Sony DSLR-A500 Service Manual

Digital single lens reflex camera

Hide thumbs Also See for DSLR-A500:

Instruction manual (178 pages)

Specifications (2 pages)

Instruction manual (178 pages)

Table of Contents

Quick Links

Revision History

Ver.

Date

History

1.0

2009.08

Official Release

1.1

2009.09

Revised-1

• Revision of Schematic Diagrams

(A1 09-234)

S.M. revised:

985272512.pdf

Contents

—

Page 6-41

Published by Tokai TEC

2009I0500-1

Table of Contents

Summary of Contents for Sony DSLR-A500

Page 1: Revision History
Replace only with part number Ne les remplacer que par une specified. pièce portant le numéro spécifié. 2009I0500-1 DSLR-A500/A550_L3 © 2009.9 Sony EMCS Co. 9-852-725-12 Published by Tokai TEC...
Page 2: Exterior Parts
CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU PUBLISHED BY SONY.
Page 3: Overall Block Diagram
(9/21) DRIVE XSD_SW MEMORY CARD SWITCH SDIO_DATA0, IC3203 DATA1 - DATA7, (1/2) BS, SCLK CN4502 ANTI-SHAKE OR_SI_AS, OR_SO_AS_LCD, OR_SCK_AS_LCD MSX_DATA0 - MSXDATA7, MSX_BS, MSX_CLK CONTROLLER, MEMORY SUB CPU STICK XMS_IN_CA (10/21) PRO DUO XMS_IN_CA XMS_IN_CA XMS_IN_CA : VIDEO SIGNAL DSLR-A500/A550_L3...
Page 4 FINDER 10MHz 4MHz (9/21) 32KHZ BACKLIGHT CAM_SI_1, CAM_SO_1, CAM_SCK_1 OVERALL (3/4) (PAGE 4-3) XAS_RESET XCA_RESET IC3201 CAM_SI_1, CAM_SO_1, CAM_SCK_1 4.0V UNREG_CAM DETECT OVERALL (4/4) XAS_RESET (10/21) (PAGE 4-4) XCA_RESET IC3202 2.7V EVER_3.15V DETECT (10/21) XRESET_OR OVERALL (1/4) (PAGE 4-1) DSLR-A500/A550_L3...
Page 5 LENS_SI, XLENS_RELEASE_SW LENS LSOUT, LENS_SO, LENS_SI, RELEASE LSCK LENS_SCK LENS_SCK LENS XLENS_RELEASE_SW LENS_SI, LENS_SO, LENS_SCK CONTACTS S8702 XAF_MODE_SW CN3705 FOCUS MODE LENS_SO TH7001 BATT_TEMP 32KHZ X3101 32.768kHz 32KHZ CAM_SI_1, CAM_SO_1, CAM_SCK_1 OVERALL (2/4) XCA_RESET (PAGE 4-2) XAS_RESET CAM_SO_1 XAS_RESET DSLR-A500/A550_L3...
Page 6 BUZZER BUZZER_CA (16/21) LITHIUM (BUZZER) BATTERY BATTERY IC0002 TERMINAL DC/DC EYE-010 FLEXIBLE BOARD CONVERTER (18/21) Q3601 CN3601 D3601 DC IN EYE_SENSE_OUT EYEPIECE IC3601 BATT_UNREG SENSOR OUT APPROACH EYEPIECE ACV_UNREG SENSOR LEDA EYE_SENSE_LED BATT_XEXT SENSOR DRIVE EYE_SENSE_CTRL (15/21) EYEPIECE SENSORS DSLR-A500/A550_L3...
Page 7: Power Block Diagram
D_1.2V_2 D_1.2V_2 A_3.15V_2 G13 PVDD2a LX2a CIS_3.3V G12 PVDD2b LX2b L0008 IS_PWR_ON8 CIS_3.3V CIS_3.3V PVDD6a LX6a POWER (4/6) PVDD6b LX6b (PAGE 4-8) DD_ON2 BL_ON CAM_ON BL_ON DD_ON1 POWER (2/6) DD_ON1 DD_ON (PAGE 4-6) BL_ON VTN_-7.5V_ON POWER (4/6) (PAGE 4-8) DSLR-A500/A550_L3...
Page 8 (TK85800): A550 (EXCEPT CH) P72/BATTEMP POWER (1/6) CN3004 (1/2) (PAGE 4-5) (1/2) S9102 XPOWER_SW XPOWER_SW (POWER) INT_FLASH_TRIG PF0/SM PD3/TRIG INT_FLASH_CHARGE N15 P67/FCHG INT_FLASH_FULL POWER (3/6) F2 P75/FPM XLENS_RELEASE_SW (PAGE 4-7) SLK-006 FLEXIBLE BOARD POWER (4/6) (PAGE 4-8) CN3401 S8701 XLENS_RELEASE_SW (LENS RELEASE) DSLR-A500/A550_L3...
