Page 1: Table Of Contents
Rear window defroster Lights Headlamps Turn signal control Bulb replacement Driver Controls Windshield wiper/washer control Steering wheel adjustment Power windows Mirrors Speed control Message center Tailgate Locks and Security Keys Locks Anti-theft system 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 2 Roadside Emergencies Getting roadside assistance Hazard flasher switch Fuel pump shut-off switch Fuses and relays Changing tires Lug Nut Torque Jump starting Wrecker towing Customer Assistance Reporting safety defects (U.S. only) Cleaning 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 4: Introduction
State of California to cause cancer and birth defects or other reproductive harm. CONGRATULATIONS Congratulations on acquiring your new Ford. Please take the time to get well acquainted with your vehicle by reading this handbook. The more you know and understand about your vehicle, the greater the safety and pleasure you will derive from driving it.
Page 5 Correct vehicle usage and the authorized disposal of waste, cleaning and lubrication materials are significant steps towards this aim. Information in this respect is highlighted in this guide with the tree symbol. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 6 Seating and Safety Restraints chapter. Failure to follow the specific warnings and instructions could result in personal injury. Front seat mounted rear-facing child or infant seats should NEVER be placed in front of an active passenger airbag. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 7 • where the driver was positioning the steering wheel. To access this information, special equipment must be directly connected to the recording modules. Ford Motor Company and Ford of Canada do not access event data recorder information without obtaining consent,...
Page 8 Driving chapter. Using your vehicle as an ambulance Do not use this vehicle as an ambulance. Your vehicle is not equipped with the Ford Ambulance Preparation Package. Notice to owners of pickup trucks and utility type vehicles Utility vehicles have a significantly higher rollover rate than other types of vehicles.
Page 9 By referring to the pages in the provided supplement, you can properly identify those features, recommendations and specifications that are unique to your vehicle. Refer to this Owner’s Guide for all other required information and warnings. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 10 Brake Fluid - Anti-Lock Brake System Non-Petroleum Based Powertrain Malfunction Speed Control Master Lighting Switch Hazard Warning Flasher Fog Lamps-Front Fuse Compartment Fuel Pump Reset Windshield Wash/Wipe Windshield Rear Window Defrost/Demist Defrost/Demist 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 11 Battery Acid or Sparks Explosive Gas Fan Warning Maintain Correct Fluid Power Steering Fluid Level Emission System Engine Air Filter Passenger Compartment Jack Air Filter Low Tire Pressure Check Fuel Cap Warning 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 12: Instrument Cluster
Instrument Cluster WARNING LIGHTS AND CHIMES Base instrument cluster Base with Tachometer instrument cluster 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 13 Instrument Cluster Family carrier instrument cluster Mid instrument cluster 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 14 If any light remains on after starting the vehicle, refer to the respective system warning light for additional information. Service engine soon: The Service engine soon indicator light illuminates when the ignition is first turned to the ON position to check 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 15 Illumination after releasing the parking brake indicates low brake fluid level and the brake system should be inspected immediately by your authorized dealer. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 16 Illuminates when the overdrive function of the transmission has been turned off, refer to the Driving chapter. If the light flashes steadily or does not illuminate, have the transmission serviced soon, or damage may occur. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 17 ON position and any door is open. Low fuel: Displays when the fuel level in the fuel tank is at or near empty (refer to Fuel gauge in this chapter). 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 18 Headlamps on warning chime: Sounds when the headlamps or parking lamps are on, the ignition is off (the key is not in the ignition) and the driver’s door is opened. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 19: Gauges
Stop the vehicle as soon as safely possible, switch off the engine and let the engine cool. Never remove the coolant reservoir cap while the engine is running or hot. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 20 ON position. If the pointer moves and stays outside the normal operating range, have the vehicle’s electrical system checked by your authorized dealer as soon as possible. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 21 The arrow next to the fuel pump icon indicates which side of the vehicle the fuel filler door is located. For more information, refer to Filling the tank in the Maintenance and Specifications chapter. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 22: Entertainment Systems
Bass: Press to adjust the bass setting. Use SEEK, SEEK Balance: Press to adjust the audio between the left and right speakers. SEEK, SEEK Fade: Press to adjust the audio between the front and rear speakers. SEEK, SEEK 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 23 “nominal” listening level when the ignition switch is turned back on. 7. CLK (Clock): Press CLK to toggle between displaying the radio frequency and the clock setting. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 24: Am/Fm Stereo With Cd
Sirius channel Categories (Pop, Rock, News, etc.). Refer to Catetory Mode under Menu for further information. Satellite radio is available only in the continental United States with a valid SIRIUS radio subscription. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 25 MENU until SSV appears in the display. Use SEEK adjust the levels. The recommended level is 1–3. Level 0 turns the Speed Sensitive Volume off and level 7 is the maximum setting. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 26 In CATEGORY MODE, press SEEK to select a category. Satellite radio is available only in the continental United States with a valid SIRIUS radio subscription. 6. Text: This control is not operational. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 27 SCAN to hear a brief sampling of the channels in the selected category. Press again to stop. Satellite radio is available only in the continental United States with a valid SIRIUS radio subscription. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 28 CD is already loaded into the system, CD play will begin where it ended last. 17. CD eject: Press to eject a CD. 18. CD slot: Insert a CD label side 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 29: Am/Fm Stereo Cassette With Cd
Sirius channel Categories (Pop, Rock, News, etc.). Refer to Catetory Mode under Menu for further information.Satellite radio is available only in the continental United States with a valid SIRIUS radio subscription. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 30 Satellite radio is available only in the continental United States with a valid SIRIUS radio subscription. TREB (Treble): Press MENU until TREBLE appears in the display. SEEK to adjust the treble levels. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 31 SAT3 modes. Satellite radio is available only in the continental United States with a valid SIRIUS radio subscription. 6. Tape eject: Press to eject a tape. 7. Text: This control currently not supported. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 32 SIRIUS radio subscription. 14. Cassette door: Insert a tape, facing to the right. 15. Tape direction: Press to change which side of the tape is playing. 16. AM/FM: Press to select AM/FM1/FM2 frequency band. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 33 SCAN to hear a brief sampling of the channels in the selected category. Press again to stop. Satellite radio is available only in the continental United States with a valid SIRIUS radio subscription. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 34: Am/Fm Stereo With In-Dash Six Cd
Sirius channel Categories (Pop, Rock, News, etc.). Refer to Catetory Mode under Menu for further information. Satellite radio is available only in the continental United States with a valid SIRIUS radio subscription. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 35 Press MENU until SSV appears in the display. Use SEEK to adjust the levels. The recommended level is 1–3. OFF turns the Speed Sensitive Volume off and level 7 is the maximum setting. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 36 4. Aux: Press to toggle between FES/DVD and AUX. If no auxiliary sources are available, NO AUX AUDIO will be displayed. If equipped with Satellite Radio, press AUX to cycle through SAT1, SAT2 and SAT3 modes. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 37 9. FOLDER: press to access the previous folder on MP3 discs, if folders are available. 10. Fast forward: Press to manually advance in a CD track. 11. Rewind: Press to manually reverse in a CD track. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 38 CD play will begin where it ended last. 17. LOAD: Press to load a CD. Press LOAD and a memory preset to load to a specific slot. Press and hold to autoload up to six CDs. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 39 10–12 hours of play to maintain good sound/operation. Don’t: • Expose tapes to direct sunlight, extreme humidity, heat or cold. • Leave tapes in the cassette player for a long time when not being played. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 40 Due to technical incompatibility, certain recordable and re-recordable compact discs may not function correctly when used in Ford CD players. Dirty, warped or damaged CDs, irregular shaped CDs, CDs with a scratch protection film attached, and CDs with homemade paper (adhesive) labels should not be inserted into the CD player.
Page 41 Note: SIRIUS reserves the unrestricted right to change, rearrange, add or delete programming including canceling, moving or adding particular channels, and its prices, at any time, with or without notice to you. Ford Motor Company shall not be responsible for any such programming changes.
Page 42 1–888–539–7474 to channel. subscribe to the channel, or, tune to another channel. NO TEXT Artist information not Artist information not available. available at this time on this channel. The system is working properly. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 43 Radio. subscription issues. Family Entertainment System (if equipped) Your vehicle may be equipped with a Family Entertainment System (FES). Refer to the DVD Supplement Guide for further information on your system. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 44: Climate Controls
