Table of Contents
Advertisement
0
OPERATING THE CAR
SET LEVER CONTROL LING THE AXLE DIRECTIONA L GEAR BOX
DIRECTION
BACK.
USED
LOW
CAUT ION:
2.
RE LEASE BRAKE AND MOVE THE
AS IN
BE DONE
3.
TO STOP CAR SET TRIMATIC TO NEUTRA L
ON LEVER.
AND. LOCK
PREVENT C LASHING OF
4.
TO LOWER TURNTABLE SET LEVER ON HAND PUMP IN
ISO LATION
VALVE.
TO RAISE TURNTABLE OPEN ISOLATION
REAR POSITION/AND PUMP UNTIL
ISOLATION VALVE AND SET
1.
FOR
HANDBOOK,
2.
WEE K LY
BE
3.
GREASE AND 0 I L ALL CAR HINGE P O INTS1
UNIVERSAL
WHATEVER
4.
LUBRICATE
CAR IS IN CONSTANT SERVICE.
5.
THE AX LE DIRECTIONA L GEAR BOX HOLDS
USE
)
OIL
FILL
IN
(�
6.
CHECK
(
CONSTRUCTION
EQUIPMENT COMPANY
OF
TRAVEL.
)
THIS ALLOWS THE ENGINE GEAR BOX TRANSMISSION SPEEDS TO BE
IN DRIVING THE CAR IN THE REQUIRED DIRECTION.
SPEED
IS AVAILABLE
AX LE
DIRECTIONAL GEAR
THE
IS
STATIONARY.
ALWAYS
POSIT I ON.
A NORMAL MOTOR CAR.
WITH THE RADIATOR
WHEN CAR COMES TO
BRAKE.
LEAVE THE AXLE
VALVE A.ND PUMP TURNTABLE
ENGINE
LUBRICATION
USE DEXTRON
CHECK BATTERY
ABOVE PLATES.
JOINTS,
AT LEAST
COMES
FIRST.
DIFFERENTIA L AXLE EVERY HUNDRED CAR MILES,
SAE140
GEAR OIL IN SUMMER AND
30
LEVEL EVERY
DAYS1
THROUGH CAP ON TOP O F GEARBOX HOUSING,
F LOOR BELOW REAR SEAT.
WHEELS
AND AXLE REGU LARLY
)
A
AXLE AND NUTS ARE SECURED BY COTTER
OPERATORS A
(
TO MOVE
FORWARD THE
FROM
THE TRIMATIC TRANSMISSION.
SHOU LD
ONLY BE SHIFTED WHEN
KEEP IT IN EITHER
SHIFT
LEVER ON THE TRIMATIC TRANSMISSION
ANY EXTENSIVE AMOUNT OF
FORWARD TO ENSURE GOOD COO
AND APPLY BRAKE BY
A STOP MOVE TRIMATIC LEVER TO
DIRECTIONAL GEAR ENGAGED,
GEARS.
FULLY DOWN.
VA LVE;
TURNTAB LE IS
LEVER ON HAND PUMP IN CENTRE POSITION.
MA INTENANCE
AND
MAINTENANCE
FLUID IN TRIMATIC TRANSMISSION.
FOR
FLUID LEVEL.
INC LUDING PROPE L LER SHAFT
ONCE�ERY THOUSAND CAR MILES OR MONTHLY,
USE
PRESSURE
APPROXIMATELY
SAE90
AT
LEVEL P LUG, . AT REAR OF �EAR BOX HOUSING.
TO ENSURE THAT:
N
MAINTENANCE
D
FOR THE
LEVER SHOULD
BE PULLED
REVERSE AT
THE
FORWARD OR
REVERSE
DRIVING SHOULD
�
ING.
PU L LING BACK
FORWARD POSITION,
C LOSE
ISOLATION
SET
LEVER ON HAND PUMP TO
FU L LY UP.
CLOSE
REFER TO ENGINE MANU FACTURER
FLUID
LEVE L
SHOULD ALWAYS
OR
DAI LY IF
GUN.
;k
4
PINTS
GEAR
OI L IN
\<INTER.
ACCESSIBLE THROUGH
PINS
a
MANUAl
INTENDED
CAR
11
11
PARK
TO
OPEN
'
S
OF
OIL.
CHECK
HO LE
3
Advertisement
Table of Contents