Page 9 EVER_3.15V EVER_3.15V EVER_3.15V CHARGE CONTROL, UNREG_DRV FLASH CONTROL INT_FLASH_CHARGE INT_FLASH_CHARGE Q6501 6 CHARGE BATT_IB_1 INT_FLASH_TRIG INT_FLASH_TRIG IGBT_C FLASH 3 IGBT_IN IGBT_OUT DRIVE POWER (1/6) POWER (2/6) (PAGE 4-5) INT_FLASH_FULL INT_FLASH_FULL (PAGE 4-6) EVER_3.15V EVER_3.15V BATT_IB_2 BATT_IB_2 (to VERTICAL GRIP) DSLR-A500/A550_L3...
Page 10 APERTURE MOTOR IS_PWR_ON6 B28 DIR1A IRIS_PI_A IRIS_PI_A ROTATION POWER (3/6) IS_PWR_ON5 DETECT (PAGE 4-7) E31 BRK2B RB3402 PH8901 POWER (5/6) IS_PWR_ON4 E30 BRK2A (PAGE 4-9) AF_PI_A IS_PWR_ON3 AF MOTOR D30 DIR2B AF_PI_C ROTATION IS_PWR_ON2 DETECT D29 DIR2A IS_PWR_ON1 G27 IC_1001_P_LIMIT DSLR-A500/A550_L3...
Page 11 (PAGE 4-8) R1713 IS_PWR_ON1 R1706 IS_PWR_ON2 R1705 IS_PWR_ON3 A550 A500 IS_PWR_ON4 R1714 IS_PWR_ON5 VDDCM_ON : A500 VREF_ON : A550 A500 R1708 IS_PWR_ON6 VDDDA_ON VDDDA_ON POWER (4/6) A500 R1779 (PAGE 4-8) IS_PWR_ON7 VDDSV_ON VDDSV_ON A500 R1704 A550 R1778 A550 R1707 IS_PWR_ON8 DSLR-A500/A550_L3...
Page 12 VDDSN (D2.5V) VDDIO (D3.15V) VDDIO (D3.15V) VDDIO (D1.8V) VDDIO (D1.8V) VDDVRH (A3.3V) VDDVRH (A3.3V) VDDVRH (A3.3V) VDDVRH (A3.3V) VDDLV (D1.8V) VDDLV (D1.8V) VDDLV (D1.8V) VDDLV (D1.8V) VDDCM_ON VDDCM_ON VREF_ON VREF_ON VDDDA_ON VDDDA_ON VDDDA_ON VDDDA_ON VDDSV_ON VDDSV_ON VDDSV_ON VDDSV_ON DSLR-A500/A550_L3 4-10E...
Page 13: Frame Schematic Diagrams
AF-119 CN6001 FLEXIBLE 3.0 inch BOARD AFP-005 FLEXIBLE COLOR LCD BH4501 MM-084 BOARD MODULE BOARD BATTERY (SIDE B) HOLDER ASM UNIT (857) SHD-001 FLEXIBLE SHUTTER BOARD IS-071 UNIT PD-390 BOARD BOARD IS-050 FLEXIBLE BOARD IS-051 FLEXIBLE BOARD DSLR-A500/A550_L3 FRAME (1/2)
Page 14 CN6001 FLEXIBLE 3.0 inch BOARD AFP-005 FLEXIBLE COLOR LCD BH4501 MM-084 BOARD MODULE BOARD BATTERY (SIDE B) HOLDER OMEGA UNIT (858) SHD-001 FLEXIBLE SHUTTER BOARD IS-060 UNIT PD-390 BOARD BOARD IS-049 FLEXIBLE BOARD IS-051 FLEXIBLE BOARD DSLR-A500/A550_L3 FRAME (2/2) 5-2E...
Page 15: Schematic Diagrams And Printed Wiring Boards
The components identified by mark or dotted line with mark are critical for safety. Replace only with part number specified. Les composants identifiés par une marque sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié. DSLR-A500/A550_L3...
Page 16 VDDSV_A4.5V VDDSC_D2.5V Note: IS-071 complete board and all mounted parts (including IC4001 (CMOS imager)) are not supplied, but they are VDDCN_D2.0V included in ASM unit (857). VDDSN_D2.5V VDDIO_D3.15V IS-071 BOARD VDDCB_A2.0V : A500 CMOS IMAGER XX MARK:NO MOUNT DSLR-A500/A550_L3 IS-071...
Page 17 Note: IS-060 complete board and all mounted parts (including IC4205 (CMOS imager)) are not supplied, but they are VDDSUB_A4.5V included in OMEGA unit (858). PVLM_A2.5V VDDCB_A2.5V VDDCM VDDSV IS-060 BOARD VDDCP/SV/CM_A4.5V VDDCP : A550 CMOS IMAGER XX MARK:NO MOUNT DSLR-A500/A550_L3 IS-060...
