Advertisement
Quick Links
LEXUS
Preparation
Part Number: Tuner Assy 86180-0W030
Mounting Kit 86100-0W230
Tuner Assy Kit Contents (86180-0W030)
Item #
Quantity Reqd.
1
1
Mounting Kit Contents (86100-0W230)
Item #
Quantity Reqd.
1
1
2
1
3
1
4
1
5
1
6
1
7
3
8
1
9
1
Hardware Bag Contents 1 (86100-0W230)
Item #
Quantity Reqd.
1
14
2
6
3
1
Hardware Bag Contents 2 (86100-0W230)
Item #
Quantity Reqd.
1
1
Hardware Bag Contents 3 (86100-0W230)
Item #
Quantity Reqd.
1
1
2
1
3
1
4
1
5
4
6
7
4
Additional Items Required For Installation
Item #
Quantity Reqd.
Conflicts
iPod Interface, Sirius Satellite Radio
Recommended Tools
Personal & Vehicle
Protection
Vehicle Protection
Issue: D
11/18/08
GX470
Description
TUNER ASSY,
STEREO COMPONENT
Description
Wire, To Radio Installation
Tuner Cover
Antenna
Grommet
Adhesive Sheet A (58mm˜185mm)
Adhesive Sheet B (26mm˜185mm)
Adhesive Sheet C (15mm˜182mm)
Adhesive Sheet D (17mm˜272mm)
Ground Cable
Description
Tie Wrap
Cushion Tape
(50mm˜100mm)
Sheet
(20mm˜80mm)
Description
˜L8 )
Screw
(
M5
Description
Housing
Template
Cord Rail
(10mm)
Cord Rail
(20mm)
Nylon Tape
(30mm˜30mm)
Cushion Tape
(20mm˜100mm)
Tie Wrap
Description
Notes
Clean Cloths, Part Boxes
Page 1 of 29 pages
2007 -
XM SATELLITE RADIO TUNER
NOTE: Part number of this accessory may not be
the same as the part number shown.
Special Tools
None
Installation Tools
Panel Clip Removal Tool
Socket
Screwdriver
Wrench
Torque Wrench
Scale
De-Burring Tool
Center Punch
Hole saw
Side Cutter
Scissors
Masking tape
Special Chemicals
None
General Applicability
Recommended Sequence of Application
Item #
Accessory
Vehicle Service Parts
Item #
Quantity Reqd.
Legend
STOP: Damage to the vehicle may occur. Do not
proceed until process has been complied with.
OPERATOR SAFETY: Use caution to avoid risk of
injury.
CAUTION: A process that must be carefully observed
in order to reduce the risk of damage to the
accessory/vehicle and to ensure a quality installation.
TOOLS & EQUIPMENT: Used in Figures calls out the
specific tools and equipment recommended for this
process.
REVISION MARK: This mark highlights a change in
installation with respect to previous issue.
SAFETY TORQUE: This mark indicates that torque is
related to safety.
Notes
Notes
e.g. Toyota SST P/N:-
00002-06002-01
10mm, 14mm
Phillips, #2
Open End, 10mm, 14mm
4.1 N M (36 lbf in) (battery cable)
32 N m (24 lbf ft) (drivers seat)
42 N m (31 lbf ft) (rear seat belt)
37 N m (27 lbf ft) (third seat)
7/8 inch
Notes
*Mandatory
(may be required for reassembly)
Description
Advertisement
Subscribe to Our Youtube Channel
Related Manuals for Lexus GX470 2007
Summary of Contents for Lexus GX470 2007
- Page 1 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Preparation NOTE: Part number of this accessory may not be Part Number: Tuner Assy 86180-0W030 the same as the part number shown. Mounting Kit 86100-0W230 Tuner Assy Kit Contents (86180-0W030) Item # Quantity Reqd.
- Page 2 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Preparation Parts Description of Tuner Assy (86180-0W030) Item # Parts Name Parts No. TUNER ASSY, STEREO COMPONENT 86180-0W030 In the installation instructions and figures, this is referred to as “Tuner”. Parts Description of Mounting Kit (86100-0W230)
- Page 3 Safety (eye protection, rechecking torque procedure, etc.). Vehicle Disassembly/Reassembly (panel removal, part storage, etc.). Electrical Component Disassembly/Reassembly (battery disconnection, connector removal, etc.). Please see your Lexus dealer for a copy of this document. 1. Vehicle Protection (a) Place front driver seat in mid position.
- Page 4 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure Masking Tape, Panel Removal Tool Masking Tape Clips (˜6) (b) Remove the Instrument Panel Cluster (L,R) Masking Tape Claw (Fig. 2-2). Claw Clips (˜6) NOTE: The illustration shows a vehicle equipped with EMV, but the procedure is the same for standard audio.
- Page 5 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure (e) Remove the front scuff plate (L) (Fig. 2-5). Panel Removal Tool (1) Pull the plate in the sequence of Claw (slide it towards the Clip as shown in the illustration to remove the...
- Page 6 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure (i) Remove the instrument panel lower cover (L) Masking Tape, Panel Removal Tool, Wrench (Fig. 2-8). 10mm Socket Instrument Panel Cluster Molding (L) Masking Tape (1) Affix masking tape around the edge of...
- Page 7 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure (k) Remove the rear step cover (L) (Fig. 2-10). Panel Removal Tool, Wrench, 10mm Socket Caps (˜2) (1) Remove the caps, then remove the bolts. Bolts (˜2) Rear Step Cover (L) (l) Remove the rear scuff plate (L) (Fig.
