Reversi SUPREME DVD-400 N Operating Instructions Manual

Multi sided direct vent fireplace

Hide thumbs

Table Of Contents

Table of Contents

Quick Links

Download this manual

REVERSO-MANUFACTURING INC.

790 Rowntree Dairy Road, Woodbridge, Ontario, Canada L4L 5V3

Website: www.reversomfg.com Email: reverso@rogers.com

INSTALLATION AND OPERATING

REVERSO "SUPREME" DIRECT VENT FIREPLACES

For Your

If you smell gas:

1. Open windows.

2. Don't touch electrical switches.

3. Extinguish any open flame.

4. Immediately call your gas supplier.

WARNING: Improper installation, adjustment, alteration, service or maintenance can cause

injury or property damage. Refer to this manual. For assistance or for additional information,

consult a qualified installer, service agency or gas utility.

PLEASE KEEP THESE OPERATING INSTRUCTIONS FOR FUTURE REFERENCE

MANUFACTURERS OF

FIREPLACE EQUIPMENT AND ACCESSORIES

Tel: (905) 851-6701

These appliances have been tested and found to comply with the

established standards for GAS-FIRED DIRECT VENT WALL

FURNACES in CANADA and the U. S. A.

CAN1-2.17-M91, CAN/CGA I.R.#41 Section 2.12

ANSI-Z21.88a-1998/CSA2.33a 1998

INSTRUCTIONS

Multi Sided Direct Vent Fireplace

DVD-400 N (Natural Gas)

DVD-400 P (Propane)

Safety

Fax: (905) 851-8376

For Your

Do not store or use gasoline or other

flammable vapors and liquids in the

vicinity of this or any other appliance.

Safety

Rev. September 2005

Table of Contents

Summary of Contents for Reversi SUPREME DVD-400 N

Page 1 REVERSO-MANUFACTURING INC. MANUFACTURERS OF FIREPLACE EQUIPMENT AND ACCESSORIES 790 Rowntree Dairy Road, Woodbridge, Ontario, Canada L4L 5V3 Tel: (905) 851-6701 Fax: (905) 851-8376 Website: www.reversomfg.com Email: reverso@rogers.com These appliances have been tested and found to comply with the established standards for GAS-FIRED DIRECT VENT WALL FURNACES in CANADA and the U.
Page 2 IMPORTANT: SAVE THESE INSTRUCTIONS To the new owner: We at REVERSO MFG. LTD. are pleased that you have chosen one of our products for your home environment. We would like to take this opportunity to assure you that you have chosen a top quality product which will provide you with all the warmth and charm of a wood fireplace at the flick of a switch without any of the fuss and mess you would normally associate with lighting a wood fire.
Page 3: General Information
GENERAL INFORMATION All "REVERSO" gas-fired appliances must be installed in accordance with these instructions. Carefully read all of the instructions in this manual first. Consult the building authority having jurisdiction to determine the need for a permit prior to commencing the installation. NOTE: Failure to follow these instructions could cause a malfunction of the fireplace which could result in death, serious bodily injury, and/or property damage.
Page 4 Clothing or other flammable material should not be placed on or near the appliance. Always connect this gas fireplace to an approved vent system and vent to the outside of the building envelope. Never vent to another room or inside a building. Make sure that the vent is properly sized and is of adequate height to provide the proper draft.
Page 5: Specifications
SPECIFICATIONS The above models have all been certified for use with either Natural or Propane gases, suffix designated in the model number by the N (Natural Gas) or P (Propane) Both of these appliances draw all of their air for combustion from the outside of the dwelling through specially designed vent pipe.
Page 6: Electrical Requirements
TWO SIDED MODEL - CLEARANCES TO COMBUSTIBLES: As above with 4" clearance to the end of the appliance Always observe the approved clearance to combustible materials. ELECTRICAL REQUIREMENTS No external electrical power supply is required to operate the REVERSO "SUPREME" DVD400 series if these models have a Millivolt gas control which uses the pilot flame to generate enough electricity to operate the main burner whenever the manual switch provided is on.
Page 7: Gas Line Connection
GAS LINE CONNECTION WARNING: Only persons licensed to work with gas piping may make the necessary gas connections to this appliance. The appliance is provided with an opening on both sides of the control compartment. A 3/8" gas supply pipe must be brought near this inlet hole, from either the left or right hand side.
Page 8: Sidewall Venting
GAS PIPE TESTING The appliance and its shutoff valves must be disconnected from the gas supply piping system during any pressure testing where the pressure exceeds 1/2 PSIG (3.45 kpa). Always check for gas leaks with a soap and water solution, after completing the required pressure test.
Page 9 A = Clearance above grade, veranda, porch, deck, or balcony H = * Not to be Installed above a meter/regulator assembly within 3 feet (90 [*12 inches (30mm) minimum] cm) horizontally from the centre line of the regulator I = Clearance to service regulator vent outlet [* 6 feet (1.8 m) Minimum] Clearance to window or door that may be opened J = Clearance to non-mechanical air supply inlet to building or the 12 Inches (30 cm) minimum]...
Page 15: Installation Of The Log Set
INSTALLATION OF THE LOG SET The log set (2 long fiber logs and 4 shorter ceramic logs) for the DVD400 is included in the master carton. Check to ensure that there is no damage to any of the logs. It is very important to install these logs in their proper position to ensure safe operating conditions.
Page 16 1. Gently remove the ember material from the plastic bag(s). 2. Spread small pieces evenly along the length of the bottom log, behind the front burner. Repeat this procedure for the other front burner. 3. Carefully avoid any clumping or large buildups and do not place on top of burner holes. 4.
Page 17 injury and property damage. Always refer to this manual for normal maintenance requirements. For further assistance or additional information consult a qualified gas installer; your REVERSO MFG. dealer or your local gas supplier. This appliance must not be operated if it or the gas controls have been under water. Contact a qualified gas technician for service before attempting to operate.
Page 18: Replacement Parts List
REVERSO DVD400 OPTIONS 1- FIREFLICK REMOTE CONTROL KIT 2 -WALL THERMOSTAT 3 -VARIABLE SPEED BLOWER 4- ROOF OR SIDEWALL VENT TERMINAL 5- PROPANE OR NATURAL GAS CONTROLS 6 -ZERO CLEARANCE KIT 7- GOLD PLATED TRIM KIT 8- GOLD PLATED DOOR KIT REPLACEMENT PARTS LIST 1- PILOTASSEMBLY 2 - PIEZO IGNITOR...
Page 23 ITEM ITEM ITEM ITEM 1 Top, Frame Transition Box Glass End Valve Bracket 2 Btm, frame Heat Shield Window, End Distributor 3 Supt Frame Cover , End * Door Side Exhaust Hood 4 Supt. Inlet End Combustion Box Heat Exchanger Glass, Side Door 5 Plate, Inlet End 11 Supt, C.B.
Page 24: Lighting Instructions
LIGHTING INSTRUCTIONS FOR YOUR SAFETY READ BEFORE OPERATING WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE. A. THIS APPLIANCE IS EQUIPPED WITH A PILOT WHICH MUST BE LIT FOLLOWING THESE INSTRUCTIONS EXACTLY. B.
Page 25: Five Year Limited Warranty
FIVE YEAR LIMITED WARRANTY Reverso Manufacturing Limited warrants to the original purchaser that the "Supreme" gas fireplace models DVD400 N/P will be free from defects in materials and workmanship, under normal use and service, for a period of five (5) years from the date of purchase. This warranty is non-transferable and is made to the original retail purchaser only.