• Remove any snow, ice or leaves from the air intake area at the base of the windshield. To aid in side window defogging/demisting in cold weather: 1. Select 2. Adjust the temperature control to maintain comfort. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 45: Manual Heating And Air Conditioning
(OFF): Outside air is shut out and the climate system is turned off. : Distributes air through the floor vents. : Distributes air through the windshield defroster vents and floor vents. : Distributes outside air through the windshield defroster vents. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 46 • For maximum cooling performance (Max A/C): Max A/C mode: • Move the temperature control to the coolest setting. • Set the fan to the highest speed initially, then adjust to maintain comfort. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 47: Automatic Temperature Control
Do not place objects on top of the instrument panel as these objects may become projectiles in a collision or sudden stop. AUTOMATIC TEMPERATURE CONTROL (ATC) SYSTEM (IF EQUIPPED) 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 48 Recirculated air may reduce the amount of time to cool down the interior of the vehicle and may also help reduce undesired odors from reaching the interior of the vehicle. Recirculation can be 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 49 The system will automatically determine fan speed, airflow location, A/C on or off, and outside or recirculated air, to heat or cool the vehicle to reach the desired temperature. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 50 If your vehicle is equipped with a full message center, refer to Units (Fahrenheit/Celsius) in the Driver Controls chapter. If your vehicle is equipped with a mini message center, refer to Mini message center electronic compass temperature display in the Driver Controls Chapter. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 51 Recirculation can be engaged manually in any other airflow selection except (defrost). Recirculation may turn off automatically. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 52 4. Set the fan speed to the highest setting. 5. Direct the outer instrument panel vents towards the side windows. To increase airflow to the outer instrument panel vents, close the vents located in the middle of the instrument panel. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 53: Rear Window Defroster
This may cause damage to the heated grid lines and will not be covered by your warranty. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 54: Lights
Steps 2 through 5 must be performed within a 10 second period. At this point, the headlamps and park lamps will turn on. 6. Deselect the autolamps after the desired autolamp delay time (maximum of 3 minutes). 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 55 Turns the headlamps on with a reduced output. In order for the DRLs to function: • the ignition must be in the ON position and • the headlamp control is in the OFF, parking lamp or autolamp position. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 56 3.0 mm circle on the lens) to the ground and mark an 8 foot (2.4 meter) horizontal reference line on the vertical wall or screen at this height (a piece of masking tape works well). 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 57: Turn Signal Control
7. Repeat Steps 3–5 for the other headlamp. 8. Close the hood and turn off the lamps. TURN SIGNAL CONTROL • Push down to activate the left turn signal. • Push up to activate the right turn signal. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 58 • OFF or : The lamp will not come on at all. The rear dome lamp can be turned ON or OFF by sliding the control. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 59: Bulb Replacement
“E” for Europe to ensure lamp performance, light brightness and pattern and safe visibility. The correct bulbs will not damage the lamp assembly or void the lamp assembly warranty and will provide quality bulb burn time. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 60 4. Slide headlamp assembly forward disconnecting the snap attachment at the fender and disconnect the electrical connector from the bulb by pulling rearward. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 61 3. Once the three retaining screws have been removed, disengage the tab at the top center of the headlamp assembly by lifting it up. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 62 4. Remove bulb socket from the lamp assembly by turning it counterclockwise. 5. Pull bulb straight out of socket and press in the new bulb. Install the new bulb(s) in reverse order. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 63 3. Pull out the old bulb from the socket and push in the new bulb. 4. Install the bulb socket in lamp assembly by turning it clockwise. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 64: Driver Controls
TILT STEERING WHEEL (IF EQUIPPED) Pull the lever down to unlock the steering column. While the lever is in the down position, tilt the steering column to its desired orientation. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 65 Use only soft cups in the cupholder. Hard objects can injure you in a collision. OVERHEAD CONSOLE (IF EQUIPPED) The appearance of your vehicle’s overhead console will vary according to your option package. The overhead console can come on rails, during 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 66 • When on the overhead rail, adjacent bins must be pinned together. Bins adjacent to the End Cap must be pinned to the End Cap. Bins without pin attachments should not be placed on the overhead rail. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 67 Bin Removal Attach and remove bins from the rail using the following instructions: Place both palms on the underside of the storage bin, avoiding the storage bin door. Push upwards with palms. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 68 Do not hang any type of accessory or accessory bracket from the plug. Improper use of the power outlet can cause damage not covered by your warranty. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 69: Power Windows
Improper use of the lighter can cause damage not covered by your warranty. POWER WINDOWS (IF EQUIPPED) Do not leave children unattended in the vehicle and do not let children play with the power windows. They may seriously injure themselves. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 70 Press the right side to restore the window controls. Power Sliding Back Window (if equipped) To operate the power sliding back window, the ignition switch must be in the Run or Accessory position. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 71 R (Reverse) to ensure a bright clear view when backing up. Do not block the sensor on the backside of the inside rear view mirror since this may impair proper mirror performance. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 72: Mirrors
Should this occur, wait approximately 3 minutes for the system to reset and function to return to normal. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 73 • Press the bottom of the control to adjust the pedals toward you. • Press the top of the control to adjust the pedals away from you. The adjustment allows for approximately 3 inches (76 mm) of maximum travel. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 74: Speed Control
• If the vehicle speed decreases more than 10 mph (16 km/h) below your set speed on an uphill, your speed control will disengage. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 75 You can also use the CST control to operate the Tap-Down function. Press and release this control to decrease the vehicle set speed in small amounts by 1 mph (1.6 km/h). 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 76 • SAT1, SAT2 or SAT3 (Satellite Radio mode if equipped). In AM, FM1, or FM2 mode: • Press SEEK to select preset stations or the next strong station within the selected radio band. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 77 Note: The moon roof will open to the “comfort” position first before opening all the way. The “comfort” position helps to alleviate rumbling wind noise which may happen in the vehicle with the roof fully opened. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 78 This feature will learn the radio frequency codes of most transmitters to operate garage doors, entry gate operators, security systems, entry door locks, and home or office lighting. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 79 2. Position the end of your hand-held transmitter 1–3 inches (2–8 cm) away from the HomeLink button you wish to program (located on your visor) while keeping the indicator light in view. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 80 HomeLink should now activate your rolling code equipped device. To program additional HomeLink buttons begin with Step 2 in the “Programming” section. For questions or comments, please contact HomeLink at www.homelink.com or 1–800–355–3515. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 81 For convenience, the hand-held transmitter of the device may also be used at any time. In the event that there are still programming difficulties, contact HomeLink at www.homelink.com or 1–800–355–3515. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 82 The compass reading may be affected when you drive near large buildings, bridges, power lines and powerful broadcast antennas. Magnetic or metallic objects placed in, on or near the vehicle may also affect compass accuracy. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 83 Perform this adjustment in an open area free from steel structures and high voltage lines. For optimum calibration, turn off all electrical accessories (heater/air conditioning, wipers, etc.) and make sure all vehicle doors are shut. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 84: Message Center
