’s Manual...
  • Page 59 If you smell filler cap, open by pressing the cap and turning the gasoline fumes, do not start the engine; cap counterclockwise (approximately 10°); remove continue to run the blower until fumes have cap. dissipated. 200 Owner’s Manual...
  • Page 60 Do not attempt to continue fueling after the nozzle automatically shuts off, indicating the tank is full. • A carbon canister is present to capture hydrocarbon molecules before air is vented outside the fuel system. 200 Owner’s Manual...

  • Page 61: Launching

    Avoid stepping on fiberglass or other potentially slippery surfaces. Board one person at a time. Do not board the boat while carrying gear. Set the gear on the dock, board the boat and then pick up the gear. 200 Owner’s Manual...

  • Page 62: Getting Underway

    Immediately have any problem attended to by your authorized Cobalt dealer. • Operate bilge blowers for at least four minutes before starting engines or generators. • Do not overload your boat. 200 Owner’s Manual...

  • Page 63: Handling Dock And Mooring Lines

    Be sure to use spring lines when boating in waters where the tide movement is significant. The forward quarter spring line is fastened to a forward cleat and heads aft. The after bow spring is fastened to a stern cleat and heads forward. 200 Owner’s Manual...
  • Page 64 ENGINE IS RUNNING. water inlets for blockage. If the inlets are open, • TURN OFF ENGINE AND ALL ELECTRICAL have your authorized Cobalt dealer service the SYSTEMS WHILE REFUELING. engine. • TURN OFF ENGINE WHEN SWIMMERS ARE NEAR BOAT. 200 Owner’s Manual...
  • Page 65 • Regularly inspect the steering system for kinks, damage and corrosion. Your Cobalt boat is equipped with a tilt steering wheel. Adjust the tilt position with the release lever. Refer to Basic Maneuvering, in this section, for additional steering information. 200 Owner’s Manual...
  • Page 66 COBAL T BOWRIDER ECTION RIGHT TURN LEFT TURN BACKING TO LEFT Turn wheel to right—Stern Turn wheel to left—Stern Turn wheel to left—Stern will move to left. will move to right. will pull to left. COB_0062_A 200 Owner’s Manual...
  • Page 67 When leaving a mooring, you should already have enough space around the boat to maneuver. Untie from the mooring and move back slowly until you can see it. Proceed slowly while giving the buoy wide clearance. 200 Owner’s Manual...
  • Page 68 If you must approach the dock downwind or down current, use a slow speed and shallow angle. Be ready to reverse in order to stop and maintain position. 200 Owner’s Manual...

  • Page 69: Basic Maneuvering

    If the steering wheel remains in a centered position, the boat will wander back and forth slightly; however, the overall course of the boat will be a straight one. 200 Owner’s Manual...
  • Page 70 To use power trim effectively, start with the drive unit trimmed in. As the boat planes, increase the angle out. Experience is the best teacher for understanding proper drive trim. 200 Owner’s Manual...
  • Page 71 Some systems may include indicators to show position of the tabs and drive unit. STARBOARD TAB LOWERED STARBOARD STERN RISES PORT BOW LOWERS COB_0067_A LOWERS STERN RISES HULL WATER IS REDIRECTED CREATING UPWARD FORCE AT STERN COB_0068_A 200 Owner’s Manual...
  • Page 72 • Prepare the boat. Be sure all gear is properly accident. stowed and compartments are latched. • Weight distribution affects performance. Keep weight in the boat to a minimum and evenly distributed. 200 Owner’s Manual...
  • Page 73 Look for signs of underwater pipes or cables. With the engine off, you have no control of the boat. Water and wind conditions will affect an anchored boat. Be sure the anchor will hold before leaving the boat. 200 Owner’s Manual...
  • Page 74 DO NOT use deck cleats or place safety switch in the ON position. handrails. DO NOT allow anyone to be in line with the tow rope. Press and hold the toggle switch down to pay out sufficient rope/chain to set the anchor. 200 Owner’s Manual...

