Page 4
SAFETY SAFETY The instructions related to the safety Please don’t use the module with the indicated in the following are for preven- broken window or the torn back side. ting unexpected danger or damage in There is a danger of electric shock. advance by safely and exactly using the WARNING product.
Page 5
SAFETY CAUTION If the installing structure has a curved surface e.g. arch type as shown in the Please use proper equipment, con- below picture, do not forcefully modify nector, wire and buttress for system con- the module in installation when connec- figuration of the module.
BEFORE & AFTER INSTALLATION BEFORE & AFTER INSTALLATION Before Installation • Do not let anyone approach the solar mo- Please carefully read this manual before dule who has little knowledge of solar mo- installation. dules or on the measures to take when •...
Deposits of foreign material on the frame thods not described in the Installation surface can be cleaned using a wet Instructions please consult LG Electro- sponge or cloth and dried in air or by nics. Failure to do so will void the war- using a clean chamois.
ELECTRICAL INSTALLATION Caution • Modules with a suspected electrical • Avoid all electrical hazards when instal- problem should be returned to LG ling, wiring, operating and maintaining Electronics for inspection and possible a module. repair or replacement as per the •...
ELECTRICAL INSTALLATION Series Connection Parallel Connection The solar modules may be wired in series The solar modules may be combined in • • to produce the desired voltage output. parallel to produce the desired current output. The current of each module connected in •...
• The minimum size should be determi- should be multiplied by a factor of 125 % ned by the applicable codes. LG when determining component voltage Electronics recommends a size not ratings, conductor ampacities, fuse sizes,...
ELECTRICAL INSTALLATION Earth Grounding One M4 stainless steel bolt, two flat • The solar modules from LG Electronics • washers, one star washer, one cup washer, meet the conditions of Safety Class II. spring washer, nut, Therefore grounding is not mandatory.
The fire areas, it is recommended to take an resistance of the solar module from appropriate countermeasure to prevent LG Electronics is Class C after ANSI/ possible damages to the lower side UL790. frame by slipping snow (e. g. attach supporting part to the lowest modules).
Page 14
MECHANICAL INSTALLATION Mounting by using frame bolts holes • Specific information on the solar module dimensions and location of Secure the solar module to the struc- • mounting holes is provided in the ture using the factory mounting holes. related data sheet. Four M6 stainless steel bolts, eight flat •...
Page 15
MECHANICAL INSTALLATION LGxxxS1C(W,K)-G3/-A3/-B3, LGxxxN1C(W,K)-G3/-A3/-B3 Use four mounting holes on two opposite sides. Use four clamps on the long frame. 2400 Pa: A = 100 mm, B = 450 mm Clamping Range 5400 Pa: A = 270 mm, B = 230 mm This method is not tested by IEC/UL.
Page 16
MECHANICAL INSTALLATION LGxxxS8C(W,K)-G3/-A3/-B3 Use four mounting holes on two opposite sides. Clamping Range Use four clamps on the long frame. 230 mm 140 mm 140 mm This method is not tested by IEC/UL. Center ± 100 mm Clamping Range: Clamping Range: from module edge to from module edge to 270 mm...
• tion, use or maintenance of the service, the company where the product module. has been purchased or LG Electronics at LG Electronics assumes no responsibi- • the address given overleaf for more infor- lity for any infringement of patents or...
TRANSPORTING AND STORAGE TRANSPORTING AND STORAGE Do not loose the banding, when module is • transported by truck, ship and etc. In case of loose banding, module will be shaken, which may cause damage, like glass brea- king. Do not stack on more than one pallet. The •...
Page 19
LG, LG logo and Life‘s Good are trademarks of LG Electronics, Inc. worldwide. Trademarks and intellectual properties of LG Electronics, Inc. are protected by international copyright laws. In case of conflict with other languages of this Installation Instruction the German version shall prevail.
Page 20
More information available at service-solar@lge.de www.lg-solar.com LG Electronics Deutschland GmbH Berliner Straße 93 40880 Ratingen, Germany Tel. +49 (0) 21 02/70 08-0 Fax +49 (0) 21 02/70 08-777...