To recline the front passenger seat in a 2007 Ford Five Hundred, follow these steps:

1. Move the seat as far back as possible.
2. Push the head restraint release button and move the head restraint fully down.
3. Pull the strap located on the back of the seat to fold the seatback.

If the seat is stuck, ensure there are no obstructions preventing movement and check for any release mechanisms such as adjustment levers or buttons.

This answer is automatically generated

Charles Russell

March 2, 2025

The passenger seat want reclined

1 comments:

Mr. Anderson

March 2, 2025

The passenger seat in a 2007 Ford Five Hundred may not recline if the seat is not moved as far back as possible before attempting to fold it down. Additionally, the head restraint must be fully lowered by pressing the release button. If these steps are not followed, the seatback may not fold properly.

This answer is automatically generated

Summary of Contents for Ford 2007 Five Hundred

Page 1 Lights Headlamps Turn signal control Bulb replacement Driver Controls Windshield wiper/washer control Steering wheel adjustment Power windows Mirrors Speed control Moon roof Message center Locks and Security Keys Locks Anti-theft system 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 2: Table Of Contents
Roadside Emergencies Getting roadside assistance Hazard flasher switch Fuel pump shut-off switch Fuses and relays Changing tires Lug nut torque Jump starting Wrecker towing Customer Assistance Reporting safety defects (U.S. only) Cleaning 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 4: Introduction
State of California to cause cancer and birth defects or other reproductive harm. CONGRATULATIONS Congratulations on acquiring your new Ford. Please take the time to get well acquainted with your vehicle by reading this handbook. The more you know and understand about your vehicle, the greater the safety and pleasure you will derive from driving it.
Page 5 Do not add friction modifier compounds or special break-in oils since these additives may prevent piston ring seating. See Engine oil in the Maintenance and Specifications chapter for more information on oil usage. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 6 In order to properly diagnose and service your vehicle, Ford Motor Company, Ford of Canada, and service and repair facilities may access vehicle diagnostic information through a direct connection to your vehicle when diagnosing or servicing your vehicle.
Page 7 • where the driver was positioning the steering wheel. To access this information, special equipment must be directly connected to the recording modules. Ford Motor Company and Ford of Canada do not access event data recorder information without obtaining consent,...
Page 8 Brake Fluid - Anti-Lock Brake System Non-Petroleum Based Powertrain Malfunction Speed Control Master Lighting Switch Hazard Warning Flasher Fog Lamps-Front Fuse Compartment Fuel Pump Reset Windshield Wash/Wipe Windshield Rear Window Defrost/Demist Defrost/Demist 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 9 Battery Acid or Sparks Explosive Gas Fan Warning Maintain Correct Fluid Power Steering Fluid Level Emission System Engine Air Filter Passenger Compartment Jack Air Filter Low Tire Pressure Check Fuel Cap Warning 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 10: Instrument Cluster
Under engine misfire conditions, excessive exhaust temperatures could damage the catalytic converter, the fuel system, interior floor coverings or other vehicle components, possibly causing a fire. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 11 ON, continues to flash or remains on, have the system serviced immediately by your authorized dealer. A chime will also sound when a malfunction in the supplemental restraint system has been detected. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 12 Driving chapter for more information. Low fuel (if equipped): Illuminates when the fuel level in the fuel tank is at or near empty (refer to Fuel gauge in this chapter). 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 13 Headlamps on warning chime: Sounds when the headlamps or parking lamps are on, the ignition is off (the key is not in the ignition) and the driver’s door is opened. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 14: Gauges
Stop the vehicle as soon as safely possible, switch off the engine and let the engine cool. Never remove the coolant reservoir cap while the engine is running or hot. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 15 Trip odometer: Registers the miles (kilometers) of individual journeys. • To reset, select the TRIP function from the INFO menu. Depressing the RESET control for approximately one second will reset the trip odometer to zero. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 16: Entertainment Systems
Satellite radio is available only with a valid SIRIUS subscription. Check with your authorized dealer for availability. 2. Phone/mute: Press to mute the playing media. Press again to return to the playing media. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 17 Treble: Press to adjust the treble setting. Use SEEK Balance: Press to adjust the audio between the left and right speakers. SEEK Fade: Press to adjust the audio between the front and rear speakers. SEEK 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 18 In TEXT MODE, sometimes the display requires additional text to be displayed. When the “>” indicator is active, press SEEK to view the additional display text. When the “<” indicator is active, press SEEK to view the previous display text. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 19 In CD mode, press to access the previous CD track. In Satellite Radio mode (if equipped), press SEEK to seek to the previous channel. If a specific category is selected, (Jazz, Rock, News, 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 20 CD is already loaded into the system, CD play will begin where it ended last. 18. CD eject: Press to eject a CD. 19. CD slot: Insert a CD label side 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 21 Sirius channel Categories (Pop, Rock, News, etc.). Refer to Category Mode under Menu for further information. Satellite radio is available only with a valid SIRIUS subscription. Check with your authorized dealer for availability. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 22 Fade: Press to adjust the audio between the front and rear speakers. SEEK Occupancy mode: (Available on Audiophile radios only): SEEK select and optimize sound for ALL SEATS, DRIVERS SEAT or REAR SEATS. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 23 FES/DVD and AUX modes. If no auxiliary sources are available, NO AUX AUDIO will be displayed. To return to radio mode, press AM/FM. If equipped with Satellite Radio, press AUX to cycle through SAT1, SAT2 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 24 8. FOLDER: Press to access next folder on MP3 discs, if folders are available. 9. FOLDER: press to access the previous folder on MP3 discs, if folders are available. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 25 “nominal” listening level when the ignition switch is turned back on. 17. CD: Press to enter CD mode. If a CD is already loaded into the system, CD play will begin where it ended last. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 26 • Inspect discs before playing. Clean only with an approved CD cleaner and wipe from the center out. Don’t: • Expose discs to direct sunlight or heat sources for extended periods of time. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 27: Satellite Radio Information
Due to technical incompatibility, certain recordable and re-recordable compact discs may not function correctly when used in Ford CD players. Irregular shaped CDs, CDs with a scratch protection film attached, and CDs with homemade paper (adhesive) labels should not be inserted into the CD player.
Page 28 Note: SIRIUS reserves the unrestricted right to change, rearrange, add or delete programming including canceling, moving or adding particular channels, and its prices, at any time, with or without notice to you. Ford Motor Company shall not be responsible for any such programming changes.
Page 29 NO TEXT Artist information not Artist information not available. available at this time on this channel. The system is working properly. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 30 Navigation supplement for further information. FAMILY ENTERTAINMENT DVD SYSTEM (IF EQUIPPED) Your vehicle may be equipped with a Family Entertainment DVD System which allows you to play commercial DVDs, CDs and also most CD R/W, 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 31: Family Entertainment System
