Page 1
Because the cast iron cylinders can be rebored, these engines can last even longer. Kohler engines are easy to service. All routine service parts - points, condensers, and carburetor are easily and quickly accessible. Every Kohler engine is backed by a worldwide support is just a phone call away.
For Your Safety! These precautions should be followed at all times. Failure to follow these precautions in injury to yourself and others. WARNING Explosive Fuel can cause fires and severe burns. Stop engine before filling fuel tank. Explosive Fuel! Gasoline is extremely flammable and its vapors can explode if ignited.
WARNING Accidental Starts can cause severe injury or death. Disconnect and ground spark plug lead before servicing. Accidental Starts! Before servicing the engine or equipment, always disconnect sparkplug lead to prevent the engine from starting accidentally. Ground the lead to prevent sparks that could cause fires.
Instrument Panel Option / Muffler Spark Plug Air Intake Screen Figure 1. Typical K582 Engine. Oil Recommendations Using the proper type and weight of oil in the crankcase is extremely important. daily and changing oil regularly. Failure to use the correct oil, or using dirty oil, causes premature engine wear and failure.
Be aware however, that the cylinder head will require more frequent. service. Gasoline/Alcohol blends Gasohol (up to 10% ethyl alcohol, 90% unleaded gasoline by volume) is approved as a fuel for Kohler engines. Other gasoline/alcohol approved. buildings, Gasoline/Ether...
If the starter does not turn the engine over, shut off starter immediately. attempts to start the engine until the condition corrected. (refer to “Battery” below). See your Kohler Engine Service Dealer for trouble analysis. Stopping Turn ignition switch OFF.
Every 500 Hours 0 Have valve and tappet clearance checked2. 0 Have cylinder heads serviced213. IPerform these maintenance procedures 2Have a Kohler Engine Service Dealer perform this service. 3250 hours when leaded gasoline is used. Cooling If debris builds NOTE:...
Page 8
Change Oil Filter Replace the oil filter every 100 hours of operation. Always use a genuine Kohler oil filter, Part No. 277233. Replace the oil filter as follows: Drain the crankcase oil filter. Use a 1” hex. wrench and turn the filter...
Page 9
Do not wash the paper element or use pressurized air, as this will damage the element. Replace a dirty, bent, or damaged element with a genuine Kohler element. Handle new elements carefully; do not use if the sealing surfaces are bent or damaged. With air cleaner disassembled, plate.
Page 10
Fuel Filter Some engines are equipped with an in-line fuel filter. Periodically inspect the filter and replace when dirty. Use a genuine Kohler filter. 0.025 in. (0.65 mm) Gap Spark Plug. Explosive Gas! charge...
Adjustments NOTE: Carburetor adjustments should be made only after the engine has warmed up. Kohler K582 engines are equipped with Kohler adjustable main jet carburetors. The carburetor is designed to deliver the correct fuel-to-air mixture to the engine under all operating conditions.
For example, a starting problem could be caused by an empty fuel tank. Some common causes of engine troubles are listed in the following table. Do not attempt to service or replace major engine components, adjustment procedures. Have your Kohler Engine Service Dealer do this work. Possible Cause Improper Problem Fuel Fuel...
Parts Ordering The engine Specification, Model, and Serial Numbers are required when ordering replacement your Kohler Engine Service Dealer. These numbers are found on the identification plate which is affixed to the engine shrouding. Include letter suffixes if there are any. See “Engine Identification Numbers”...
Page 14
Our obligation under this warranty is expressly limited, at our option, to the replacement or repair at Kohler Co., Kohler, Wisconsin 53044, or at a service facility designated by us, of such part or parts as inspection shall disclose to have been defective.
Page 16
ENGINE DIVISION, FOR SALES AND SERVICE iNFORMATION FORM NO.: TP-2123-B 1 I84 ISSUED: 1 REVISED: Ii/95 1 MAILED: LITHO IN U.S.A. KOHLER CO., KOHLER, WISCONSIN IN U.S. AND CANADA, CALL I-800-544-2444 53044...
Need help?
Do you have a question about the K582 and is the answer not in the manual?
Questions and answers