  • Page 75: Environmental Considerations

    This will help prevent damage from freezing. Upon removing your Cobalt boat from the water, leave the drive unit in the vertical position until cooling system has drained. Refer to your propulsion unit operator’s manual for additional information regarding winterization. 200 Owner’s Manual...

  • Page 76: Entertainment System

    The speakers can be damaged if struck by a sharp object or if the moving elements are restricted from movement. Do not store or place any sharp objects near the speakers, or restrict the element movement. 200 Owner’s Manual...

  • Page 77: Cobalt Instrumentation System

    (go to zero, or minimum reading). With the speedometer as the Data Interface Gauge, it will perform an LCD all-segments-on test. Once the initializations are complete, the gauges will be able to receive and display data. 200 Owner’s Manual...

  • Page 78: Helm And Instrumentation

    Cobalt dealer. equipment or lives. DO NOT jeopardize Refer to the engine operator’s manual for normal the safety of you or others to protect recommended ranges. your boat. 200 Owner’s Manual...
  • Page 79 BILGE PUMP - This switch manually controls the keep the engine within the proper operating range. bilge pump. Refer to the engine operator’s manual for correct specifications. INTERIOR LIGHTS - This switch provides illumination within the cockpit. 200 Owner’s Manual...
  • Page 80 (all one size) the ignition safety switch, shutting off the engine. grouped together and throttle levers (all one size, and larger than the shift levers) grouped together. COB_0042_A 1 – Ignition Safety Switch 2 – Lanyard 3 – Hook 200 Owner’s Manual...

  • Page 81: Remote Control(S)

    If combined with the optional trim tabs, more enhancement to performance and ride can be achieved. 9. SHIFT DETENT BUTTON - Press to shift from NEUTRAL into FORWARD or REVERSE. 10. GAUGE MODE SWITCH - Allows toggling of LCD screen on speedometer. 200 Owner’s Manual...

  • Page 82: 3" Digital Gauge

    Cobalt dealer. Your boat may not be equipped with all of these features or options. Overheat Alarm Appearance - Coolant temperature is displayed in the Fuel Gauge, on an LCD, in the form of a bar-type histogram. 200 Owner’s Manual...
  • Page 83 Helm Fault Alarm Appearance - When the Helm Fault Alarm is received, the Tachometer LCD display, in the segmented digits, shows “H F”, alternating with the magnetic heading and any other alarm message, in 1.0 ±0.3 second intervals. 200 Owner’s Manual...

  • Page 84: Standard And Optional Equipment

    Graphics, Molded-In Gelcoat Lights, Tower Midship Cleats Recessed Hull - Side Logo Ski Tow Eye - Stainless Steel Sof-Trac Mat (std swim platform) Sof-Trac Mat (swim platform w/step) SS Tubular Platform Perimeter Rail Stainless Top Trim Windshield 200 Owner’s Manual...
  • Page 85 WSS Custom Interior (piping, monograms) Stereo AM-FM, Single CD Stereo w/6 Speakers iPod/MP3 Port Premium Sound System w/Transom Remote Premium Sound w/Transom Remote & Speakers Satellite Radio System Speakers, WSS Tower - 1 Pr. Stereo Remote, Dash Stereo Remote, Transom 200 Owner’s Manual...
  • Page 86 Cruise Control (Perfect Pass) w/GPS Cruise Control, Volvo w/EVC Driver’s Rearview Mirror Fiberglass Cockpit Liner Fiberglass Stringer System Fire Extinguisher, Automatic System Fire Extinguisher, Manual Ignition Safety Switch Kevlar™ Reinforced Hull Stainless Steel Windshield Braces Through-Prop Exhaust Tool Kit 200 Owner’s Manual...

  • Page 87: Captain's Chair Adjustments And Operation

    DANGER Avoid potential injury or ejection of occupants. DO NOT stand while driving above engine idle speeds and make sure all passengers are seated and seats are in a locked/secured position when the boat is underway. 200 Owner’s Manual...