Selectable features Reset Press this control to select and reset functions shown in the INFO menu and SETUP menu. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 85 This variation is four degrees between adjacent zones and will become noticeable as the vehicle crosses multiple zones. A correct zone setting will eliminate this error. Refer to Compass zone/calibration adjustment. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 86 9. Slowly drive the vehicle in a circle (less than 3 mph [5 km/h]) until the CIRCLE SLOWLY TO CALIBRATE display changes to CALIBRATION COMPLETED. It will take up to five circles to complete calibration. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 87 • Rounding of the displayed values to the nearest 0.1 gallon (liter) 1. Drive the vehicle at least 5 miles (8 km) with the speed control system engaged to display a stabilized average. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 88 Pressing the RESET control cycles the message center through each of the systems being monitored. The sequence of the system check report and how it appears in the message center is as follows: 1. FUEL LEVEL 2. ENGINE TEMP 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 89 2. Press the RESET control to select the new Autolamp delay values of >0, >10, >20, >30, >60, >90, >120 or >180. Language 1. Select this function from the SETUP menu for the current language to be displayed. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 90 Door ajar Warning can be reset Low fuel level Warning returns after 10 minutes Check charging system Low brake fluid level Low oil pressure Check engine temperature Reduced engine power Stop engine safely 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 91 Refer to Engine oil in the Maintenance and Specifications chapter for information about adding engine oil. If the oil level is OK and this warning persists, shut down the engine immediately and contact your authorized dealer for service. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 92 Make sure that the mat does not interfere with the operation of the accelerator or the brake pedal. To remove the floor mat, reverse the installation procedure. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 93: Tailgate
5. Lift right side off of its hinge. 6. Lift tailgate to a 80–degree angle from horizontal. 7. Remove tailgate from left side hinge by sliding tailgate to the right. To install, follow the removal procedures in reverse order. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 94 The bed extender should always be kept in the stowed position with the tailgate closed when not in use. When driving the vehicle off road, the bed extender should be in the stowed position and the tailgate closed. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 95 Note: Remove and store the bed extender when not in use. To install the bed extender, follow the removal procedure in reverse order. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 96: Locks And Security
• Pressing the manual lock button on the door. • Operating the remote entry transmitter. • Operating the keyless entry keypad. • Operating the driver’s door with a key. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 97 • weather conditions, • nearby radio towers, • structures around the vehicle, or • other vehicles parked next to your vehicle. Your vehicle is equipped with a remote entry system which allows you to: 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 98 (while the accompanying door is open). (lock) and (unlock) features will work again after: • a door has become ajar, 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 99 (the memory position corresponds to the transmitter being used). Activating the memory feature To activate this feature: 1. Position the seat and adjustable pedals to the positions you desire. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 100 1. Twist a thin coin between the two halves of the remote entry transmitter near the key ring. DO NOT TAKE THE RUBBER COVER AND CIRCUIT BOARD OFF THE FRONT HOUSING OF THE REMOTE ENTRY TRANSMITTER. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 101 If all remote entry transmitters are not present during the programming procedure, the transmitters that are not present during programming will no longer operate the vehicle. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 102 • the remote transmitter lock control is pressed, or • after 25 seconds of illumination. The dome lamp control (if equipped) must not be set to the off position for the illuminated entry system to operate. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 103 4. Within five seconds, press the control two times. Note: One horn chirp should be heard, indicating the system has been disabled. Conversely, a horn chirp followed by a honk will indicate the system is 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 104 (if equipped). Before following the activation or deactivation procedures, unlock all doors using the power door lock/unlock control and ensure all vehicle doors are closed. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 105 Message center procedure For information regarding the activation and deactivation of the autolocks feature using the message center, refer to Message center (if equipped) in the Driver Controls chapter. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 106 1. Enter the factory set code (keypad will illuminate when pressed). 2. Within five seconds press the 1 • 2 on the keypad. 3. Enter your personal 5-digit code. Each number must be entered within five seconds of each other. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 107: Anti-Theft System
The authorized dealer can program your spare keys to your vehicle or you can program the keys yourself. Refer to Programming spare keys for instructions on how to program the coded key. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 108 Note: The SecuriLock passive anti-theft system is not compatible with non-Ford aftermarket remote start systems. Use of these systems may result in vehicle starting problems and a loss of security protection. Note: Large metallic objects, electronic devices that are used to purchase gasoline or similar items, or a second coded key on the same key chain may cause vehicle starting issues.
Page 109 3 (ON) position for at least one second but no more than ten seconds). 4. Turn the ignition from the 3 (ON) position back to the 1 (OFF/LOCK) position in order to remove the second coded key from the ignition. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 110 Steps 1 through 5. If failure repeats, bring your vehicle to your authorized dealer to have the new spare key(s) programmed. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 111: Seating And Safety Restraints
Head restraints help to limit head motion in the event of a rear collision. Adjust your head restraint so that it is located directly or as close as possible behind your head. The head restraints can be moved up and down. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 112 Make sure that the seat is relatched into place. • Pull the release lever handle located on the side of the seat up to move the seat back forward or backward. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 113 Reclining the seatback can cause an occupant to slide under the seat’s safety belt, resulting in severe personal injuries in the event of a collision. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 114 The control is located on the outboard side of the seat cushion. Press the front or rear portion to tilt the seat. Press the control to move the seat forward, backward, up or down. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 115 To properly adjust your head restraints, lift the head restraint so that it is located directly behind your head or as close to that position as possible. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 116 The rear seat has a split 60/40 cushion. Each seat cushion can be flipped up into the seatback position. 1. Pull control to release seat cushion. 2. Rotate seat cushion up until it locks into vertical storage position. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 117: Safety Restraints
How does the Personal Safety System work? The Personal Safety System can adapt the deployment strategy of your vehicle’s safety devices according to crash severity and occupant 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 118 For other occupants, this occurs when the occupant is not properly restrained by safety belts or child safety seats 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 119 The safety belt pretensioners can be either activated alone or, if the collision is of sufficient severity, together with the airbags. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 120 Always drive and ride with your seatback upright and the lap belt snug and low across the hips. To reduce the risk of injury, make sure children sit in the back seat where they can be properly restrained. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 121 Safety belts and seats can become hot in a vehicle that has been closed up in sunny weather; they could burn a small child. Check seat covers and buckles before you place a child anywhere near them. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 122 If you carry large cargo behind the seat or items that might damage or soil the belt, detach the belt from the seat: 1. Release the mini-buckle by inserting a key or safety belt tongue into the slot. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 123 The cinch tongue will slide up and down the belt webbing when the belt is stowed or while putting safety belts on. When the lap/shoulder safety belt is buckled, the cinch tongue will allow the lap portion to be 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 124 The lap belt should fit snugly and as low as possible around the hips, not across the waist. Front and rear seat occupants, including pregnant women, should wear safety belts for optimum protection in an accident. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 125 To tighten the belt, pull the loose end of the belt through the tongue until it fits snugly across the hips. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 126 In this mode, the shoulder belt is automatically pre-locked. The belt will still retract to remove any slack in the shoulder belt. The automatic locking mode is not available on the driver safety belt, or the Regular Cab center safety belt. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 127 Refer to Safety Restraints for Children or Safety Seats for Children later in this chapter. How to use the automatic locking mode 1. Buckle the combination lap and shoulder belt. • Right front passenger seat • Rear seats (if equipped) 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 128 Do NOT place objects between the seats, as this could interfere with the functioning of the pretensioner. The driver and front outboard passenger safety belt pretensioners are designed to activate only during certain frontal or near-frontal collisions 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 129 The Personal Safety System provides the most benefit to belted occupants. The system monitors and tailors the air bag deployment based upon safety belt usage. Failure to properly wear your safety belt will increase your risk of injury. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 130 Safety belt warning light and indicator chime The safety belt warning light illuminates in the instrument cluster and a chime sounds to remind the occupants to fasten their safety belts. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 131 If the BeltMinder warnings have expired (warnings for approximately 5 minutes) for one occupant (driver or front passenger), the other occupant can still activate the BeltMinder feature. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 132 1 in 4 of us will be seriously injured in a crash during our lifetime. “I’m not going far” 3 of 4 fatal crashes occur within 25 miles of home. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 133 One time disable If at any time the driver/front passenger quickly buckles then unbuckles the BeltMinder feature for that seating position, the BeltMinder disabled for the current ignition cycle. The BeltMinder feature will 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 134 • This will disable the BeltMinder feature for that seating position if it is currently enabled. As confirmation, the restraint system warning light will flash 4 times per second for 3 seconds. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 135 (if equipped), shoulder belt guide on seatback (if equipped), child safety seat LATCH and tether anchors, and attaching hardware, should be inspected after a collision. Ford Motor Company recommends that all safety belt assemblies in use in vehicles involved in a collision be replaced.
