Table of Contents
Related Manuals for Charnwood OLX
Summary of Contents for Charnwood OLX
- Page 1 CHARNWOOD OLX Oil Fired Hearth Boiler Operating Installation Instructions Bishops Way, Newport, Isle of Wight, PO30 5WS Tel: +44 (0)1983 537799 Fax: +44(0)1983 537788 E-Mail: charnwood@ajwells.co.uk Internet: www.charnwood.com...
-
Page 3: Table Of Contents
Wiring Diagram............15 Electrode Settings...........16 Exploded Parts Drawing - Boiler......17 Exploded Parts Drawing - Burner......18 Bishops Way, Newport, Isle of Wight, PO30 5WS Technical Support Tel: +44 (0)1983 537799 Fax: +44(0)1983 537788 E-Mail: charnwood@ajwells.co.uk Internet: www.charnwood.com Page 3 OLX V5.2 05.04... -
Page 4: Operating Instructions
Charnwood OLX Oil Fired Hearth Boiler Operating Instructions GENERAL POINTS Before using the boiler for the first time, check with the installer that it has been correctly installed and commissioned. Do not attempt to use the boiler before it has been commissioned. - Page 5 Replace the fibreglass coal effect, with the rear edge passing just under the Perspex. Re-fit the front fence and replace the coals. 1) Lift Bulb from clip Sleeve Bulb 2) Remove Bulb from Holder Fig. 3. Flame Effect Bulb Replacement Page 5 OLX V5.2 05.04...
-
Page 6: Installation Instructions
Charnwood OLX Oil Fired Hearth Boiler Installation Instructions HEALTH AND SAFETY PRECAUTIONS boiler and a ducted air supply must be provided to the Please take care when installing the appliance that the right hand side of the boiler at this point. A two metre... - Page 7 Page 7 OLX V5.2 05.04...
-
Page 8: Hearth & Fire Surround
In order to ensure quietness of operation of the The boiler waterways totally enclose the combustion Charnwood OLX a single pipe system is used. The oil chamber. This means that the maximum temperature storage tank should ideally be positioned with the base below the boiler is 100°C and therefore a... -
Page 9: Preparation Of The Fireplace
When replacing an existing boiler the system should and switch the burner off. If this is a possibility then Page 9 OLX V5.2 05.04... -
Page 10: Fitting The Fire
Bleed Screw Oil Pressure Adjustment screw. COMBUSTION CHAMBER ASSEMBLY Clockwise to Increase, Bleed Hose Anti-Clockwise to Decrease. Connection Point The boiler comes with the internal insulation bricks and Fig. 9. Oil Pump Details Page 10 OLX V5.2 05.04... -
Page 11: Finishing The Installation
Once the installation is complete ensure that the air Fig 11. Combustion Chamber Components control is set at maximum (No. 10) before the burner is fired (see Fig. 8.) Otherwise sooting may occur. This will be re-adjusted during commissioning. Page 11 OLX V5.2 05.04... -
Page 12: Commissioning
Flue Fixings Boiler tappings are 1” BSP Female, 2 each side ø130 (693 with optional fan heater) Charnwood OLX Overall Dimensions (all dimensions are in mm) Page 12 OLX V5.2 05.04... - Page 13 Advise the customer on the use of the boiler, and the system controls. Also advise of the need for annual servicing of the boiler by an OFTEC trained & registered technician. Leave these Operating and Installation Instructions with the customer. Page 13 OLX V5.2 05.04...
-
Page 14: Specifications
OLX Boiler - Specifications Max. Allowable Operating Temperature 95°C Max. Allowable Operating Pressure 3 bar (Pressure Class 2) Test Pressure 4.5 bar Heat Output Range 11-13 kW Heat Input at Rated Output 15 kW Oil Pump Pressure 110 - 140 psi Required Flue Draught 0.07 in H O (0.17 mbar) -
Page 15: Wiring Diagram
Mains Input from Timer AirPressure Switched Live. Switch Fused at 3Amp. Ignition Unit Pump IEC Chassis IEC Lead TR TB Outlet Socket Plug to Burner Diode Dual Acting Thermostat SolenoidValve Burner Control (Oil) Thermostat Mounting Box Page 15 OLX V5.2 05.04... -
Page 16: Electrode Settings
Charnwood OLX Electrode Settings 0.5 ±0.5 3.0 ±0.2 9.0 ±1.0 All dimensions are in mm Page 16 OLX V5.2 05.04... -
Page 17: Exploded Parts Drawing - Boiler
Issue C Charnwood OLX Mk.2 Parts List NOTE! Mk.3 Replacement Burners for appliances before Serial No. 45****1562 require bracket to align control box with re-set hole. 45 44 47a 47b 47c Item Part No. Description Item Part No. Description 008/KV35S Door Seal Set Inc. -
Page 18: Exploded Parts Drawing - Burner
Issue A Charnwood OLX Burner Mk.3 Parts List These Items shown Rotated Item Part No. Description Item Part No. Description 040/TV61 Nozzle - 0.4 80° EH 040/TV124 Solenoid Valve 040/TV154 Electrode Mounting Block 040/TV123 Solenoid Plug & Lead 040/TV153 Electrode...