Panasonic NV-FJ623EG Service Manual
  1. Manuals
  2. Brands
  3. Panasonic Manuals
  4. VCR
  5. NV-FJ623EG
  6. Service manual
Panasonic NV-FJ623EG Service Manual

Panasonic NV-FJ623EG Service Manual

Video cassette recorder
Hide thumbs Also See for NV-FJ623EG:
Table of Contents

Advertisement

Quick Links

Service Manual
ORDER NO. VRD0202004C2
Video Cassette Recorder
NV-FJ623EG/NV-FJ623EGY/NV-FJ628EE
l
Z-MECHANISM
© 2002 Matsushita Electric Industrial Co., Ltd. All rights reserved. Unauthorized copying and distribution is a
violation of law.

Advertisement

Table of Contents
loading

Related Manuals for Panasonic NV-FJ623EG

Summary of Contents for Panasonic NV-FJ623EG

  • Page 1 Service Manual ORDER NO. VRD0202004C2 Video Cassette Recorder NV-FJ623EG/NV-FJ623EGY/NV-FJ628EE Z-MECHANISM © 2002 Matsushita Electric Industrial Co., Ltd. All rights reserved. Unauthorized copying and distribution is a violation of law.
  • Page 2 Procedures for Mechanism Chassis are separate volume from this service manual./Please refer to the service manual for Z-Mechanism Chassis. (Order No. VRD9802005C2) 2. The Model No. is indicated on the Schematic Diagram and Circuit Board Diagrams as follows. Model No. Indication Mark NV-FJ623EG (EG) NV-FJ623EGY (EGY) NV-FJ628EE (EE)
  • Page 3 2.1.1 REPLACING IC7702/EEPROM When the EEPROM: IC7702 is replaced, applicable model code, option code and electrical adjustment data will not be available. Therefore, enter and/or adjust the necessary data after replacing IC7702 by referring following procedure. STEP1.REPLACE THE IC7702 1. Remove the C.B.A. with Mechanism unit by referring the Disassembly procedure. 2.
  • Page 4 Model No. Model Option Code 1 Option Code 2 Option Code 3 Code NV-FJ623EG/EGY (41h) (7Dh) (C4h) (6h) NV-FJ628EE (46h) (79h) (C4h) (6h) Fig. S2 Model Code & Option Code NOTE: Since all electrical adjustments data is still not available, perform the Electrical Adjustment continuously.

  • Page 5: Cylinder Unit Replacement

    2.1.2 CYLINDER UNIT REPLACEMENT 1. CYLINDER UNIT REPLACEMENT A. Remove the mechanism unit from MAIN C.B.A./Chassis by referring “SECTION 2. Disassembly Procedure”. B. Remove the 3 screws (A) of the CYLINDER UNIT with a screw driver. C. Unlock the 4 locking tabs (B) and disconnect the Cylinder flexible card from the FPC Holder. D.
  • Page 6 3. UPPER CYLINDER ASSEMBLY When reassembling, perform the steps in the reverse order. Notes: A. Install the Cylinder Retainer so that the 2 holes on top of the Cylinder Retainer are at right angles with the P3502 Connection. B. Tighten the Hex screw (C) (1.5 mm) while pressing down on top of the Cylinder Retainer. Fig.
  • Page 7 C. Install the Cylinder Rotor Unit so that the inner hole of the Cylinder Rotor Unit fits to the small projection (D) on top of the Upper Cylinder. D. Tighten 2 screws (B). Fig. S6 E. install the Cylinder Stator Unit. F.

  • Page 8: Checking Of Main C.b.a

    2.1.3 CHECKING OF MAIN C.B.A. When servicing the MAIN C.B.A., take out the MAIN C.B.A. and mechanism from the frame and turn over. Fig. S8 2.1.4 FLAT CARD CABLE INSTALLATION When installing the Flat Card Cable on the connector, install the Flat Card Cable with the cable contacts facing the connector contacts.

  • Page 9: Removal Of Cassette Tape

    2.2 REMOVAL OF CASSETTE TAPE There are 2 ways to remove a cassette tape. 1. Service Information Display Operation A. Press the FF and EJECT keys simultaneously for 3 seconds and set the Service Mode 7. B. Press STOP key in order to rotate the Loading Motor for unloading operation. (Pay an attention of tape slack) 2.
  • Page 10 2.3 INTRODUCTION OF VIDEO HEAD CLEANING CASSETTE/ (POLISHING TYPE) 1. We are pleased to introduce Panasonic Video Head Cleaning Cassette, VFK0923FT [for service purposes] VFK0923FSE [ for end users] for all VHS/SVHS VCP and VCR. 2. These cleaning cassettes are exclusive removing the hard and sticky clogging on video heads.

