Table of Contents
Advertisement
USE OF THE RESPIRATOR
The following information provides the basic steps for use of the AIR-PAK
X3 SNAP-CHANGE SCBA. Training and practice with the equipment are
required before use to assure that the user is completely familiar with
the operation of the respirator.
The AIR-PAK X3 SNAP-CHANGE SCBA must be worn over protective
garments such as fire fighting turnout gear, but may be worn under en-
capsulating protective garments such as hazardous material (haz-mat)
suits. Determine what other protective gear will be used and don the
SCBA and the facepiece accordingly.
The AV-3000 HT Facepiece is made of heat resistant materials. When us-
ing the AV-3000 HT Facepiece in applications where high heat may occur,
follow all training and operating procedures relating to heat exposure. To
avoid possible injury, the respirator user must understand the hazards of
heat exposure including temperature, duration and repeat exposure. If
respirator use is expected at temperatures near or below freezing, or if
respirator is to be used after being kept at temperatures near or below
freezing, refer to LOW TEmPERATURE OPERATION Section for additional
information and supplemental procedures.
DONNING AND PREPARATION FOR USE
1. Always check the cylinder gauge for a "FULL" indication. If the cyl-
inder is not full, replace the cylinder before use. A gauge indication
of other than full may indicate an air leak in the cylinder and valve
assembly or a malfunction of the gauge assembly.
2. Always verify that the cylinder is held securely by the cylinder reten-
tion assembly.
3. If a wall storage bracket is used, follow the instructions of the bracket
manufacturer for placing arms through shoulder straps and freeing
the respirator from the bracket.
4. If the respirator is stored in a hard or soft storage case, place the
case on the ground or level surface and open the case. Secure the
regulator in the regulator holder. Proceed as shown in FIGURES* 9-A
thru 9-F.
a) Adjust the shoulder straps to their full outward (fully loose) posi-
tion.
b) Spread shoulder straps and fold open waist pad. Stand the res-
pirator on the cylinder valve with cylinder toward you and the
shoulder straps away from you.
9-A
Spread shoulder straps and fold
open waist pad. Stand the res-
p i r a t o r o n t h e c y l i n d e r v a l v e
with cylinder toward you and the
shoulder straps away from you.
* Illustrations chosen for clarity. Actual color and appearance of SCBA may vary from
illustrations.
P/N 595279-01 Rev. B 5/14
9-B
Pick up the respirator and swing
it around behind you as if you
were donning a coat.
Page 20 of 48
WARNING
THE INFORMATION IN THIS INSTRUCTION
I S
M E A N T
T O
S U P P l E M E N T,
REPlACE, THE INSTRUCTIONS, TRAINING,
S U P E R V I S I O N , M A I N T E N A N C E , A N D
OTHER ElEMENTS OF yOUR ORGANIZED
RESPIRATORy PROTECTION PROGRAM.
S E E WA R N I N G O N S E C O N D PA G E O F
THIS DOCUMENT. FAIlURE TO HEED ANy
WARNINGS IN THIS INSTRUCTION MAy
RESUlT IN SERIOUS INJURy OR DEATH.
WARNING
THE AV-3000 HT FACEPIECE IS MADE OF
HEAT RESISTANT MATERIAlS. WHEN USING
THE AV-3000 HT FACEPIECE, FOllOW All
TRAINING AND OPERATING PROCEDURES
R E l AT I N G T O H E AT E X P O S U R E . T H E
RESPIRATOR USER MUST UNDERSTAND
T H E H A Z A R D S O F H E AT E X P O S U R E
INClUDING TEMPERATURE, DURATION,
AND REPEAT EXPOSURE. FAIlURE TO DO
SO MAy RESUlT IN SERIOUS INJURy OR
DEATH.
WARNING
D O N O T O P E R A T E T H I S E Q U I P M E N T
WHIlE UNDER THE INFlUENCE OF DRUGS,
A l C O H O l , O R A N y M E D I C A T I O N S O R
SUBSTANCES WHICH MAy AFFECT VISION,
DEXTERITy, OR JUDGMENT. USERS OF
T H I S E Q U I P M E N T M U S T B E I N G O O D
PHySICAl AND MENTAl HEAlTH IN ORDER
TO OPERATE SAFEly. DO NOT USE THIS
EQUIPMENT WHEN FATIGUE PREVENTS
SAFE OPERATION. STAy AlERT WHEN
OPERATING THIS EQUIPMENT. INATTENTION
OR CARElESSNESS WHIlE OPERATING
THIS EQUIPMENT MAy RESUlT IN SERIOUS
INJURy OR DEATH.
WARNING
CERTAIN ENVIRONMENTS MAy REQUIRE
THAT PROTECTIVE MATERIAl COVER SOME
OR All OF THE RESPIRATOR IN ADDITION
TO COVERING THE USER. THE USER MUST
BE ABlE TO ACCESS THE CONTROlS
O F T H E R E S P I R ATO R AT A l l T I M E S .
INABIlITy TO ACCESS CONTROlS OF THE
RESPIRATOR WHEN THE RESPIRATOR IS
NEEDED FOR ESCAPE MAy RESUlT IN
SERIOUS INJURy OR DEATH.
N O T
Hide quick links:
Advertisement
Table of Contents
