Page 1
* Refer to parts list on page 62. In compliance with Federal Regulations, following are reproduc- KENWOOD-Corp. certifies this equipment conforms to DHHS Reg- tions of labels on, or inside the product relating to laser product ulations No. 21 CFR 1040. 10, Chapter 1, Subchapter J.
Lock terminal board * FRONT SPEAKERS (E63-0200-05) (6-16Ω) (E70-0057-05) SUPER WOOFER OUTPUT INPUT PRE OUT Power cord bushing (J42-0083-05) AC power cord * (E30-) AC110- AC220- 120V 240V Slide switch (S62-0001-05) Illustration is RXD-790. * Refer to parts list on page 62.
RXD-790/V860/V890 DISASSEMBLY FOR REPAIR Remove main PCB's, then connect between PCB GND and chassis with alligator clip. 1. How to remove the main PCB. (1) Remove the 4 screws 1. (2) Remove the 9 screws 2. (3) Lay the rear panel with left side downward on the small box 2.
RXD-790/V860/V890 CIRCUIT DESCRIPTION 1. Initialization 1-1 Setting of initial conditions While pressing the [ENTER] key, plug the AC cord into the AC power outlet. 1-2 Initializing operation • A microcomputer is initialized for start when the AC power is turned on while pressing the [ENTER] key. At that time, CD mechanism are also initialized.
Page 7
RXD-790/V860/V890 CIRCUIT DESCRIPTION 2. KEY MATRIX No. of : Port No. of (X14)IC1 u-COM. KEY1 B PACK B PLAY STEREO F REC KEY2 A PACK A PLAY R REC KEY3 POWER A/B/BEATC INPUT KEY4 EQ. OFF MANU/REF CLASSIC ROCK KEY5...
Page 8
CD 4 CENTER LEVEL DOWN TAPE ¡ REAR LEVEL UP TAPE 1 REAR LEVEL DOWN 6. Main microprocessor M38198MCA-807FP (X14: IC1) : RXD-790 M38199MF-069FP (X14: IC1) : RXD-V860/V890 6-1 Microprocessor periphery block diagram (X14) IC1 (X14) ED1 (X14) IC5 RECEIVER SECTION...
Page 9
RXD-790/V860/V890 CIRCUIT DESCRIPTION 6-2 Pin description Pin No. Name Description BP-IN Speana input (A/D convertor input) Rotary encoder input B Rotary encoder input A A-PH A photo sensor input B-PH B photo sensor input HEAD PHONE Head phone sw input...
Page 10
RXD-790/V860/V890 CIRCUIT DESCRIPTION 7. Expander IC 7-1 Expander port connection EX ST IC DATA IC CLK SEL ST DOLBY ST (X14) IC5 EMPHASICE DAC ST SANYOU CE ECHO A (X05) IC2 ECHO B POWER SRS LED LW/SW 3ST LED PLL IC...
Page 11
RXD-790/V860/V890 CIRCUIT DESCRIPTION 7-2 Expander IC port description 7-2-1 Display section NJU7314(X14 : IC5) Pin No. Name Description SRS_LED SRS LED H=ON L=OFF 3ST_LED 3STEREO LED H=ON L=OFF PRO_LED PRO LOGIC LED H=ON L=OFF H.TAP HIGH TAP control H=ON L=OFF...
Page 12
DECK non music (black) cletect H=MUSIC L=NON MUSIC PAL/NTSC VCD board visual mode H=PAL L=NTSC PSSW CDM-27 MECHA position sw H=OFF L=ON STSW CDM-27 MECHA stop sw H=OFF L=ON CD section (RXD-790) : refer to RXD-500/700 service manual (B51-5300-00) on page11.
Page 14
RXD-790/V860/V890 ADJUSTMENT 2. Test mode of CD player 2-2 Main unit (X32) 2-1 Mechanism (1)Setting of the test mode (1) Setting of the test mode While pressing the [TIME DISP] key, plug the AC While pressing the [PLAY/PAUSE] key, plug the AC power cord in AC outlet.
Page 15
RXD-790/V860/V890 ADJUSTMENT 3. Adjustment of CD player INPUT OUTPUT PLAYER ALIGNMENT ITEM ALIGN FOR FIG. SETTING SETTING SETTING POINT Step 1~4 are in TEST MODE TEST MODE : While pressing the (TIME DISP.) key, plug the AC power cord into the AC outlet.
Page 16
RXD-790/V860/V890 ADJUSTMENT 4. Cassette Deck adjustment DECK INPUT OUTPUT ALIGNMENT ITEM ALIGN FOR FIG. SETTING SETTING SETTING POINT Unless otherwise specified, set the respective switches as follows: 0dBs=0.775V TAPE : NORMAL DOLBY : OFF PLAY OUT : Lch (X28,CN6 4pin), Rch (X28,CN6 1pin) ø...