  • Page 11: Self-Diagnosis Result Display

    2.4 SELF-DIAGNOSIS RESULT DISPLAY The "SELF-DIAGNOSIS RESULT DISPLAY & MEMORY function is built in this VTR. It means that when the VCR detects undesirable condition, it can be displayed a “Error code (Two numbers from the right)” with Service Mode 2. Since the "Error code"...

  • Page 12: Disassembly Flow Chart

    3.1.1 DISASSEMBLY FLOW CHART This flow chart indicates disassembly steps of the cabinet parts and the circuit boards in order to find the necessary items for servicing. When reassembling, perform the steps in the reverse order. Fig. D1...

  • Page 13: Detail Of Disassembly Method

    3.1.2 DETAIL OF DISASSEMBLY METHOD 1. REMOVAL OF THE TOP PANEL Remove 4 Screws (A) Fig.D2 2. REMOVAL OF THE FRONT PANEL UNIT Unlock 7 Tabs (B) Fig. D3 3. REMOVAL OF THE MECHANISM UNIT Remove Screw (C) Remove 3 Screws (D) Remove 2 Screws (E) Note: A.
  • Page 14 4. REMOVAL OF THE MAIN C.B.A. Remove 4 Screws (F) Unlock 4 Tabs (G) Fig. D5 NOTE: Before mounting the MAIN C.B.A. onto the frame, be sure to confirm that the insulation sheet is mounted on the frame as shown in Fig. D6 . Fig.

  • Page 15: Servicing Position

    5. SERVICING POSITION Fig. D7 3.2 MECHANICAL ADJUSTMENT PROCEDURES Refer to the Service Manual for Z-Mechanism Chassis./(Order No. VRD9802005C2)

  • Page 16: Test Equipment

    3.3.1 TEST EQUIPMENT The following equipments are required for Electrical Adjustments. 1. Dual-Trace Oscilloscope Voltage Range: 0.005-5V/div ¡ Frequency Range: DC-35MHz ¡ Probes: 10:1 / 1:1 ¡ 2. Frequency Counter Frequency Range: 0-10MHz ¡ Probes: 1:1 ¡ 3. Universal Counter 4.

  • Page 17: Pg Shifter Adjustment/(Automatic)

    3.3.3 ADJUSTMENTS Fig.E1 Fig.E2 CONDITION: BURST SIGNAL OFF / 75 ohm TERMINATED 3.3.4 PG SHIFTER ADJUSTMENT/(AUTOMATIC) PROCEDURES FIP DISPLAY Press the FF and EJECT Keys simultaneously for 3 seconds. Press the FF and EJECT Keys simultaneously twice. Press the EJECT key for 3 seconds. Press the CH UP key once.
  • Page 18 3.3.5 AI FUNCTION ADJUSTMENT (AUTOMATIC) PROCEDURES FIP DISPLAY Press the FF and EJECT Keys simultaneously for 3 seconds. Press the FF and EJECT Keys simultaneously twice. Press the EJECT key for 3 seconds. Press the CH UP key in 3 times. Insert the blank cassette tape.

