Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Future Orion III
Summary of Contents for Future Orion III
- Page 1 OWNERS MANUAL...
-
Page 2: Contact Information
Supplier: Please give this manual to the user of the wheelchair. User: Please read this entire manual before using this wheelchair. Thank you for choosing Future Mobility Healthcare Inc. If you have any questions please do not hesitate to write or call us at the address and telephone number below: Future Mobility Healthcare Inc. -
Page 3: Table Of Contents
CUSHION INSTALLATION ............40 CLIMBING A CURB ..............11 TIE-DOWNS ................41 DESCENDING STAIRS............11 TROUBLE SHOOTING ............42 COMPONENT WARNINGS ..........13 MAINTENANCE ..............43 ANTI-TIP WHEELS ..............13 SAFETY INSPECTION CHECKLIST ........43 WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... - Page 4 CLEANING YOUR CHAIR ............45 WARRANTY ................47 LIFETIME ................. 47 FOR TWO (2) YEARS .............. 47 FOR ONE (1) YEAR ..............47 FOR (90) DAYS ................ 47 LIMITATIONS ................47 WARRANTY PROCEDURES ........... 47 WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III...
-
Page 5: Parts Of The Wheelchair
Back Post Rear Wheel Stroller Bar Trigger Handle and Cable Anti-tip Seatpan T-Style Armrest Wheel Lock Lower Frame 10. Caster Fork 11. Caster Wheel 12. Swing Away Footrest 13. Composite Footplate WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... -
Page 6: Notice - Read Before Use
NOTICE – READ BEFORE USE CHOOSE THE CORRECT CHAIR AND OPTIONS Future Mobility Healthcare Inc. provides a choice of many wheelchair styles to meet the requirements of the wheelchair user. However, the final selection of the wheelchair and its options rests solely with you and your health care advisor. -
Page 7: General Warnings
Check to see that both quick-release rear axles are locked. a fall, tip over or loss of control may occur and cause severe injury When locked, the axle button will “pop out” fully. to the rider or others. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... -
Page 8: Changes And Adjustments
The Center Of Gravity Is Also Affected By: Consult your authorized supplier BEFORE you modify A change in the set-up of your chair, including: or adjust your chair, or contact Future Mobility i. The seat height and seat angle. Healthcare. -
Page 9: Reaching Or Leaning
Do not put pressure on the footrests. Move your chair as close as you can to the object you WARNING wish to reach. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... - Page 10 If you can, remove or swing footrests out of the way. Make sure your feet do not catch in the space between the footrests. Avoid putting weight on the footrests as this may cause the chair to tip. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III...
-
Page 11: Attendant Warnings
While looking over your shoulder, carefully step back until stairs. you are off the curb or stair and standing on the lower level. Move the chair and rider FORWARD down the stairs. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... - Page 12 He or she lowers the chair one step at a time by letting the rear wheels roll over the stair edge. The attendants move to the next stair down. Repeat for each stair, until you reach the landing. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III...
-
Page 13: Component Warnings
At these you can. times, make sure anti-tip tubes are up, out of the way. FOOTRESTS ARMRESTS WARNING WARNING Footrests will not bear the weight of this chair WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... -
Page 14: Positioning Belts
Use positioning belts only with a rider who can cooperate. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... -
Page 15: Rear Wheel Locks
Make sure wheel locks are embed in tires at least 1/8 inch when locked. If you fail to do so, the locks may not work. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... -
Page 16: Wheelchair Set-Up And Adjustments
Move the receiver to the required position. Armtop Pad Replace the two screws holding the receiver. Release Pin Re-install the armrest into the receiver. C. Release Lever D. Armpost Receiver Mounting Screws WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... -
Page 17: Height Adj. T-Style Knob Release Arm
Move the receiver to the required position. Replace the two screws holding the receiver. Re-install the armrest into the receiver. Armtop Pad Release Knob C. Release Lever D. Armpost Receiver Mounting Screws WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... -
Page 18: Height Adj. Flip-Back Arm
Pull the release knob (B) out to disengage the ball pin. Slide armrest pad up or down to desired height. Release the release knob to lock the armpost. Push arm pad to check that it is locked firmly into place. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... -
Page 19: Center Pivot Swingaway And Hanger
Slide the footrest extension tube up or down to the desired height. Note a minimum of 2” should be kept between the footplate (E) and the floor. Re-install and tighten the bolt (D) in place. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... -
Page 20: Pin Style Swingaway And Hanger
Slide the footrest extension tube up or down to the desired height. Note a minimum of 2” should be kept between the footplate (E) and the floor. Re-install and tighten the bolt (D) in place. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... -
Page 21: Dual Swingaway And Hanger
Slide the footrest extension tube up or down to the desired height. Note a minimum of 2” should be kept between the footplate (E) and the floor. Re-install and tighten the bolt (D) in place. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... -
Page 22: Dual Elevating Legrest And Hanger
Turn the release knob (F) counter-clock wise to disengage the ball pin. Move the legrest up or down to desired height. Listen for the “clicks” to verify position. Turn the release knob clock wise to lock the position. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... -
Page 23: Caster And Fork Assembly
Replace dust cover to caster housing. Height Adjustment Loosen and remove bolt (H). Set axle at desired height using pre-set holes in the fork. Replace and tighten bolt. Repeat on other side. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... -
Page 24: Rear Wheel Axle (Quick Release)
You will also need a 10mm wrench on the opposite end of the axle, and prevent the axle from turning. Turn the outside axle nut clockwise to tighten. There should only be zero to ten thousandths of an inch (.010") of play. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... -
Page 25: Front Seat To Floor Set-Up Chart
FRONT SEAT TO FLOOR SET-UP CHART WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... - Page 26 WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III...