  • Page 88: Flip Down Swim Step - Optional

    Pull the plunger and raise the step at the same time. Be careful when folding the step over onto the platform. Do not allow the step to slam down. Always make sure the area in the platform is clear before closing the step. 200 Owner’s Manual...

  • Page 89: Volvo Penta Ocean Series Outdrive

    Please refer to the Neutra-Salt Operator’s Manual create the sun deck. located in your boat bag for operating information. ICE CHEST The ice chest can be accessed by lifting the starboard aft sunpad cushion UP and OUT. 200 Owner’s Manual...

  • Page 90: Air Compressor - Optional

    WAKEBOARD PRO ANCHOR LIGHT COB_0029_A To install anchor light insert pole into socket and turn clockwise until it locks into place. COB_0097_A Cap the anchor light socket when the anchor light is removed. 200 Owner’s Manual...

  • Page 91: Battery Switch

    • Ignition protected – safe for installation aboard gasoline-powered boats • Undervoltage lockout will not close when the lower battery is below 10.8V at 12V operation – lockout indicated by blinking LED • Built-in LED light indicates when batteries are combined 200 Owner’s Manual...

  • Page 92: Cockpit Tonneau Cover - Optional

    2. Unroll canvas from bows. 3. Fold bimini forward. COB_0138_A 4. Put aft end of canvas over the top of the tower, and zip pockets together around the rear tube of tower. 5. Install adjustable poles. 6. Tighten adjustable poles. 200 Owner’s Manual...

  • Page 93: Ski Tow Eye

    WARNING Avoid injury or death. DO NOT overload the ski tow eye or use it for anything other than water sports. The ski tow eye maximum load is 1,000 lbs (454 kg). COB_0151 COB_0245_A 200 Owner’s Manual...

  • Page 94: Tie-Down Locations

    2 – Cleats during these conditions. 3 – Stern Eyes WARNING Avoid injury, death or property damage. Never anchor a boat from the stern, and keep the boat headed into the waves. 200 Owner’s Manual...

  • Page 95: Tool Kit - Optional

    30°, pushing it in and twisting it clockwise to secure. Make sure the pole is secured before getting underway. Do not use the flagpole for any purpose other than displaying the flag. (30˚) COB_0244_A 200 Owner’s Manual...
  • Page 96 COBAL T BOWRIDER ECTION NOTES 200 Owner’s Manual...

  • Page 97: Systems

    ECTION 200 Owner’s Manual YSTEMS INTRODUCTION This section discusses the mechanical, electronic, and manual operating systems of your Cobalt boat. It describes basic operating characteristics and provides information for efficient use of the equipment, and for prevention of casualties. Be sure to read and understand all information provided before operating its systems.

  • Page 98: Electrical Wiring Harness

    COBAL T BOWRIDER ECTION ELECTRICAL WIRING HARNESS COB_0321_A 200 Owner’s Manual...

  • Page 99: Fuel Routing

    YSTEMS FUEL ROUTING FUEL FILL HOSE FUEL VENT HOSE FUEL LINE TO ENGINE COB_0322_A 200 Owner’s Manual...

  • Page 100: Fire Suppression Equipment

    The breakers are labeled to identify the automatic fire extinguisher that uses FE-241 (or device protected. These breakers will activate if optional FM-200, for European requirements) as an overloaded and cut power to the switch. To restore extinguishing agent, it is mounted on the engine...

  • Page 101: Fuses

    20 amp (located at battery switch) Amplifier 40 amp (located at battery switch) Bilge Pump 1000 GPH 5 amp (located behind dash) Head Blower* 3” 6 amp Head Blower* 4” 6 amp *Fuses are located behind the dash panel. 200 Owner’s Manual...

  • Page 102: Lighting/Bulb Replacement

    Black Rectangular Courtesy Light 1044-99A Chrome Courtesy Light (Round) Overhead Console Light GE 912 Dome Light Instrument Lighting Tachometer 194 SF2 Speedometer 194 SD2 Voltmeter 658 S11 Oil Pressure 658 SH2 Temperature 658 SC2 Fuel 658 SC2 Trim 658 SC2 200 Owner’s Manual...