  • Page 19: Location Of Test Points& Controls

    3.3.7 LOCATION OF TEST POINTS& CONTROLS 3.3.8 CIRCUIT BOARD LAYOUT...
  • Page 20 4.43 NTSC L BILINGUAL 443NT [L] BILINGUAL L A. COMP BIL [L] AUDIO COMPONENT SIGNAL BILINGUAL H BIL. [H] A. COMPO AUDIO COMPONENT SIGNAL BILINGUAL L AUDIO DUBBING PAUSE L BIL/M1 [L] A. D.P [L] AUDIO DUBBING PAUSE L BS CLOCK A.
  • Page 21 CYL GND CYLINDER GND FULL. E. 12V FULL ERASE 12V DELAIED FM RECORDING H D.F.M. REC [H] GND (ANALOG) GND [A] DELAIED FM RECORDING L D. FM REC [L] GND (TUNER) GND [TU] D. GND GND/NON SW 12V DIGITAL GND GND/N.
  • Page 22 POWER OFF H LINE IN [R] LINE INPUT (R) P-OFF [H] POWER OFF L LINE OUT [L] LINE OUTPUT (L) P-OFF [L] LINE OUT [R] LINE OUTPUT (R) P. FAIL POWER FAILURE DETECT LP H POWER OFF H LP [H] P.
  • Page 23 SYSTEM CONTROL 5V RF OUT RF OUTPUT SYSCON 5V SYSTEM SW RF Y RF LUMINANCE SIGNAL SYSTEM TAKE-UP PHOTO TRANSISTOR RF. Y. IN RF LUMINANCE SIGNAL INPUT T-PHOTO TAKE-UP REEL PULSE RF. Y. OUT RF LUMINANCE SIGNAL OUTPUT T-RL. PLS TIMER BUS CLOCK ROTAR.
  • Page 24 No. Port Name Description P-OFF P-Save P-FAIL Reset CURRENT_LIMIT O Capstan motor current limit terminal. F ADJUST O Analogue voltage output for HEAD frequency response adjustment N.C. -- Low fix (No Connection.) Terminal of the Current emphasis video/FM audio recording current. [HIFI/2HEAD ]:Fix to Low (Normal mode) C EMPHA(H) [4HEAD]...
  • Page 25 No. Port Name Description P-OFF P-FAIL Reset P-Save ROTARY.SW O Output terminal for rotary switch. H.A.SW O Output terminal for HEAD AMP switch. ENVE.SELECT I Input terminal for enverope selection. VIDEO.H.SW O Output terminal for video HEAD switch. A.H.SW O Output terminal for FM audio HEAD switch. Audio Mute output terminal for tuner and decoder.
  • Page 26 No. Port Name Description P-OFF P-FAIL Reset P-Save LC.OSC OUT O The oscillation output terminal for OSD dot clock. RESET(L) I Input terminal for microprocessor reset. 4FC.LPF I 4fc clock input terminal OSD.FSC IN I OSD clock input terminal 5V(OSD) I 5V input terminal CVIN I Input terminal for Composite video signal.
  • Page 27 No. Port Name Description P-OFF P-FAIL Reset P-Save FLD/T2 DATA OUT O Serial data output terminal for FIP driver and TEST_2(Factory use). Not fix Low FLD_CS O Chip select terminal for FIP driver. Not fix Low T.REEL.PULSE I Input terminal for Take-up Reel sensor pulse. S.REEL.PULSE I Input terminal for Supply Reel sensor pulse.
  • Page 28 INPUT CONDITION VIDEO OUTPUT RESULT AUDIO OUTPUT RESULT POWER INPUT RF (C) AV1 Out AV2 Out SELECT ON(H) PB(H) PB(H) PB(H) Selector Selector AV2 In AV1 In AV2 In AV1 In Mute AV2 In AV1 In AV2 In AV1 In AV2 In AV1 In Mute...
  • Page 29 INPUT CONDITION VIDEO OUTPUT RESULT AUDIO OUTPUT RESULT POWER INPUT RF (C) AV1 Out AV2 Out SELECT ON(H) PB(H) PB(H) PB(H) Selector Selector P.ON NO.TU VCR out VCR out INSEL C+.TU VCR out VCR out INSEL VCR out VCR out AV1 In AV1 In AV1 In...
  • Page 30 INPUT CONDITION VIDEO OUTPUT RESULT AUDIO OUTPUT RESULT POWER INPUT RF (C) AV1 Out AV2 Out SELECT ON(H) PB(H) PB(H) PB(H) Selector Selector P.ON DECODER VTR NO.TU VCR out AV1 In AV1 In AV1 In VCR out AV1 In AV1 In AV1 In C+.TU VCR out TUN IN...
  • Page 31 T1101-3 STOP T1101-7 STOP IC1101-1 STOP IC1101-2 STOP IC1101-4 STOP 9.0Vp-p (2msec. div.) 100Vp-p (5µsec. div.) 470Vp-p (5µsec. div.) 8.0Vp-p (10µsec. div.) 0.5Vp-p (10µsec.div.) IC1101-5 STOP IC6001-20 PAUSE IC6001-21 REC IC6001-24 REC IC6001-61 REC 0.6Vp-p (10µsec.div.) 5.0Vp-p (10msec.div.) 5.0Vp-p (10msec.div.) 5.0Vp-p (10msec.div.) 2.4Vp-p (20µsec.div.) IC6001-68 REC...
  • Page 32 SYSTEM CONTROL & SERVO ICs DC VOLTAGE CHART (SP MODE) IC1501 IC1502 Ref. No. MODE STOP PLAY IC2501 Ref. No. MODE STOP 16.8 16.8 16.8 16.8 PLAY 14.9 14.9 15.2 14.9 15.1 15.1 15.4 15.1 14.4 14.4 14.6 14.7 14.3 14.3 14.6 14.9...