Page 18 IMG_TEMP1 IMG_TEMP1 LND003 VDDDA_ON VDDDA_ON LND100 VDDCM_ON : A500 VDDCM_ON : A500 pin50 LND002 LND101 pin50 VREF_ON : A550 VREF_ON : A550 LND001 VDDSV_ON VDDSV_ON LND102 pin51 pin51 IS-051 FELEXIBLE BOARD AM-IS CONNECTION (PRINTED WIRING BOARD is omitted.) DSLR-A500/A550_L3 IS-051...
Page 19 MCLK LND004 LND099 LND003 LND100 pin50 LND002 LND101 PIN50 pin51 LND102 LND001 PIN51 IS-050 FLEXIBLE BOARD IS-049 FLEXIBLE BOARD : A500 : A550 AM-IS CONNECTION AM-IS CONNECTION (PRINTED WIRING BOARD is omitted.) (PRINTED WIRING BOARD is omitted.) DSLR-A500/A550_L3 IS-050, IS-049...
Page 20 Note: VTN-003 flexible complete board and all mounted parts are not supplied, but thay are included in VM PENTA unit 857S. ESD_GND LN5024 VTN_V1A VTN_V1B VTN_V2A VTN_V2B VTN_V3 VTN_V4 VTN-003 FLEXIBLE BOARD LIVE VIEW CCD XX MARK:NO MOUNT DSLR-A500/A550_L3 VTN-003...
Page 21 Note: X2901 is not supplied, but this is L2903 10uH VTN_HVDD_RGVDD A_3.15V included in AM-019 complete board. VTN_VDVDD FB2906 VTN_IOVDD FB2905 R2953 D_1.8V_1 L2902 C2921 C2929 C2931 10uH 6.3V 6.3V AGND REG_GND REG_GND AM-019 BOARD (1/21) AFE, TIMING GENERATOR XX MARK:NO MOUNT DSLR-A500/A550_L3 AM-019 (1/21)
Page 22 DDR_DATA_7 DDR_DATA_8 AB20 DDR_DATA_9 AB21 DDR_DATA_10 DDR_DATA_11 AB22 REG_GND DDR_DATA_12 AC21 DDR_DATA_13 DDR_DATA_14 AB18 DDR_DATA_15 DDR_DATA_16 DDR_DATA_17 DDR_DATA_18 DDR_DATA_19 DDR_DATA_20 DDR_DATA_21 DDR_DATA_22 DDR_DATA_23 DDR_DATA_24 DDR_DATA_25 DDR_DATA_26 DDR_DATA_27 DDR_DATA_28 DDR_DATA_29 DDR_DATA_30 DDR_DATA_31 AM-019 BOARD (2/21) XX MARK:NO MOUNT DSLR-A500/A550_L3 AM-019 (2/21)
Page 23 AC20 C1627 VDE4 C1628 VDE4 0.1u VDE5 C1629 C1630 0.1u VDE5 C1631 C1632 C1633 0.1u C1634 0.1u C1635 TDTMODE FJTEST TRST AB11 AB23 AB16 AM-019 BOARD (3/21) AC11 AC22 NC AC16 AC23 AC18 XX MARK:NO MOUNT REG_GND DSLR-A500/A550_L3 AM-019 (3/21)
Page 24 OR_EMC_D[04] VDD_POP_DDR TH_DAT_5 OR_EMC_D[05] OR_EMC_D[06] TH_DAT_6 OR_EMC_D[07] TH_DAT_7 TH_DAT_8 OR_EMC_D[08] OR_EMC_D[09] TH_DAT_9 OR_EMC_D[10] TH_DAT_10 TH_DAT_11 OR_EMC_D[11] TH_DAT_12 OR_EMC_D[12] OR_EMC_D[13] TH_DAT_13 TH_DAT_14 OR_EMC_D[14] AM-019 BOARD (4/12) TH_DAT_15 OR_EMC_D[15] DEF, IMAGE PROCESSOR, FLASH, SDRAM REG_GND XX MARK:NO MOUNT DSLR-A500/A550_L3 AM-019 (4/21) 6-10...
Page 25 AVSS_AUDIO_ADC0 CL1104 SENS_CLK_M PG_SUBL_CLKN A500 A550 RB1101 R1101 IS_SO SENSSCK IS_SCK SENSSO VDDE_SENS XCS_IS C1106 SENSXCS 0.1u VDDE_SENS CLK_SENS_IN PG_VD SENS_VD PG_VD PG_HD SENS_HD PG_HD R1103 100k REG_GND AM-019 BOARD (5/21) IMAGE PROCESSOR XX MARK:NO MOUNT DSLR-A500/A550_L3 AM-019 (5/21) 6-11...
Page 26 AJ15 R1270 C1208 R1235 A550 AL16 PLL0_VCC L1201 4.7uH AK16 PLL0_GND R1237 AL17 PLL1_VCC AK17 PLL1_GND R1239 AL18 PLL2_VCC AK18 PLL2_GND R1241 AL19 PLL3_VCC AK19 R1284 PLL3_GND REG_GND AM-019 BOARD (6/21) IMAGE PROCESSOR XX MARK:NO MOUNT DSLR-A500/A550_L3 AM-019 (6/21) 6-12...