  • Page 103: Battery Connections

    Loose battery connections can cause errant signals to the boat’s electrical system. Read and understand the safety information on or supplied with your battery(ies). Maintain the battery(ies) following the manufacturer’s recommendations. COB_0090_A 200 Owner’s Manual...
  • Page 104 COBAL T BOWRIDER ECTION NOTES 200 Owner’s Manual...

  • Page 105: Vinyl Interior And Upholstery

    NTERIOR XTERIOR The best way to take care of your Cobalt boat is The vinyl manufacturer or Cobalt Boats warranties with prevention and proper care. All of the care do not cover vinyl staining from suntan lotions. methods within this section may not apply to your Special care should be taken to prevent dark boat.
  • Page 106 Do not apply water or try to wash a butter, oil or grease spot. Hair oil tonic Blood NOTICE: DO NOT use saddle soap, cleaning solvents, Urine furniture polish, oils, varnish, Grape juice abrasive cleaners, soaps or Olive oil ammonia water. Chocolate Ketchup Baby oil 200 Owner’s Manual...

  • Page 107: Sea Grass Floor Covering Cleaning Instructions

    Crystal Dry™ as well; see Periodic Comprehensive and other foot-borne contaminants onto the Plynyl Cleaning (1) on next page. floor. If a walk-off mat is not provided, it will result in premature wear of the Plynyl installation. 200 Owner’s Manual...

  • Page 108: Spot And Stain Removal

    Care should be taken to remove all detergent residue or it may attract more dirt. Care should be taken not to abrade Plynyl with the rotating pad. Hard-to-remove stains should be treated by hand, not machine, as per instructions in Spot and Stain Removal. 200 Owner’s Manual...
  • Page 109 5 minutes. Rinse the area with water only in order to remove the bleach residue. Allow to dry completely before trafficking. Some stains may require a professional to complete the stain-removal process. 200 Owner’s Manual...

  • Page 110: Cabinetry And Wood

    In some instances, foam-backed tape used in The finish on your Cobalt boat is known as gelcoat. manufacturing will absorb and retain these The gelcoat used by Cobalt Boats is the finest substances and result in premature fading available on the market today. With all its and/or discoloration of your woodgrain dash.

  • Page 111: Stainless Steel And Chrome

    These types of cleaners can damage the surface permanently. Apply metal or automotive wax after cleaning for additional protection. Always test any product in an inconspicuous area before applying to the complete surface. 200 Owner’s Manual...

  • Page 112: Topside

    Refer to the propulsion unit operator’s manual for http://www.corrosionx.com or manufacturer’s saltwater operating call 800-638-7361. recommendations. Corrosion destroys underwater metal parts and can occur in fresh or salt water. Salt, brackish and polluted waters will accelerate corrosion. 200 Owner’s Manual...

  • Page 113: Canvas

    (no more than 100°F). Rinse thoroughly to remove soap. DO NOT USE DETERGENTS. Allow to air dry. Do not store canvas wet or in an unventilated, moist area. 200 Owner’s Manual...

  • Page 114: Other Canvas Components

    Use care when starting zipper to prevent damage. the hull to slow growth and prevent gelcoat damage. Consult your authorized Cobalt dealer for recommendations. 200 Owner’s Manual...

  • Page 115: Scheduled Maintenance And Service

    ECTION 200 Owner’s Manual AINTENANCE AND ROUBLESHOOTING SCHEDULED MAINTENANCE Use the following chart to establish your maintenance routine. Detailed information AND SERVICE concerning the task is listed in this section. Your Cobalt boat may not include all of the features...

  • Page 116: Break-In

    4. Check the air conditioning and generator described in Before Each Use, Step 3. seawater strainers for leaks and accumulation of debris. • If a hose is leaking or damaged, close the appropriate seacock. Consult your authorized Cobalt dealer for repairs. 200 Owner’s Manual...