RXD-790/V860/V890 RXD-790/V860/V890 WIRING DIAGRAM USED RXD-790/ RXD-V890 SUPER WOOFER PHONES (PRE OUT) FRONT SPEAKERS AUX INPUT MIC 1 AUDIO UNIT (X09-4XXX-XX) (A/5) USED RXD-V860 (K) : X09-4720-11 MIC 2 (M,I) : X09-4720-20 RXD-790 (X) : X09-4720-71 (H) : X09-4724-11 CONSTANT VOLTAGE UNIT...
PC BOARD(Component side view) CASSETTE MECHANISM UNIT TUNER UNIT (X05-4660-11) : KH (X28-2880-20) (X05-4660-20) : MI (X05-4660-71) : X (X05-4752-10) : V Refer to the schematic diagram for the value of resistors and capacitors.
Page 19
PC BOARD(Component side view) CD MECHANISM UNIT (X32-3270-20) : RXD-790 Refer to the schematic diagram for the value of resistors and capacitors.
Page 20
PC BOARD(Component side view) AUDIO UNIT (X09-48XX-XX) 80-20 [RXD-V860 (MI)] 32-10 [RXD-V860 (V)] Refer to the schematic diagram for the value of resistors and capacitors.
Page 21
PC BOARD(Component side view) Refer to the schematic diagram for the value of resistors and capacitors.
Page 22
PC BOARD(Component side view) Refer to the schematic diagram for the value of resistors and capacitors.
Page 23
PC BOARD(Component side view) Refer to the schematic diagram for the value of resistors and capacitors.
Page 24
(X05-4752-10) : V (X05-466X-XX) M,I,X,K,H TYPE 2.1V FM FRONT END A1 (W02-2608-05) 2.7V AM/FM 1.7V (2.0V) 3.7V SYSTEM J2 0 220 1/4W 0.01 (2.0V) 2.1V ANT1 5.1V FM 75Ω (3.0V) Ω FM 300 RF.AMP 10.2V(0V) ANT2 BUFF AM ANT 100K FM IF 1.9V 10.4V...
Page 25
50uS: 0V W116 PILOT PHASE DET 0.5V DESTINATION C21, 22 COUNTRY ABB. 4.0V 4.0V GENERAL MARKET 2.2u50 (1.5V) (0V) 0.012 µ MALAYSIA SHANGHAI C11 1u50 U.S.A. 0.018 µ KOREA AUSTRALIA 0.012 FM/AM C23 1u50 5.1V 12.3V RXD-790/V860/V890 (1/8) RXD-790/V860/V890 Y39-2600-20...
Page 27
1.3K 3.4V C52 10u50 R110 RXD-790/V860/V890 (2/8) CAUTION: For continued safety, replace safety critical components only with manufacturer's rec- The DC voltage is an actual reading measured with a high impedance type volt- ommended parts (refer to parts list). indicates safety critical components. For continued protec-...
Page 28
(X28-2880-20) Lch(+) Lch(-) Rch(+) WHITE GREEN E(+) Rch(-) BLUE Rch(-) GRAY BLUE Lch(+) BLUE E(-) Rch(+) WHITE E(+) BLACK Rch(+) GRAY COM(-) Rch(+) E(-) BLUE BLACK Lch(-) Lch(+) E(-) Lch(+) Lch(+) Rch(+) GREEN BLACK WHITE WHITE WHITE E(+) Rch(-) BLUE GRAY BLUE Rch(+)
Page 29
MTZJ2.7(B) 2SC1740S A PLAY : 3.0V A PLAY : 4.0V B PLAY : 0V RECORDING LINE B REC : 0V SIGNAL LINE GND LINE A PLAY : 0V B PLAY : 4.0V RXD-790/V860/V890 (3/8) B REC : 4.0V RXD-790/V860/V890 Y39-2600-20...
Page 30
CD UNIT (X32-3440-20) (A/2) : RXD-V860(M,I)/RXD-V890(M,I) CD CHANGER MECHA. :CDM-27 (D40-1562-X5) (X32-3532-10) (A/2) : RXD-V860(V)/RXD-V890(V) PICKUP ASS’Y:T25-0050-05 10.3V 1/2VCC 13.3K 13.3K 1/2VCC DRIVER- T.S.D MUTE SW-GND LD GND SL SW SHORT LAND REGULATOR REGULATOR SLM(-) BIAS T.S.D. MONITOR VR1 1K SLM(+) 13.3K 13.3K...
Page 31
5.7V 0.01 DSP+5.0V RXD-790/V860/V890(K) (4/8) The DC voltage is an actual reading measured with a high impedance type volt- meter as the AM/FM signal generator is specified to the conditions as shown in the list below. The measurement value may vary depending on the measuring instru- RXD-790/V860/V890 ments used or on the product.
