Sony FD Triniton KV-29FQ76E Service Manual
  1. Manuals
  2. Brands
  3. Sony Manuals
  4. TV
  5. FD Triniton KV-29FQ76E
  6. Service manual

Sony FD Triniton KV-29FQ76E Service Manual

Color tv ae-6a chassis
Hide thumbs
Table of Contents

Advertisement

Quick Links

SERVICE MANUAL

MODEL
KV-29FQ76E
COMMANDER
DEST
CHASSIS NO.
RM-938
ESP
SCC-Q81H-A
MODEL
KV-29FQ76K
KV-29FQ76
- 1 -
AE-6A
CHASSIS
COMMANDER
DEST
CHASSIS NO.
RM-938
OIRT
SCC-Q82D-A
RM-938

Advertisement

Table of Contents
loading

Related Manuals for Sony FD Triniton KV-29FQ76E

Summary of Contents for Sony FD Triniton KV-29FQ76E

  • Page 1: Service Manual

    SERVICE MANUAL AE-6A CHASSIS MODEL MODEL COMMANDER DEST CHASSIS NO. COMMANDER DEST CHASSIS NO. KV-29FQ76E KV-29FQ76K RM-938 SCC-Q81H-A RM-938 OIRT SCC-Q82D-A KV-29FQ76 RM-938 - 1 -...

  • Page 2: Table Of Contents

    TANCE CRITIQUE POUR LA SÈCURITÈ DU FONCTIONNEMENT, THESE COMPONENTS WITH SONY PARTS WHOSE PART NE LES REMPLACER QUE PAR DES COMPSANTS SONY DONT NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN LE NUMÈRO DE PIÈCE EST INDIQUÈ DANS LE PRÈSENT SUPPLEMENTS PUBLISHED BY SONY.

  • Page 3: Caution

    Due to the higher melting point of Lead Free Solder the soldering iron tip temperature needs to be set to 370 degrees centigrade. This requires soldering equipment capable of accurate temperature control coupled with a good heat recovery characteristics. For more information on the use of Lead Free Solder, please refer to http://www.sony-training.com - 3 -...
  • Page 4 l l a . s l . s l . s l . s l . s l e i l . s l n i l s i l i n i y t i - 4 -...

  • Page 5: Connectors

    21 pin connector Pin No Signal Signal level Audio output B Standard level : 0.5V rms (right) Output impedence : Less than 1kohm* Audio input B Standard level : 0.5V rms (right) Output impedence : More than 10kohm* Audio output A Standard level : 0.5V rms (left) Output impedence : Less than 1kohm*...

  • Page 6: Self Diagnostic Software

    AE-6A SELF DIAGNOSTIC SOFTWARE The identification of errors within the AE-6A chassis is triggered in one of two ways :- 1: Busy or 2: Device failure to respond to IIC. In the event of one of these situations arising the software will first try to release the bus if busy (Failure to do so will report with a continuous flashing LED) and then communicate with each device in turn to establish if a device is faulty.
  • Page 7 Error Detection Monitor Device acknowledge is used to check IIC errors. Device acknowledge is checked by sending an IIC start sequence during CRT power on. Each device is checked three times, if there is no acknowledge after each attempt, it will be regarded as an error. There are three steps to check for errors.
  • Page 8 2. Error Reader Display The error reader display is connected to the service connector to read actual error codes. The part number for the error reader display is S-188-900-10. Once an error has been detected it will then be displayed on the two digit error reader. The errors displayed refer to the following table.

  • Page 9: General

    SECTION 1 GENERAL - 9 -...
  • Page 10 - 10 -...
  • Page 11 - 11 -...
  • Page 12 - 12 -...
  • Page 13 - 13 -...
  • Page 14 - 14 -...

  • Page 15: Disassembly

    SECTION 2 DISASSEMBLY 2-1. Rear Cover Removal (Step 1) 2-2. Rear Cover Removal (Step 2) => <= <= => => <= <= => <= => Remove the eight fixing screws indicated and remove the Remove the rear cover fixing screws indicated. Take care ornamental cover by sliding back over the rear cover.

  • Page 16: Service Position

    2-5. Service Position 2-6. G Board Removal Screw Clips To place the chassis in the service position, remove the D2 bracket (see 2-8.) and locate on the outer edge of the main To remove the G Board first remove the PFC bracket by bracket as shown.

  • Page 17: Side Control Module Removal

    2-9. Side Control Module Removal 2-10. H2 Board Removal Screws Clips Remove the two screws fixing the user control module to the To remove the H2 Board release the two clips circled and ease side of the set. The control module can then be removed by the board gently away from the support bracket.

  • Page 18: Wire Dressing

    2-13. Wire Dressing 3 2-14. Wire Dressing 4 Ensure the RF lead is dressed as shown circled above to avoid To avoid damage to the ground interconnecting leads from the obstructing the rear cover. sharp edges of the heatsink they must be dressed as shown above between the rear of the heatsink and the tuner.

  • Page 19: Picture Tube Removal

    2-17. Picture Tube Removal WARNING: BEFORE REMOVING THE ANODE CAP High voltage remains in the CRT even after the power is disconnected. To avoid electric shock, discharge CRT before attempting to remove the anode cap. Short between anode and CRT coated earth ground strap.
  • Page 20 - 20 -...

  • Page 21: Set-Up Adjustments

    SECTION 3 SET-UP ADJUSTMENTS • When complete readjustment is necessary or a new picture tube Carry out the adjustments in the following order : is installed, carry out the following adjustments. 3-1. Beam Landing and Geometry. • Unless there are specific instructions to the contrary, carry out 3-2.