Page 136: Airbags
Safety System. They are designed to be deployed in cases where the Personal Safety System has determined the occupant conditions and crash severity are appropriate to activate these devices. Refer to the Personal Safety System section in this chapter. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 137 To properly position yourself away from the airbag: • Move your seat to the rear as far as you can while still reaching the pedals comfortably. • Recline the seat slightly one or two degrees from the upright position. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 138 Additional equipment may affect the performance of the airbag sensors increasing the risk of injury. Please refer to the Body Builders Layout Book for instructions about the appropriate installation of additional equipment. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 139 This arrangement provides lap and shoulder belt protection for all occupants, and airbag protection for the adults. A child or infant properly restrained in the center front seat should not incur risk of serious injury from the airbags. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 140 Thus, it is extremely important that occupants be properly restrained as far away from the airbag cover as possible while maintaining vehicle control. Several airbag system components get hot after inflation. Do not touch them after inflation. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 141 The sensors are designed to detect the presence of a properly seated occupant and determine if the front passenger’s frontal airbag should be enabled (may inflate) or disabled (will not inflate). 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 142 The front passenger sensing system is designed to enable (may inflate) the front passenger’s frontal airbag anytime the system senses that a person of adult size is sitting properly in the front passenger seat. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 143 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 144 The front passenger airbag is not designed to offer protection to an occupant in the center seating position. An out of position front center occupant could affect the decision of the front passenger sensing system. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 145: Child Restraints
Seating and Safety Restraints If it is necessary to modify an advanced front airbag system to accommodate a person with disabilities, contact the Ford Customer Relationship Center at the phone number shown in the Customer Assistance section of this Owner’s Guide.
Page 146 To improve the fit of both the lap and shoulder belt on children who have outgrown child safety seats, Ford Motor Company recommends use of a belt-positioning booster. Booster seats position a child so that safety belts fit better. They lift the child up so that the lap belt rests low across the hips and the knees bend comfortably.
Page 147 Either type can be used at any seating position equipped with lap/shoulder belts if your child is over 40 lb. (18 kg). 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 148 Never put the shoulder belt under a child’s arm or behind the back because it eliminates the protection for the upper part of the body and may increase the risk of injury or death in a collision. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 149 (passenger side front and rear seating positions-SuperCrew and SuperCab) (if equipped). • LATCH lower anchors are recommended for use by children up to 22 kg (48 pounds) in a child restraint. Top tether anchors can be used 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 150 36 kg (80 pounds) using an upper torso harness and a belt-positioning booster. Ford recommends the use of a child safety seat having a top tether strap. Install the child safety seat in a seating position with LATCH and tether anchors.
Page 151 3. While holding the shoulder and lap belt portions together, route the tongue through the child seat according to the child seat manufacturer’s instructions. Be sure the belt webbing is not twisted. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 152 7. Pull the lap belt portion across the child seat toward the buckle and pull up on the shoulder belt while pushing down with your knee on the child seat. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 153 Always use both lap and shoulder safety belt in the Regular Cab center seating position. 1. Position the child safety seat in the Regular Cab center front seat. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 154 4. While holding both shoulder and lap portions next to the tongue, route the tongue and webbing through the child seat according to the child seat manufacturer’s instructions. Be sure that the belt webbing is not twisted. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 155 To check this, grab the seat at the belt path and attempt to move it side to side and forward and back. There should be no more than one inch of movement for proper installation. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 156 Tether straps are available as an accessory for many older safety seats. Contact the manufacturer of your child seat for information about ordering a tether strap. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 157 1. Position the child safety seat on the seat cushion. 2. Route the child safety seat tether strap over the back of the seat and under the head restraint. 3. Locate the correct anchor for the selected seating position. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 158 5. Install the child safety seat tightly using the LATCH anchors or safety belts. Follow the instructions in this chapter. 6. Tighten the child safety seat tether strap according to the manufacturer’s instructions. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 159 Many tether straps cannot be tightened if the tether strap is hooked to the loop directly behind the child seat. To provide a tight tether strap: 1. Route the tether strap under the head restraint and through the loop directly behind the child seat. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 160 This type of child seat eliminates the need to use safety belts to attach the child seat. For forward-facing child seats, the tether strap must also be attached to the proper tether anchor. See Attaching safety seats with tether straps in this chapter. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 161 Follow the child seat manufacturer’s instructions to properly install a child seat with LATCH attachments. Attach LATCH lower attachments of the child seat only to the anchors shown. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 162 Also try to tug the seat forward. Check to see if the anchors hold the seat in place. If the safety seat is not anchored properly, the risk of a child being injured in a crash greatly increases. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 163: Tires, Wheels And Loading
A vehicle equipped with AWD or 4WD (when selected) has the ability to use all four wheels to power itself. This increases traction which may enable you to safely drive over terrain and road conditions that a conventional two-wheel drive vehicle cannot. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 164 All other things held equal, a shorter wheelbase may make your vehicle quicker to respond to steering inputs than a vehicle with a longer wheelbase. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 165: Tire Information
10 to 12 inches or limited production tires as defined in Title 49 Code of Federal Regulations Part 575.104(c)(2). U.S. Department of Transportation-Tire quality grades: The U.S. Department of Transportation requires Ford Motor Company to give you the following information about tire grades exactly as the government has written it.
Page 166 Glossary of tire terminology • Tire label: A label showing the OE (Original Equipment) tire sizes, recommended inflation pressure and the maximum weight the vehicle can carry. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 167: Tire Inflation
INFLATING YOUR TIRES Safe operation of your vehicle requires that your tires are properly inflated. Remember that a tire can lose up to half of its air pressure without appearing flat. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 168 Always inflate your tires to the Ford recommended inflation pressure even if it is less than the maximum inflation pressure information found on the tire. The Ford recommended tire inflation pressure is found on the Safety Compliance Certification Label or Tire Label which is located on the B-Pillar or the edge of the driver’s door.
Page 169 For Full Size and Dissimilar spare tires (see Dissimilar Spare Tire/Wheel Information section for description): Store and maintain at the higher of the front and rear inflation pressure as shown on the Safety Compliance Certification Lable or the Tire Label. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 170 If damage is observed or suspected have the tire inspected by a tire professional. Tires can be damaged during off-road use, so inspection after off-road use is also recommended. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 171 Only use replacement tires and wheels that are the same size and type (such as P-metric versus LT-metric or all-season versus all-terrain) as those originally provided by Ford. Use of any tire or wheel not recommended by Ford can affect the safety and performance of your vehicle, which could result in an increased risk of loss of vehicle control, vehicle rollover, personal injury and death.