Press (+) to increase or (-) to decrease the brightness on the screen. 4. ENTER control Press to select the function highlighted on the active menu. ENTER may also be used by some user interactive discs during movie play. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 32 Once in MENU mode: • Press the NEXT control to move the cursor one position upward NEXT PREV • Press the PREV control to move the cursor one position downward NEXT PREV 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 33 REV/FWD control again to cancel the reverse/advance action and return to normal playback mode Enter control The ENTER control allows you to ENTER select highlighted items when in MENU mode. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 34 To enter zoom mode, press DISP once for the player menu and again to adjust the display setting. Select zoom from the screen settings by using the arrow and ENTER controls. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 35 6. ENTER /MEMORY control In DVD playback mode, press the control to select a highlighted item from the menu. In stop mode, press the control to select the next audio memory preset. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 36 DVD player off. When radio is powered off and back on, it will be in Single Play mode, even if upon power off the radio was in Dual play mode. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 37 Simultaneously press the preset controls 3 and 5 to enable or disable the rear seat controls, the controls on your Family Entertainment DVD system including the remote control, and the DVD screen (if equipped). 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 38 Family Entertainment System (FES). Note: Ensure that the line of sight between the headphone and infrared transmitter (mounted on the DVD housing) is not obstructed for optimal performance. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 39 “playback” mode. (The DVD player does not offer a record feature.) • The system plays standard CDs, DVDs and also plays most CD R/W, DVD R/W, VCD and MP3 media. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 40 • The DVD player is only capable of reading the bottom side of a disc. When inserting a single sided disc, the label should be up. For a multi-sided disc, the desired play side should be down when the disc is inserted into the player. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 41 DVDs only. Due to technical incompatibility, certain recordable and re-recordable compact discs may not function correctly when used in Ford DVD/CD players. Irregular shaped discs, discs with a scratch protection film attached, and discs with homemade paper (adhesive) labels should not be inserted into the player.
Page 42 • Do not attempt to service, repair or modify the Family Entertainment DVD System. See your Ford or Lincoln Mercury dealer. • Do not insert foreign objects into the DVD compartment. 2007 Five Hundred (500)
Page 43 Federal Communication Commission (FCC) Compliance Changes or modifications not approved by Ford or Lincoln Mercury could void user’s authority to operate the equipment. This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to Part 15 of the FCC Rules.
Page 44 Overspray from these fluids could drip down into the internal electronics of the screen and cause damage. Do not apply excessive pressure while cleaning the screen. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 45 Clean the exterior of the DVD player with a damp cloth. Do not use CD cleaning kits or CDs intended to clean the interior of your DVD player. Use of these products may damage your system. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 46: Climate Controls
5. A/C: Press to activate/deactivate air conditioning. Use with recirculated air to improve cooling performance and efficiency. Engages automatically in MAX A/C, (defrost) and (floor/defrost). Cannot be disabled in MAX A/C mode. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 47 5. Direct the outer instrument panel vents towards the side windows. Do not place objects on top of the instrument panel as these objects may become projectiles in a collision or sudden stop. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 48: Automatic Temperature Control
: Distributes air through the windshield defroster, demister and floor vents. : Distributes air through the floor vents. Note: You may notice a small amount of air flowing from the demister and defroster vents. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 49 The system will automatically determine fan speed, airflow location, A/C on or off, and outside or recirculated air, to heat or cool the vehicle to reach the desired temperature. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 50 Recirculation can be engaged manually in any other airflow selection except defrost. Recirculation may turn off automatically in all airflow selections. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 51 The system will automatically determine fan speed, airflow location, A/C on or off, and outside or recirculated air, to heat or cool the vehicle to reach the desired temperature. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 52 5. Direct the outer instrument panel vents towards the side windows. Do not place objects on top of the instrument panel as these objects may become projectiles in a collision or sudden stop. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 53: Rear Window Defroster
This may cause damage to the heated grid lines and will not be covered by your warranty. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 54: Lights
2. Turn the headlamp switch to 3. Turn the ignition switch to RUN and then back to LOCK. 4. Turn the headlamp switch to the autolamp position. The headlamps will turn on. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 55 Pull the lever towards you, to the second detent, to activate. Pull the lever towards you again to deactivate. Flash to pass Pull toward you, to the first detent, to activate and release to deactivate. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 56 Vertical aim adjustment 1. Park the vehicle directly in front of a wall or screen on a level surface, approximately 25 feet (7.6 meters) away. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 57 The horizontal edge of the brighter light should touch the horizontal reference line. 6. Close the hood and turn off the lamps. HORIZONTAL AIM IS NOT REQUIRED FOR THIS VEHICLE AND IS NON-ADJUSTABLE. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 58: Turn Signal Control
45 minutes of headlamp operation. Using the right bulbs Replacement bulbs are specified in the chart below. Headlamp bulbs must be marked with an authorized “D.O.T.” for North America and an 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 59 Replacing headlamp (low beam) bulbs 1. Make sure headlamp switch is in the OFF position, then open the hood. 2. Reach in behind the headlamp assembly to access the bulbs and connectors. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 60 Grasp the bulb only by its plastic base and do not touch the glass. The oil from your hand could cause the bulb to break the next time the headlamps are operated. Install the new bulb(s) in reverse order. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 61 2. Carefully pull the carpet away to expose the backside of the tail lamp assembly. 3. Remove the nut and washer assemblies, then pull the lamp assembly away from the vehicle. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 62 2. Remove the two screws from the license plate lamp assembly. 3. Remove bulb socket by turning counterclockwise. 4. Carefully pull the bulb out from the socket. Install new bulb(s) in reverse order. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 63 1. Make sure the foglamp switch is in the OFF position. 2. Remove the bulb socket from the foglamp by turning counterclockwise. 3. Disconnect the electrical connector. Install the new bulb in reverse order. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 64: Driver Controls
Before operating the wiper on a dry windshield, always use the windshield washer. In freezing weather, be sure the wiper blades are not frozen to the windshield before operating the wipers. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 65 Rotate the visor towards the side window and extend it rearward for additional sunlight coverage. Note: To stow the visor back into the headliner, visor must be retracted before moving it back towards the windshield. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 66 The storage compartment may be used to secure sunglasses or a similar object. CLOCK (IF EQUIPPED) Press and release the button to adjust forward. Press and hold to fast forward. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 67 Always keep the power point caps closed when not being used. Cigar/Cigarette lighter (if equipped) Do not plug optional electrical accessories into the cigarette lighter socket. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 68: Power Windows
ONE TOUCH UP position during a ONE TOUCH DOWN event, the window will stop. If, after 1/2 second the switch is still held, the window will perform a normal close or ONE TOUCH UP. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 69 Security override can be used if the window movement is restricted in some way, for example, if there is ice on the window or seals. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 70: Mirrors