  • Page 22: Convergence

    Fig.3-4 Align both Purity Purity magnets Purity control magnets magnets to the vertical position Align pips on each magnet 3-2. Convergence (1) Screen centre convergence [Static convergence] Input a dot pattern signal from the pattern generator. GREEN Normalize the picture setting. [Moving vertically], adjust the V.STAT magnet so that the BLUE vertical red, green and blue dots coincide at the centre of the...
  • Page 23 Correction for HMC [Horizontal mis-convergence] and VMC HTIL correction can be performed by adding a THL correction [Vertical mis-convergence] by using the BMC [Hexapole] assembly to the Deflection yoke. magnet. a). HMC correction by BMC [Hexapole] magnet and movement of the electron beam.

  • Page 24: Focus Adjustment

    Layout of each control 3-3. Focus Adjustment Receive a cross hatch pattern from a video generator. Adjust the focus control located on the flyback transformer to the best level at the centre of the screen. Purity magnet Check left and right x-axis vertical line thickness and adjust to BMC (Hexaploe) magnet V STAT convergence magnet make them as thin as possible.

  • Page 25: Circuit Adjustments

    SECTION 4 CIRCUIT ADJUSTMENTS Initialising Menu 4-1. Electrical Adjustments Service adjustments to this model can be performed using the supplied remote Commander RM-938. s i l Programming the Remote Commander for Operation in Service Mode Press the VCR/TV/DVD button until the TV LED lights.
  • Page 26 Basic Setting t l i f a l i a l i a l i a l i Table.4-2 Feature Setting Table.4-5 Table.4-3 Device Register Setting l v l " 6 Table.4-6 c t i Table.4-4 t l i Table.4-7 - 26 -...
  • Page 27 Table.4-8 Table.4-9 - 27 -...
  • Page 28 . f f . f f . f f . f f Table.4-10 Table.4-12 Table.4-11 - 28 -...

  • Page 29: Volume Electrical Adjustments

    4-2. Volume Electrical Adjustments Deflection System Adjustment Sub Colour Adjustment Enter into the service mode and select ‘Deflection’ from the menu. The ‘Deflection’ adjustment menu will be displayed. Input a PAL colour bar signal. Select and adjust each item to obtain the optimum image. Connect an oscilloscope to CN5400 pin 5 located on the C Board.

  • Page 30: Test Mode

    4-3. TEST MODE 2: Is available by pressing the ‘TEST’ button twice, OSD ‘TT’ appears. The functions described below are available by selecting the two numbers. To release the ‘Test mode 2’, press 0 twice, press the TV button or switch the TV set into Stand-by mode. Pressing the two Local Control buttons (+ and -) during power ON will also switch into ‘TT’...

  • Page 31: Block Diagrams

    5-1. BLOCK DIAGRAMS (1) CN2000 ANALOGUE TU1001 TUNER VELOCITY MODULATION CP1100 CN1602 SWATT CN5444 MAIN RY CN5602 DGCRY Q.P - Q.P - A BOARD FM/AM Q.P + Q.P + CN1803 CN1201 LEFT SP VIDEO TO SPEAKERS RIGHT SP VM BUFFER VM IN VM AMP VM OUT...

  • Page 32: Block Diagrams

    5-1. BLOCK DIAGRAMS (2) IC1801 IC1804 IC1808 IC1811 DQP- S2601 IC1402 DF-DRIVE PHASE AC-AMP DQP-PHASE CN1803 CN2601 POWER CN2603 VM-OUT DQP-DC-LEVEL VM BOARD DPIC CN5602 DPDT-OFF Y100 BOARD G Y-IN CN6001 U100 CB-IN V100 CR-IN POWER SWITCH, CN1804 IC1950 F3 ( R-OUT SIRCS RECEIVER ROTATION (N/S)

  • Page 33: Block Diagrams

    5-1. BLOCK DIAGRAMS (3) VG(L) Q6804, Q6805 T6800 VG(H) CN6801 200V SS RESET OVERSHOOT AFC PULSE Q6814, PULSE PROJECT DETECT V SENSE Q6813 Q6816, Q6817 Q6802, Q6803 IC6800 200V DYNAMIC DYNAMIC FOCUS FOCUS CN6801 Q8918 T8901 HPROT PROTECT Q6807 A BOARD CN1903 IC6802 BUFFER...
  • Page 34 5-1. BLOCK DIAGRAMS (4) CN3600 RIGHT IN(4) AV4R LEFT IN(4) AV4L MODE(4) AV4MODE C IN(2) AV4C Y IN AV4Y IC3500 BLUE IN V-IN-1-B GREEN IN ASSY V-IN-1-G RED IN CN8612 V-IN-1-R BLANKING BLK-1 A BOARD IC3300 CN1802 MAIN AUDIO/VIDEO SWITCH RGBSEL RIGHT OUT(1) MAIN-TV-R-IN...

  • Page 35: Block Diagrams

    5-1. BLOCK DIAGRAMS (5) CN4472(2) Y 100 OUT AMP Q4903 IC4900 U 100 OUT AMP Q4904 V 100 OUT AMP Q4905 R(0) D(31) D(31) SDDAT31 DSPCR0 DQ31 R(1) D(30) D(30) DSPCR1 SDDAT30 DQ30 R(2) D(29) D(29) DSPCR2 SDDAT29 DQ29 R(3) D(28) D(28) DSPCR3...