-
Page 27: Rear Wheel Axle Mount
Important Note – The adjustment on each side of the chair should be exactly equal. Important Note – The adjustment should be done by an authorized dealer only. Note – Use a torque setting of 120 in-lbs when tightening the lock-nut. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... -
Page 28: Rear Wheel Bracket Mount
Moving the axles FORWARD shifts more of the rider’s weight onto the REAR wheels, providing the following benefits: the front end of the wheelchair becomes lighter, thus reducing the turning effort, and with a shorter wheelbase the turning radius is reduced. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... -
Page 29: Rear Anti-Tips
Pull the sleeve (E) on the anti-tip out towards the wheel to release the pin engagement Rotate the anti-tip up until the pin engages in the upper slot. The same procedure is used to flip the anti-tip down. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... -
Page 30: Backrest And Stroller Handle
To lock it back in position, push the release pins (A) sideways to allow them to reposition and lift the backrest firmly until it locks in its original position. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... - Page 31 Recline Backrest Adjustment Depress trigger handle (A) which will disengage the recline gas cylinder. Tilt the backrest (B) to the desired angle and release the trigger handle. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III...
-
Page 32: Tilt Mechanism
Tilt the chair (B) to the desired angle and release the foot pedal. A locking collar can be used on the gas cylinder rod to limit the tilt angle if required. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... -
Page 33: Trigger Cable Adjustment
(D) is fully out. This will be when the trigger handle is released. The gas cylinder should be allowed to lock when the rod end pin on the gas cylinder is extended when the handle is released. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... -
Page 34: Wheel Locks
Tighten screws. To engage wheel lock, push handle (C) forward for the Push to Lock or pull the handle rearward for the Pull to lock version until the mechanism locks in place. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... - Page 35 Once proper adjustment is attained, lock cable adjustment screw in position by tightening jam nuts against mounting block. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III...
-
Page 36: Chair Width Adjustment
(B) and center tube (C). (See Seat Frame Set-Up Chart) Replace and tighten screws. Repeat procedure for other side of seat frame. Check overall width to confirm. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... - Page 37 To adjust, loosen all screws (A) on both sides of the H-Links frame (B) cross tubes. Slide the H-Link frame to the desired width using the pre-set holes in both the H-Link frame cross tube and center tube (C). Tighten screws (A). WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III...
- Page 38 WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III...
- Page 39 WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III...
-
Page 40: Seat Depth Adjustment
Important Note – The adjustment on each side of the chair should be exactly equal. CUSHION INSTALLATION Place cushion on seat pan with hook material side down. The pommel of the cushion should be in front. Press cushion into place. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... -
Page 41: Tie-Downs
If the wheelchair is used for transport, it must be used in a forward-facing seating position. The rider must not weigh more than 275 lbs. Front attachment point (A) and rear attachment point (B) WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... -
Page 42: Trouble Shooting
To keep track of your progress, make only ONE change at a time Solutions Check for loose nuts and bolts Check angle adjustable caster assembly Check that rear wheels are equally spaced away from seat frame. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... -
Page 43: Maintenance
Inspect cane and hand grips for wear/looseness TIRES Inspect for flat spots, cracks and wear Caution: as with any vehicle, the wheels and tires should be checked periodically for cracks and wear and should be replaced. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III... - Page 44 Adjust bearing system if wheel wobbles or binds to a stop. Ensure wheel bearings are clean and free of moisture. Check stem caster journal and lock nut for tightness Inspect casters for cracks and wear Inspect for cracked, bent or broken spokes CLEANING Clean upholstery and armrests WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III...
- Page 45 Future Mobility for repairs. Paint Finish Contact Future Mobility directly by telephone, fax, or e-mail Clean the painted surfaces with mild soap at least to obtain information regarding repair at Future Mobility once a month facilities.
- Page 46 Do not use abrasive powders or scouring pads on painted surfaces. Do not ever submerge chair in water. Do not use cleaning products without consulting the products’ instructions and taking appropriate precautions for human exposure to chemicals. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III...
- Page 47 WARRANTY LIFETIME FOR (90) DAYS Wheelchair Frame and Cross- Brace Future Mobility Healthcare Inc. guarantees the frame and Cushion and Back Upholstery cross brace against defects in material and workmanship Future Mobility Healthcare Inc. guarantees the wheelchair for life or for as long as the original purchaser owns the cushion and back upholstery to be free of defects in chair.
- Page 48 FMHI shall not be liable for any consequential or incidental damages whatsoever. WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III...
- Page 49 WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III...
- Page 50 WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III...
- Page 51 WC ORION III ENGLISH CDN 1230 REV01.DOCX ORION III...
Need help?
Do you have a question about the Orion III and is the answer not in the manual?
Questions and answers