  • Page 33 PLAY PAUSE CH UP Q1501 D1501 Q1502 S7507 S7512 S7511 S7503 S7504 TAKE UP SENSOR SUPPLY SAFETY T-REEL PULSE PHOTO PHOTO TAB SW SENSOR SENSOR P4003 CTL HEAD(-) HEAD P4003 112 CTL HEAD(+) NV-FJ623EG/EGY,FJ628EE SYSTEM CONTROL & SERVO BLOCK DIAGRAM...
  • Page 34 FAMI MODE:When setting the NTSC CONVERTER to ON on the OSD Screen Display, SYSTEM AV PB the signals from NTSC Signal Source (ex.NTSC GAME Machine)connected CONTROL to the VCR can be appeared on the PAL TV.However when recording, X3001 it is not recorded correctly. NV-FJ623EG/EGY,FJ628EE LUMINANCE & CHROMINANCE BLOCK DIAGRAM...
  • Page 35 & SWITCH P3502 Hi-Fi (EE) P3502 IC3001 AUDIO HEAD P3502 GAIN QR7601 FROM DECODER/ TUNER AUDIO (N) MUTE TV DEMODU (EG/EGY) FM MODULATOR/ DEMODULATOR A.HEAD (W) NORMAL SELECT SWITCH TO/FROM AC HEAD & SWITCH A.HEAD (R) NV-FJ623EG/EGY,FJ628EE AUDIO BLOCK DIAGRAM...
  • Page 36 2200 NOTE1:WHEN MEASURE THE VOLTAGE OR WAVEFORM ON THE POWER TRANSFORMER CIRCUIT,SET THE GND TERMINAL OF MEASURING POINT AS FOLLOWS. PRIMARY SIDE..NV-FJ623EG/EGY,FJ628EE SECONDARY SIDE... NOTE:DO NOT USE ANY PART NUMBER SHOWN ON THIS SCHEMATIC DIAGRAM FOR IMPORTANT SAFETY NOTICE:...
  • Page 37 C7627 0.01 QR7601 UN2215 D1002 D1007 (MUTE) NV-FJ623EG/EGY,FJ628EE IMPORTANT SAFETY NOTICE: NOTE:DO NOT USE ANY PART NUMBER SHOWN ON THIS POWER SUPPLY/RF COMPONENTS IDENTIFIED WITH THE MARK HAVE THE SPECIAL CHARACTERISTICS FOR SAFETY. SCHEMATIC DIAGRAM FOR ORDERING.WHEN YOU SECTION SCHEMATIC DIAGRAM NOTE:THE MEASUREMENT MODE OF THE DC VOLTAGE ON THIS DIAGRAM IS STOP MODE.
  • Page 38 4300 5600 8200 BACK UP 5V NV-FJ623EG/EGY,FJ628EE NOTE:DO NOT USE PART NUMBER SHOWN ON THIS SCHEMATIC DIAGRAM FOR NOTE:THE MEASUREMENT MODE OF THE DC VOLTAGE ON THIS DIAGRAM IS STOP MODE. ORDERING.WHEN YOU ORDER A PART,PLEASE REFER TO PARTS LIST.
  • Page 39 R6005 R6004 H0H200- X6001 220K RESET 500011 VSX1022 C7713 6V47 Y/C VIDEO OUT C6012 C6011 C6010 C6009 SAFETY TAB SLEEP C6008 C SYNC 1000P BACK UP 5V B14 B15 B16 B19 B20 NV-FJ623EG/EGY,FJ628EE SYSTEM CONTROL & SERVO SECTION SCHEMATIC DIAGRAM...
  • Page 40 35V4.7 UNREG 14V L2501 R2509 N.SW 5V NV-FJ623EG/EGY,FJ628EE NV-FJ623EG/EGY,FJ628EE SYSTEM CONTROL & SERVO NOTE:DO NOT USE ANY PART NUMBER SHOWN ON THIS SCHEMATIC DIAGRAM FOR ORDERING.WHEN YOU ORDER A PART,PLEASE REFER TO PARTS LIST. SYSTEM CONTROL & SERVO SECTION SCHEMATIC DIAGRAM...
  • Page 41 PAL EP BIAS 5V VIDEO 5V NV-FJ623EG/EGY,FJ628EE NOTE:THE MEASUREMENT MODE OF THE DC VLOLTAGE IN THE BRACKETS( )ON THIS DIAGRAM IS RECORD MODE THE MEASUREMENT MODE OF THE DC VOLTAGE OUT OF THE BRACKETS ON THIS DIAGRAM IS PLAYBACK MODE LUMINANCE &...
  • Page 42 C4007 6V220 1200P R4008 220K L3005 NV-FJ623EG/EGY,FJ628EE LUMINANCE & CHROMINANCE/AUDIO NV-FJ623EG/EGY,FJ628EE NOTE:DO NOT USE ANY PART NUMBER SHOWN ON THIS SCHEMATIC DIAGRAM FOR SECTION SCHEMATIC DIAGRAM LUMINANCE & CHROMINANCE/AUDIO SECTION SCHEMATIC DIAGRAM ORDERING.WHEN YOU ORDER A PART,PLEASE REFER TO PARTS LIST.
  • Page 43 D.FM REC NOTE:DO NOT USE ANY PART NUMBER SHOWN ON THIS NV-FJ623EG/EGY,FJ628EE NOTE:THE MEASUREMENT MODE OF THE DC VOLTAGE IN THE BRACKETS( )ON THIS DIAGRAM IS RECORD MODE THE MEASUREMENT MODE OF THE DC VOLTAGE OUT OF THE BRACKETS ON THIS DIAGRAM IS PLAYBACK MODE SCHEMATIC DIAGRAM FOR ORDERING.WHEN YOU...
  • Page 44 THIS DIAGRAM IS RECORD MODE WITH PAL COLOUR.(SP MODE) THE MEASUREMENT MODE OF THE DC VOLTAGE OUT THE BRACKETS( )ON THIS DIAGRAM IS RECORD MODE WITH PAL COLOUR SIGNAL.(SP MODE) NV-FJ623EG/EGY,FJ628EE NOTE:DO NOT USE ANY PART NUMBER SHOWN ON THIS SCHEMATIC DIAGRAM FOR INPUT/OUTPUT SECTION ORDERING.WHEN YOU ORDER A PART,PLEASE REFER TO PARTS LIST.

