Master Pro MHP-135-KFA User's Manual & Operating Instructions
Hide thumbs
Also See for MHP-135-KFA:
- User's manual & operating instructions (48 pages) ,
- Operating instructions manual (16 pages) ,
- User's manual and operating instructions (32 pages)
Table of Contents
Advertisement
User's Manual & Operating Instructions
MHP-135-KFA / MHP-190-KFA / MHP-215-KFA
CONSUMER: READ AND SAVE THESE INSTRUCTIONS
GENERAL HAZARD WARNING:
DANGER
READ AND UNDERSTAND ALL OF THE INSTRUCTIONS IN THIS MANUAL
BEFORE ASSEMBLING, STARTING, OR SERVICING THE HEATER. Be sure to comply with the
instructions and warnings provided with this heater. Failure to comply can result in fire or explosion
that can cause property loss, bodily injury, or loss of life. Only persons who can follow and
understand these instructions should operate or service this heater. If you need heater info; such as
an operating manual, labels, etcetera, contact Pinnacle Products International at 800-641-6996.
NOT FOR USE IN RESIDENTIAL LIVING AREAS OR IN ENCLOSED SPACES
DANGER
WITHOUT ADEQUATE VENTILATION. FOR OUTDOOR USE. INDOOR USE
PERMITTED ONLY FOR: THE TEMPORARY HEATING OF ADEQUATELY VENTILATED
BUILDINGS OR STRUCTURES UNDER CONSTRUCTION, ALTERATION OR REPAIR. This is
an unvented portable heater that uses air (Oxygen) from within the area in which it is used. Failure
to provide adequate combustion and ventilation air will result in asphyxiation, carbon monoxide
poisoning, bodily injury or death. Refer to "Ventilation" on Page 6.
668 Stony Hill Road #302 Yardley, PA 19067 USA
Fax: (215)-891-8461
Model Numbers
© 2014 Pinnacle Products International, Inc.
• Web: www.masterindustrialproducts.com • Email: info@pinnacleint.com
Toll Free (800)-641-6996
•
701000113-14
Advertisement
Table of Contents
Related Manuals for Master Pro MHP-135-KFA
Summary of Contents for Master Pro MHP-135-KFA
- Page 1 User’s Manual & Operating Instructions Model Numbers MHP-135-KFA / MHP-190-KFA / MHP-215-KFA CONSUMER: READ AND SAVE THESE INSTRUCTIONS GENERAL HAZARD WARNING: DANGER READ AND UNDERSTAND ALL OF THE INSTRUCTIONS IN THIS MANUAL BEFORE ASSEMBLING, STARTING, OR SERVICING THE HEATER. Be sure to comply with the instructions and warnings provided with this heater.
-
Page 2: Table Of Contents
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Table Of Contents Safety Information..........1-2 Wiring Diagram..........10 Features and Specifications.........3 Troubleshooting Guide........11 135 / 190 / 215-KFA Assembly......4-5 Exploded View...........12 Operation............6-7 Parts List............13 Ventilation.............6 Warranty.............14 Maintenance...........8-10 Safety Information FIRE, BURN, INHALATION AND EXPLOSION HAZARD. -
Page 3: Safety Information
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Safety Information RISK OF INDOOR AIR WARNING WARNING RISK OF ELECTRIC SHOCK! POLLUTION! ALWAYS use only the electrical power (voltage and The products described in this manual are frequency) specified on the model plate of the heater. -
Page 4: Features And Specifications
120VAC / 60Hz Amps 2.92 Phase Single Single Single Specifications subject to change without notice. Features Models: MHP-135-KFA / MHP-190-KFA / MHP-215-KFA Front Handle Hot Air Outlet Upper Shell Digital Display Power Switch Thermostat Knob Rear Handle Lower Shell Cord Wrap... -
Page 5: 135 / 190 / 215-Kfa Assembly
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Assembly Instructions Models: MHP-135-KFA / MHP-190-KFA / MHP-215-KFA Remove the heater and all packaging Tools Needed: materials from the shipping carton. - Phillips Head Screw Driver - 8 mm open end wrench... - Page 6 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Assembly Instructions Models: MHP-135-KFA / MHP-190-KFA / MHP-215-KFA 1. Insert axle through holes in wheel support. 6. Attach rear handle with (4) long screws (50 mm) and (4) nuts through the first second 2.
-
Page 7: Operation
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Operation Fueling The Heater: NOTE: Kerosene should only be stored in a blue Kerosene (1-K) container that is clearly marked “Kerosene.” For optimal performance of this heater, it is Never store kerosene in a red container. - Page 8 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Operation Starting the Heater: (Ignition) NOTE: If if the heater still does not ignite, refer to “Troubleshooting Guide” on page 11. 1. Fill the tank with kerosene or other approved The room temperature display will indicate the fuel until needle on fuel gauge points to “F”.
-
Page 9: Maintenance
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Maintenance Long Term Storage: Service: Never service heater while it is WARNING Models 135-KFA / 190-KFA / 215-KFA: plugged in or hot! 1. Drain fuel through the drain plug in the bottom DO NOT TAMPER WITH THE UNIT. - Page 10 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Maintenance Service (Continued): SPARK PLUG: FAN BLADES: Clean and re-gap every 600 hours of operation, or Blades should be cleaned at least once per replace as needed. After removing the spark plug, heating season, depending on conditions.
-
Page 11: Wiring Diagram
POWER LIMIT CON4 FUSE SWITCH CONTROL 5A/250VAC BLACK ACN1 POWER PLUG LEVEL WHITE BLACK SWITCH AC 120V 60Hz BLACK GREEN EARTH Figure 15: MHP-135-KFA / MHP-190-KFA / MHP-215-KFA © 2014, Pinnacle Products International, Inc. Kerosene Forced Air Heater User’s Manual... -
Page 12: Troubleshooting Guide
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Troubleshooting Guide Problem Possible Cause Solution Heater Ignites, but main PCB shuts 1. Incorrect pump pressure. 1. Adjust pump pressure. off after a short period of time. 2. -
Page 13: Exploded View
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Exploded View © 2014, Pinnacle Products International, Inc. Kerosene Forced Air Heater User’s Manual... -
Page 14: Parts List
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Parts List MHP-135-KFA MHP-190-KFA MHP-215-KFA Fuel Tank Assembly 70-002-0610 70-002-0620 70-002-0620 Drain Plug 70-002-0105 70-002-0105 70-002-0105 Fuel Gauge Assembly 70-007-0210 70-007-0210 70-007-0215 Fuel Filter Assembly 70-003-0200 70-003-0200... -
Page 15: Limited Warranty
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE LIMITED WARRANTY Pinnacle Products International, Inc. warrants this heater If Pinnacle Products International, Inc. finds the item to to the original retail purchaser only, to be free from defects be in normal operating condition, or not defective the item in material and workmanship for a period of one (1) year will be returned freight collect. - Page 16 © 2014 Pinnacle Products International, Inc. 668 Stony Hill Road #302 Yardley, PA 19067 USA • Toll Free (800)-641-6996 Fax: (215)-891-8461 • Web: www.pinnacleint.com • Email: info@pinnacleint.com...
Need help?
Do you have a question about the MHP-135-KFA and is the answer not in the manual?
Questions and answers