Page 36
SURROUND UNIT (XO8-28XX-XX) 00-20 : RXD-790(K,M,I,X,H)/RXD-V890(M,I) 32-10 : RXD-V890(V) Sch TEST POINT Cch TEST POINT -12.5V X1 8MHz 12.1V +4.9V TEST POINT 4.7V 0.01 ELECTRIC VOL.(C.SURR) 5.2V 4.7V SOUT (2/2) 2.3V AGND VREF C90 4.7u35 5.1V TEST POINT INV-PHASE 0.3V...
Page 44
ITEM CARTON CASE RXD-V860 A70-1161-05 REMOTE CONTROL ASSY RXD-V860 H50-2598-14 ITEM CARTON CASE RXD-V860 A70-1162-05 REMOTE CONTROL ASSY RXD-V890 H50-2599-04 ITEM CARTON CASE RXD-790 H50-2600-04 ITEM CARTON CASE RXD-790 B10-2390-02 FRONT GLASS RXD-V860 B10-2391-02 FRONT GLASS RXD-790 J19-3325-05 UNIT HOLDER...
Page 45
TRANSISTOR RK73FB2A681J CHIP R 1/10W RK73FB2A5R6J CHIP R 1/10W W02-2608-05 FM FRONT-END ASSY R4 ,5 RK73FB2A331J CHIP R 1/10W SURROUND UNIT (X08-28XX-XX) : RXD-790/V890 RK73FB2A101J CHIP R 1/10W RK73FB2A473J CHIP R 1/10W C1 ,2 CE04LW1H010M ELECTRO 1.0UF 50WV RK73FB2A331J CHIP R...
Page 46
ALUMINUM ELECTROLYTIC C. HSS104A DIODE L : Scandinavia K : USA P : Canada R : Mexico 1 : RXD-790 2 : RXD-V860 L : Scandinavia K : USA P : Canada R : Mexico 1 : RXD-790 2 : RXD-V860...
Page 48
R187,188 RS14KB3D681J FL-PROOF RS L : Scandinavia K : USA P : Canada R : Mexico 1 : RXD-790 2 : RXD-V860 L : Scandinavia K : USA P : Canada R : Mexico 1 : RXD-790 2 : RXD-V860...
Page 49
CE04LW1H010M ELECTRO 1.0UF 50WV L : Scandinavia K : USA P : Canada R : Mexico 1 : RXD-790 2 : RXD-V860 L : Scandinavia K : USA P : Canada R : Mexico 1 : RXD-790 2 : RXD-V860...
Page 50
D1 -6 HSS104A DIODE L : Scandinavia K : USA P : Canada R : Mexico 1 : RXD-790 2 : RXD-V860 L : Scandinavia K : USA P : Canada R : Mexico 1 : RXD-790 2 : RXD-V860...
Page 51
R92-0670-05 CHIP R 0 OHM L : Scandinavia K : USA P : Canada R : Mexico 1 : RXD-790 2 : RXD-V860 L : Scandinavia K : USA P : Canada R : Mexico 1 : RXD-790 2 : RXD-V860...
Page 52
50WV DTA124ESA DIGITAL TRANSISTOR L : Scandinavia K : USA P : Canada R : Mexico 1 : RXD-790 2 : RXD-V860 L : Scandinavia K : USA P : Canada R : Mexico 1 : RXD-790 2 : RXD-V860...
Page 54
D10 ,11 1SR139-400 DIODE L : Scandinavia K : USA P : Canada R : Mexico 1 : RXD-790 2 : RXD-V860 L : Scandinavia K : USA P : Canada R : Mexico 1 : RXD-790 2 : RXD-V860...
Page 55
(TRAY) D14-0388-08 PINCH ASSY (L) L : Scandinavia K : USA P : Canada R : Mexico 1 : RXD-790 2 : RXD-V860 L : Scandinavia K : USA P : Canada R : Mexico 1 : RXD-790 2 : RXD-V860...
Page 56
N19-1316-08 POLY WASHER 1.8X6X0.5CUT L : Scandinavia K : USA P : Canada R : Mexico 1 : RXD-790 2 : RXD-V860 L : Scandinavia K : USA P : Canada R : Mexico 1 : RXD-790 2 : RXD-V860...
Tuning frequency range (except for U.S.A. and Canada) 9 kHz step........531 kHz ~ 1,602 kHz 10 kHz step........530 kHz ~ 1,610 kHz 1. KENWOOD follows a policy of continuous advancements in development. For this reason specifications may be changed without notice. Notes Notes 2.
Page 58
[FM Tuner section] RXD-V890..............10.8 kg Tuning frequency range ......87.5 MHz ~ 108 MHz RXD-V860..............10.0 kg [AM Tuner section] 1. KENWOOD follows a policy of continuous advancements in devel- opment. For this reason specifications may be changed without Notes Tuning frequency range notice.