2. Move the control in the direction you wish to tilt the mirror. 3. Return to the center position to lock mirrors in place. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 71 • Press the bottom of the control to adjust the pedals towards you. The adjustment allows for approximately 2.8 inches (71 mm) of maximum travel. Never adjust the accelerator and brake pedal with feet on the pedals while the vehicle is moving. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 72: Speed Control
2. Accelerate to the desired speed. 3. Press the SET + control and release it. 4. Take your foot off the accelerator CNCL pedal. 5. The indicator light on the instrument cluster will turn on. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 73 1 mph (1.6 km/h). • Use the accelerator pedal to get to the desired speed. When the vehicle reaches that speed press and release the SET + control. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 74 CNCL • Press the speed control OFF control. Note: When you turn off the speed control or the ignition, your speed control set speed memory is erased. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 75: Moon Roof
You can move the glass panel of the moon roof back to open or tilt up to ventilate the vehicle. Do not let children play with the moon roof or leave children unattended in the vehicle. They may seriously hurt themselves. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 76 The moon roof has a sliding shade that can be opened or closed when the glass panel is shut. To close the shade, pull it toward the front of the vehicle 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 77 ACC position for programming and/or operation of the HomeLink . It is also recommended that a new battery be placed in the hand-held transmitter of the device being programmed to HomeLink for quicker training and accurate transmission of the radio-frequency signal. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 78 “learn” or “smart” button (usually near where the hanging antenna wire is attached to the unit). 7. Press and release the “learn” or “smart” button. (The name and color of the button may vary by manufacturer.) 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 79 HomeLink . The indicator light will flash slowly and then rapidly after HomeLink accepts the radio frequency signal. • Proceed with Step 4 in the “Programming” section. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 80 2. The indicator light will begin to flash after 20 seconds. Without releasing the HomeLink button, follow Step 2 in the “Programming” section. For questions or comments, contact HomeLink at www.homelink.com or 1–800–355–3515. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 81: Message Center
Remember to turn the ignition OFF when refueling to allow this feature to correctly detect the added fuel. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 82 INFO menu, XX.X G USED will display the fuel used since last reset. The information displayed will be in gallons or liters, depending on English/metric mode state. Press and hold RESET to reset mode. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 83 2. Start the engine. 3. Press the INFO button repeatedly until the Compass and Odometer are displayed. (Do not select Trip, DTE, or AFE. The top of the message center must be blank). 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 84 2. Start the engine. 3. Press the INFO button repeatedly until the Compass and Odometer are displayed. (Do not select Trip, DTE, or AFE. The top of the message center must be blank). 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 85 Language 1. Select this function from the SETUP menu for the current language to be displayed. 2. Pressing the RESET control cycles the message center through each of the language choices. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 86 7. BRAKE FLUID LEVEL 8. COOLANT LEVEL 9. FUEL CAP SECURE 10. FUEL LEVEL 11. DISTANCE TO E System warnings System warnings alert you to possible problems or malfunctions in your vehicle’s operating systems. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 87 DRIVER’S DOOR AJAR. Displayed when the driver’s door is not completely closed. PASSENGER DOOR AJAR. Displayed when the passenger side door is not completely closed. LEFT REAR DOOR AJAR. Displayed when the left rear door is not completely closed. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 88 USE ONLY RECOMMENDED ENGINE OILS. To reset the oil monitoring system to 100% after each oil change [approximately 5,000 miles (8,000 km) or 180 days] perform the following: 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 89 2. Press and hold the RESET until “IF NEW OIL HOLD RESET” is displayed, then release. 3. Press and hold RESET control again until OIL LIFE SET TO 100% is displayed. Your oil life is now reset. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 90 Attach the net to the anchors provided. Do not put more than 50 lbs. (22 kg) in the net. This net is not designed to restrain objects during a collision. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 91: Locks And Security
• the brake pedal is released and the vehicle attains a speed greater than 5 mph (8 km/h). The autolock feature repeats when: • any door is opened then closed while the ignition is in the 3 (RUN) position, and 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 92 6. Release the 7 • 8. The user should receive a horn chirp to indicate the system has been disabled or a chirp followed by a honk to indicate the system has been enabled. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 93 7. Turn the ignition from the 3 (RUN) position to the 1 (LOCK) position. The horn will chirp one time to confirm the programming mode has been exited. Repeat the procedure to turn the feature on or off. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 94 Adults are advised to familiarize themselves with the operation and location of the release handle. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 95 Exposure of people or animals to these high temperatures for even a short time can cause death or serious heat-related injuries, including brain damage. Small children are particularly at risk. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 96 ALL remote entry transmitters with you to the authorized dealer in order to aid in troubleshooting the problem. Unlocking the doors 1. Press and release to unlock the driver’s door. Note: The interior lamps will illuminate. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 97 Failure to properly latch the trunk may cause objects to fall out or block the driver’s rear view. Memory seats/power mirrors/adjustable pedals (if equipped) The remote entry system can also control the memory seat /power mirrors/adjustable pedals feature. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 98 1. Twist a thin coin between the two halves of the remote entry transmitter near the key ring. DO NOT TAKE THE RUBBER COVER AND CIRCUIT BOARD OFF THE FRONT HOUSING OF THE REMOTE ENTRY TRANSMITTER. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 99 Driver 2 settings. How to reprogram your remote entry transmitters You must have all remote entry transmitters (maximum of four) available before beginning this procedure. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 100 • the ignition is turned to the 3 (RUN) position, or • the remote transmitter lock control is pressed, or • after 25 seconds of illumination. The inside lights will not turn off if: 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 101 The lights will turn off if all the doors and the trunk remain closed and • 25 seconds elapse, or • the key is inserted in the ignition. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 102 Note: The factory-set code cannot be associated with a memory setting. 5. The doors will again lock then unlock to confirm that your personal keycode has been programmed to the module. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 103: Anti-Theft System
SECURILOCK PASSIVE ANTI-THEFT SYSTEM SecuriLock passive anti-theft system is an engine immobilization system. This system is designed to help prevent the engine from being 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 104 Note: The SecuriLock passive anti-theft system is not compatible with non-Ford aftermarket remote start systems. Use of these systems may result in vehicle starting problems and a loss of security protection. Note: Large metallic objects, electronic devices that are used to purchase gasoline or similar items, or a second coded key on the same key chain may cause vehicle starting issues.