  • Page 36: Circuit Board Location

    5-1. BLOCK DIAGRAMS (6) 5-2. CIRCUIT BOARD LOCATION Reference Information CN100/1 IC103 RESISTOR : METAL FILM CS DISABLE CS DISABLE AGC-MON P5.0 CN100/2 P2.14 KEY2/SCL3.3 AGC-DEFEAT MS SHUT DOWN : SOLID P6.5 AGC DEFEAT P3.2 C Board KEY1/SCL3.3 RESET AUDIO FPRD : NON FLAMMABLE CARBON P6.2...
  • Page 37 ~ A Printed Wiring Board Conductor side A ~ - 37 -...
  • Page 38 ~ A Printed Wiring Board Conductor side B ~ - 38 -...
  • Page 39 A Board Location Table (A Side) ~ A Board Waveforms ~ 10us/div 10us/div 10us/div 2ms/div 750 mVp-p (H) 650 mVp-p (H) 600 mVp-p (H) 2.8 Vp-p (V) 10us/div 10us/div 20us/div 10us/div A Board Location Table (B Side) ~ 5.2 Vp-p (H) 800 mVp-p (H) 700 mVp-p (H) 580 mVp-p (H)

  • Page 40: A Board Schematic

    A..-29FQ76 INTERFACE +5V_STBY D1016 UDZS-5.6B D1015 AOPP D1NL20U-TR 3.3V_STBY Page 3 D1017 IC1012 Page 4 D1NL20U-TR BA033T D1012 +5V_STBY FL1010 UDZSTE-174.7B VIDEO 2.5V SCL-TV SDA-TV Page 4 C1052 C1053 C1047 C1049 R1041 D1007 2200 IC1008 DAP202K 6.3V CXA1875AM-T4 PROT AM, QSS I/O EXPANDER R1043 Page 4...
  • Page 41 TO G BOARD TO G BOARD CN6006 CN6008 CN1602 CN2000 A..-29FQ76 +5V_STBY R1068 4.7k Q1012 R1059 2SC2412K-R AC_ON/OFF R1057 4.7k 6.8k D1019 R1060 C1014 UDZS-5.6B 0.22 R1069 IC1011 4.7k PS1011 PS1012 BA05T R1058 Q1011 2SC2412K-R +5V_STBY 3.3V_STBY C1043 C1045 C1044 C1046 IC1005 2200...
  • Page 42 A..-29FQ76 IC1201 POWER-OFF-MUTE TDA7482 AOPP AUDIO AMPLIFIER WOOFER +5V_STBY D1003 Page 2 D1201 DAN202K DAN202K Page 3 5V_1 R1014 R1027 CHIP 4.7k 5V_1 CHIP Q1001 R1021 AUDIO PROTECTION R1079 2SC2412K C1205 R1205 2200 CHIP Q1003 Q1007 CHIP DTA144EKA 2SC2412K Q1002 Q1201 R1210 L1202...
  • Page 43 A Schematic [ Audio Decoder &Amplifier,Vertical Deflection, Picture Rotation, Dynamic Convergence] page 1/4~ - - 43 -...
  • Page 44 J2 Schematic [ AV, Scart, I/O Switching and Sockets] page 1/2~ - - 44 -...

  • Page 45: J2 Board Schematic

    J2 Board Schematic Diagram [ AV, Scart, I/O Switching and Sockets ] Page 2/2 ~ H Board Schematic Diagram [ AV Link Processor ] ~ J2.-29FQ76 H..-29FQ76 CN301 AV LINK PROCESSOR +5V_STBY 3.3V_STBY +5V_STBY TO F3 BOARD SIRCS CN2151 R323 R3866 L3803 RESP_LED...
  • Page 46 ~ J2 Printed Wiring Board Conductor side A ~ ~ J2 Printed Wiring Board Conductor side B ~ ~ J2 Board Location Table A side ~ ~ J2 Board Location Table B side ~ ~ F3 Printed Wiring Board Conductor side ~ ~ H Printed Wiring Board Conductor side ~ ~ H2 Printed Wiring Board Conductor side ~ - 46 -...

  • Page 47: C Board Schematic

    CN5633 TO FBT FV FOCUS C..-29FQ76 CN5634 R,G,B OUT +200V TO D1 BOARD external CN8614 RV5375 110M R5383 L5376 20MM CN5600 R5300 R5376 R5325 +200V J5375 R5384 D5375 D5376 G2 (+1100V) R5377 20MM R5375 ISS133T ISS133T 2.2k R5385 R5387 L5377 D5381 RED-VIDEO-OUT RED.OUT 1/2W...
  • Page 48 ~ C Printed Wiring Board Conductor side ~ ~ M2 Printed Wiring Board Conductor side A ~ ~ C Board Waveforms ~ 10us/div 10us/div 2.0 Vp-p (H) 2.2 Vp-p (H) 10us/div 5us/div ~ M2 Printed Wiring Board Conductor side B ~ 20.0 Vp-p (H) 2.2 Vp-p (H) 5us/div...

  • Page 49: M2 Board Schematic

    CN104 M2.-29FQ76 +2.5VCORE +3.3V R187 R213 R215 R216 R217 R214 R188 4.7k R100 R101 3.3k +3.3V R189 3.3k C113 RB111 RB113 IC101 C101 R102 Q100 PST6001MT Q118 Q120 Q116 DTC114YKA DTC114YKA DTC114YKA R124 IC104 /RESET M24C32-WMN6T(A) R248 3.3k C100 C150 Q119 0.47 RB108...
  • Page 50 ~ M2 Board IC Voltages ~ ~ M2 Board Semiconductor Voltages ~ ~ D2 Printed Wiring Board Conductor Side~ ~ D2 Board Location Table ~ ~ D2 Board IC Voltages ~ ~ D2 Board Semiconductor Voltages ~ - 50 -...