  • Page 45: Tv Demodulator Pack Schematic Diagram

    4MHz C0711 R0715 16V22 NV-FJ623EG/EGY,FJ628EE NOTE:DO NOT USE ANY PART NUMBER SHOWN ON THIS SCHEMATIC DIAGRAM FOR TV DEMODULATOR PACK SCHEMATIC DIAGRAM NOTE:THE MEASUREMENT MODE OF THE DC VOLTAGE ON THIS DIAGRAM IS STOP MODE. ORDERING.WHEN YOU ORDER A PART,PLEASE REFER TO PARTS LIST.

  • Page 46: Audio Signal Path

    0.012 0.012 NOTE: DO NOT USE ANY PART NUMBER SHOWN ON THIS SCHEMATIC DIAGRAM FOR NV-FJ623EG/EGY NOTE:THE MEASUREMENT MODE OF THE DC VOLTAGE ON THIS DIAGRAM IS STOP MODE. ORDERING. WHEN YOU ORDER A PART,PLEASE REFER TO PARTS LIST. DECODER PACK SCHEMATIC DIAGRAM...
  • Page 47 L7302 AUDIO SIGNAL PATH X7302 VSX0953 C7316 R7327 R7325 8200 SIF2 C7315 NICAM INPUT DEMODULATION NICAM SWITCH VREF1 AGC, C7307 R7302 C7311 FM/AM PK7301 0.01 DEMODULATION SIF1 QPSK/SIF TUNER AUDIO (N) IC7302 NICAM CRESET DEMATRIX VDEC2 PST7043 DECODER TUNER 5V (RESET) IDENTIFI- VSSA3...
  • Page 48 P2901 MAIN COIL 2 MAIN COIL 3 HALL IC GND (CYL) MAIN COIL 1 NOTE:DO NOT USE ANY PART NUMBER SHOWN ON THIS SCHEMATIC DIAGRAM FOR NV-FJ623EG/EGY,FJ628EE ORDERING.WHEN YOU ORDER A PART,PLEASE REFER TO PARTS LIST. CYLINDER STATOR SCHEMATIC DIAGRAM...
  • Page 49 L0201 R0208 UNLOADING C0208 HOLE LOADING SENSOR R0204 C0209 C0210 ED/S TORQUE DIRECTION OUT2 CAPSTAN MOTOR DRIVER MAIN COIL HALL POWER R0209 OUT1 EC AMP HOLE SENSOR TL0205 DRIVER CONTROL LOGIC R0201 R0211 C0206 C0207 NV-FJ623EG/EGY,FJ628EE CAPSTAN UNIT SCHEMATIC DIAGRAM...