Page 105 • If two previously programmed coded keys are not available, you must take your vehicle to your authorized dealer to have the spare key(s) programmed. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 106 Steps 1 through 8. If failure repeats, bring your vehicle to your authorized dealer to have the new key(s) programmed. To program additional new unprogrammed key(s), wait twenty seconds and then repeat this procedure from Step 1. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 107 • Press the driver or passenger interior door lock control while the door is open, then close the door. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 108 Triggering the anti-theft system The armed system will be triggered if: • Any door, the hood or the trunk is opened without using the door key, keypad or the remote entry transmitter. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 109: Seating And Safety Restraints
Adjust your head restraint so that it is located directly or as close as possible behind your head. The head restraints can be moved up by pulling up on the head restraint. Push release button to lower head restraint. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 110 After returning the seatback to its original position, pull on the seatback to ensure that it has fully latched. An unlatched seat may become dangerous in the event of a sudden stop or collision. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 111 An unlatched seat may become dangerous in the event of a sudden stop or collision. Adjusting the front power seat (if equipped) Never adjust the driver’s seat or seatback when the vehicle is moving. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 112 The control is located on the outboard side of the seat cushion. Press the front or rear portion to tilt the seat. • Driver 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 113 The heating of the seat turns off after 10 minutes or when the vehicle is turned off. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 114 Locks and Security chapter. REAR SEATS Head restraints (if equipped) Lift the head restraint so that it is located directly or as close as possible behind your head. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 115 When raising the seatback(s), make sure you hear the seat latch into place. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 116: Safety Restraints
Your vehicle’s Personal Safety System consists of: • Driver and passenger dual-stage airbag supplemental restraints. • Front outboard safety belts with pretensioners, energy management retractors (first row only), and safety belt usage sensors. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 117 The front crash severity sensor enhances the ability to detect the severity of an impact. Positioned up front, it provides valuable information early in the crash event on the severity of the impact. This 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 118 Front safety belt usage sensors The front safety belt usage sensors detect whether or not the driver and front outboard passenger safety belts are fastened. This information 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 119 If any of these things happen, even intermittently, have the Personal Safety System serviced at an authorized dealer immediately. Unless serviced, the system may not function properly in the event of a collision. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 120 3) Never use a single belt for more than one person. Always transport children 12 years old and under in the back seat and always properly use appropriate child restraints. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 121 Failure to inspect and replace if necessary the Belt and Retractor assembly after an accident could increase the risk of injury in a collision. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 122 Refer to Safety restraints for children or Safety seats for children later in this chapter. How to use the automatic locking mode • Buckle the combination lap and shoulder belt. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 123 This indicates the safety belt is now in the automatic locking mode. How to disengage the automatic locking mode Ford Motor Company recommends that all passenger safety belt assemblies and attaching hardware should be inspected by an authorized dealer after any collision to verify that the automatic locking retractor feature for child seats is still working properly.
Page 124 Inspect the safety belt systems periodically to make sure they work properly and are not damaged. Inspect the safety belts to make sure there are no nicks, tears or cuts. Replace if necessary. All safety belt 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 125 (if equipped), shoulder belt guide on seatback (if equipped), child safety seat LATCH and tether anchors, and attaching hardware, should be inspected after a collision. Ford Motor Company recommends that all safety belt assemblies in use in vehicles involved in a collision be replaced.
Page 126 6 seconds every 30 km/h) and 1-2 minutes have seconds, repeating for approximately elapsed since the ignition 5 minutes or until the safety belts are switch has been turned to buckled. ON... 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 127 Nearly 1 of 2 deaths occur in single-vehicle crashes, many when no other vehicles are around. “Belts wrinkle my Possibly, but a serious crash can do much more clothes” than wrinkle your clothes, particularly if you are unbelted. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 128 The driver and front passenger BeltMinder features can be deactivated/activated by performing the following procedure: Before following the procedure, make sure that: • The parking brake is set 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 129 4 times per second for 3 seconds, followed by 3 seconds with the light off, then followed by the safety belt warning light flashing 4 times per second for 3 seconds again. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 130: Airbags
Important supplemental restraint system precautions Airbags DO NOT inflate slowly or gently and the risk of injury from a deploying airbag is greatest close to the trim covering the airbag module. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 131 (including frame, bumper, front end body structure and tow hooks) may affect the performance of the airbag system, increasing the risk of injury. Do not modify the front end of the vehicle. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 132 Front airbags are designed to inflate in frontal and near-frontal collisions, not rollover, side-impact, or rear-impacts unless the collision causes sufficient longitudinal deceleration. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 133 • driver and passenger airbag modules (which include the inflators and airbags). • side airbags and curtain (if equipped). Refer to Side airbag system later in this chapter. • one or more impact and safing sensors. • Safety belt pretensioner 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 134 • the system determines that a small child is present in a booster seat, • a front passenger takes his/her weight off of the seat for a period of time, • a child or a small person occupies the front passenger seat. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 135 • Turn the vehicle off and ask the person to place the seatback in the full upright position. • Have the person sit upright in the seat, centered on the seat cushion, with the person’s legs comfortably extended. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 136 Even though the passenger airbag is disabled, the pass airbag off lamp may or may not be illuminated according to the table below. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 137 (if equipped). Check the “passenger airbag off” or “pass airbag off” indicator lamp for proper airbag Status. Failure to follow these instructions may interfere with the front passenger seat sensing system. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 138 If it is necessary to modify an advanced front airbag system to accommodate a person with disabilities, contact the Ford Customer Relationship Center at the phone number shown in the Customer Assistance chapter of this Owner’s Guide.
Page 139 See your authorized dealer. All occupants of the vehicle should always wear their safety belts even when an airbag SRS is provided. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 140 Side airbags are designed to inflate in side-impact collisions, not roll-over, rear-impact, frontal or near-frontal collisions, unless the collision causes sufficient lateral deceleration. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 141 Do not attempt to service, repair, or modify the Safety Canopy system, its fuses, the A, B, or C pillar trim, or the headliner on a vehicle containing a Safety Canopy . See your authorized dealer. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 142 • Two crash sensors mounted on the B pillar (one on each side of the vehicle). • Two crash sensors located at the C pillar behind the rear doors (one on each side of the vehicle). • Rollover sensor in the restraints control module (RCM). 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 143 Several Safety Canopy system components get hot after inflation. Do not touch them after inflation. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 144: Child Restraints