  • Page 117: Every 100 Hours

    Have your authorized Cobalt dealer repair all electrical problems. An electrical problem must be treated seriously. DANGER TEST RESET Avoid fire or explosion. Whenever checking for electrical problems, use extreme caution. Fuel and fumes are extremely flammable and explosive. COB_0079_A 200 Owner’s Manual...

  • Page 118: Fuel System

    Slings must be the flat, 2 – Gap between hull and cradle — wrong wide-belting type. Do not use cable-type slings. The spreader bars used with the slings must be wide enough to avoid pressure to the gunwales. 200 Owner’s Manual...

  • Page 119: Storage/Winterization

    Section 5, Interior and Exterior Care. Cover the boat with the mooring cover. If a temporary poly cover, such as shrink wrap, is used, your authorized Cobalt dealer will install several vents to provide adequate ventilation to prevent mold or mildew. 200 Owner’s Manual...

  • Page 120: Cockpit Heater

    The removable feature is for boat storage only. Cockpit Heater To winterize the optional cockpit heater, remove the two 5/8-inch cockpit heater hoses from the engine. Pump antifreeze into one hose until entire heater system is filled. 200 Owner’s Manual...

  • Page 121: Engine

    Boat overloaded – reduce load. Boat trim – distribute boat load evenly. Improper propeller selection – see your authorized Cobalt dealer. Excessive bilge water – check for excessive water, drain bilge. Boat hull condition – clean if marine growth is present. 200 Owner’s Manual...

  • Page 122: Electrical

    Damaged freshwater pump, restriction or obstruction in water line – see your authorized sink Cobalt dealer. Head will not flush Head circuit breaker tripped or in OFF position – correct the problem and reset; turn circuit breaker ON. Line to waste tank blocked – see your authorized Cobalt dealer. 200 Owner’s Manual...

  • Page 123: Reference And Forms

    ECTION 200 Owner’s Manual EFERENCE AND ORMS OPERATION QUICK Pre-Operation • Test operation of carbon monoxide detector. REFERENCE • Open all seacocks and check for leaks. Your safety, the safety of your passengers and • Check seawater strainers for leaks and other boats are among your responsibilities as accumulation of debris.

  • Page 124: Starting Engines

    Returning to Port the boat. • Come to a stop a short distance from the dock, • Secure lockers, hatches and canvas as then proceed slowly. equipped. • Have your fenders, mooring lines and the crew ready. 200 Owner’s Manual...

  • Page 125: Service Log

    EFERENCE AND ORMS SERVICE LOG Date Hour Reading Service/Repairs Performed 200 Owner’s Manual...

  • Page 126: Fuel Log

    COBAL T BOWRIDER ECTION FUEL LOG Gallons/ Gallons/ Date Gallons Hours Date Gallons Hours Hour Hour 200 Owner’s Manual...

  • Page 127: Float Plan

    Radio: Yes Type Freq Destination Est. Time of Arrival Expect to Return By Auto Type License No. Parked If not returned by call the Coast Guard, or (Local Authority). Coast Guard Telephone Number: Local Authority Telephone Number: 200 Owner’s Manual...

  • Page 128: Boat Information

    DVD Make and Model Number Serial Number Stereo Make and Model Number Serial Number TV, Cabin Make and Model Number Serial Number TV, Mid-berth Make and Model Number Serial Number Subwoofer Make and Model Number Serial Number 200 Owner’s Manual...

  • Page 129: Warranty Transfer Form

    A $350 Warranty Transfer fee is applicable for the remainder of the Cobalt boat warranties on all 2011 and newer models. Please mail the fee with this form to Cobalt Boats, 1715 N. 8th Street, Neodesha, KS 66757. If you wish to update our ownership records only and decline any warranties that may still be in effect, please check the box below.
  • Page 130 COBAL T BOWRIDER ECTION NOTES 200 Owner’s Manual...
  • Page 132 Cobalt Boats 1715 North 8th Street Neodesha, KS 66757 www.cobaltboats.com P/N 452819 All Rights Reserved, © 2012 Printed in U.S.A.

Table of Contents

Save PDF