Page 27 D1(-)(D3) D1(+)(D2) REG_GND REGGND D2(-)(D1) D2(+)(D0) REGGND REGGND LCD_CLK REGGND HSYNC VSYNC REGGND LCD_DG[0-7] D_1.8V_1 D_1.8V D_3.15V D_3.15V XRESET_OR XRESET_OR LCD_DR/ETM[0-7] REGGND OR_SCK_BB OR_SCK_BB OR_SO_BB OR_SO_BB XOR_CS_LCD XOR_CS_LCD REGGND AM-019 BOARD (7/21) SERIALIZER XX MARK:NO MOUNT DSLR-A500/A550_L3 AM-019 (7/21) 6-13...
Page 28 C4 D4 D3 C2 E1 F1 D2 D5 E3 F2 F3 F5 IC1301 R1304 VOUT 820 +-0.5% R1306 R1307 68 +-0.5% C1301 C1305 0.1u XHDMI_CABLE_IN CL1301 HDMI_DE CL1302 HDMI_HSYNC Q1301 DTC144EMFS6T2L HDMI_VSYNC CL1303 HDMI DETECT HDMI_CLK C1310 0.1u REG_GND AM-019 BOARD (8/21) HDMI OUT XX MARK:NO MOUNT DSLR-A500/A550_L3 AM-019 (8/21) 6-14...
Page 29 3.1V REG AS_7.0V R3020 D3002 ON/OFF R3043 1SS387-TPL3 CAM_ON +-0.5% BATT_AD_IN 2 GND VOUT CAM_VREF VOUT C3016 C3031 C3032 C3038 R3021 0.1u C3035 C3036 4.7u 4.7u AM-019 BOARD (9/21) +-0.5% MAIN CPU PGND XX MARK:NO MOUNT DSLR-A500/A550_L3 AM-019 (9/21) 6-15...
Page 30 X3201 4MHz REG_GND UNREG_DET R3205 UNREG_CAM R3210 IC3201 IC3202 BD4840FVE-TR BD4827FVE-TR XCA_RESET 2.7V DETECT 4.0V DETECT VOUT VOUT C3202 C3205 D3201 MA2SD320G8S0 C3206 R3211 XAS_RESET XAS_RESET AM-019 BOARD (10/21) ANTI-SHAKE CONTROL, SUB CPU XX MARK:NO MOUNT DSLR-A500/A550_L3 AM-019 (10/21) 6-16...
Page 31 R3322 PINALN +-5% BR_Y1 BR_Y1 PINALN BR_Y2 CL3330 BR_Y2 AVSS HOL-006 FLEXIBLE LN8801-LN8816 (Page 6-35) 10 11 12 13 14 15 16 17 C3325 REG_GND REG_GND PGND PGND AM-019 BOARD (11/21) ANTI-SHAKE DRIVE XX MARK:NO MOUNT DSLR-A500/A550_L3 AM-019 (11/21) 6-17...
Page 32 A1 C3 C2 D2 C1 D3 D1 E2 E3 E1 E4 F1 F2 G1 G2 H1 XCS_OSD CAM_SCK_2 CAM_SO_2 C3803 R3810 XAS_RESET R3809 XCA_RESET REG_GND C3801 0.1u R3808 100k R3804 EVER_3.15V OVF_HDMI_5V AM-019 BOARD (12/21) SEGMENT DRIVER XX MARK:NO MOUNT DSLR-A500/A550_L3 AM-019 (12/21) 6-18...
Page 33 Q3101 LENS_SO LVDD1 XCS_LENS_MOUNT 2SJ0674G0LS0 XCS_LENS_MOUNT B+ SWITCH LENS_SI 32KHZ LENS_SI LENS_SCK R3111 R3107 R3117 BKUPVDDOUT +-0.5% EXT_FLASH_F3 EXT_FLASH_F2 R3116 X3101 Q3102 32.768kHz UP04211G08S0 BUFFER REG_GND C3105 C3106 AM-019 BOARD (13/21) I/O CONTROL XX MARK:NO MOUNT DSLR-A500/A550_L3 AM-019 (13/21) 6-19...
Page 34 CHG_M_1 AF_M- CHG_M_2 D3405 AF_M- R3407 CAM_6.0V D3403 IC3403 REG_GND REG_GND XC6201P552PR 5.5V REG SH_2C SH_COM SH_COM C3408 C3409 SH_1C Q3401 UNREG_DRV SSM6N15FU(TE85R) SHUTTER DRIVE 1ST_CURTAIN_MG 2ND_CURTAIN_MG PGND AM-019 BOARD (14/21) MOTOR DRIVE XX MARK:NO MOUNT DSLR-A500/A550_L3 AM-019 (14/21) 6-20...
Page 35 LN3601-LN3606 (Page 6-38) EYE_SENSE_LED LEDON R3603 LEDA EYE_SENSE_CTRL LEDA REG_GND PD_GND DOUT PFILT PD_GND PD_GND IC3601 CN3601 QPDS-M906 R3604 C3604 EYEPIECE C3605 SENSOR 0.001u DRIVE 6.3V REG_GND AM-019 BOARD (15/21) EYEPIECE SENSOR DRIVE XX MARK:NO MOUNT DSLR-A500/A550_L3 AM-019 (15/21) 6-21...
Page 36 BATTERY DETECTOR BATTERY DETECTOR AVREF P14/RxD6 AVREF P14/RxD6 BATT_IB_1 BATT_IB_2 BATT_IB_1 TxRx P20/ANI0 BATT_IB_2 TxRx P20/ANI0 CL3501 P30/INTP1 P30/INTP1 C3503 C3507 C3501 C3505 XAS_RESET XAS_RESET CAM_SI_2 CS_RTC RB3501 REG_GND AM-019 BOARD (16/21) BATTERY DETECTOR XX MARK:NO MOUNT DSLR-A500/A550_L3 AM-019 (16/21) 6-22...