You are required by law to use safety restraints for children in the U.S. and Canada. If small children (generally children who are four years old or younger and who weigh 40 lb. [18 kg] or less) ride in your vehicle, you 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 145 To improve the fit of both the lap and shoulder belt on children who have outgrown child safety seats, Ford Motor Company recommends use of a belt-positioning booster. Booster seats position a child so that safety belts fit better. They lift the...
Page 146 (top of ear level) above the top of the seat. In this case, move the backless booster to another seating position with a higher seat back and lap/shoulder belts. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 147 It is best to use a booster seat with lap/shoulder belts in the back seat- the safest place for children to ride. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 148 • Keep the buckle release button pointing up and away from the safety seat, with the tongue between the child seat and the release button, to prevent accidental unbuckling. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 149 80 lb (36 kg) using an upper torso harness and a belt-positioning booster. Ford Motor Company recommends the use of a child safety seat having a top tether strap. Install the child safety seat in a seating position with LATCH and tether anchors.
Page 150 3. While holding the shoulder and lap belt portions together, route the tongue through the child seat according to the child seat manufacturer’s instructions. Be sure the belt webbing is not twisted. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 151 7. Pull the lap belt portion across the child seat toward the buckle and pull up on the shoulder belt while pushing down with your knee on the child seat. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 152 The tether anchors in your vehicle are located under a cover marked with the tether anchor symbol (shown with title). The tether strap anchors in your vehicle are in the following positions (shown from top view): 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 153 6. Install the child safety seat tightly using the LATCH anchors or safety belts. Follow the instructions in this chapter. 7. Tighten the child safety seat tether strap according to the manufacturer’s instructions. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 154 Never attach two LATCH child safety seats to the same anchor. In a crash, one anchor may not be strong enough to hold two child safety seat attachments and may break, causing serious injury or death. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 155 Also try to tug the seat forward. Check to see if the anchors hold the seat in place. If the safety seat is not anchored properly, the risk of a child being injured in a crash greatly increases. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 156: Tires, Wheels And Loading
10 to 12 inches or limited production tires as defined in Title 49 Code of Federal Regulations Part 575.104(c)(2). U.S. Department of Transportation-Tire quality grades: The U.S. Department of Transportation requires Ford Motor Company to give you the following information about tire grades exactly as the government has written it.
Page 157 • Extra load: A class of P-metric or Metric tires designed to carry a heavier maximum load at 41 psi [43 psi (2.9 bar) for Metric tires]. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 158: Tire Inflation
At least once a month and before long trips, inspect each tire and check the tire pressure with a tire gauge (including spare, if equipped). Inflate all tires to the inflation pressure recommended by Ford Motor Company. Use a tire gauge to check the tire inflation pressure, including the spare (if equipped), at least monthly and before long trips.
Page 159 Always inflate your tires to the Ford recommended inflation pressure even if it is less than the maximum inflation pressure information found on the tire. The Ford recommended tire inflation pressure is found on the Safety Compliance Certification Label or Tire Label which is located on the B-Pillar or the edge of the driver’s door.
Page 160: Tire Information
Improper or inadequate vehicle maintenance can cause tires to wear abnormally. Inspect all your tires, including the spare, frequently, and replace them if one or more of the following conditions exist: 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 161 The next two numbers or letters are the plant code designating where it was manufactured, the next two are the tire size code and the last four numbers represent the week and year the tire was 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 162 Only use replacement tires and wheels that are the same size and type (such as P-metric versus LT-metric or all-season versus all-terrain) as those originally provided by Ford. Use of any tire or wheel not recommended by Ford can affect the safety and performance of your vehicle, which could result in an increased risk of loss of vehicle control, vehicle rollover, personal injury and death.
Page 163 If your vehicle seems to pull to one side when you’re driving, the wheels may be out of alignment. Have an authorized dealer check the wheel alignment periodically. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 164 Unless otherwise specified, rotate the tires approximately every 5,000 miles (8,000 km). • Front Wheel Drive (FWD) vehicles (front tires at top of diagram) 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 165 This information identifies and describes the fundamental characteristics of the tire and also provides a U.S. DOT Tire Identification Number for safety standard certification and in case of a recall. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 166 These speed ratings may need to be adjusted for the difference in conditions. The ratings range from 81 mph (130 km/h) to 186 mph (299 km/h). These ratings are listed in the following chart. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 167 Refer to the Safety Compliance Certification Label, which is located on the B-Pillar or the edge of the driver’s door, for the correct tire pressure for your vehicle. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 168 The cold inflation pressure should never be set lower than the recommended pressure on the vehicle label. The tire suppliers may have additional markings, notes or warnings such as standard load, radial tubeless, etc. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 169 4. Maximum Load Single lb. (kg) at psi (kPa) cold: Indicates the maximum load and tire pressure when the tire is used as a single; defined as two tires (total) on the rear axle. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 170 Vehicle loading — with and without a trailer section. SNOW TIRES AND CHAINS Snow tires must be the same size and grade as the tires you currently have on your vehicle. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 171: Vehicle Loading
Tire Label or Safety Compliance Certification Label: Base Curb Weight – is the weight of the vehicle including a full tank of fuel and all standard equipment. It does not include passengers, cargo, or optional equipment. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 172 Overloading or improperly loading your vehicle can contribute to loss of vehicle control and vehicle rollover. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 173 GAW (Gross Axle Weight) – is the total weight placed on each axle (front and rear) – including vehicle curb weight and all payload. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 174 Exceeding the Safety Compliance Certification Label vehicle weight rating limits could result in substandard vehicle handling or performance, engine, transmission and/or structural damage, serious damage to the vehicle, loss of control and personal injury. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 175 Steps for determining the correct load limit: 1. Locate the statement “The combined weight of occupants and cargo should never exceed XXX kg or XXX lbs.” on your vehicle’s placard. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 176 198 — 540 = —103 kg. You will need to reduce the load weight by at least 240 lb. (104 kg). If you remove 3-100 lb. (45 kg) cement bags, then the load calculation would be: 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 177: Trailer Towing
Always connect the trailer’s safety chains to the frame or hook retainers of the vehicle hitch. To connect the trailer’s safety chains, cross the chains under the trailer tongue and allow slack for turning corners. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 178 • Practice turning, stopping and backing up before starting on a trip to get the feel of the vehicle trailer combination. When turning, make wider turns so the trailer wheels will clear curbs and other obstacles. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 179: Recreational Towing