Page 172 Have an authorized dealer check the wheel alignment periodically. Wheel misalignment in the front or the rear can cause uneven and rapid treadwear of your tires and should be corrected by an authorized dealer. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 173 If you have a dissimilar spare tire/wheel it is intended for temporary use only and should not be used in a tire rotation. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 174 6. 95: Indicates the tire’s load index. It is an index that relates to how much weight a tire can carry. You may find this information in your Owner’s Guide. If not, contact a local tire dealer. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 175 For example, 2501 means the 25th week of 2001. The numbers in between are identification codes used for traceability. This information is used to contact customers if a tire defect requires a recall. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 176 The cold inflation pressure should never be set lower than the recommended pressure on the vehicle label. The tire suppliers may have additional markings, notes or warnings such as standard load, radial tubeless, etc. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 177 4. Maximum Load Single lb. (kg) at psi (kPa) cold: Indicates the maximum load and tire pressure when the tire is used as a single; defined as two tires (total) on the rear axle. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 178 Snow tires must be the same size and grade as the tires you currently have on your vehicle. The tires on your vehicle have all weather treads to provide traction in rain and snow. However, in some climates, you may need to use snow 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 179: Vehicle Loading
It does not include passengers, cargo, or optional equipment. Vehicle Curb Weight – is the weight of your new vehicle when you picked it up from your authorized dealer plus any aftermarket equipment. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 180 Overloading or improperly loading your vehicle can contribute to loss of vehicle control and vehicle rollover. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 181 GAW (Gross Axle Weight) – is the total weight placed on each axle (front and rear) – including vehicle curb weight and all payload. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 182 Note: For trailer towing information refer to Trailer towing found in this chapter or the RV and Trailer Towing Guide provided by your authorized dealer. GVW (Gross Vehicle Weight) – is the Vehicle Curb Weight + cargo + passengers. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 183 Maximum Loaded Trailer Weight – is the highest possible weight of a fully loaded trailer the vehicle can tow. It assumes a vehicle with only mandatory options, no cargo (internal or external), a tongue load of 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 184 = 650 lb.). In metric units (635–340 (5 x 68) = 295 kg.) 5. Determine the combined weight of luggage and cargo being loaded on the vehicle. That weight may not safely exceed the available cargo and luggage load capacity calculated in Step 4. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 185 Front or the Rear Gross Axle Weight Rating specified for your vehicle on the Safety Compliance Certification Label found on the edge of the driver’s door. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 186: Trailer Towing
Towing trailers beyond the maximum recommended gross trailer weight exceeds the limit of the vehicle and could result in engine damage, transmission damage, structural damage, loss of vehicle control, vehicle rollover and personal injury. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 187 4.6L 3.55 11700 (5307) 6700 (3039) 4.6L 3.73 12200 (5534) 7200 (3266) 5.4L 3.55 14000 (6350) 8800 (3992) 5.4L 3.73 15000 (6804) 9800 (4445) 5.4L Heavy Duty 4.10 15300 (6940) 9900 (4491) 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 188 7800 (3538) or 20” tires) 5.4L (with 17” 3.73 15000 (6804) 9300 (4218) tires) 5.4L (with 18” 3.73 14500 (6577) 8800 (3992) or 20” tires) 5.4L Heavy Duty 4.10 15300 (6940) 9500 (4309) 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 189 11200 (5081) 5900 (2677) tires) 4.6L (with 17” 3.73 12200 (5534) 6900 (3130) tires) 4.6L (with 18” 3.73 11700 (5307) 6400 (2903) tires) 5.4L (with 17” 3.55 14000 (6350) 8600 (3901) tires) 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 190 11500 (5216) 6000 (2721) tires) 4.6L (with 18” 3.55 11000 (4990) 5500 (2494) tires) 4.6L (with 17” 3.73 12000 (5443) 6500 (2948) tires) 4.6L (with 18” 3.73 12500 (5670) 6000 (2721) tires) 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 191 5.4L (with 18” 3.55 13500 (6123) 7800 (3538) or 20” tires) 5.4L (with 17” 3.73 15000 (6804) 9300 (4218) tires) 5.4L (with 18” 3.73 14500 (6577) 8800 (3992) or 20” tires) 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 192 Tires, Wheels and Loading Super Cab 4x4 (144.5” wheelbase) Harley-Davidson Version (not available for F-150 Lobo) Engine Rear axle ratio Maximum Maximum GCWR-lb. (kg) trailer weight-lb. (kg) 5.4L 3.73 11500 (5216) 5600 (2540) SuperCab 4x4 (163” wheelbase) Engine Rear axle ratio...
Page 193 6200 (2812) tires) 5.4L (with 17” 3.55 14000 (6350) 8400 (3810) tires) 5.4L (with 18” 3.55 13500 (6123) 7900 (3583) or 20” tires) 5.4L (with 17” 3.73 15000 (6804) 9400 (4263) tires) 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 194 Do not use hitches that clamp onto the vehicle’s bumper or attach to the axle. You must distribute the load in your trailer so that 10%–15% of the total weight of the trailer is on the tongue. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 195 The braking system of the tow vehicle is rated for operation at the GVWR not GCWR. Trailer lamps Trailer lamps are required on most towed vehicles. Make sure all running lights, brake lights, turn signals and hazard lights are working. See your 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 196 • The trailer tongue weight should be 10–15% of the loaded trailer weight. • If you will be towing a trailer frequently in hot weather, hilly conditions, at GCW, or any combination of these factors, consider 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 197: Recreational Towing
These guidelines are designed to ensure that your transmission is not damaged. 4x4 vehicles equipped with manual-shift transfer case: • Release the parking brake. • Turn the key in the ignition to the OFF position. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 198 If a distance of 50 miles (80 km) or a speed of 35 mph (56 km/h) must be exceeded, you must disconnect the front (4x4 only) and rear driveshafts. Ford recommends the driveshafts be removed/installed only by a qualified technician at an authorized dealer. See your authorized dealer for driveshaft removal/installation.
Page 199 Vehicles equipped with the Control Trac four-wheel drive system cannot be towed with any wheels on the ground. See your authorized dealer if you must flat-tow a vehicle equipped with the Control Trac four-wheel drive system. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 200: Driving
Do not park, idle, or drive your vehicle in dry grass or other dry ground cover. The emission system heats up the engine compartment and exhaust system, which can start a fire. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 201 Seating and Safety Restraints chapter. 2. Make sure the headlamps and vehicle accessories are off. If starting a vehicle with an automatic transmission: • Make sure the gearshift is in P (Park). 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 202 3. Turn the key to 3 (ON) without turning the key to 4 (START). Some warning lights will briefly illuminate. See Warning lights and chimes in the Instrument Cluster chapter for more information regarding the warning lights. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 203 Your vehicle is designed to operate on E ethanol alone, unleaded gasoline alone, or any mixture of the two. See Choosing the right fuel in the Maintenance and Specifications chapter for more information on ethanol. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 204: Brakes
If the vehicle has continuous vibration or shudder in the steering wheel while braking, the vehicle should be inspected by an authorized dealer. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 205 ABS may be disabled and may need to be serviced. Even when the ABS is disabled, normal braking is still effective. (If your BRAKE warning lamp illuminates with the parking brake released, have your brake system serviced immediately.) 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 206 To release, pull the lever (2). Always set the parking brake fully and make sure that the gearshift is securely latched in P (Park) (automatic transmission) or in 1 (First) (manual transmission). 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 207: Traction Control
Traction Control button will not turn the system on or off and your vehicle should be serviced by an authorized dealer. STEERING To help prevent damage to the power steering system: 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 208 Avoid sharp turns, excessive speed and abrupt maneuvers in these vehicles. Failure to drive cautiously could result in an increased risk of loss of vehicle control, vehicle rollover, personal injury and death. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 209: Transmission Operation