  • Page 50: Address Information

    DECODER PACK C.B.A. Integrated Circuit IC7301 Test Point TL7301 TL7302 TL7303 Adjustment VR7301 Connector PK7301 PK7302 ADDRESS INFORMATION (VEP07A16A:NV-FJ623EG/EGY) VR7301 TL7303 IC7301 TL7302 TL7301 PK7302 PK7301 NV-FJ623EG/EGY DECODER PACK C.B.A.
  • Page 51 NICAM DECODER PACK C.B.A. Integrated Circuit IC7301 IC7302 Test Point TL7301 TL7303 TL7304 Integrated Circuit PK7301 PK7302 ADDRESS INFORMATION (VEP07A18T:NV-FJ628EE) IC7301 TL7304 TL7303 TL7301 PK7302 PK7301 NV-FJ628EE NICAM DECODER PACK C.B.A.
  • Page 52 (VEP06E55M:NV-FJ623EG/EGY)(VEP06E55Q:NV-FJ628EE) R4918 TU7601 R4916 C7603 P2502 C4910 C4909 K7601 R2509 R4914 LB4905 P1102 R7617 TW3003 JK4903 C4915 P4003 C2518 K7603 R7604 W409 C2520 C4914 R7616 K7611 C4032 LB4906 R4030 R7605 C7604 IC2501 QR4904 QR4905 C4501 R4535 W402 C2505 C4532 R4902...
  • Page 53 TW3030 QR3502 TW4501 QR4001 TW4502 QR4002 TW4901 QR4003 TW4902 QR4005 TW4903 QR4501 TW4906 QR4502 TW4907 QR4505 TW6002 QR4506 Connector QR4904 P1102 QR4905 P1501 QR6001 P2501 QR6006 P2502 QR7601 P3502 P4002 P4003 DU7601 PK7301 PK7302 TU7601 ADDRESS INFORMATION NV-FJ623EG/EGY,FJ628EE MAIN C.B.A.

  • Page 54: Cylinder Stator Unit

    (VEM0715) CYLINDER STATOR UNIT Integrated Circuit HALL IC Connector M1 VM P2901 ADDRESS INFORMATION HALL IC VM M2 P2901 NV-FJ623EG/EGY,FJ628EE CYLINDER STATOR UNIT...

  • Page 55: Tv Demodulator Pack C.b.a

    TV DEMODULATOR PACK C.B.A. Transistor Q0702 Integrated Circuit IC0701 Adjustment T0701 VR0701 Connector PK0701 PP0701 ADDRESS INFORMATION (VEP07A23S:NV-FJ623EG/EGY) (VEP07A23U:NV-FJ628EE) IC0701 (EE) (EG/EGY) (EE) (EG/EGY) (EE) LB0701 (EE) PK0701 Q0702 NV-FJ623EG/EGY,FJ628EE TV DEMODURATOR PACK C.B.A.

  • Page 59: Chassis Parts Section Parts List

    11.1 CHASSIS PARTS SECTION PARTS LIST Ref. No. Part No. Part Name & Description Remarks VEG1598 CYLINDER UNIT [MAVD] VXP2170 UPPER CYLINDER UNIT [MAVD] VDB1256 CYLINDER RETAINER VEM0715 CYLINDER MOTOR UNIT VXS0135 EARTH BRUSH UNIT VMD3795 FLAT CABLE HOLDER VEK9069 CAPSTAN UNIT L1AZ00000004 FE HEAD VDB1431...

  • Page 60: Casing Parts Section Parts List

    11.2 CASING PARTS SECTION PARTS LIST Ref. No. Part No. Part Name & Description Remarks VGM1834 TOP PANEL [MAVD] VYP8350 FRONT PANEL UNIT [MAVD] NV-FJ623EG-S VYP8406 FRONT PANEL UNIT [MAVD] NV-FJ623EGYS VYP8360 FRONT PANEL UNIT [MAVD] NV-FJ628EE-S RKA0072-K FOOT RKA0072-K...

  • Page 61: Packing Parts Section Parts List

    11.3 PACKING PARTS SECTION PARTS LIST Ref. Part No. Part Name & Description Remarks VQT9525 OPERATING INSTRUCTIONS (GERMAN) [MAVD] NV-FJ623EG- VQT9840 OPERATING INSTRUCTIONS (ENGLISH/GERMAN/FRENCH/ITALIAN/DUTCH/GREEK) [MAVD] NV- FJ623EGYS VQT9549 OPERATING INSTRUCTIONS [MAVD] NV-FJ628EE- (ENGLISH/POLISH/CZECHOSLOVAK/HANGARIAN/RUSSIAN) N2QAHB000022 REMOTE CONTROLLER [MAVD] R0185-720010 BATTERY COVER...

