Table of Contents
Advertisement
CONTENTS
TOPIC
WARNING: This product contains crystalline silica, which has been identified by the International Agency for Research
on Cancer (IARC) as carcinogenic to humans. This product also contains refractory ceramic fibers, which have been
identified by the IARC as possibly carcinogenic to humans. Avoid breathing fiber particulates and dust.
RISKS:
Airborne fibrous insulation is a possible cancer hazard by inhalation.
Airborne crystalline silica may cause silicosis (lung disease) by inhalation.
May cause temporary irritation to eyes, skin, and respiratory tract.
PRECAUTIONARY MEASURES:
Minimize airborne fibers with engineering controls.
Use NIOSH/MSHA approved respirators as required (see MSDS).
Wear long sleeved, loose-fitting clothing, eye protection and gloves.
FIRST AID MEASURES: (If any of the irritations listed persists, seek medical attention)
Eyes:
Flush with water.
Skin:
Wash with soap and warm water.
Ingestion:
Do not induce vomiting. Get medical attention if gastrointestinal symptoms develop.
Inhalation:
Remove to fresh clean air.
WARNING: If you are unfamiliar with the safe handling of refractory ceramic fiber products, or if you wish additional
information prior to beginning any disassembly of the water heater or boiler that might expose refractory ceramic fiber
materials, contact: Unifrax Corporation, 2351 Whirlpool Street, Niagara Falls, NY 14305-2413, 1-800-322-2293.
IDENTIFICATION OF REFRACTORY CERAMIC FIBER MATERIALS (RCF): The combustion chamber top and bottom utilize
RCF material. (The RCF materials are located within the product and not generally exposed except during service, disassembly or
assembly.)
PRODUCT SAFETY INFORMATION
REFRACTORY CERAMIC FIBER PRODUCT WITH CRYSTALLINE SILICA
CHECKING EQUIPMENT BEFORE YOU INSTALL
PAGE
Inspect the unit completely upon receipt from the
1
freight carrier before signing the bill of lading.
4
Inspect the appliance and all accompanying parts
5
for signs of impact or mishandling. Verify the total
5
number of pieces shown on packing slips with those
6
actually received. Contact the freight carrier
8
immediately if any damage or shortage is detected.
9
11
Factory warranty does not cover improper
11
installation or operation, which rather than faulty
12
equipment, is the primary cause of most operating
13
problems. (See attached warranty for complete
13
details)
15
Warranty exclusions include but are not limited to
failure or malfunctions resulting from:
1. Failure to properly apply, install, operate, or
maintain the appliance in accordance to
16
printed instructions.
16
2. Abuse, alteration, accident, fire, flood and the
17
like.
18
3. Sediment or lime buildup, freezing or any
19
other conditions causing inadequate
20
circulation.
4. Corrosive or contaminated atmosphere.
20
5. A water velocity flow rate exceeding or below
20
the product design flow rate.
21
23
Important: This equipment is intended to operate in
23
non-condensing conditions. Inlet water to the
24-30
appliance must not drop below 130
2
WARRANTY
º
F.
34-50 04/02/2010
Hide quick links:
Advertisement
Table of Contents