- Page 8 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure (5) Tilt seat back. Do not remove the seat. Panel Removal Tool NOTE: Ensure there is enough slack in wire The seat as seen from below harness when the seat is tilted back.
- Page 9 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure (4) Remove the seat hinge (Fig. 2-16). Panel Removal Tool, Wrench, 14mm Socket Bolts (˜2) NOTE : When putting the mounting bolts Seat Hinge back, tighten them to 37.0 N m (27 lbf ft).
- Page 10 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure (q) Fold and rotate driver side second row seat forward to access rear quarter panel trim. (r) Remove the luggage side lower trim (L) (Fig. Panel Removal Tool, Wrench, 14mm Socket 2-19).
- Page 11 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure 3. Antenna installation and wiring (a) Place the template in the position indicated in Masking Tape the diagram on the rear edge of the roof, and provisionally fix it with masking tape (Fig. 3- (1) Use the pole antenna if equipped to align the template as shown.
- Page 12 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure (d) Run the antenna cable through the rear gate. Panel Removal Tool (1) Fasten with cords along the body face of Antenna the rear gate (Fig. 3-4). Cord Rail A NOTE: Clean all dirt, oil etc. off the...
- Page 13 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure (e) Run the antenna cable into the luggage Panel Removal Tool compartment (Fig. 3-6). (1) The antenna cable should be routed through the Hole with the cap as shown Rear Combination Lamp position (Fig.
- Page 14 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure Panel Removal Tool (2) Remove the masking tape and then wrap the cushion tape around the cable as shown in the illustration (Fig. 3-8). 30mm Grommet NOTE: Clean all dirt, oil etc. off the body Cushion Tape (20˜100mm)
- Page 15 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure (h) Use tie wraps to fasten the antenna cable to Side Cutter the harness shown in the diagram (Fig. 3-10). Tie Wraps (˜2) (i) Use a side cutter to cut off the excess tie wrap length.
- Page 16 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure (4) Push the lock plate in (Fig. 3-14). Push in until it clicks. NOTE: Refer to procedure #5 on page 20 for details on laying the cable through to the tuner attachment area.
- Page 17 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure (4) Remove the audio harnesses (12P) from the audio head unit and connect the tuner cable (Fig. 4-2). Cushion Tape (5) Connect the tuner cable to the audio head (50mm˜100mm) Fig. 4-3 unit (Fig.
- Page 18 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure (d) Lay the cable underneath the driver’s seat Pass under NOTE: The illustration shows a vehicle the bracket. equipped with Mark Levinson Audio, but the procedure is the same for standard audio amp.
- Page 19 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure (e) Wiring behind the center pillar rear scuff Side Cutter plate Tuner Cable Rear scruff plate (From the audio unit) (1) Pull the tuner cable underneath that center pillar cover (Fig. 4-10).
- Page 20 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure 5. Ground Cable, Tuner Cable and Antenna Cable Wiring (a) Secure the ground cable in place with the Wrench, 10mm Socket bolt shown in the illustration (Fig. 5-1). Pull it through from where Pass it between the oil this harness branches.
- Page 21 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure (d) Secure the tuner cable and ground cable to Align it along the upper Side Cutter side of the harness. Tie Wraps (˜2) the harness with the tie wraps (Fig. 5-4).
- Page 22 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure 6. Tuner installation and Wiring (a) Remove the belt from the accessory box Phillips Screwdriver (Fig. 6-1). Screws (˜2) (1) Discard the two (2) screws from the Bottom surface accessory box.
- Page 23 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure Adhesive Sheet A Adhesive Sheet C (1) Attach adhesive sheets A, B and C to the (58mm˜185mm) (15mm˜182mm) tuner (Fig. 6-5). NOTE: Leave the separator on the other side in position when these sheets have been attached.
- Page 24 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure (3) Attach the tuner to the location shown in Peel the separator from adhesive sheet A. the illustration on the accessory box Separator (Fig. 6-7). Adhesive Sheet A Stick adhesive sheet A onto the side.
- Page 25 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure (f) Reattach the luggage side lower trim (L) onto Luggage side lower trim (L) its original position. (g) Pull the cables through the hole on the accessory box’s attachment area (Fig. 6-8).
- Page 26 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure (2) Reattach the accessory box onto its Tuner Cable Antenna Cable original position on the luggage side lower trim (Fig. 6-11). (3) Connect the antenna cable and tuner cable to the tuner (Fig. 6-11).
- Page 27 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure (n) Reattach the tuner cover. (1) Peel the separator from adhesive sheet C (Fig. 6-14). Tuner Cover (2) Place the tuner cover inside the accessory box (Fig. 6-14). Adhesive Sheet C Insert adhesive sheet D with the separator in place.
- Page 28 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Procedure 7. Completing the installation (a) Complete the reassembly of the vehicle. Torque Wrench, 10mm Socket Negative Battery Cable (1) Reconnect any disconnected connectors. (2) Verify the panels fit together properly with no uneven gaps between them.
- Page 29 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Checklist - these points MUST be checked to ensure a quality installation. Check: Look For: Accessory Function Checks Verify the proper operation of the satellite radio tuner referring to the receiver assy and radio owner’s manuals.
- Page 30 LEXUS GX470 2007 - XM SATELLITE RADIO TUNER Checklist - these points MUST be checked to ensure a quality installation. Check: Look For: Functioning AC 115V switch AC 115V Switch Functioning Center Differential Switch Center Differential Lock Switch Functioning Mirror Heater Switch...
Need help?
Do you have a question about the GX470 2007 and is the answer not in the manual?
Questions and answers