N (Neutral). 4. Reinstall the access plug cover, start the vehicle and release the parking brake. Do not drive your vehicle until you verify that the brakelamps are working. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 210 Using a screwdriver, carefully pry off the console finish panel surrounding the shifter mechanism by inserting a screwdriver into the latch slot as shown. 3. Remove console finish panel assembly to expose the inside of the gearshift. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 211 If the parking brake is fully released, but the brake warning lamp remains illuminated, the brakes may not be working properly. See your authorized dealer. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 212 • Move the gearshift lever into the desired gear • Release the parking brake. To put your vehicle in P (Park): • Come to a complete stop • Move the gearshift lever and securely latch it in P (Park) 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 213 R N D 2 1 Overdrive can be deactivated by pressing the transmission control switch on the end of the gearshift lever (column-shift transmission) or on the gearshift bezel (floor-shift transmission). • Column-shift transmission 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 214 • To return to D (Overdrive), move the gearshift lever into the D (Overdrive) position. • Selecting 2 (Second) at higher speeds will cause the transmission to downshift to second gear at the appropriate vehicle speed. 1 (First) • Provides maximum engine braking. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 215 3. Start the engine, then press the brake pedal and release the parking brake. 4. Move the gearshift lever to 1st gear, then slowly release the clutch pedal while slowly pressing on the accelerator. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 216 43 mph (69 km/h) 17 mph (27 km/h) (Overdrive) Maximum downshift speeds Shift from: Transfer case position (if equipped) 2H or 4H 55 mph (89 km/h) 21 mph (34 km/h) (Overdrive) - 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 217 “parking speeds”. Inclement weather may also affect the function of the RSS; this may include reduced performance or a false activation. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 218 If the tailgate is down, the RSS tone may be heard intermittently or continuously. The tone may also be heard if items in the truck bed protrude rearward outside the bed. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 219 Refer to Shifting to/from 4WD Low for proper operation. System indicator lights • 4X4 HI - Momentarily illuminates 4x4 HI when the engine is started. Illuminates when 4H is selected. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 220 Note: Some noise may be heard as the system shifts or engages; this is normal. Shifting to/from 4L (4WD Low) 1. Bring the vehicle to a complete stop. 2. Depress the brake. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 221 Provides optimal smoothness and fuel economy at high speeds. 4H (4WD High) - Used for extra traction such as in snow or icy roads or in off-road situations. Not intended for use on dry pavement. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 222 (if equipped, Harley-Davidson only) This system includes an electronically controlled transfer case. The system is interactive with the road, continually monitoring and adjusting torque delivery to the front and rear wheels to optimize traction. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 223 Drive cautiously to avoid vehicle damage from concealed objects such as rocks and stumps. You should either know the terrain or examine maps of the area before driving. Map out your route before driving in the area. To maintain 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 224 If your vehicle gets stuck in mud or snow it may be rocked out by shifting between forward and reverse gears, stopping between shifts, in a steady pattern. Press lightly on the accelerator in each gear. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 225 (steering, acceleration or braking). Again, avoid these abrupt inputs. Parking On some 4WD vehicles, when the transfer case is in the N (Neutral) position, the engine and transmission are disconnected from the rest of 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 226 When driving over sand, try to keep all four wheels on the most solid area of the trail. Avoid reducing the tire pressures but shift to a lower gear and drive steadily through the terrain. Apply the accelerator slowly and avoid spinning the wheels. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 227 Ford Motor Company joins the U.S. Forest Service and the Bureau of Land Management in encouraging you to help preserve our national forest and other public and private lands by “treading lightly.”...
Page 228 Rapid pumping of the brake pedal will help you slow the vehicle and still maintain steering control. If your vehicle has anti-lock brakes, apply the brakes steadily. Do not “pump” the brakes. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 229 Ford Motor Company recommends that caution be used with any vehicle equipped with a high load or device (such as ladder racks or pickup box cover).
Page 230 Snow Plow Prep Package is not available. Installing the snowplow Weight limits and guidelines for selecting and installing the snowplow can be found in the Ford Truck Body Builders Layout Book, Snowplow section, found at www.fleet.ford.com/truckbbas. A typical installation affects the following: •...
Page 231 Operating the vehicle with the snowplow attached Ford recommends that the F–150 be limited to low speed, personal-use snow removal. Do not use your vehicle for snow removal until it has been driven at least 500 miles (800 km).
Page 232 Do not attempt to service, repair, or modify the air bag supplemental restraint system (SRS) or its fuses. See your Ford or Lincoln Mercury dealer. Transmission operation while plowing •...
Page 233: Roadside Emergencies
50,000 miles (80,000 km) on Lincoln vehicles. Roadside assistance will cover: • a flat tire change with a good spare (except Ford GT which has a tire inflation kit) • battery jump start • lock-out assistance (key replacement cost is the customer’s responsibility) •...
Page 234 1–800–241–3673; Lincoln vehicle customers call 1–800–521–4140. Canadian customers who require roadside assistance, call 1–800–665–2006. If you need to arrange roadside assistance for yourself, Ford Motor Company will reimburse a reasonable amount. To obtain reimbursement information, U.S. Ford or Mercury vehicles customers call 1–800–241–3673;...
Page 235: Hazard Flasher Switch
This device stops the electric fuel pump from sending fuel to the engine when your vehicle has had a substantial jolt. After an accident, if the engine cranks but does not start, this switch may have been activated. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 236: Fuses And Relays
Note: Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 237 To reinstall the fuse box cover, place the top part of the cover on the fuse panel, then push the bottom part of the cover until you hear it click shut. Gently pull on the cover to make sure it is seated properly. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 238 Radio (start signal) 10A* Heated mirrors, Switch indicator 20A* Fuel pump relay, Fuel injectors, Intake manifold runner control (4.2L) 20A* Trailer tow back-up lamps relay (PCB1), Trailer tow parklamp relay (R201) 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 239 LH low beam headlamp 20A* Horn relay (PCB3), Horn power Passenger Air bag Deactivation (PAD) warning lamp, Cluster air bag warning lamp, Cluster RUN /START power SecuriLock transceiver (PATS), PCM IGN monitor 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 240 ABS valves — Not used 30A** Electric trailer brakes 30A** Trailer tow battery charge 30A** Power door locks (BSM) 30A** Passenger power seat 30A** Driver power seat, Adjustable pedals — Not used 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 241 Trailer tow battery charge relay Full ISO Blower motor relay R201 Half ISO Trailer tow park lamps relay R202 Half ISO Fog lamps relay R203 Half ISO relay * Mini fuses ** Cartridge fuses 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 242 Location Rating Clockspring illumination Full ISO 4x4 CCW Relay Full ISO 4x4 CW Relay ⁄ Daytime Running Lamps (DRL) high beam Relay disable R201 Relay R202 Relay A/C clutch Diode A/C clutch 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 243: Changing Tires
Ford. If the dissimilar spare tire or wheel is damaged, it should be replaced rather than repaired.
Page 244 • Driving vehicles equipped with a camper body • Driving vehicles with a load on the cargo rack Drive cautiously when using a full-size dissimilar spare tire/wheel and seek service as soon as possible. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 245 3. Turn the handle counterclockwise until tire is lowered to the ground, the tire can be slid rearward and the cable is slightly slack. 4. Slide the retainer through the center of the wheel. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 246 5. Use the tip of the lug wrench to remove any wheel trim. 6. Loosen each wheel lug nut one-half turn counterclockwise but do not remove them until the wheel is raised off the ground. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 247 If the vehicle slips off the jack, someone could be seriously injured. • Front Note: Use the frame rail as the jacking location point, NOT the control arm. • Rear 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 248 12. Stow the flat tire. Refer to Stowing the flat/spare tire. 13. Stow the jack and lug wrench. Make sure the jack is fastened so it does not rattle when you drive. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 249 6. If removed, install the spare tire lock (if equipped) into the bumper drive tube with the spare tire lock key (if equipped) and jack handle. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 250: Lug Nut Torque
M14 x 2.0 * Torque specifications are for nut and bolt threads free of dirt and rust. Use only Ford recommended replacement fasteners. When a wheel is installed, always remove any corrosion, dirt or foreign materials present on the mounting surfaces of the wheel or the surface of the wheel hub, brake drum or brake disc that contacts the wheel.
Page 251 Connecting the jumper cables 1. Connect the positive (+) jumper cable to the positive (+) terminal of the discharged battery. Note: In the illustrations, lightning bolts are used to designate the assisting (boosting) battery. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 252 2. Connect the other end of the positive (+) cable to the positive (+) terminal of the assisting battery. 3. Connect the negative (-) cable to the negative (-) terminal of the assisting battery. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 253 2. Start the engine of the disabled vehicle. 3. Once the disabled vehicle has been started, run both engines for an additional three minutes before disconnecting the jumper cables. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 254 1. Remove the jumper cable from the ground metal surface. Note: In the illustrations, lightning bolts are used to designate the assisting (boosting) battery. 2. Remove the jumper cable on the negative (-) connection of the booster vehicle’s battery. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 255 4. Remove the jumper cable from the positive (+) terminal of the disabled vehicle’s battery. After the disabled vehicle has been started and the jumper cables removed, allow it to idle for several minutes so the engine computer can relearn its idle conditions. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 256: Wrecker Towing
Ford recommends your vehicle be towed with a wheel lift or flatbed. Do not tow with a slingbelt. Ford Motor Company has not approved a slingbelt towing procedure.
Page 257: Customer Assistance
Center at 1-800-392-3673 (FORD). Away from home If you own a Ford or Mercury vehicle and are away from home when your vehicle needs service, or if you need more help than the authorized dealer could provide, after following the steps described above, contact the Ford Customer Relationship Center to find an authorized dealer to help you.