Page 37 DC IN MA2SD320G8S0 PGND Q0503 LSK3541FS8T2L Note: J902 is not included in AM-019 complete board. R0508 REG_GND R0501 D0506 MA2SD320G8S0 XDC_JACK_SENSE REG_GND R0504 PGND LF0501 C0502 C0503 R0505 AM-019 BOARD (17/21) DC IN XX MARK:NO MOUNT DSLR-A500/A550_L3 AM-019 (17/21) 6-23...
Page 38 C0035 R0054 VTN_-7.5V D0009 015AZ18-X(L3SONY,F IC0003 TK72200CS2GOB-C BL_ON -7.5V REG VCONT VOUT BL_K Q0003 2SC4081T106QRS LCD BACKLIGHT DRIVE C0056 C0060 C0057 0.01u R0039 +-0.5% R0102 C0073 0.022u AM-019 BOARD (18/21) R0103 DC/DC CONVERTER XX MARK:NO MOUNT DSLR-A500/A550_L3 AM-019 (18/21) 6-24...
Page 39 Q1713, Q1733 R1747 B+ SWITCH R1725 R1738 R1767 100k 100k A550 Q1713 R1713 C1708 LSK3541FS8T2L 0.0047u : A500 R1714 0.01u : A550 IS_PWR_ON4 A500 Q1733 AM-019 BOARD (19/21) LSK3541FS8T2L Q1704 UNR32A3G0LS0 CONNECTOR REG_GND XX MARK:NO MOUNT PG_1.8V_SLVDS DSLR-A500/A550_L3 AM-019 (19/21) 6-25...
Page 40 MA2SD320G8S0 SD_D[2] SD_3.15V_ON R1406 470 SD_D[3] SD_D[0] SD_D[1] SD_CMD SD_CMD SD_CLK SD_CLK SD_WP SD_WP XSD_IN_CA XSD_IN_CA XSD_IN_OR D1402 MA2SD320G8S0 SD_D[2] SD_D[3] SD_D[0] SD_D[1] S1401 (MEMORY CARD SWITCH) XSD_SW REG_GND AM-019 BOARD (20/21) CONNECTOR XX MARK:NO MOUNT DSLR-A500/A550_L3 AM-019 (20/21) 6-26...
Page 41 MOD4 AFCCD_VOUT_1 VOUT REG_GND VCC1 CL3713 AFCCD_CBG AF-119 CL3709 FLEXIBLE AFCCD_RST LN7801-LN7814 CL3710 AFCCD_IST (Page 6-36) CL3711 AFCCD_CLK CL3712 AFCCD_ADT_1 CL3705 AFCCD_MOD_1 MOD1 CL3706 AFCCD_MOD_2 MOD2 CL3707 AFCCD_MOD_3 MOD3 AM-019 BOARD (21/21) CONNECTOR XX MARK:NO MOUNT DSLR-A500/A550_L3 AM-019 (21/21) 6-27...
Page 42 AMB_LIGHT_OUT LND059 OR_SO_BB LND031 LND060 CAM_6.0V N.C. pin32 LND032 LND061 REGGND XOR_CS_LCD LND033 LND062 pin33 CAM_3.15V REGGND LND063 AMB_LIGHT_OUT LND064 CAM_6.0V LND065 pin38 REGGND LND066 pin39 CAM_3.15V LCD-014 FLEXIBLE BOARD AM-PD CONNECTION (PRINTED WIRING BOARD is omitted.) DSLR-A500/A550_L3 LCD-014 6-28...
Page 43 2.2u C6026 4.7u LCD902 3.0inch LED- COLOR R6038 XX LED+ MODULE C6033 4.7u C6034 4.7u CL6010 R6039 DCLK CL6007 HSYNC CL6008 VSYNC CL6009 SLCK RESB R6040 C6041 0.01u VCOMTFT VCOMCF VCOMCF CN6004 PD-390 BOARD XX MARK:NO MOUNT DSLR-A500/A550_L3 PD-390 6-29...
Page 44 XSD_IN, SD_CLK, SD_CMD, SD_D[0-3], SD_WP REG_GND REG_GND C4504 0.01u REG_GND REG_GND BT901 (LITHIUM BATTERY) BZ4501 (BUZZER) BH4501 (BATTERY HOLDER) Note: BT901 (lithium battery) is not included in MM-084 complete board. MM-084 BOARD (1/2) MS CONNECTOR XX MARK:NO MOUNT DSLR-A500/A550_L3 MM-084 (1/2) 6-30...
Page 45: Flexible Board
Note: LCD903, IFL-004 flexible complete board and mounted part are not supplied, but they are included in VM PENTA unit 857S. MM-084 BOARD (2/2) IFL-004 FLEXIBLE BOARD SD CARD CONNECTOR FINDER XX MARK:NO MOUNT DSLR-A500/A550_L3 MM-084 (2/2), SHD-001, IFL-004 6-31...