  • Page 62: Electrical Parts List

    11.4 ELECTRICAL PARTS LIST Ref. No. Part No. Part Name & Description Remarks VEP06E55M MAIN C.B.A. (RTL)[MAVD] *1 THE FOLLOWING C.B.A.S ARE INCLUDED IN MAIN C.B.A. VEP07A16A,VEP07A23S VEP06E55Q MAIN C.B.A. (RTL)[MAVD] *2 THE FOLLOWING C.B.A.S ARE INCLUDED IN MAIN C.B.A. VEP07A18T,VEP07A23U VEP07A16A DECODER PACK C.B.A.
  • Page 63 C1010 ECA1EHJ470 E.CAPACITOR 25V 47U [MAVD] C1011 ECUX1C104KBV C.CAPACITOR CH 16V 0.1U ECJ1XB1C104K C1012 ECEA1AKS220 E.CAPACITOR 10V 22U C1025 ECUV1H104KBN C.CAPACITOR CH 50V 0.1U [MAVD] ECJ2YB1H104K C1026 ECUV1H104KBN C.CAPACITOR CH 50V 0.1U [MAVD] ECJ2YB1H104K C1101 VCF2AAF683M X2 CAPACITORS [MAVD] C1102 F1BAF1020020 CERAMIC CAPACITOR [MAVD]...
  • Page 64 C3019 ECUX1C104ZFV C.CAPACITOR CH 16V 0.1U C3020 ECEA1HKS010 E.CAPACITOR 50V 1U C3021 ECUX1H103KBV C.CAPACITOR CH 50V 0.01U C3022 ECUX1C104ZFV C.CAPACITOR CH 16V 0.1U C3023 ECEA0JKS470 E.CAPACITOR 6.3V 47U C3024 ECUX1C104KBV C.CAPACITOR CH 16V 0.1U ECJ1XB1C104K C3025 ECUX1H222KBV C.CAPACITOR CH 50V 2200P ECJ1XB1H222K C3027 ECEA1HKSR33...
  • Page 65 C4013 ECUX1E223KBV C.CAPACITOR CH 25V 0.022U *2 F1H1E223A024 C4014 ECEA1HKS010 E.CAPACITOR 50V 1U C4015 ECEA0JKS470 E.CAPACITOR 6.3V 47U C4016 ECUX1C104KBV C.CAPACITOR CH 16V 0.1U ECJ1XB1C104K C4017 ECEA1AKS220 E.CAPACITOR 10V 22U C4018 ECUX1C104KBV C.CAPACITOR CH 16V 0.1U ECJ1XB1C104K C4019 ECUX1C104ZFV C.CAPACITOR CH 16V 0.1U C4020 ECEA0JKS470 E.CAPACITOR 6.3V 47U...
  • Page 66 C6002 ECUX1H151JCV C.CAPACITOR CH 50V 150P ECJ1XC1H151J C6003 ECUX1H471JCV C.CAPACITOR CH 50V 470P ECJ1XC1H471J C6004 ECUX1H103ZFV C.CAPACITOR CH 50V 0.01U ECJ1XF1H103Z C6005 ECUX1H103ZFV C.CAPACITOR CH 50V 0.01U ECJ1XF1H103Z C6008 ECUX1H102KBV C.CAPACITOR CH 50V 1000P C6009 ECUX1H180JCV C.CAPACITOR CH 50V 18P C6010 ECUM1H240JCV C.CAPACITOR CH 50V 24P...
  • Page 67 C7328 ECUM1H152KBM C.CAPACITOR CH 50V 1500P C7341 ECUX1H472KBV C.CAPACITOR CH 50V 4700P C7342 ECUX1H472KBV C.CAPACITOR CH 50V 4700P C7343 ECUX1H222KBV C.CAPACITOR CH 50V 2200P *2 ECJ1XB1H222K C7501 ECUX1H103ZFV C.CAPACITOR CH 50V 0.01U ECJ1XF1H103Z C7502 ECEA1HKS100 E.CAPACITOR 50V 10U ECEA1HKA100B C7503 ECUX1H120JCV C.CAPACITOR CH 50V 12P C7504...
  • Page 68 D2502 MA165 DIODE MA2C165 D3001 MA165 DIODE MA2C165 D4502 MA165 DIODE MA2C165 D4901 MA4051N-M DIODE MAZ4051NM D4902 MA4051N-M DIODE MAZ4051NM D4904 MA165 DIODE MA2C165 D7501 MA4220N-M DIODE [MAVD] D7503 RB441P DIODE D7601 MA4300M DIODE MAZ43000M DP7501 A2BD00000040 DISPLAY TUBE F1101 VSF0243C16 FUSE K5D162BL0004...
  • Page 69 K7605 ERJ6GEY0R00V M.RESISTOR CH 1/10W 0 D0GBR00JA017 K7611 ERJ6GEY0R00V M.RESISTOR CH 1/10W 0 D0GBR00JA017 K7613 ERJ6GEY0R00V M.RESISTOR CH 1/10W 0 *2 D0GBR00JA017 K7615 ERJ6GEY0R00V M.RESISTOR CH 1/10W 0 D0GBR00JA017 K7702 ERJ6GEY0R00V M.RESISTOR CH 1/10W 0 D0GBR00JA017 L0701 ELJNAR27JF INDUCTOR 0.27UH L0703 ELJNA2R2JF INDUCTOR 2.2UH...