Page 258 If you own a Lincoln vehicle and are away from home when your vehicle needs service, or if you need more help than the authorized dealer could provide, after following the steps described above, contact the Ford Customer Relationship Center to find an authorized dealer to help you.
Page 259 Customer Assistance In some states (in the U.S.) you must directly notify Ford in writing before pursuing remedies under your state’s warranty laws. Ford is also allowed a final repair attempt in some states. In the United States, a warranty dispute must be submitted to the BBB...
Page 260 You are not bound by the decision but may choose to accept it. If you choose to accept the BBB AUTO LINE decision then Ford must abide by the accepted decision as well. If the arbitrator has decided in...
Page 261 United States and Canada, provided by a network of more than 4,600 participating authorized dealers. If you did not take advantage of the Ford Extended Service Plan at the time of purchasing your vehicle, you may still be eligible. Since this...
Page 262 The use of leaded fuel in your vehicle without proper conversion may damage the effectiveness of your emission control system and may cause engine knocking or serious engine damage. Ford Motor Company/Ford of Canada is not responsible for any damage caused by use of improper fuel.
Page 263: Reporting Safety Defects (U.s. Only)
Obtaining a French owner’s guide French Owner’s Guides can be obtained from your authorized dealer or by writing to Ford Motor Company of Canada, Limited, Service Publications, P.O. Box 1580, Station B, Mississauga, Ontario L4Y 4G3. REPORTING SAFETY DEFECTS (U.S. ONLY)
Page 264: Cleaning
• Never use abrasive materials such as steel wool or plastic pads as they can scratch the chrome surface. WAXING Applying Motorcraft Paint Sealant (ZC-45) to your vehicle every six months will assist in reducing minor scratches and paint damage. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 265 • To remove tar and grease, use Motorcraft Bug and Tar Remover (ZC-42), available from your authorized dealer. ENGINE Engines are more efficient when they are clean because grease and dirt buildup keep the engine warmer than normal. When washing: 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 266 • Spray Motorcraft Engine Shampoo and Degreaser (ZC-20) on all parts that require cleaning and pressure rinse clean. • Cover the highlighted areas to prevent water damage when cleaning the engine. • 4.2L engine • 4.6L engine 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 267 Motorcraft Ultra-Clear Spray Glass Cleaner (ZC-23), available from your authorized dealer. • The wiper blades can be cleaned with isopropyl (rubbing) alcohol or Motorcraft Premium Windshield Washer Concentrate (ZC-32–A), 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 268 In order to maintain the finish of the instrument panel and console, the high gloss areas should be treated similar to the that of exterior paint or glossy plastic surfaces. When cleaning the high gloss areas: • Do not use paper towels or newspaper. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 269 • Remove light stains and soil with Motorcraft Professional Strength Carpet & Upholstery Cleaner (ZC-54). • If grease or tar is present on the material, spot-clean the area first with Motorcraft Spot and Stain Remover (ZC-14). 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 270 Note: In some instances, color or dye transfer can occur when wet clothing comes in contact with leather upholstery. If this occurs, the leather should be cleaned immediately to avoid permanent staining. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 271 • Clean the surfaces using the steps outlined in the Cleaning section. • Ensure the leather is dry then apply a nickel-sized amount of conditioner to a clean, dry cloth 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 272 FORD AND LINCOLN MERCURY CAR CARE PRODUCTS Your Ford or Lincoln Mercury authorized dealer has many quality products available to clean your vehicle and protect its finishes. These quality products have been specifically engineered to fulfill your automotive needs;...
Page 273 Motorcraft Tire Clean and Shine (ZC-28) Motorcraft Triple Clean (U.S. only) (ZC-13) Motorcraft Ultra-Clear Spray Glass Cleaner (ZC-23) Motorcraft Vinyl Cleaner (Canada only) (CXC-93) Motorcraft Vinyl Conditioner (Canada only) (CXC-94) Motorcraft Wheel and Tire Cleaner (ZC-37–A) 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 274: Maintenance And Specifications
(First). 2. Turn off the engine and remove the key. 3. Block the wheels. Working with the engine on • Automatic transmission: 1. Set the parking brake and shift to P (Park). 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 275 2. Go to the front of the vehicle and release the auxiliary latch that is located on the front bumper under the grill. 3. Lift the hood until the lift cylinders hold it open. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 276: Engine Compartment
4. Engine coolant reservoir 5. Power steering fluid reservoir 6. Air filter assembly 7. Engine oil filler cap 8. Engine oil dipstick 9. Transmission fluid dipstick (automatic transmission) 10. Windshield washer fluid reservoir 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 277 2. Transmission fluid dipstick (automatic transmission) 3. Engine oil filler cap 4. Engine oil dipstick 5. Brake fluid reservoir 6. Power steering fluid reservoir 7. Engine coolant reservoir 8. Air filter assembly 9. Windshield washer fluid reservoir 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 278 2. Transmission fluid dipstick (automatic transmission) 3. Air filter assembly 4. Engine oil dipstick 5. Brake fluid reservoir 6. Engine coolant reservoir 7. Power steering fluid reservoir 8. Engine oil filler cap 9. Windshield washer fluid reservoir 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 279 2. Attach the new wiper to the wiper arm and press it into place until a click is heard. Replace wiper blades at least once per year for optimum performance. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 280: Engine Oil
3. Set the parking brake and ensure the gearshift is securely latched in P (Park) (automatic transmission) or 1 (First) (manual transmission). 4. Open the hood. Protect yourself from engine heat. • 4.2L V6 engine 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 281 • If the oil level is between the lower and upper holes or between the MIN and MAX marks (depending on application), the oil level is acceptable. DO NOT ADD OIL. • 4.2L V6 engine 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 282 1/4 of a turn until three clicks are heard or until the cap is fully seated. To avoid possible oil loss, DO NOT operate the vehicle with the engine oil level indicator and/or the engine oil filler cap removed. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 283 Change your engine oil and filter according to the appropriate schedule listed in scheduled maintenance information. Ford production and aftermarket (Motorcraft) oil filters are designed for added engine protection and long life. If a replacement oil filter is used that does not meet Ford material and design specifications, start-up engine noises or knock may be experienced.
Page 284: Battery
Therefore, do not allow flames, sparks or lighted substances to come near the battery. When working near the battery, always shield your face and protect your eyes. Always provide proper ventilation. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 285 If the battery has been disconnected or a new battery has been installed, the clock and the preset radio stations must be reset once the battery is reconnected. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 286: Engine Coolant
50–50 mixture of coolant and water provides the following: • Freeze protection down to -34°F (-36°C). • Boiling protection up to 265°F (129°C). • Protection against rust and other forms of corrosion. • Enables calibrated gauges to work properly. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 287 Do not add engine coolant when the engine is hot. Steam and scalding liquids released from a hot cooling system can burn you badly. Also, you can be burned if you spill coolant on hot engine parts. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 288 • Add Motorcraft Premium Gold Engine Coolant (yellow-colored), VC-7-A (U.S., except CA, OR, and NM), VC-7-B (CA, OR and NM), meeting Ford Specification WSS-M97B51–A1. Note: Use of Motorcraft Cooling System Stop Leak Pellets, VC-6, may darken the color of Motorcraft Premium Gold Engine Coolant from yellow to golden tan.
Page 289 Recycled engine coolant Ford Motor Company does NOT recommend the use of recycled engine coolant in vehicles originally equipped with Motorcraft Premium Gold Engine Coolant since a Ford-approved recycling process is not yet available.
Page 290 If the engine coolant supply is depleted, this feature allows the vehicle to be driven temporarily before incremental component damage is incurred. The “fail-safe” distance depends on ambient temperatures, vehicle load and terrain. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 291 2. Arrange for the vehicle to be taken to an authorized dealer. 3. If this is not possible, wait a short period for the engine to cool. 4. Check the coolant level and replenish if low. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 292: Fuel Information
Automotive fuels can cause serious injury or death if misused or mishandled. Fuel ethanol and gasoline may contain benzene, which is a cancer-causing agent. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 293 FFV, then the character will be labeled as a “V”. Pure ethanol is the alcohol which is the intoxicating agent in liquor, beer and wine. It is distilled from the fermentation of plants such as field corn 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 294 Fuel vapor burns violently and a fuel fire can cause severe injuries. To help avoid injuries to you and others: • Read and follow all the instructions on the pump island; • Turn off your engine when you are refueling; 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 295 The customer warranty may be void for any damage to the fuel tank or fuel system if the correct genuine Ford or Motorcraft fuel filler cap is not used. 2006 F-150 (f12) Owners Guide (post-2002-fmt)
Page 296 Repairs to correct the effects of using a fuel for which your vehicle was not designed may not be covered by your warranty. Cleaner air Ford endorses the use of reformulated “cleaner-burning” gasolines to improve air quality. 2006 F-150 (f12)