Page 46 GINB pin1 LN7001 REG_GND IC7001 RS-770 C7005 R7001 D7001 REMOTE SML-D12V8WT86SN SENSOR (SELF-TIMER) C7002 C7004 SE7001 YAW SENSOR SE7002 32.2kHz 30.8kHz PITCH SENSOR Vref Vref C7001 C7003 GYJ-001 FLEXIBLE BOARD 0.1u 0.1u REMOTE/GYRO SENSOR XX MARK:NO MOUNT DSLR-A500/A550_L3 GYJ-001 6-32...
Page 47: Lens Contacts
LN7913 LN7933 pin13 pin14 pin14 LN7914 LN7934 Note: LCD904 and SI-066 flexible board are not supplied, but they are included in VM OSD UNT (service). BL-034 FLEXIBLE BOARD SI-066 FLEXIBLE BOARD LENS CONTACTS SI LCD DSLR-A500/A550_L3 BL-034, SIL-001, SI-066 6-33...
Page 48 GRPON LMCK PHOTOMETRY KSPC RWLM ASPC MODE VREF LMSIN C8004 4.7u 6.3V Note: AE-036 flexible complete board and all mounted parts are not supplied, but they are included in VM PENTA unit 857S. AE-036 FLEXIBLE BOARD PHOTOMETRY DSLR-A500/A550_L3 AE-036 6-34...
Page 49 OUT3N OUT2P +-5% IN3P IN2P OUT3P IN4N OUT4N OUT4P IN4P Note: HOL-006 flexible complete board and all mounted parts are not supplied, but they are included in slider unit (857 service). HOL-006 FLEXIBLE BOARD HALL ELEMENT, ACTUATOR DSLR-A500/A550_L3 HOL-006 6-35...
Page 50 AF CCD (Page 6-27) LN7809 LN7810 LN7811 LN7812 MOD1 LN7813 MOD2 LN7814 MOD3 pin14 Note: AF-119 flexible complete board and IC7801 are not supplied, but they are included in ALX-8520 (AF module). AF-119 FLEXIBLE BOARD AF CCD DSLR-A500/A550_L3 AF-119 6-36...
Page 51 AP aperture unit. AP-033 FLEXIBLE BOARD SLK-006 FLEXIBLE BOARD APERTURE MOTOR AP-033 flexible board is replaced as AP aperture unit, CHARGE MOTOR so that PRINTED WIRING BOARD is omitted. DSLR-A500/A550_L3 AFP-005, AP-033, SLK-006 6-37...
Page 52 LN7309 LN7303 S2_REMOTE CN3706 (Page 6-27) S1_REMOTE LN7308 LN7302 S1_REMOTE LN7307 LN7301 REG_GND pin1 STG-001 FLEXIBLE BOARD RM-098 FLEXIBLE BOARD VERTCIAL GRIP TERMINAL REMOTE JACK (PRINTED WIRING BOARD is omitted.) (PRINTED WIRING BOARD is omitted.) DSLR-A500/A550_L3 EYE-010, RM-098, STG-001 6-38...
Page 53: Flash Drive
(For Discharge) UNREG_OUT_FL DETECT EVER_3.15V Q6501 INT_FLASH_CHARGE TIG052TS-TL-E IGBT_IN R6511 FLASH DRIVE INT_FLASH_TRIG IGBT_OUT REG_GND INT_FLASH_FULL FULL R6507 C6505 R6512 C6502 C6508 0.1u R6510 REG_GND PGND PGND R6501 REG_GND PGND ST-218 BOARD FLASH DRIVE XX MARK:NO MOUNT DSLR-A500/A550_L3 ST-218 6-39...
Page 54 CONTROL SWITCH BLOCK (RS85700) FLASH UNIT (FL85700) FLASH UNIT (FL85700) is replaced as block, CONTROL SWITCH BLOCK (RS85700) is replaced as block, so that PRINTED WIRING BOARD is omitted. so that PRINTED WIRING BOARD is omited. DSLR-A500/A550_L3 FL85700, RS85700 6-40...
Page 55 FB9101 REG_GND FB9103 REG_GND FB9104 R9103 EXT_FLASH_F2 D9101 EXT_FLASH_F3 EMZ6.8ET2R LN9142 ESD_GND TK85700: A500/A550(CH) TK85800: A550 (EXCEPT CH) CONTROL SWITCH BLOCK (TK85700/TK85800) CONTROL SWITCH BLOCK (TK85700/TK85800) is replaced as block, so that PRINTED WIRING BOARD is omitted. DSLR-A500/A550_L3 TK85700/TK85800 6-41...