Do not tow your All Wheel Drive vehicle with any wheels on the ground as vehicle or transaxle damage may occur. It is recommended to tow your vehicle using a car-hauling trailer. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 180: Driving
10 minutes of moderate driving or idling. Extended idling at high engine speeds can produce very high temperatures in the engine and exhaust system, creating the risk of fire or other damage. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 181 Seating and Safety Restraints chapter. 2. Make sure vehicle accessories are off. • Make sure the parking brake is set. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 182 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 183: Brakes
BRAKE system warning light. Four-wheel anti-lock brake system (ABS) Your vehicle is equipped with an Anti-lock Braking System (ABS). This system helps you maintain steering control during emergency stops by 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 184 Parking brake Apply the parking brake whenever the vehicle is parked. To set the parking brake, press the parking brake pedal down until the pedal stops. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 185: Traction Control
This process is very sensitive to driving conditions and very fast acting. The wheels “search” for optimum traction several times a second and adjustments are made accordingly. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 186 • Do not fill the power steering pump reservoir above the maximum level, as this may result in leaks from the reservoir. See Checking and adding power steering fluid in the Maintenance and Specifications chapter. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 187 1. Remove the trim ring around the gearshift lever. 2. Remove the console panel by opening the armrest, grasping the panel firmly, then pulling up. This will allow access to the gearshift assembly. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 188 CVT continually adjusts the optimum overall drive ratio between engine and drive wheels for all operating conditions. As traditional automatic transmissions/transaxles shift up or down in gears, this shifting in gear ratios is noticeable by increasing and 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 189 Always set the parking brake fully and make sure the gearshift is latched in P (Park). Turn the ignition to the LOCK position and remove the key whenever you leave your vehicle. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 190 To put your vehicle in gear: • Depress the brake pedal • Move the gearshift lever into the desired gear To put your vehicle in P (Park): • Come to a complete stop 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 191 Inclement weather may also affect the function of the RSS; this may include reduced performance or a false activation. To help avoid personal injury, always use caution when in R (Reverse) and when using the RSS. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 192 R (Reverse) and the ignition is ON. An RSS control on the instrument panel allows the driver to turn the RSS on and off. To turn the RSS off 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 193 L (Low) gear when possible. L (Low) gear operation will maximize the engine and transmission cooling capability. Under severe operating conditions, the A/C may cycle on and off to protect overheating of the engine. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 194 Always set the parking brake fully and make sure the gearshift is latched in P (Park). Turn the ignition to the LOCK position and remove the key whenever you leave your vehicle. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 195 Sand When driving over sand, try to keep all four wheels on the most solid area of the trail. Avoid reducing the tire pressures but shift to a lower 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 196 PTU (Power Transfer Unit) lubricant should be checked and changed if necessary. After driving through mud, clean off residue stuck to rotating driveshafts and tires. Excess mud stuck on tires and rotating driveshafts causes an imbalance that could damage drive components. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 197 The front wheels have to be turning in order to steer the vehicle. If your vehicle has anti-lock brakes, apply the brakes steadily. Do not “pump” the brakes. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 198 Any modifications to a vehicle that raise the center of gravity can make it more likely the vehicle will rollover as a result of a loss of control. Ford Motor Company recommends that caution be used with any vehicle equipped with a high load or device (such as ladder or luggage racks).
Page 199 Once through the water, always dry the brakes by moving your vehicle slowly while applying light pressure on the brake pedal. Wet brakes do not stop the vehicle as quickly as dry brakes. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 200: Roadside Emergencies
50,000 miles (80,000 km) on Lincoln vehicles. Roadside assistance will cover: • a flat tire change with a good spare (except Ford GT which has a tire inflation kit) • battery jump start • lock-out assistance (key replacement cost is the customer’s responsibility) •...
Page 201 1–800–241–3673; Lincoln vehicle customers call 1–800–521–4140. Canadian customers who require roadside assistance, call 1–800–665–2006. If you need to arrange roadside assistance for yourself, Ford Motor Company will reimburse a reasonable amount. To obtain reimbursement information, U.S. Ford or Mercury vehicles customers call 1–800–241–3673;...
Page 202: Fuel Pump Shut-Off Switch
If electrical components in the vehicle are not working, a fuse may have blown. Blown fuses are identified by a broken wire within the fuse. Check the appropriate fuses before replacing any electrical components. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 203 Yellow Yellow Blue Blue Natural Natural — — — Green Green Green Pink Pink — — Orange Green Green — — — — Blue Yellow Yellow — — Natural Black Black 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 204 Access/Security (Power door lock actuators, Decklid lock actuator, Decklid solenoid) Adjustable pedal switch Horns Audio (Subwoofer) 7.5A Power/Keep Alive Memory (KAM): Cluster and Powertrain Control Module (PCM), Climate control, Analog clock 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 205 Fuel relay coil, Brake lamps, Center High-Mounted Stop Lamp (CHMSL) Anti-lock Brake System (ABS)/Traction control module, All Wheel Drive (AWD) module, RSS, Heated seat modules 7.5A Cluster, Climate control 7.5A Restraint Control Module (RCM) 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 206 Power Distribution Box before reconnecting the battery or refilling fluid reservoirs. If the battery has been disconnected and reconnected, refer to the Battery section of the Maintenance and Specifications chapter. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 207 Not used 60A* Engine cooling fan — Not used 40A* Anti-lock Brake System (ABS) (Motor) 30A* Starter 30A* Powertrain Control Module (PCM) relay 20A* ABS (Valves) — Not used — Not used 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 208 Ignition switch (to SJB) — Not used 40A* Front A/C blower motor — Not used — Not used — Not used 1A Diode 1A Diode A/C clutch ⁄ ISO relay Fog lamps 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 209 • hold the steering wheel firmly. • slowly move to a safe place on the side of the road. The use of tire sealants is not recommended and may damage your tires. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 210 Ford. If the dissimilar spare tire or wheel is damaged, it should be replaced rather than repaired.
Page 211 • Driving vehicles equipped with a camper body • Driving vehicles with a load on the cargo rack Drive cautiously when using a full-size dissimilar spare tire/wheel and seek service as soon as possible. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 212 When one of the front wheels is off the ground, the transaxle alone will not prevent the vehicle from moving or slipping off the jack, even if the vehicle is in P (Park). 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 213 3. Remove wheel cover (if equipped) with the lug wrench tip and loosen each wheel lug nut one-half turn counterclockwise but do not remove them until the wheel is raised off the ground. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 214 9. Install the wheel cover (if equipped). The wheel cover will only install if the Ford/Mercury logo is aligned over the valve stem on the wheel. 2007 Five Hundred (500) Owners Guide (post-2002-fmt)
Page 215 If you are stowing the flat tire, place the tire, with the tire’s valve stem facing down, into the spare tire well and secure the wheel with the large wing nut. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 216: Lug Nut Torque
1/2-20 UNF * Torque specifications are for nut and bolt threads free of dirt and rust. Use only Ford recommended replacement fasteners. When a wheel is installed, always remove any corrosion, dirt or foreign materials present on the mounting surfaces of the wheel or the surface of the wheel hub, brake drum or brake disc that contacts the wheel.
