Page 1
Gas-Fired Wood-Burning Stationary Rack BBQ Smoker OWNER’S MANUAL Southern Pride smokers have been tested and approved by Intertek Testing Services, and are ETL listed to ANSI Z83.11b - 2009, CSA 1.8b - 2009, and to NSF/ANSI Standard 4. ETL File Number 4007026...
Page 2
Southern Pride smokers are gas-fired, wood-burning, ETL listed, commercial cooking appliances whose installation, operation, and maintenance should comply with the instructions in this manual, NFPA® 96 and other codes and standards as called out in this manual. For more information on NFPA® 96, or to obtain a copy of the latest publication, please contact: NFPA®...
Page 3
CONGRATULATIONS! In selecting Southern Pride, you have chosen the finest, most advanced and most fully automatic wood burning barbecue smoker available. With us, “ It’s Simply, a Matter of Pride”. Please read this Manual carefully prior to installation, operation and maintenance of your Southern Pride smoker.
As Needed ...................... 32-33 Wiring Diagram ....................34 Replacement Parts List ..................35 Before You Call For Service ................36 Troubleshooting the Gas Burner ..............37 Limited Warranty ....................38 Copyright 2015 by Southern Pride Distributing, LLC Volume 1 4 of 38...
12. Ashes removed from the firebox should be stored in a non-combustible container with a sealed lid only. Store ashes in a well ventilated area. FUMES COULD BE HAZARDOUS. Copyright 2015 by Southern Pride Distributing, LLC Volume 1 5 of 38...
DIAGRAM OF CONTROLS AND COMPONENTS Front View Rear View Top View Left Side View Right Side View Copyright 2015 by Southern Pride Distributing, LLC Volume 1 6 of 38...
Page 7
13. TETHER / WALL ANCHOR BOLT MOUNTING LOCATION - Threaded hole for installation of eyelet bolt used to attach restraining device for smokers mounted on caster wheels to guard against transmission of strain to the gas and electrical connec- tions. Required by ANSI Z83.11b - 2009. Copyright 2015 by Southern Pride Distributing, LLC Volume 1 7 of 38...
This duty should only be performed by professionals trained in this kind of work. Improper handling of the equipment could result in damaging the smoker or personal injury and even death. Copyright 2015 by Southern Pride Distributing, LLC Volume 1 8 of 38...
Restraining device. SITE INSTRUCTIONS The Southern Pride smoker must be installed in a location that will permit the smoker to function for its in- tended purpose and to allow adequate clearance for ventilation, proper cleaning, and maintenance access. Minimum Clearance Requirement from Combustible Material Back…...18”...
5. If venting or gas connections are to be done at a later time, be sure that the power remains OFF. 6. The restraining device must be installed. Electrical Connection Tether Connection Gas Supply Connection Copyright 2015 by Southern Pride Distributing, LLC Volume 1 10 of 38...
Be sure to relight all the gas pilots on other appliances. NOTE: The burner and its individual shutoff valve must be disconnected from the gas supply piping system during any pressure testing in excess of 1/2 psig. Copyright 2015 by Southern Pride Distributing, LLC Volume 1 11 of 38...
7. Burner orifice MUST correlate with the type of gas being supplied, as specified in the Burner Specifica- tions on page WARNING: Improper gas hookup will void the warranty and could result in a hazardous condition. Copyright 2015 by Southern Pride Distributing, LLC Volume 1 14 of 38...
1. Staple bracket 2. Eyebolt with jam nut 3. Restraining cable 4. Spring loaded hook 5. #10 x 1” screws 6. Plastic anchors 7. Instruction sheet Figure B Figure C Copyright 2015 by Southern Pride Distributing, LLC Volume 1 15 of 38...
11.0” w.c. 13.0” w.c. 9.5” w.c. 10.0” w.c. Gas valve: Control knob must be ON. Gas valve- Supply gas pressure On position test port Wiring Diagram for Gas Burner Copyright 2015 by Southern Pride Distributing, LLC Volume 1 16 of 38...
Placement under a common hood shared with other appliances may be prohibited. NFPA® 96 specifies a minimum canopy overhang of 6 inches on all sides. Southern Pride recommends a minimum 18 inch overhang on the product loading door side of the smoker.
Repeat steps 2 and 3 until all product is loaded into the smoker. Product height will determine how many rack slide spaces you need to advance to maintain an air gap between each loaded product rack. Copyright 2015 by Southern Pride Distributing, LLC Volume 1 18 of 38...
Do not overload firebox. Too much wood or charcoal can cause overheating of the smoker. Keep wood at least 4 inches from the burner. Do not allow ashes in or near the burner opening. Copyright 2015 by Southern Pride Distributing, LLC Volume 1 19 of 38...