Page 297 “Regular” unleaded gasoline. “Premium” unleaded gasoline is not recommended (particularly in the United States) because it may cause these problems to become more pronounced. If the problems persist, see your authorized dealer. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 298 The advertised fuel capacity of the fuel tank on your vehicle is equal to the rated refill capacity of the fuel tank as listed in the Refill capacities section of this chapter. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 299 5. Follow one of the simple calculations in order to determine fuel economy: Calculation 1: Divide total miles traveled by total gallons used. Calculation 2: Multiply liters used by 100, then divide by total kilometers traveled. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 300 • Keep tires properly inflated and use only recommended size. • Operating a vehicle with the wheels out of alignment will reduce fuel economy. • Use recommended engine oil. Refer to Lubricant specifications in this chapter. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 301 EMISSION CONTROL SYSTEM Your vehicle is equipped with various emission control components and a catalytic converter which will enable your vehicle to comply with 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 302 If other than Ford, Motorcraft or Ford-authorized parts are used for maintenance replacements or for service of components affecting emission control, such non-Ford parts should be equivalent to genuine Ford Motor Company parts in performance and durability.
Page 303 To ready the on-board diagnostics system for I/M testing, a minimum of 30 minutes of city and highway driving is necessary as described below: • First, at least 10 minutes of driving on an expressway or highway. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 304 5. If the fluid is low, add fluid in small amounts, continuously checking the level until it reaches the range between the MIN and MAX lines. Be sure to put the cap back on the reservoir. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 305 If the fluid level drops, refill the fluid level to the step in the reservoir. Use only a DOT 3 brake fluid designed to meet Ford specification ESA-M6C25–A. Refer to Lubricant specifications in this chapter. Brake fluid is toxic. If brake fluid contacts the eyes, flush eyes with running water for 15 minutes.
Page 306 3. With the parking brake engaged and your foot on the brake pedal, start the engine and move the gearshift lever through all of the gear ranges. Allow sufficient time for each gear to engage. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 307 (150°F-170°F COLD FoMoCo 5L 3P -7A020- CB [66°C-77°C]). The transmission fluid should be in this range if at ambient temperature (50°F-95°F [10°C-35°C]). COLD FoMoCo 5L 3P -7A020- CB 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 308 Do not use supplemental transmission fluid additives, treatments or cleaning agents. The use of these materials may affect transmission operation and result in damage to internal transmission components. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 309 5. Install and tighten the fill plug securely. Use only fluid that meets Ford specifications. Refer to Lubricant specifications in this chapter. 2006 F-150 (f12) Owners Guide (post-2002-fmt)
Page 310 Use only fluid that meets Ford specifications. Refer to Lubricant specifications in this chapter. DRIVELINE UNIVERSAL JOINT AND SLIP YOKE Your vehicle may be equipped with universal joints that require lubrication.
Page 311: Air Filter(S)
This could cause filter damage and allow unmetered air to enter the engine if not properly seated. • 5.4L Engine 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 312 3. Install a new air filter element into the tray assembly. 4. Return air filter tray to original position by pressing firmly on the handle until all rearward movement stops and secure the two clamps. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 313: Part Numbers
PCV valve. Replace the PCV valve with one that meets Ford material and design specifications for your vehicle, such as a Motorcraft or equivalent replacement part. The customer warranty may be void for any damage to the emissions system if such a PCV valve is not used.
Page 314: Refill Capacities
6.0 quarts (5.7L) (includes SAE 5W-20 filter Premium change) Synthetic Blend Motor 4.6L engine 6.0 quarts (5.7L) Oil (US) Motorcraft SAE 5W-20 Super 5.4L engine 7.0 quarts (6.6L) Premium Motor Oil (Canada) 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 315 Motorcraft 5–speed manual 3.75 quarts (3.5L) fluid MERCON Motorcraft Automatic 4R70E 13.9 quarts (13.2L) MERCON V and 4R75E Front axle Motorcraft 4x4 vehicles 3.7 pints (2.0L) SAE 80W-90 Premium Rear Axle Lubricant 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 316 (i.e. coolers size, cooling lines, auxiliary cooler capacities). The amount of transmission fluid and fluid level should be set by the indication on the dipstick’s normal operating range. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 317: Lubricant Specifications
Add 4 oz. (118 ml) of Additive Friction Modifier XL–3 or equivalent meeting Ford specification EST-M2C118–A, for complete fill of 8.8 inch and 9.75 inch Traction-Lok axles. Service refill capacity is determined by filling the axle to the bottom of the filler hole with the vehicle on a level surface.
Page 318 Grease Hinges, latches, Motorcraft striker plates, Silicone Brake fuel filler door Caliper Grease XG-3-A ESE-M1C171–A hinge and door and Dielectric check arm Compound Motorcraft Lock cylinders Penetrating and XL-1 none Lock Lubricant 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 319 Some transmission fluids may be labeled as dual usage, such as MERCON and MERCON V. These dual usage fluids are not to be used in an automatic transmission that requires use of the MERCON type fluid. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 320 73.8 (1875) / 73.8 (1875) / height – 75.6 (1921) 75.6 (1921) 75.6 (1921) 4x2/4x4 (4) Wheelbase 126.0 (3198) / 126.0 (3198) / 144.5 (3671) / – 4x2/4x4 126.0 (3198) 126.0 (3198) 144.5 (3671) 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 321 - inches box - inches box - inches (mm) (mm) (mm) (5) Track - 67.0 (1701) 67.0 (1701) 67.0 (1701) Front (5) Track - 67.0 (1701) 67.0 (1701) 67.0 (1701) Rear 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 322 144.5 (3671) / 163.1 (4143) / – 4x2/4x4 132.5 (3366) 144.5 (3671) 163.1 (4143) (5) Track - 67.0 (1701) 67.0 (1701) 67.0 (1701) Front (5) Track - 67.0 (1701) 67.0 (1701) 67.0 (1701) Rear 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 323 (mm) inches (mm) (1) Overall length 223.8 (5685) 235.8 (5990) (2) Overall width 78.9 (2005) 78.9 (2005) (3) Overall height – 73.5 (1867) / 73.5 (1867) / 4x2/4x4 76.0 (1931) 76.0 (1931) 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 324 Styleside 5.5’ box - Styleside 6.5’ box - inches (mm) inches (mm) (4) Wheelbase 138.5 (3518) 150.5 (3823 ) (5) Track - Front 67.0 (1701) 67.0 (1701) (5) Track - Rear 67.0 (1701) 67.0 (1701) 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 325 The vehicle identification number is attached to a metal tag and is located on the driver side XXXXXXXXXXXXXXXXX instrument panel. Please note that in the graphic, XXXX is representative of your vehicle identification number. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 326 You can find a transmission/transaxle code on the Safety Compliance Certification Label. The following table tells you which transmission or transaxle each code represents. Description Code Four-speed automatic (4R70E) Four-speed automatic (4R75E) Five-speed manual (M5R2) 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 327: Accessories
GENUINE FORD ACCESSORIES FOR YOUR VEHICLE A wide selection of Genuine Ford Accessories are available for your vehicle through your local Ford or Ford of Canada dealer. These quality accessories have been specifically engineered to fulfill your automotive needs; they are custom designed to complement the style and aerodynamic appearance of your vehicle.
Page 328 • To avoid interference with other vehicle functions, such as anti-lock braking systems, amateur radio users who install radios and antennas onto their vehicle should not locate the Amateur Radio Antennas in the area of the driver’s side hood. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 329 Accessories • Electrical or electronic accessories or components that are added to the vehicle by the authorized dealer or the owner may adversely affect battery performance and durability. 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 330: Index
........269 lubricant interior trim ......269 specifications ....317, 320 plastic parts ......267 refill capacities ......314 safety belts ......269 traction lok ......208 washing ........264 waxing ........264 wheels ........265 Battery ........284 wiper blades ......267 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 331 ......314 you need .........257 service points ....276–278 Ordering additional owner’s starting after a collision ..235 literature .........262 Engine block heater ....204 Utilizing the Mediation/ Arbitration Program ....260 Engine oil ........280 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 332 Hood ..........275 filter, specifications ..292, 313 fuel pump shut-off switch ..235 improving fuel economy ..298 octane rating ....297, 320 Ignition .......200, 320 quality ........297 running out of fuel ....298 Illuminated visor mirror .....65 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 333 ........55 Octane rating ......297 headlamps .........54 Oil (see Engine oil) ....280 headlamps, flash to pass ..55 instrument panel, dimming ..56 interior lamps .....58–59 Parking brake ......206 replacing bulbs ....60, 63 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 334 Safety Belt Maintenance ..135 specifications .....313, 320 Safety belts Special notice (see Safety restraints) ..117, 120, ambulance conversions ....8 122–123, 126–128, 130 four-wheel drive vehicles ..232 utility-type vehicles ....8 Safety defects, reporting ..263 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)
Page 335 ......165, 170 power down back window ..70 Towing ........186 Windshield washer fluid and recreational towing ....197 wipers ..........64 trailer towing ......186 checking and adding fluid ..279 replacing wiper blades ...279 Traction control ......207 2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Ford F-150 Owner's Manual

Introduction

Instrument Cluster

Entertainment Systems

Climate Controls

Lights

Driver Controls

Locks and Security

Seating and Safety Restraints

Tires, Wheels and Loading

Driving

Roadside Emergencies

Customer Assistance

Cleaning

Maintenance and Specifications

Accessories

Index

Quick Links

Table of Contents

Related Manuals for Ford F-150

Summary of Contents for Ford F-150

Table of Contents