Page 217: Transmission Operation
Connecting the jumper cables 1. Connect the positive (+) jumper cable to the positive (+) terminal of the discharged battery. Note: In the illustrations, lightning bolts are used to designate the assisting (boosting) battery. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 218 2. Connect the other end of the positive (+) cable to the positive (+) terminal of the assisting battery. 3. Connect the negative (-) cable to the negative (-) terminal of the assisting battery. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 219 2. Start the engine of the disabled vehicle. 3. Once the disabled vehicle has been started, run both engines for an additional three minutes before disconnecting the jumper cables. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 220 1. Remove the jumper cable from the ground metal surface. Note: In the illustrations, lightning bolts are used to designate the assisting (boosting) battery. 2. Remove the jumper cable on the negative (-) connection of the booster vehicle’s battery. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 221 After the disabled vehicle has been started and the jumper cables removed, allow it to idle for several minutes so the engine computer can relearn its idle conditions. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 222: Wrecker Towing
It is recommended that your vehicle be towed with a wheel lift or flatbed equipment. Do not tow with a slingbelt. Ford Motor Company has not approved a slingbelt towing procedure. If the vehicle is being towed using wheel lift equipment, the wheels being raised should be brought to a height of 12 inches (30 cm) above the non-raised wheels to prevent damage to the vehicle.
Page 223 If the vehicle is towed by other means or incorrectly, vehicle damage may occur. Ford Motor Company produces a towing manual for all authorized tow truck operators. Have your tow truck operator refer to this manual for proper hook-up and towing procedures for your vehicle.
Page 224: Customer Assistance
Center at 1-800-392-3673 (FORD). Away from home If you own a Ford or Mercury vehicle and are away from home when your vehicle needs service, or if you need more help than the authorized dealer could provide, after following the steps described above, contact the Ford Customer Relationship Center to find an authorized dealer to help you.
Page 225 If you own a Lincoln vehicle and are away from home when your vehicle needs service, or if you need more help than the authorized dealer could provide, after following the steps described above, contact the Ford Customer Relationship Center to find an authorized dealer to help you.
Page 226 Customer Assistance In some states (in the U.S.) you must directly notify Ford in writing before pursuing remedies under your state’s warranty laws. Ford is also allowed a final repair attempt in some states. In the United States, a warranty dispute must be submitted to the BBB...
Page 227 You are not bound by the decision but may choose to accept it. If you choose to accept the BBB AUTO LINE decision then Ford must abide by the accepted decision as well. If the arbitrator has decided in...
Page 228 United States and Canada, provided by a network of more than 4,600 participating authorized dealers. If you did not take advantage of the Ford Extended Service Plan at the time of purchasing your vehicle, you may still be eligible. Since this...
Page 229 The use of leaded fuel in your vehicle without proper conversion may damage the effectiveness of your emission control system and may cause engine knocking or serious engine damage. Ford Motor Company/Ford of Canada is not responsible for any damage caused by use of improper fuel.
Page 230: Reporting Safety Defects (U.s. Only)
Obtaining a French owner’s guide French Owner’s Guides can be obtained from your authorized dealer or by writing to Ford Motor Company of Canada, Limited, Service Publications, P.O. Box 1580, Station B, Mississauga, Ontario L4Y 4G3. REPORTING SAFETY DEFECTS (U.S. ONLY)
Page 231: Cleaning
• Never use abrasive materials such as steel wool or plastic pads as they can scratch the chrome surface. WAXING Applying Motorcraft Paint Sealant (ZC-45) to your vehicle every six months will assist in reducing minor scratches and paint damage. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 232 • To remove tar and grease, use Motorcraft Bug and Tar Remover (ZC-42), available from your authorized dealer. ENGINE Engines are more efficient when they are clean because grease and dirt buildup keep the engine warmer than normal. When washing: 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 233 • For plastic headlamp lenses, use Motorcraft Ultra Clear Spray Glass Cleaner (ZC-23). WINDOWS AND WIPER BLADES The windshield, rear and side windows and the wiper blades should be cleaned regularly. If the wipers do not wipe properly, substances on the 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 234 The dull finish in this area helps protect the driver from undesirable windshield reflection. Do not use chemical solvents or strong detergents when cleaning the steering wheel or instrument panel to avoid contamination of the airbag system. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 235 Your leather seating surfaces have a clear, protective coating over the leather. • To clean, use a soft cloth with Motorcraft Deluxe Leather and Vinyl Cleaner (ZC-11–A). Dry the area with a soft cloth. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 236 FORD AND LINCOLN MERCURY CAR CARE PRODUCTS Your Ford or Lincoln Mercury authorized dealer has many quality products available to clean your vehicle and protect its finishes. These quality products have been specifically engineered to fulfill your automotive needs;...
Page 237 Motorcraft Spot and Stain Remover (U.S. only) (ZC-14) Motorcraft Tire Clean and Shine (ZC-28) Motorcraft Triple Clean (U.S. only) (ZC-13) Motorcraft Ultra-Clear Spray Glass Cleaner (ZC-23) Motorcraft Vinyl Cleaner (Canada only) (CXC-93) Motorcraft Wheel and Tire Cleaner (ZC-37–A) 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 238: Maintenance And Specifications
To reduce the risk of vehicle damage and/or personal burn injuries do not start your engine with the air cleaner removed and do not remove it while the engine is running. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 239 3. Lift the hood and support it with the prop rod. Lift the prop rod by the sleeve and not the bare metal. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 240: Engine Compartment
5. Battery 6. Power distribution box 7. Air filter assembly 8. 6–speed automatic transmission fluid dipstick (if equipped) 9. Engine oil dipstick 10. Engine oil filler cap 11. Windshield washer fluid reservoir 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 241 Note: Do not put washer fluid in the engine coolant reservoir. Washer fluid placed in the cooling system may harm engine and cooling system components. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 242: Engine Oil
2. Turn the engine off and wait a few minutes for the oil to drain into the oil pan. 3. Set the parking brake and ensure the gearshift is securely latched in P (Park). 4. Open the hood. Protect yourself from engine heat. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 243 DO NOT ADD OIL. • If the oil level is below this mark, engine oil must be added to raise the level within the normal operating range. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 244 5. Fully install the engine oil filler cap by turning the filler cap clockwise until it stops. To avoid possible oil loss, DO NOT operate the vehicle with the engine oil level indicator and/or the engine oil filler cap removed. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 245 Change your engine oil and filter according to the appropriate schedule listed in scheduled maintenance information. Ford production and aftermarket (Motorcraft) oil filters are designed for added engine protection and long life. If a replacement oil filter is used that does not meet Ford material and design specifications, start-up engine noises or knock may be experienced.
Page 246: Battery
Lift the battery with a battery carrier or with your hands on opposite corners. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 247 If the battery has been disconnected or a new battery has been installed, the clock and radio settings must be reset once the battery is reconnected. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 248: Engine Coolant
