IMPORTANT SAFETY INSTRUCTIONS Proper installation and usage of your DEL Spa Ozone Generator is your responsibility. Read and follow this Owner’s Manual carefully for important installation, operation and safety information. Basic safety precautions should always be followed, including but not limited to the following: 1.
Spa Ozone Generator Installation & Operation Manual Table of Contents Installation Instructions How the DEL Spa Ozone Generator Works Installation Parts Installation Tools and Materials Unit Assembly Mounting Plumbing - Vacuum System Plumbing - Ozone Generator Electrical Operation Installation Complete Maintenance Troubleshooting Warranty...
Installation Instructions How the DEL Spa Ozone Generator Works DEL Ozone Generators produce ozone gas which is introduced to the spa water through suction created by the spa. Tubing is used to connect the Ozone Generator to an injector or a vacuum port provided by the spa manufacturer. The injector or port are vacuum sources used to pull the ozone gas out of the Ozone Generator and into the water.
Figure 3. Review your Spa’s Installation Manual to identify the correct ozone connection location. If the spa is not equipped with a vacuum source, DEL Ozone provides a wide range of optional installation kits. Contact DEL Customer Service for assis- tance at 800.676.1335 x 249.
Verify that the Ozone Generator turns on and off as required by the controller: For the ZO-300, ZO-302 and ZO-301, the plastic end-caps will glow blue after a few seconds. For the SpaEclipse™ and CDS-16, a purple glow will be visible from the CD Chip Performance Window. iii.
One instruction sheet Renewal Interval Model Renewal Kit 8 hour/day 12 hr/day ozone 24 hr/day ozone Part Number ozone cycle cycle cycle CDS-16 9-0720-01 3 years 2 year 1 year Spa-Eclipse 9-0720-01 3 years 2 year 1 year ZO-300 9-0721-01...
Spa Ozone Generator Installation & Operation Manual Troubleshooting SYMPTOM: Cloudy water condition even though the unit appears to be operating properly PROBABLE CAUSE: CORRECTIVE ACTION: Unit and pump not operating Increase operating time (min. long enough 6 hours is recommended) Total alkalinity not correct Adjust total alkalinity between 80 and 150 ppm...
The limited warranty set forth below applies to products manufactured by DEL Ozone - and sold by DEL Ozone or its authorized dealers. This limited warranty is given only to the first retail purchaser of such products and is not transferable to any subsequent owners or purchasers of such products.
Page 11
DEL Ozone WARRANTY REGISTRATION CARD Product Serial Date: Fill out completely and return to DEL Ozone within ten (10) days of purchase. Customer Info: Name____________________________________Phone ( ) ________________ Address_____________________________________________________________ City______________________________________State_________Zip__________ Dealer Info: Dealer Name______________________________Phone ( ) ________________ Dealer Address_______________________________________________________ City______________________________________State_________Zip__________...
Page 12
PO Box 4509, San Luis Obispo, Ca. 93401 800.676.1335 www.delozone.com...