Napoleon GDS3700-N Installation And Operation Instructions Manual
  1. Manuals
  2. Brands
  3. Napoleon Manuals
  4. Wall Furnaces
  5. GDS3700-N
  6. Installation and operation instructions manual

Napoleon GDS3700-N Installation And Operation Instructions Manual

Gas-fired gravity direct vent wall furnace
Hide thumbs Also See for GDS3700-N:

Advertisement

Table of Contents

INSTALLER: THESE INSTRUCTIONS MUST BE CONVEYED TO AND REMAIN WITH THE HOMEOWNER.
CERTIFIED UNDER CANADIAN AND AMERICAN NATIONAL STANDARDS, CSA 2.33 AND ANSI Z21.88 RESPECTIVELY FOR VENTED GAS-FIRED SPACE HEATING APPLIANCES.
GAS-FIRED GRA
GAS-FIRED
GAS-FIRED
GAS-FIRED
GAS-FIRED
W W W W W ARNING:
ARNING:
ARNING:
ARNING:
ARNING: If the information in these instructions is not followed exactly, a fire or
explosion may result causing property damage, personal injury or death.
Do not store or use gasoline or other flammable vapours and liquids in the vicinity of
• Do not try to light any appliance.
• Do not touch any electrical switch.
• Do not use any phone in your building.
Installation and service must be performed by a qualified installer, service
Fax: (705)722-6031 Email: ask@napoleon.on.ca
Web: www.napoleon.on.ca
GRA
GRAVITY DIRECT VENT
GRA
VITY DIRECT VENT
VITY DIRECT VENT
VITY DIRECT VENT W W W W WALL FURNACE
GRA
VITY DIRECT VENT
INST
INSTALLA
INST
INST
INST
ALLA
ALLATION AND OPERA
ALLA
ALLA
TION AND OPERATION INSTRUCTIONS FOR:
TION AND OPERA
TION AND OPERA
TION AND OPERA
NATURAL GAS MODEL
PROPANE GAS MODEL
FOR YOUR SAFETY
FOR YOUR SAFETY
FOR YOUR SAFETY
FOR YOUR SAFETY
FOR YOUR SAFETY
this or any other appliance.
WHAT T T T T T T T T TO DO IF YOU SMELL
WHA
WHA
WHA
WHA
O DO IF YOU SMELL
O DO IF YOU SMELL
O DO IF YOU SMELL GAS:
O DO IF YOU SMELL
agency or the gas supplier.
Wolf Steel Ltd., RR#1, 9 Napoleon Rd.,
Barrie, ON., Canada L4M 4Y8 (705)721-1212
ALL FURNACE
ALL FURNACE
ALL FURNACE
ALL FURNACE
TION INSTRUCTIONS FOR:
TION INSTRUCTIONS FOR:
TION INSTRUCTIONS FOR:
TION INSTRUCTIONS FOR:
GDS3700 - N
GDS3700 - N
GDS3700 - N
GDS3700 - N
GDS3700 - N
GDS3700 - P
GDS3700 - P
GDS3700 - P
GDS3700 - P
GDS3700 - P
GAS:
GAS:
GAS:
GAS:
• Immediately call your gas supplier from
a neighbour's phone. Follow the gas
supplier's instructions.
• If you cannot reach your gas supplier,
call the fire department.
R-2000
WS-415-63 / 11.24.98

Advertisement

Table of Contents
loading

Related Manuals for Napoleon GDS3700-N

Summary of Contents for Napoleon GDS3700-N

  • Page 1 INSTALLER: THESE INSTRUCTIONS MUST BE CONVEYED TO AND REMAIN WITH THE HOMEOWNER. CERTIFIED UNDER CANADIAN AND AMERICAN NATIONAL STANDARDS, CSA 2.33 AND ANSI Z21.88 RESPECTIVELY FOR VENTED GAS-FIRED SPACE HEATING APPLIANCES. GAS-FIRED GAS-FIRED GRA GAS-FIRED GRAVITY DIRECT VENT VITY DIRECT VENT VITY DIRECT VENT VITY DIRECT VENT W W W W WALL FURNACE ALL FURNACE...

  • Page 2: Table Of Contents

    PLEASE RET PLEASE RET PLEASE RETAIN THIS MANUAL FOR FUTURE REFERENCE AIN THIS MANUAL FOR FUTURE REFERENCE AIN THIS MANUAL FOR FUTURE REFERENCE AIN THIS MANUAL FOR FUTURE REFERENCE PLEASE RET PLEASE RET AIN THIS MANUAL FOR FUTURE REFERENCE T T T T T ABLE ABLE ABLE ABLE of of of of of CONTENTS...
  • Page 3 NAPOLEON gas fireplaces are manufactured under the strict Standard of the world recognized ISO9002 Quality Assurance Certificate. NAPOLEON products are designed with superior components and materials, assembled by trained craftsmen who take great pride in their work. The burner and valve assembly are leak and test-fired at a quality test station.

  • Page 4: General Instructions

    GENERAL INSTRUCTIONS GENERAL INSTRUCTIONS GENERAL INSTRUCTIONS GENERAL INSTRUCTIONS GENERAL INSTRUCTIONS ALL HORIZONT ALL HORIZONT ALL HORIZONTAL RUNS MUST HA ALL HORIZONT ALL HORIZONT AL RUNS MUST HA AL RUNS MUST HA AL RUNS MUST HAVE A 1 INCH RISE PER FOOT AL RUNS MUST HA VE A 1 INCH RISE PER FOOT VE A 1 INCH RISE PER FOOT...