Page 56 C4009 R4027 R4026 R4029 C4074 C4073 CL4002 C4056 Q4005 C4012 R4024 R4023 1-880-853- Note: IS-071 complete board and all mounted parts 1-880-853- (including IC4001 (CMOS imager)) are not supplied, but they are included in ASM unit (857). DSLR-A500/A550_L3 IS-071 6-42...
Page 57 C4233 C4247 C4295 C4294 CL4203 R4222 C4259 C4260 CL4204 R4217 R4219 C4228 1-880-449- Note: IS-060 complete board and all mounted parts (including IC4205 (CMOS imager)) 1-880-449- are not supplied, but they are included in OMEGA unit (858). DSLR-A500/A550_L3 IS-060 6-43...
Page 58 : Uses unleaded solder. VTN-003 FLEXIBLE BOARD R5007 C5004 R5001 C5005 LN5024 R5002 C5002 R5008 Note: VTN-003 flexible complete board and all mounted parts are not supplied, but they are included in VM PENTA unit 857S. 1-880-359- DSLR-A500/A550_L3 VTN-003 6-44...
Page 59 CN3301 CN3403 CN1801 D3106 D3115 C0054 1-878-802- Note: CN1801 and CN1802 have the same mount location. When you replace, since either CN1801 or CN1802 are used, please refer to schematic diagram and electrical parts list. DSLR-A500/A550_L3 AM-019 (SIDE A) 6-45...
Page 60 CL3014 CL3082 C0081 C3002 C0055 CL3065 CL3081 CL1203 CL1213 R3009 C3041 D0011 R1403 D3012 R3065 D1403 R0035 C0045 R0042 C0043 C0066 CL1011 Q0006 R1009 D0009 C0080 CL1012 Q0005 R0076 D0008 D0007 R0055 FL1002 R0043 1-878-802- DSLR-A500/A550_L3 AM-019 (SIDE B) 6-46...
Page 61 Note: SI-066 flexible board is not supplied, LN7901 but this is included in VM OSD UNT (service). LN7902 S H D 0 0 1 LN7903 LN7904 LN7905 LN7906 LN7907 LN7908 LN7909 LN7910 LN7911 LN7912 LN7913 LN7914 1-880-356- DSLR-A500/A550_L3 PD-390, SHD-001, IFL-004, SI-066 6-47...
Page 62 MM-084 BOARD (SIDE A) LITHIUM SECONDARY Note: BT901 (lithium battery) is not included in MM-084 complete board. MM-084 BOARD (SIDE B) BZ4501 (BUZZER) C4501 R4510 CL4502 MEMORY C4603 STICK PRO DUO R4602 CL4501 RB4501 RB4502 CL4503 1-880-437- 1-880-437- DSLR-A500/A550_L3 MM-084 6-48...
Page 63 LN7025 LN7024 LN7023 CN7003 LN7022 LN7021 LN7020 CN7002 LN7019 LN7018 LN7017 LN7016 LN7015 LN7014 LN7013 LN7012 LN7011 LN7010 LN7009 LN7008 LN7007 LN7006 LN7005 LN7004 LN7003 LN7002 LN7001 R7001 IC7001 D7001 (SELF-TIMER) C7004 C7005 SE7001 (YAW) 1-880-445- DSLR-A500/A550_L3 GYJ-001, EYE-010 6-49...
Page 64 BL-034 (1 layer) : Uses unleaded solder. BL-034 FLEXIBLE BOARD B L 0 3 4 Note: BL-034 flexible board is not supplied, but this is included in MB BL contact holder unit 857. (LENS CONTACTS) 1-880-355- DSLR-A500/A550_L3 BL-034 6-50...
Page 65 VM PENTA unit 857S. LN8010 LN8009 LN8008 LN8007 LN8006 LN8005 LN8004 LN8003 LN8002 LN8001 1-880-354- AF-119 FLEXIBLE BOARD Note: AF-119 flexible complete board and IC7801 are not supplied, but they are included in ALX-8520 (AF module). IC7801 1-877-471- 11 DSLR-A500/A550_L3 AE-036, AF-119 6-51...
Page 66 HOL-006 FLEXIBLE BOARD >PI< HOL-006 LN8818 LN8817 ACTUATOR (PITCH) ACTUATOR (YAW) LN8819 LN8820 Note: HOL-006 flexible complete board and all mounted parts are not supplied, but they are included in slider unit (857 service). RB8802 IC8801 RB8801 1-877-508- 11 DSLR-A500/A550_L3 HOL-006 6-52...
