Table of Contents
Advertisement
Quick Links
SINCE 1932
SINCE 1932
SINCE 1932
SINCE 1932
Propane 2Burner Drop-in Cooker
INSTALLATION – USE AND CARE MANUAL
DICKINSON RESERVES THE RIGHT TO CHANGE PRODUCTS OR DOCUMENTS AT ANY TIME
QUALITY INSPECTED BY-
This manual MUST be read carefully
Doug & Don
Dickinson Marine
#407-204 Cayer St Coquitlam
BC Canada V3K 5B1
www.dickinsonmarine.com
info@dickinsonmarine.com
T: 800 659 9768
F: 604 525 6417
July 1 / 2008
DATE-
1
Advertisement
Table of Contents
Summary of Contents for Dickinson Propane 2Burner Drop-in Cooker
- Page 1 F: 604 525 6417 Propane 2Burner Drop-in Cooker INSTALLATION – USE AND CARE MANUAL This manual MUST be read carefully DICKINSON RESERVES THE RIGHT TO CHANGE PRODUCTS OR DOCUMENTS AT ANY TIME Doug & Don July 1 / 2008 QUALITY INSPECTED BY-...
- Page 2 • Shut off main supply tank, and call the fire department if the boat has filled with gas. IMPORTANT Safety is everyone’s responsibility. Your Dickinson product is designed and constructed to give you many years of safe use. The operation will be further enhanced if proper care and judgment are exercised in the use and maintenance of the appliance.
-
Page 3: What Not To Do
• USE ONLY approved materials, hose, regulators and fittings to install. 10ft Hose – ULC Type III CGA St 8.1 – Dickinson Prt# 19-100-10 20ft Hose – ULC Type III CGA St 8.1 – Dickinson Prt# 19-100-20 Propane Low Pressure Regulator UL/C.G.A – Dickinson Prt# 19-151 •... -
Page 4: Packing List
Never leave the appliance unattended when in use. Do not use oversized pots or pans. See section on ‘burners’. Do not use abrasive or caustic cleaners or detergents on this appliance. Keep appliance area clear and free from combustible material. PACKING LIST INSTRUCTION MANUAL TWO BURNER DROP IN COOKTOP... - Page 5 POT HOLDERS AND RAIL There is a set of potholders and a potholder rail standard with your appliance. The rail is attached, as shown in the diagram, by inserting the legs into the grate and tightening the brass thumbscrews. The grate can be removed and turned to position the sea rail at the back or front as required.
- Page 6 FLAME CLEARANCE AND POT SIZES Space is always at a premium on a boat and the Dickinson Two Burner Drop In Cooktop gives you the most versatility and the most powerful burners available in a marine cooktop format. For your safety and for the good maintenance of the appliance, use the appropriate size pots for the right and left burners.
- Page 7 (11 ins W/C), a hose or 1lb bottle connector fitting and a mounting kit. The Kit must be mounted outside and away from a hatch or entry. A Dickinson AGA/CGA propane hose can be used to connect this Kit to the heater. These are available in 10 ft ( 3m) (Part No.
- Page 8 • USE ONLY approved materials, hose, regulators and fittings to install. 10ft Hose – ULC Type III CGA St 8.1 – Dickinson Prt# 19-100-10 20ft Hose – ULC Type III CGA St 8.1 – Dickinson Prt# 19-100-20 Propane Low Pressure Regulator UL/C.G.A –...
-
Page 9: Installation
INSTALLATION COUNTERTOP PREPARATION Prior to preparing the countertop check that the depth of the cook top will fit in the desired location and that there is room for the gas inlet fitting and the gas lines. The 3/8” flare inlet fitting protrudes ¾”... -
Page 10: Operation
INSTALLATION Installing when you have access under the countertop. • Ensure the cut out dimensions. A small bead of sealant is recommended for a good seal. • Install the four metal angle brackets into the tie down flanges that are on the side of the housing. -
Page 11: Care And Cleaning
Ensure burners are properly seated in their base. Each knob controls a different valve. To light the burner press down on the knob to activate the electronic ignition. Rotate the knob counter clockwise until the red dot is level with the thickest part of the indicator line. -
Page 12: Troubleshooting Guide
Use the mildest cleaner available to perform the cleaning operation. Use only a sponge and soft cloth, fibrous or nylon pad for cleaning. Do not use abrasive cleaners such as steel wool. Always dry components completely before using the cook top. CLEANING ORIFICE The orifices of both burners are easily accessed. - Page 13 If any part of your new product fails because of a manufacturing defect within the warranty period dickinson offers to replace said parts free of charge, provided, however, that such parts have not been improperly repaired, altered or tampered with or subjected to misuse, abuse or exposed to corrosive conditions.
-
Page 14: Warranty Form
Return to: SINCE 1932 SINCE 1932 SINCE 1932 SINCE 1932 #407 – 204 Cayer Street, Coquitlam, B.C. Canada V3K 5B1 WARRANTY FORM I have read and understand the Limited Warranty and the Instruction Manual and agree to the terms and conditions (please print) Date……………………………………………………………………………...