  • Page 51: D2 Board Schematic

    D2.-29FQ76 C6852 R6865 SS RESET 0.01 C6849 470p HV OVERSHOOT PROTECT 1608 Q6813 +12V DYNAMIC PICTURE STABLISING CIRCUIT 2SB709A-QRS-TX R6862 R6897 470k R6870 R6867 D6820 220k R6885 MTZJ-7.5B 1/10W 1/10W 1/10W CHIP CHIP Q6817 CHIP 2SB709A-QRS Q6812 R6896 C6848 R6882 R6869 Q6815 R6868...

  • Page 52: D1 Board Schematic

    R8320 JL041 1.5kV STP5NB40FP R8803 T8101 C8120 LINEARITY R8118 PROT. REF D8802 Q8103 C8111 C8113 0.18 C8807 1SS355 R8104 R8105 2SC5696-SONY-CA 470p 6200P 250V 1/4W 4.7K 4.7K LOWER H-OUT 1.5kV C8118 C8818 R8832 R8810 D8311 0.12 C8809 C8122 100k JL040 250V 0.01...
  • Page 53 ~ D1 Printed Wiring Board Conductor side ~ ~ D1 Board Location Table ~ ~ D1 Board Waveforms ~ ~ D1 Board Semiconductor Voltages ~ 10us/div 10us/div 10us/div 4.0 Vp-p (H) 20.0 Vp-p (H) 4.0 Vp-p (H) ~ D1 Board IC Voltages ~ 10us/div 10us/div 10us/div...

  • Page 54: G Board Schematic

    ~ G Board Schematic Diagram [ Power Supply ] ~ - 54 -...
  • Page 55 ~ G Board IC Voltages ~ ~ G Board Semiconductor Voltages ~ ~ G Board Semiconductor Location Table ~ ~ G Printed Wiring Board Conductor side ~ ~ VM Printed Wiring Board Conductor side ~ ~ VM Board Waveforms ~ ~ VM Board Semiconductor Voltages ~ 500ns/div 500ns/div...

  • Page 56: Vm Board Schematic

    ~ B5 Board Schematic Diagram [ Picture Decoder, DRC, Digital Noise Reduction ] Page 7/7 ~ ~ B5 Board Schematic Diagram [ Picture Decoder, DRC, Digital Noise Reduction ] Page 5/7 ~ B5.-29FQ76 B5.-29FQ76 COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL ADD, DATA, WE, RAS, CAS, CS DS_OUT FL4607...
  • Page 57 B5.-29FQ76 CN4472 R4447 POWER_INT POWER_INT PICTURE DECODER, DRC, DIGITAL NOISE REDUCTION IC4402 TC7SET04F(TE85R) INVERTER +3.3V D3.3V-AD +3.3V HP_100_OUT FL4405 D3.3V-AD L4411 C4459 R4428 R4427 R4426 R4425 R4423 C4429 R4424 10uH R4484 FB4403 2.2k 2.2k 4.7k 4.7k 0.01 1/10W 1/10W 1/10W 1/10W VP100_OUT IC4403...
  • Page 58 B5.-29FQ76 COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL DIYD[0-7],DICD[0-7],W13ID,IHDD,IVDD DDTB FL4202 Page 1 +1.8V R4239 Q4200 C4206 C4208 0.01 R4238 R4245 R4246 FL4201 D3.3V-1 C4209 C4217 C4207 C4219 +3.3V 0.01 0.01 0.01 C4225 R4235 C4221 C4226 0.01 0.01 0.01 W13ID...
  • Page 59 B5.-29FQ76 C3219 C3220 FL3203 FL3202 A5V-1 FL4901 D5V-SCD R3226 C3222 C3208 C3235 R3201 C3212 C3217 R3212 CHIP 0.01 A5V-1 Q3202 2PD601AR-115 R4908 R4910 C4902 C4905 C3209 C3213 R4906 0.01 RN-CP RN-CP RN-CP PDACY R3227 R3235 X3200 R4909 C4908 16.2MHz RN-CP R4915 R4916 R4917...
  • Page 60 B5.-29FQ76 COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL C4629 ADD, DATA, WE, RAS, CAS, CS R4698 C4627 0.01 Page 5 0.01 C4628 C4630 0.01 0.01 Q4600 2PD601AR-115 BUFFER VDOCIN7 SDADR3 D[16] VP_SUB_IN R4601 VDOCIN6 SDDAT16 D[17] VDOCIN5 R4600 CHIP SDDAT17...
  • Page 61 B5.-29FQ76 A5V-ADC C3149 C3150 Q3117 0.01 2PD601AR-115 BUFFER DCDB Page 1 R3152 5.6k R3156 R3168 R3150 C3116 C3119 C3121 C3125 0.01 0.01 0.01 0.01 CHIP FL3107 C3120 C3122 C3127 C3131 0.01 0.01 0.01 0.01 C3117 C3126 0.01 0.01 C3114 C3129 0.01 0.01 R3154...
  • Page 62 ~ B5 Printed Wiring Board Conductor side A ~ ~ B5 Location Table A Side ~ ~ B5 Printed Wiring Board Conductor side B ~ ~ B5 Location Table B Side ~ - 62 -...

