National Fuel Gas Code, ANSI Z223.1 / NFPA54, Natural Gas and Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code, B149.2), as applicable. 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
Page 4
• Never allow clothing, pot holders or other flammable materials come in contact with or be close to any grate, burner or hot 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
• Do not store items of interest to children around or below the grill. • Never allow children to sit or stand on any part of the grill. 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
Without it you will not be able to attach your tank to your Cal Flame grill or refill the tank at your local propane refill station. 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
Grill Model Width Depth Height G3 Three Burner 23 ¼” 22” 9 ¼” G4 Four Burner 31” 22” 9 ¼” G5 Five Burner 38 7/8” 22” 9 ¼” DEPTH WIDTH HEIGHT 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
LP-Gas Cylinders of the U.S. Department of Transportation or the National Standard of Canada, CAN/CSA-B339, Cylinders, Spheres and Tubes for Transportation of Dangerous Goods; and Commission, as applicable. • Approximately 12 inches in diameter and 18 inches high. 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
Page 9
Store cylinders outdoors and out of reach of children. Do not store cylinders in a building, garage, or any other enclosed area. 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
Natural Gas Converting Gas Grills IMPORTANT: Cal Flame G Series gas grills are manufactured to operate on liquid propane (LP). However, they can be converted to operate on natural gas (NG) by an authorized service technician. Consult your Cal Flame dealer for information on converting your gas grill.
Turn all control knobs back to the full OFF position. Shut off the gas supply to the grill and release pressure in the hose and manifold by pushing in and turning any of the control valves one quarter turn counter-clockwise. 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
If the grill is not level or is unstable, use non-combustible shims under the outside lip to stabilize it. Perform the leak test procedure as described earlier in this manual. 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
Grill Controls The controls shown below are for the G4 grill. Familiarize yourself with these controls before using your Cal Flame barbecue. High Grill Knob Operation Burners 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
• Ensure the propane cylinder, regulator, and rubber hose are installed in a location not subject to heating above 125º F (51º C). 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
Upon successful lighting, repeat the process on the other burners you wish to light. To shut off the burners, rotate the knob and turn to OFF. It is normal to hear a popping sound when the burners are turned off. 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
Shut off gas to the appliance. • Extinguish any open flame. • Open lid. • If odor continues, keep away from the appliance and imme- diately call your gas supplier or your fire department. 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
Following these simple instructions will help avoid scratching or damaging the finish and keep your stainless steel attractive. Cleaning instructions for grill interiors, including racks and burners, are described after this section. 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
Page 18
Do not use steel wool or wire brushes to scrub your grill. For light soil, use a damp sponge or cloth. For heavier stains, use a Scotch- Brite scrubber or similar product. 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
Page 19
Caution inside of cabinets, warming drawers, and ovens. NEVER spray WD-40 or Sheila Shine near an open flame! These products are extremely flammable while in their Fire aerosol forms. Hazard 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
The racks, flame tamers, and flavor bars can all be removed for cleaning and are dishwasher safe. 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
Be sure to allow the drip pan to cool prior to cleaning. You may clean the drip pan with a solution of warm soapy water. Make sure to rinse thoroughly to avoid staining. 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
(See your local Cal Flame dealer for details.) The cover will help protect your grill from detrimental effects of weather and environmental pollutants. Never put a cover on a hot grill. Allow the grill to cool before covering. 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
Make sure the valve orifice is aligned inside the front hole of the burner. • If there is no spark at all, replace the electrode or igniter wire. Note: Turn source while troubleshooting. 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
Page 24
Open the gas valve for one second to blow out any debris. Close off the gas valve and reconnect the fuel line securely. 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
Page 25
‘OFF’ position. Wait until the grill has cooled off and then clean the burner tubes and burners as described on page of this manual. 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
Raise the stud from the locking hole and move the burner forward carefully to release it from the ignition and gas supply valve. Take the burner out of the grill and store it in a safe and dry place. 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
If LMS determines that repair of a covered item is not feasible, LMS reserves the right to replace the defective merchandise with merchandise equal in value 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
Page 28
This Limited Warranty applies only to barbecue grills normally used for personal, family, or household purposes and specifically excludes commercial use of the barbecue grill. 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
91766 or call (800) 225-7727. See your Cal Flame barbecue dealer for a copy of the applicable warranty, details and any questions you may have regarding the warranty coverage on your barbecue. 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
Type of fuel (circle one): Liquid propane Natural gas Date purchased: Date installed: Cal Flame dealer’s phone number: Cal Flame dealer’s address: Don’t forget to register your new product at www.calflamebbq.com. 2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
Page 31
2010 G Series Gas Grills LTR50001050, Rev. B www.calspas.com...
Page 32
LMS Customer Service Department 1462 East Ninth Street Pomona, CA 91766 Toll Free: 1-800-CAL-SPAS Fax: 1-909-629-3890 www.calflamebbq.com California Proposition 65 Warning: Chemicals known to the State of California to cause cancer, birth defects or other reproductive harm are found in and/or created by the combustion of natural gas, propane, butane and other fuels.
Need help?
Do you have a question about the G Series and is the answer not in the manual?
Questions and answers