  • Page 70 P1102 K2AA2K000012 AC INLET [MAVD] P1501 VJS3837A002 CONNECTOR (FEMALE) 2P K1KB02A00035 P2501 VJP3835E012 CONNECTOR (MALE) 12P [MAVD] K1KA12A00127 P2502 VJS3537A009G CONNECTOR (FEMALE) 9P K1MN09A00012 P3502 VJS3537A010G CONNECTOR (FEMALE) 10P K1MN10A00036 P4002 VJS3837A002 CONNECTOR (FEMALE) 2P K1KB02A00035 P4003 VJS3537A006G CONNECTOR (FEMALE) 6P K1MN06A00034 PK0701 VJR0826E009W CONNECTOR (MALE) 9P...
  • Page 71 QR6006 UN2211 TRANSISTOR UNR2211 QR7601 UN2215 TRANSISTOR-RESISTOR *1 UNR2215 R0705 ERJ3GEYJ472 M.RESISTOR CH 1/16W 4.7K R0707 ERJ3GEYJ393 M.RESISTOR CH 1/16W 39K R0708 ERJ3GEYJ103 M.RESISTOR CH 1/16W 10K R0709 ERJ6GEYG104 M.RESISTOR CH 1/10W 100K R0711 ERJ3GEYJ181V M.RESISTOR CH 1/16W 180 R0713 ERJ3GEY0R00 M.RESISTOR CH 1/16W 0 R0714...
  • Page 72 R1113 ERDS2FJ330 C.RESISTOR 1/4W 33 ERDS2TJ330T R1201 ERJ6GEYG222 M.RESISTOR CH 1/10W 2.2K R1202 ERJ6GEYG271 M.RESISTOR CH 1/10W 270 R1203 ERJ6GEYG223V M.RESISTOR CH 1/10W 22K R1204 ERJ6GEYF123 M.RESISTOR CH 1/10W 12K R1205 ERJ6GEYG222 M.RESISTOR CH 1/10W 2.2K ERJ6GEYG222V R1206 ERJ6GEYF333 M.RESISTOR CH 1/10W 33K R1207 ERJ6GEYF333 M.RESISTOR CH 1/10W 33K...
  • Page 73 R4001 ERJ6GEYG102 M.RESISTOR CH 1/10W 1K R4002 ERJ6GEYJ334 M.RESISTOR CH 1/10W 330K R4003 ERJ6GEYG103 M.RESISTOR CH 1/10W 10K R4004 ERJ6GEYG241 M.RESISTOR CH 1/10W 240 R4005 ERJ6GEYJ223 M.RESISTOR CH 1/10W 22K R4006 ERJ6GEYG753 M.RESISTOR CH 1/10W 75K R4007 ERJ6GEYJ153V M.RESISTOR CH 1/10W 15K R4008 ERJ6GEYJ224 M.RESISTOR CH 1/10W 220K...
  • Page 74 R4909 ERJ6GEYJ223 M.RESISTOR CH 1/10W 22K R4910 ERJ6GEYJ474V M.RESISTOR CH 1/10W 470K R4913 ERJ6GEYJ750 M.RESISTOR CH 1/10W 75 R4914 ERJ6GEYJ750 M.RESISTOR CH 1/10W 75 R4916 ERJ6GEYG331 M.RESISTOR CH 1/10W 330 R4918 ERJ6GEYG331 M.RESISTOR CH 1/10W 330 R4928 ERJ6GEY0R00V M.RESISTOR CH 1/10W 0 D0GBR00JA017 R4945 ERJ6GEYJ153V...
  • Page 75 R7320 ERJ6GEYG332 M.RESISTOR CH 1/10W 3.3K R7324 ERJ3GEYJ221 M.RESISTOR CH 1/16W 220 R7325 ERJ3GEY0R00 M.RESISTOR CH 1/16W 0 R7327 ERJ3GEYJ822V M.RESISTOR CH 1/16W 8.2K *2 D0GB822JA002 R7328 ERJ3GEYJ221 M.RESISTOR CH 1/16W 220 R7329 ERJ3GEYJ221 M.RESISTOR CH 1/16W 220 R7501 ERJ6GEYF822 M.RESISTOR CH 1/10W 8.2K R7502 ERJ6GEYG562...
  • Page 76 R7733 ERJ6GEYJ101V M.RESISTOR CH 1/10W 100 S1501 K0G934A00002 SWITCH K0ZZ00000452 S7501 EVQ11G07K SWITCH S7502 EVQ11G07K SWITCH S7503 EVQ11404M SWITCH S7504 EVQ11404M SWITCH S7505 EVQ11L07B SWITCH S7506 EVQPC005B SWITCH S7507 K0C111A00003 SWITCH S7511 EVQ11L07B SWITCH S7512 EVQ11G07K SWITCH S7513 EVQ11L07B SWITCH S7514 EVQ11G07K SWITCH...

This manual is also suitable for:

Nv-fj628eeNv-fj623egy

Table of Contents