  • Page 63: Semiconductors

    5-4. SEMICONDUCTORS BA033T CXD2088Q-TX MSP3411G-QA-B10 BA05T CXD2095AQ BA12T CXD2096Q SE-012N-LF4 CXD2309Q-T6 CXD9509AQ CXD9665Q CXD2095AQ ( TOP VIEW ) ( TOP VIEW ) NJM2903M NJM2904M CXAB070AP NJM3403AM MCZ3001D UPC4558G2 LA6500-FA ( TOP VIEW ) CXA1875AM-T4 PQ1CG2032FZ LM318P LM358D LM393DT LM393N M24C32-WMN6T(A) ( TOP VIEW ) CXA1855Q CXA2149AQ-TL...
  • Page 64 2SA1162-G 2SA1037AK-T146 2SC1623-L5L6 2SC2412K-T-146 2SD601A-Q-TX SE-135N SE135N-LF4 TDA7482 DTA144ESA 2SA933AS-QT 2SC2785-HFE 3 GND STV9379A TLC2932IPWR TLC2933IPWR-12 L7809CV/LSY STP5NB40FP STP5NB40(030Y) 2SC5698-CA 2S5696-SONY-CA TCET1103G BA12T BAO33T IRFI644G-LF36 IRF614-005 IRF720-LF49 IRF620 SPA07N60C2-E8152 2SA1837 2SA2005 MSB709-RT1 TC7SET04F(TE85R) 2SC5511 MSD601-RST1 TC7SET08F(TE85L) M1MA152WA-T1 TC7SET08FU(TE85) UN2111 UN213...
  • Page 65 2SB733-34 DAP202K GS1B460/45 D1NL20U D1NL20U-TR D1NL40-TA2 2SC2688(5)-LK D1NS4 EGP20G EL1Z GP08D L-59SRSGC-CC RGP10GPKG23 UF4005PKG23 CATHODE ANODE RD15ES-B2 ERA22-08 BAS316-115 RD18ES-B2 ERA85-009 DTZ-TT11-6.8B HZS9.1NB2 RD5.1ESB2 MMDL914T1 MA3062M-TX RD5.6ESB2 MTZJ-13B UDZS-TE17-12B RD5.1M-B2 MTZJ-33B RD6.8ESB2 UDZSTE-174.7B MTZJ-3.6A RD8.2ESB3 UDZSTE-175.1B 1SS119-25 MTZJ-30C UDZSTE-175.6B MTZJ-7.5B 1SS133T-77 UDZSTE-176.2B MTZJ-T-77-15B...

  • Page 66: Ic Blocks

    5-5 IC BLOCK DIAGRAMS J2 BOARD IC3500 TDA8601T DECODING SELECTABLE CLAMP SELECTABLE 3-STATE CLAMP SELECTABLE CLAMP SELECTABLE 3-STATE CLAMP SELECTABLE CLAMP SELECTABLE 3-STATE CLAMP 3-STATE G BOARD IC6001 MCZ3001D D2 BOARD IC6800 MCZ3001D Remote Internal DVLD Driver ref 5v Sel=34v Reg.
  • Page 67 A BOARD IC1231 MSP3411G SBUS Interface I2C Interface DEMODULATOR IDENT SCART Switching Facilities G BOARD IC6003 SE135N-LF4 A BOARD IC1801/IC1804/IC1808 LM393DT A BOARD IC1701 STV9379 A BOARD IC1802 LM358N FLYBACK GENERATOR POWER AMPLIFIER THERMAL PROTECTION - 67 -...
  • Page 68 A BOARD IC1006/IC1007/IC1010 PQ1CG2032FZ Vout ON/OFF PWM COMP ON/OFF ERROR AMP Oadj Vref A BOARD IC1012/IC1812 BA033T/BA12T D2 BOARD IC6801/IC6802 NJM2903/NJM2904 REFERENCE VOLTAGE D2 BOARD IC6803/IC6807 TLV431 Cathode Vref Anode - 68 -...

  • Page 69: Exploded Views

    SECTION 6 EXPLODED VIEWS NOTE : Items with no part number and no description are not Items marked “*” are not stocked stocked because they are seldom required for routine since they are seldom required for service. routine service. Some delay should The construction parts of an assembled part are indicated be anticipated when ordering these with a collation number in the remarks column.

  • Page 70: Picture Tube

    6-2. PICTURE TUBE REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK X-4039-956-1 BEZNET ASSY 52-56 4-206-678-01 ORNAMENTAL WINDOW 4-206-679-01 BUTTON, POWER 4-204-426-01 SPRING 4-206-680-01 GUIDE, LIGHT 4-204-295-01 SHEET, BLOTTING X-4039-957-1 DOOR ASSY 58-60 4-206-681-01 DOOR 4-206-682-01 BRACKET, DOOR 4-047-464-01 CATCHER, PUSH £...