  • Page 5: Venting

    W W W W W ARNING ARNING ARNING ARNING ARNING •The stove is a direct vented gas-fired room heater. Do not burn wood or other materials in this stove. •Adults and especially children should be alerted to the hazards of high surface temperatures and should stay away to avoid burns or clothing ignition.
  • Page 6 Use only Napoleon or Simpson Dura-Vent Model DV-GS venting components. Minimum and maximum vent lengths, for both horizontal and vertical installations, and air terminal locations for either system are set out in this manual and must be adhered to. For Simpson Dura-Vent, follow the installation procedure provided with the venting components. When using Napoleon venting components, use only the following vent kits: WALL TERMINAL KIT GD175 (7-1/2' of venting included), or 1/12 TO 7/12 PITCH ROOF TERMINAL KIT GD110, 8/12 TO 12/12 ROOF TERMINAL KIT GD111, FLAT ROOF TERMINAL KIT GD112 or STOVE PERISCOPE KIT GD180 (for wall penetration below grade) in conjunction...
  • Page 7 SPECIAL INST SPECIAL INST ALLA ALLA TION EXAMPLE TION EXAMPLE SPECIAL INST SPECIAL INSTALLA SPECIAL INST ALLA ALLATION EXAMPLE TION EXAMPLE TION EXAMPLE A through the roof installation requires a total 5 foot rise. FIGURE 6. The location of the fireplace dictates a horizontal run of 5 feet. What is the required vertical rise to the centre of the initial 90°...
  • Page 8 The air terminal must be located with the minimum clearances as illustrated in FIGURE 9: FIGURE 9 (G) Seven feet above public walkways unless fitted (A) Flush ( 0 inches) with outside non-combustible cor- with heat shield kit GD301. ner walls. (H) One foot below windows that open.

  • Page 9: Venting Specifics

    VENTING SPECIFICS FOR SAFE AND PROPER OPERA FOR SAFE AND PROPER OPERA TION OF THE STOVE, FOLLOW THE VENTING INSTRUCTIONS EXACTL TION OF THE STOVE, FOLLOW THE VENTING INSTRUCTIONS EXACTL TION OF THE STOVE, FOLLOW THE VENTING INSTRUCTIONS EXACTLY Y Y Y Y ..FOR SAFE AND PROPER OPERA FOR SAFE AND PROPER OPERA FOR SAFE AND PROPER OPERATION OF THE STOVE, FOLLOW THE VENTING INSTRUCTIONS EXACTL...

  • Page 10: Stove Vent Connection

    5. Apply high temperature sealant to the outer edge of the inner sleeve of the air terminal. Slip FIGURE 15 a 4" diameter coupler a minimum of 2" over the sleeve and secure using 3 screws. 6. Apply high temperature sealant to the outer edge of the of the outside sleeve of the air terminal.

  • Page 11: Finishing

    LOG PLACEMENT INSTRUCTIONS / CHARCOAL EMBERS PHAZER logs and charcoal embers, exclusive to Napoleon Fireplaces, provide a unique and realistic glowing effect that is different in every installation. Take the time to carefully position the charcoal embers for a maximum glowing effect.

  • Page 12: Maintenance

    OPERATION / MAINTENANCE OPERA OPERA OPERATING INSTRUCTIONS TING INSTRUCTIONS TING INSTRUCTIONS TING INSTRUCTIONS OPERA OPERA TING INSTRUCTIONS The on-off switch is located on the back of the unit at the top left corner. When lit for the first time, the fireplace will emit a slight odour for a few hours.

  • Page 13: Adjustments

    OPTIONAL BLOWER INSTALLATION Provision has been made on the Napoleon stove to install an optional blower on the rear wall. Because the blower is thermally activated, when turned on, it will automatically start after approximately 30 minutes from a cold start (pilot off) or 15 minutes from a warm start (pilot on) and will run for approximately 30 minutes after the stove has been turned off.
  • Page 14 REPLACEMENTS ORDERING REPLACEMENT P ORDERING REPLACEMENT P ORDERING REPLACEMENT P ORDERING REPLACEMENT P ORDERING REPLACEMENT PAR ARTS Contact your dealer or the factory for questions concerning prices and policies on replacement parts. Normally all parts can be ordered through your Napoleon dealer or distributor. When ordering replacement parts always give the following information: 1.
  • Page 15 included with GD180 included with GD175 WS-415-63 / 11.24.98...

  • Page 16: Trouble Shooting Guide

    TROUBLE SHOOTING GUIDE EFORE ATTEMPTING TO TROUBLESHOOT PURGE YOUR UNIT AND INITIALLY LIGHT THE PILOT AND THE MAIN BURNER WITH THE GLASS DOOR REMOVED SYMPTOM SYMPTOM SYMPTOM SYMPTOM SYMPTOM PROBLEM PROBLEM PROBLEM PROBLEM PROBLEM TEST SOLUTION TEST SOLUTION TEST SOLUTION TEST SOLUTION TEST SOLUTION No spark at pilot burner...
  • Page 17 SYMPTOM SYMPTOM SYMPTOM PROBLEM PROBLEM PROBLEM TEST SOLUTION TEST SOLUTION TEST SOLUTION SYMPTOM SYMPTOM PROBLEM PROBLEM TEST SOLUTION TEST SOLUTION REFER TO "MAIN BURNER GOES OUT; PILOT STAYS ON" Main burner goes out; pilot goes out. Vent re-circulating - check joint seals and installation. - loosen and tighten thermocouple Thermocouple shorting or - clean thermocouple and valve connection.
  • Page 18 NOTES: WS-415-63 / 11.24.98...

This manual is also suitable for:

Gds3700-p

Table of Contents