“OFF” is displayed in the LED display. This turns off the gas burner. Press the start/stop button to start the cool down cycle. Run the cool down cycle until the smoker tempera- ture falls below 90°. Copyright 2015 by Southern Pride Distributing, LLC Volume 1 20 of 38...
Page 21
Repeat the above steps to program the next menu. Once pro- gramming is complete, press the enter button twice to return to “IDLE”. Copyright 2015 by Southern Pride Distributing, LLC Volume 1 21 of 38...
Page 22
“OFF” is displayed in the LED display. This turns off the gas burner. Press the start/stop button to start the cool down cycle. Run the cool down cycle until the smoker tempera- ture falls below 90°. Copyright 2015 by Southern Pride Distributing, LLC Volume 1 22 of 38...
CAUTION Be sure smoker product loading door(s) and firebox door are secured in the closed position immediately following a cook cycle and during non-use periods. Copyright 2015 by Southern Pride Distributing, LLC Volume 1 23 of 38...
6. Wheel chocks must be used when the smoker is sitting stationary. 7. Level the smoker, both front to back and side to side, before operating the smoker. Copyright 2015 by Southern Pride Distributing, LLC Volume 1 25 of 38...
Page 26
6. Cylinders should not be allowed to remain in a high heat area such as a closed car, trunk, or in direct sun- light. Copyright 2015 by Southern Pride Distributing, LLC Volume 1 26 of 38...
Page 27
16. Do not attempt to disconnect any gas fitting while your smoker is in operation. 17. Although your liquid propane cylinder may appear to be empty, gas may still be present. The cylinder should be transported and stored with the valve closed. Copyright 2015 by Southern Pride Distributing, LLC Volume 1 27 of 38...
CAUTION: The latch rollers are spring-loaded and will open quickly with a lot of force. Do not pinch a finger or hand. Copyright 2015 by Southern Pride Distributing, LLC Volume 1 28 of 38...
Page 29
5. The combustion chamber shall be scraped clean to its original surface once each week and shall be inspect- ed for deterioration or defects. Copyright 2015 by Southern Pride Distributing, LLC Volume 1 29 of 38...
Remove the retaining ring on the end of convection motor shaft. To re-install repeat the above steps in reverse order. Be sure to tighten the blower wheel set screw against the flat portion of the convection motor shaft. Copyright 2015 by Southern Pride Distributing, LLC Volume 1 30 of 38...
1. Scrape creosote buildup off of the firebox side of the baffle board. SEMI - ANNUALLY: 1. Have an experienced service technician inspect and clean the burner electrode. Southern Pride recom- mends replacing the burner electrode every 12-18 months, depending on usage.
To dry interior of the smoker leave product door(s) open and allow to air dry. Note: Consult with the appropriate state or local health department regarding all applicable cleaning and sanitation requirements for equipment. Copyright 2015 by Southern Pride Distributing, LLC Volume 1 32 of 38...
Always use the proper cleaning agent at the manufacturer’s recommended strength. EXTERIOR: Southern Pride BBQ Smokers are known for their attractive appearance. We achieve this by selecting only the finest grade of type 304 stainless steel and applying exacting workmanship.
582008 582010 (Nat.) Gas valve 582016 (LP) 582011 (Nat.) Electrode/pilot assembly 582015 (LP) High voltage lead 582012 Igni on control module 582019 Door Hinges/Closers Product door hinge 870003 Mechanical door closer 771001 Mechanical door closer latch 771002 Product Racks/Hangers Nickel chrome product rack 970002 Stainless steel product rack 971001 Stainless steel rack slides 977013 Copyright 2015 by Southern Pride Distributing, LLC Volume 1 35 of 38...
Error 7 appears on the digital roast Wet a cloth with warm water and hold it against the thermocouple and hold control located on the left inside wall of the smoker for 20-30 seconds. Copyright 2015 by Southern Pride Distributing, LLC Volume 1 36 of 38...
Check for loose wire connection at the valve and control module. Clean the igniter rod. Pilot lights, but does not stay lit Check the igniter-sensor probe and wire. Copyright 2015 by Southern Pride Distributing, LLC Volume 1 37 of 38...
WILL SOUTHERN PRIDE OR ANY COMPANY/INDIVIDUAL AFFILIATED WITH IT BE LIABLE FOR INCI- DENTAL OR CONSEQUENTIAL DAMAGES. In no event shall Southern Pride be liable for loss of use, loss of reve- nue or profit, or loss of product, or for any indirect, incidental or consequential damages.