  • Page 71: Electrical Parts List

    SECTION 7 ELECTRICAL PARTS LIST PARTS LISTING TABLE OF CONTENTS Page D1 BOARD COMPLETE Parts List : ..................72 D2 BOARD COMPLETE Parts List : ..................74 B5 BOARD COMPLETE Parts List : ..................76 G BOARD COMPLETE Parts List : ..................
  • Page 72 H6 D1 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK *A-1300-275-A D1 Board, Complete C8820 1-164-227-11 CERAMIC CHIP 0.022UF 10.00% 25V C8821 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 16V *3-646-071-02 HOLDER, WIRE C8822 1-136-479-11 FILM 0.001UF 2.00% 50V 4-382-854-01 SCREW (M3X8), P, SW (+) C8823 1-162-964-11 CERAMIC CHIP 0.001UF 5.00% 50V...
  • Page 73 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK Q8102 8-729-056-16 TRANSISTOR 2SC5698-SONY-CA R8309 1-216-841-11 RES-CHIP 1/10W Q8103 8-729-056-17 TRANSISTOR 2SC5696-SONY-CA R8317 1-215-473-00 METAL 150K 1% 1/4W Q8105 8-729-050-48 TRANSISTOR IRF614-005 R8318 1-215-461-00 METAL 1/4W Q8106 8-729-047-59 TRANSISTOR STP5NB40FP R8319 1-218-871-11 METAL CHIP 0.5% 1/10W...
  • Page 74 D1 D2 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R8844 1-215-469-00 METAL 100K 1% 1/4W C6835 1-127-715-91 CERAMIC CHIP 0.22UF R8845 1-215-469-00 METAL 100K 1% 1/4W C6836 1-136-165-00 FILM 0.1UF 5.00% 50V R8847 1-216-833-11 RES-CHIP 1/10W C6837 1-136-103-00 FILM 0.1UF 5.00% 200V R8848...
  • Page 75 F4 A D2 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < FERRITE BEAD > R6819 1-215-445-00 METAL 1/4W R6820 1-216-837-11 RES-CHIP 1/10W FB6801 1-412-911-11 FERRITE R6821 1-216-837-11 RES-CHIP 1/10W FB8901 1-535-143-61 LEAD, JUMPER (5.0MM) R6823 1-247-843-11 CARBON 3.3K 5% 1/4W R6825 1-218-912-11 METAL CHIP...
  • Page 76 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R8951 1-216-486-21 METAL OXIDE 8.2K 5% C3125 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V R8952 1-216-486-21 METAL OXIDE 8.2K 5% C3126 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V R8954 1-260-123-11 CARBON 100K 5% 1/2W C3127 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V...
  • Page 77 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C3213 1-124-779-00 ELECT CHIP 10UF 20.00% 16V C4232 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V C3214 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V C4233 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V C3215 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V C4234 1-107-826-11 CERAMIC CHIP 0.1UF...
  • Page 78 M B5 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C4605 1-124-779-00 ELECT CHIP 10UF 20.00% 16V C4909 1-162-927-11 CERAMIC CHIP 100PF 5.00% 50V C4606 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V C4910 1-162-927-11 CERAMIC CHIP 100PF 5.00% 50V C4607 1-124-779-00 ELECT CHIP 10UF 20.00% 16V C4608...
  • Page 79 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK FL4412 1-234-177-21 FERRITE < TRANSISTOR > FL4600 1-234-177-21 FERRITE FL4601 1-234-177-21 FERRITE Q3100 8-729-422-33 TRANSISTOR 2SD601A-Q-TX FL4602 1-234-177-21 FERRITE Q3102 8-729-422-33 TRANSISTOR 2SD601A-Q-TX FL4603 1-234-177-21 FERRITE Q3104 8-729-026-49 TRANSISTOR 2SA1037AK-T146 Q3106 8-729-422-33 TRANSISTOR 2SD601A-Q-TX FL4604 1-234-177-21 FERRITE Q3107...
  • Page 80 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R3101 1-216-864-11 SHORT CHIP R3154 1-216-818-11 RES-CHIP 1/10W R3102 1-216-813-11 RES-CHIP 1/10W R3155 1-216-818-11 RES-CHIP 1/10W R3103 1-216-813-11 RES-CHIP 1/10W R3156 1-216-818-11 RES-CHIP 1/10W R3104 1-216-815-11 RES-CHIP 1/10W R3157 1-216-818-11 RES-CHIP 1/10W R3105 1-218-843-11 METAL CHIP 0.5% 1/10W...
  • Page 81 H5 D2 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R3236 1-218-865-11 METAL CHIP 5.6K 0.5% 1/10W R4219 1-216-833-11 RES-CHIP 1/10W R3237 1-218-865-11 METAL CHIP 5.6K 0.5% 1/10W R4232 1-216-864-11 SHORT CHIP R3238 1-218-865-11 METAL CHIP 5.6K 0.5% 1/10W R4234 1-216-809-11 RES-CHIP 1/10W R3239...
  • Page 82 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R4456 1-216-841-11 RES-CHIP 1/10W R4633 1-216-864-11 SHORT CHIP R4457 1-216-841-11 RES-CHIP 1/10W R4634 1-216-833-11 RES-CHIP 1/10W R4458 1-216-815-11 RES-CHIP 1/10W R4635 1-216-864-11 SHORT CHIP R4459 1-216-815-11 RES-CHIP 1/10W R4636 1-216-833-11 RES-CHIP 1/10W R4461 1-216-841-11 RES-CHIP 1/10W...