Page 67 MB charge base plate B assy. LN8715 LN8714 LN8713 1 - 8 8 0 S L K - 0 0 6 LN8712 LN8711 - 3 5 8 LN8710 LN8709 LN8708 LN8707 LN8706 LN8705 LN8704 LN8703 LN8702 LN8701 1-880-358- CHARGE CAM DETECT DSLR-A500/A550_L3 SLK-006 6-53...
Page 68 : Uses unleaded solder. ST-218 BOARD (SIDE A) ST-218 BOARD (SIDE B) CN6501 R6511 R6512 C6507 IC6501 C6501 RB6501 C6506 T6501 D6503 D6502 LN6504 LN6503 Note: C901 is not included in C901 ST-218 complete board. CHARGING CAPACITOR 1-880-438- 1-880-438- DSLR-A500/A550_L3 ST-218 6-54E...
Page 69: Electrical Parts List
1-165-989-11 CERAMIC CHIP 10uF 6.3V C0064 1-165-908-11 CERAMIC CHIP C1216 1-165-989-11 CERAMIC CHIP 10uF 6.3V (A500) C1217 1-165-989-11 CERAMIC CHIP 10uF 6.3V C1218 1-165-989-11 CERAMIC CHIP 10uF 6.3V C0066 1-125-891-11 CERAMIC CHIP 0.47uF C1219 1-165-989-11 CERAMIC CHIP 10uF 6.3V DSLR-A500/A550_L3...
Page 70 1-125-777-11 CERAMIC CHIP 0.1uF (A500) C3023 1-100-567-81 CERAMIC CHIP 0.01uF C3502 1-125-777-11 CERAMIC CHIP 0.1uF D1301 6-500-854-01 DIODE 1SS413 (TPL3) C3024 1-100-567-81 CERAMIC CHIP 0.01uF * D1303 6-502-150-01 DIODE MA2SD320G8S0 C3503 1-165-908-11 CERAMIC CHIP * D1304 6-502-150-01 DIODE MA2SD320G8S0 DSLR-A500/A550_L3...
Page 71 MCH6305-TL-E-S R0020 1-220-802-11 METAL CHIP 1/16W * D3701 6-502-150-01 DIODE MA2SD320G8S0 * IC3202 6-714-057-01 IC BD4827FVE-TR * D3703 6-502-135-01 DIODE CMG03 (T2L, SONY, Q) * IC3203 6-714-408-01 IC MB91F233LALGV-G-12-ERE1 Q0013 6-551-346-01 TRANSISTOR LSK3541FS8T2L R0021 1-208-927-11 METAL CHIP 0.5% 1/16W * D3704...
Page 72 METAL CHIP 1/16W (A500) R3322 1-218-608-11 METAL CHIP R1406 1-218-949-11 METAL CHIP 1/16W R1765 1-218-941-81 METAL CHIP 1/16W R3602 1-218-973-11 METAL CHIP 1/16W * D3601 1-487-295-11 SENSOR, APPROACH (EYEPIECE SENSORS) R1416 1-218-945-11 METAL CHIP 1/16W R3603 1-216-150-91 METAL CHIP 1/8W DSLR-A500/A550_L3...
Page 73 SENSOR, ANGULAR VELOCITY (30.8kHz) (PITCH) C6036 1-112-021-91 CERAMIC CHIP 2.2uF RB4501 1-234-945-21 RES, NETWORK 100 (1005X4) (A500) IC7401 6-600-447-01 IC TPS853 (SONY, F) < THERMISTOR > RB4502 1-234-945-21 RES, NETWORK 100 (1005X4) RB4601 1-234-945-21 RES, NETWORK 100 (1005X4) C6037 1-165-884-11 CERAMIC CHIP 2.2uF...
Page 74 Ref. No. Part No. Description Ref. No. Part No. Description R6513 1-218-990-81 SHORT CHIP < COMPOSITION CIRCUIT BLOCK > RB6501 1-234-375-21 RES, NETWORK 1K (1005X4) < TRANSFORMER > * T6501 1-445-335-21 TRANSFORMER, D.C.-D.C.CONVERTER 1-880-444-11 STG-001 FLEXIBLE BOARD ********************* DSLR-A500/A550_L3 7-6E...

This manual is also suitable for:

Dslr-a550

Sony DSLR-A500 Service Manual

Quick Links

Revision History

Related Manuals for Sony DSLR-A500

Summary of Contents for Sony DSLR-A500

This manual is also suitable for:

Table of Contents