50–50 mixture of coolant and water provides the following: • Freeze protection down to -34°F (-36°C). • Boiling protection up to 265°F (129°C). • Protection against rust and other forms of corrosion. • Enables calibrated gauges to work properly. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 249 When adding coolant, make sure it is a 50/50 mixture of engine coolant and distilled water. Add the mixture to the coolant reservoir, when the engine is cool, until the appropriate fill level is obtained. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 250 Motorcraft Premium Gold Engine Coolant from yellow to golden tan. • Do not add/mix an orange-colored, extended life coolant such as Motorcraft Specialty Orange Engine Coolant, meeting Ford specification WSS-M97B44-D, with the factory-filled coolant. Mixing Motorcraft Specialty Orange Engine Coolant or any orange-colored extended life product with your factory filled coolant can result in degraded corrosion protection.
Page 251 6. Replace the cap. Turn until tightly installed. (Cap must be tightly installed to prevent coolant loss.) 7. Pull off metal pin and remove coolant bleed plug from the thermostat housing. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 252 If necessary, add enough 50/50 concentration of engine coolant and distilled water to bring the liquid level to the proper level. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 253 Recycled engine coolant Ford Motor Company does NOT recommend the use of recycled engine coolant in vehicles originally equipped with Motorcraft Premium Gold Engine Coolant since a Ford-approved recycling process is not yet available.
Page 254 Automotive fuels can cause serious injury or death if misused or mishandled. Gasoline may contain benzene, which is a cancer-causing agent. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 255 Care should be taken to avoid inhaling excess fumes. The flow of fuel through a fuel pump nozzle can produce static electricity, which can cause a fire if fuel is pumped into an ungrounded fuel container. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 256 Turn off the engine, remove the fuel filler cap, align the cap properly and reinstall it. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 257 The customer warranty may be void for any damage to the fuel tank or fuel system if the correct genuine Ford or Motorcraft fuel filler cap is not used. The fuel system may be under pressure. If the fuel filler cap is venting vapor or if you hear a hissing sound, wait until it stops before completely removing the fuel filler cap.
Page 258 Ask your fuel supplier about gasolines that meet the World-wide Fuel Charter. Cleaner air Ford endorses the use of reformulated “cleaner-burning” gasolines to improve air quality. Running out of fuel Avoid running out of fuel because this situation may have an adverse effect on powertrain components.
Page 259 For consistent results when filling the fuel tank: • Turn the engine/ignition switch to the off position prior to refueling, an error in the reading will result if the engine is left running. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 260 Habits • Smooth, moderate operation can yield up to 10% savings in fuel. • Steady speeds without stopping will usually give the best fuel economy. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 261 1 mpg [0.4 km/L] is lost for every 400 lb [180 kg] of weight carried). • Adding certain accessories to your vehicle (for example bug deflectors, rollbars/light bars, running boards, ski/luggage racks) may reduce fuel economy. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 262 If other than Ford, Motorcraft or Ford-authorized parts are used for maintenance replacements or for service of components affecting emission control, such non-Ford parts should be equivalent to genuine Ford Motor Company parts in performance and durability.
Page 263 3. The fuel cap may not have been securely tightened. See Fuel filler cap in this chapter. These temporary malfunctions can be corrected by filling the fuel tank with good quality fuel and/or properly tightening the fuel cap. After three 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 264 POWER STEERING FLUID Refer to the scheduled maintenance information for the service interval schedules. If adding fluid is necessary, use only MERCON ATF. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 265 If the fluid levels are outside of the normal operating range the performance of your brake system could be compromised; seek service from your authorized dealer immediately. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 266 30 minutes to allow fluid to cool before checking. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 267 Fluid levels above the safe range may result in transaxle failure. An overfill condition of transmission fluid may cause shift and/or engagement concerns and/or possible damage. High fluid levels can be caused by an overheating condition. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 268: Part Numbers
For PCV valve replacement, see your authorized dealer. Refer to scheduled maintenance information for the appropriate intervals for changing the PCV valve. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 269 Maintenance and Specifications Replace the PCV valve with one that meets Ford material and design specifications for your vehicle, such as a Motorcraft or equivalent replacement part. The customer warranty may be void for any damage to the emissions system if such a PCV valve is not used.
Page 270 Maintenance and Specifications 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 271 Maintenance and Specifications 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 272: Engine Data
183 cubic inches Required fuel 87 octane Firing order 1–4–2–5–3–6 Spark plug gap (0.052–0.056 inch) 1.32–1.42 mm Ignition system Coil on plug Compression ratio 10.0:1 Engine drivebelt routing • 3.0L V6 Engine 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 273 The vehicle identification number is attached to a metal tag and is located on the driver side XXXXXXXXXXXXXXXXX instrument panel. Please note that in the graphic, XXXX is representative of your vehicle identification number. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 274 You can find a transmission/transaxle code on the Safety Compliance Certification Label. The following table tells you which transmission or transaxle each code represents. Description Code CVT (continuously variable transaxle) Six-speed automatic (Aisin F21) 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 275: Accessories
GENUINE FORD ACCESSORIES FOR YOUR VEHICLE A wide selection of Genuine Ford Accessories are available for your vehicle through your local Ford or Ford of Canada dealer. These quality accessories have been specifically engineered to fulfill your automotive needs; they are custom designed to complement the style and aerodynamic appearance of your vehicle.
Page 276 • Electrical or electronic accessories or components that are added to the vehicle by the authorized dealer or the owner may adversely affect battery performance and durability. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 277: Index
Cleaning your vehicle Automatic transmission engine compartment ....232 driving an automatic instrument panel ....234 overdrive ......188, 190 interior ........235 interior trim ......235 plastic parts ......233 washing ........231 Battery ........246 waxing ........231 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 278 ..245, 268 Getting the service you recommendations ....245 need .........224 refill capacities ......270 Ordering additional owner’s specifications ......270 literature .........229 Exhaust fumes ......183 Utilizing the Mediation/Arbitration Program ........227 Fluid capacities ......270 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 279 Head restraints ..109, 114–115 Keyless entry system ....102 Headlamps ........54 autolock ........91 aiming ........56 keypad ........102 autolamp system .......54 locking and unlocking doors ..103 bulb specifications ....58 programming entry code ..102 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 280 ....86 warning messages .....86 Mirrors .........70 Radio ........16, 21 automatic dimming rearview Relays ........202 mirror ........70 fold away ........71 Remote entry system ....96 heated ........71 illuminated entry ....100–101 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 281 ......157 front seats ....109, 111, 113 tire grades .......157 heated ........50 treadwear ......156, 161 memory seat .....97, 114 Towing ........177 SecuriLock passive anti-theft recreational towing ....179 system ........103 trailer towing ......177 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)
Page 282 ....90, 97 Windshield washer fluid and Turn signal ........58 wipers checking and adding fluid ..241 operation ........64 Vehicle Identification Number replacing wiper blades ...242 (VIN) ..........273 Wrecker towing ......222 Vehicle loading ......171 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus)

Ford 2007 Five Hundred Owner's Manual

Introduction

Instrument Cluster

Entertainment Systems

Climate Controls

Lights

Driver Controls

Locks and Security

Seating and Safety Restraints

Quick Links

Table of Contents

Need help?

Questions and answers

Related Manuals for Ford 2007 Five Hundred

Summary of Contents for Ford 2007 Five Hundred

Table of Contents