  • Page 83 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R4915 1-216-821-11 RES-CHIP 1/10W RB4628 1-234-523-21 RES, CHIP NETWORK 0 (3216) R4916 1-216-821-11 RES-CHIP 1/10W R4917 1-216-821-11 RES-CHIP 1/10W < CRYSTAL > < NETWORK RESISTOR > X3100 1-781-723-21 OSCILLATOR, CRYSTAL X3200 1-781-914-21 VIBRATOR, CRYSTAL RB4200 1-239-409-11 RES, CHIP NETWORK 47 (3216) X4601...
  • Page 84 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C6102 1-126-943-11 ELECT 2200UF 20.00% 25V L6002 1-412-521-31 INDUCTOR 4.7UH C6103 1-126-971-11 ELECT 470UF 20.00% 50V L6003 1-412-521-31 INDUCTOR 4.7UH C6105 1-126-964-11 ELECT 10UF 20.00% 50V L6004 1-535-143-61 LEAD, JUMPER (5.0MM) C6106 1-126-964-11 ELECT 10UF 20.00% 50V...
  • Page 85 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R6033 1-215-481-00 METAL 330K 1% 1/4W C2305 1-126-941-11 ELECT 470UF 20.00% 25V R6035 1-260-083-11 CARBON 1/2W C2306 1-104-665-11 ELECT 100UF 20.00% 25V R6036 1-216-817-11 RES-CHIP 1/10W C2307 1-104-665-11 ELECT 100UF 20.00% 25V R6037 1-249-405-11 CARBON 1/4W...
  • Page 86 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C3300 1-126-947-11 ELECT 47UF 20.00% 25V C3415 1-164-346-11 CERAMIC CHIP 1UF C3301 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V C3416 1-164-346-11 CERAMIC CHIP 1UF C3302 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V C3417 1-164-346-11 CERAMIC CHIP 1UF C3304 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V...
  • Page 87 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK D2676 8-719-083-82 DIODE UDZS-TE17-12B < COIL > D2700 8-719-083-82 DIODE UDZS-TE17-12B D2701 8-719-083-82 DIODE UDZS-TE17-12B L3305 1-414-934-21 INDUCTOR 10UH D3600 8-719-083-82 DIODE UDZS-TE17-12B L3306 1-414-934-21 INDUCTOR 10UH D3601 8-719-083-82 DIODE UDZS-TE17-12B L3307 1-414-934-21 INDUCTOR 10UH L3308...
  • Page 88 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R2305 1-216-819-11 RES-CHIP 1/10W R2659 1-216-841-11 RES-CHIP 1/10W R2306 1-216-029-00 RES-CHIP 1/10W R2660 1-216-813-11 RES-CHIP 1/10W R2307 1-216-029-00 RES-CHIP 1/10W R2661 1-216-821-11 RES-CHIP 1/10W R2308 1-216-029-00 RES-CHIP 1/10W R2662 1-216-853-11 RES-CHIP 470K 5% 1/10W R2309 1-216-029-00 RES-CHIP...
  • Page 89 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R3146 1-216-813-11 RES-CHIP 1/10W R3422 1-216-839-11 RES-CHIP 1/10W R3147 1-216-813-11 RES-CHIP 1/10W R3423 1-216-841-11 RES-CHIP 1/10W R3300 1-218-827-11 METAL CHIP 0.5% 1/10W R3456 1-216-825-11 RES-CHIP 2.2K 5% 1/10W R3301 1-218-827-11 METAL CHIP 0.5% 1/10W R3460 1-218-871-11 METAL CHIP...
  • Page 90 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R3660 1-216-022-00 RES-CHIP 1/10W < TUNER > R3661 1-216-805-11 RES-CHIP 1/10W R3675 1-216-809-11 RES-CHIP 1/10W TU3800 8-598-534-10 FRONTEND BTF-EC412 R3676 1-216-833-11 RES-CHIP 1/10W R3677 1-216-022-00 RES-CHIP 1/10W *A-1400-437-A H Board, Complete < CAPACITOR > R3678 1-216-805-11 RES-CHIP 1/10W...
  • Page 91 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R315 1-216-809-11 RES-CHIP 1/10W C137 1-126-947-11 ELECT 47UF 20.00% 25V R316 1-216-825-11 RES-CHIP 2.2K 5% 1/10W C138 1-126-947-11 ELECT 47UF 20.00% 25V R317 1-216-825-11 RES-CHIP 2.2K 5% 1/10W C139 1-126-947-11 ELECT 47UF 20.00% 25V R318 1-216-825-11 RES-CHIP...
  • Page 92 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R171 1-216-821-11 RES-CHIP 1/10W Q105 8-729-120-28 TRANSISTOR 2SC1623-L5L6 R172 1-216-821-11 RES-CHIP 1/10W Q106 8-729-120-28 TRANSISTOR 2SC1623-L5L6 R173 1-216-821-11 RES-CHIP 1/10W Q108 8-729-028-28 TRANSISTOR 2SK2036(TE85L) R174 1-216-824-11 RES-CHIP 1.8K 5% 1/10W Q109 8-729-028-28 TRANSISTOR 2SK2036(TE85L) R175 1-216-824-11 RES-CHIP 1.8K 5%...
  • Page 93 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < NETWORK RESISTOR > C1031 1-164-004-11 CERAMIC CHIP 0.1UF 10.00% 25V C1032 1-126-916-11 ELECT 1000UF 20.00% 6.3V RB100 1-239-621-11 NETWORK RESISTOR (CHIP) 22 C1033 1-126-916-11 ELECT 1000UF 20.00% 6.3V RB101 1-239-621-11 NETWORK RESISTOR (CHIP) 22 C1034 1-126-935-11 ELECT 470UF...
  • Page 94 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C1220 1-164-004-11 CERAMIC CHIP 0.1UF 10.00% 25V C1403 1-164-222-91 CERAMIC CHIP 0.22UF C1222 1-130-777-00 MYLAR 0.1UF 5.00% 63V C1404 1-164-222-91 CERAMIC CHIP 0.22UF C1223 1-126-952-11 ELECT 1000UF 20.00% 35V C1405 1-104-665-11 ELECT 100UF 20.00% 25V C1224...
  • Page 95 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C1710 1-130-785-11 MYLAR 0.47UF 10.00% 100V C1950 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V C1711 1-163-021-91 CERAMIC CHIP 0.01UF 10.00% 50V C1951 1-136-165-00 FILM 0.1UF 5.00% 50V C1712 1-126-968-11 ELECT 100UF 20.00% 50V C1952 1-126-947-11 ELECT 47UF...
  • Page 96 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK FB1004 1-535-143-61 LEAD, JUMPER (5.0MM) D1009 8-719-069-55 DIODE UDZSTE-175.6B FB1005 1-414-766-22 FERRITE D1010 8-719-914-43 DIODE DAN202K FB1006 1-414-766-22 FERRITE D1011 8-719-069-55 DIODE UDZSTE-175.6B FB1007 1-414-766-22 FERRITE D1012 8-719-083-60 DIODE UDZSTE-174.7B FB1008 1-414-766-22 FERRITE D1013 8-719-069-56 DIODE UDZSTE-176.2B FB1009...
  • Page 97 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK IC1801 8-759-665-11 IC LM393DT Q1003 8-729-027-38 TRANSISTOR DTA144EKA-T146 IC1802 8-759-998-98 IC LM358D Q1004 8-729-901-81 TRANSISTOR 2SC2412K-T-146 IC1803 8-759-567-08 IC MB88141APF-ER Q1005 8-729-026-49 TRANSISTOR 2SA1037AK-T146 IC1804 8-759-665-11 IC LM393DT Q1006 8-729-901-81 TRANSISTOR 2SC2412K-T-146 IC1806 8-759-595-52 IC CXA8070AP Q1007...
  • Page 98 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R1059 1-216-829-11 RES-CHIP 4.7K 5% 1/10W < RESISTOR > R1060 1-216-821-11 RES-CHIP 1/10W R1063 1-216-864-11 SHORT CHIP JR1006 1-216-864-11 SHORT CHIP R1066 1-216-864-11 SHORT CHIP JR1007 1-216-864-11 SHORT CHIP R1068 1-216-829-11 RES-CHIP 4.7K 5% 1/10W JR1238...
  • Page 99 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R1145 1-216-650-11 METAL CHIP 0.5% 1/10W R1273 1-218-867-11 RES-CHIP 6.8K 5% 1/10W R1146 1-216-661-11 METAL CHIP 2.7K 0.5% 1/10W R1274 1-218-867-11 RES-CHIP 6.8K 5% 1/10W R1150 1-216-864-11 SHORT CHIP R1275 1-216-821-11 RES-CHIP 1/10W R1151 1-216-864-11 SHORT CHIP...
  • Page 100 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R1466 1-216-833-11 RES-CHIP 1/10W R1806 1-216-817-11 RES-CHIP 1/10W R1468 1-216-864-11 SHORT CHIP R1807 1-208-806-11 METAL CHIP 0.5% 1/10W R1469 1-216-809-11 RES-CHIP 1/10W R1809 1-216-833-11 RES-CHIP 1/10W R1470 1-216-809-11 RES-CHIP 1/10W R1811 1-216-825-11 RES-CHIP 2.2K 5% 1/10W R1471...
  • Page 101 A H2 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R1876 1-218-873-11 METAL CHIP 0.5% 1/10W R1971 1-216-825-11 RES-CHIP 2.2K 5% 1/10W R1879 1-208-804-11 METAL CHIP 8.2K 0.5% 1/10W R1972 1-216-829-11 RES-CHIP 4.7K 5% 1/10W R1880 1-218-913-91 METAL CHIP 560K 0.5% 1/10W R1973 1-216-825-11 RES-CHIP 2.2K 5%...
  • Page 102 H2 F3 C REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK CN809 *1-564-522-11 PLUG, CONNECTOR 7P < DIODE > < DIODE > D2150 8-719-081-56 DIODE L-59SRSGC-CC D2151 8-719-109-89 DIODE RD5.6ESB2 D802 8-719-929-15 DIODE HZS9.1NB2 D2152 8-719-109-89 DIODE RD5.6ESB2 D803 8-719-929-15 DIODE HZS9.1NB2 D804 8-719-109-97 DIODE RD6.8ES-B2 <...
  • Page 103 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < IC > C5325 1-163-087-00 CERAMIC CHIP 4PF 0.25PF 50V C5326 1-163-017-00 CERAMIC CHIP 0.0047UF 10.00% 50V IC5300 8-759-360-83 IC TDA6111Q/N4 C5328 1-128-528-11 ELECT 470UF 20.00% 16V IC5325 8-759-360-83 IC TDA6111Q/N4 C5329 1-107-967-11 ELECT 20.00% 400V IC5350...
  • Page 104 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R5350 1-249-417-11 CARBON 1/4W C5414 1-107-652-11 ELECT 10UF 20.00% 250V R5351 1-247-807-31 CARBON 1/4W C5415 1-107-363-91 MYLAR 0.0068UF 10.00% 200V R5352 1-249-416-11 CARBON 1/4W C5417 1-102-514-11 CERAMIC 22PF 5.00% 50V R5353 1-249-421-11 CARBON 2.2K 5% 1/4W C5418...
  • Page 105 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R5411 1-249-401-11 CARBON 1/4W MISCELLANEOUS R5412 1-249-429-11 CARBON 1/4W R5413 1-249-414-11 CARBON 1/4W £ 1-571-433-31 SWITCH, PUSH (AC POWER) R5414 1-249-432-11 CARBON 1/4W £ 1-756-286-11 CORD, POWER R5415 1-260-316-51 CARBON 1/2W 1-424-855-11 COIL, CHOKE 29MMH 8-598-534-10 FRONTEND BTF-EC412 R5416 1-249-388-11 CARBON...
  • Page 106 • User programmable Functional Check through Infrared • Fast and documented Test Mode setting of all Sony TV chassis Additional features such as Adjustments and Troubleshooting are available in chassis-dependent software modules. Please contact your local Sony Service organisation for the latest information.

This manual is also suitable for:

Fd triniton kv-29fq76kTrinitron kv-29fq76eTrinitron kv-29fq76k

Table of Contents