Sony KP-41PX1 Service Manual
  1. Manuals
  2. Brands
  3. Sony Manuals
  4. Projection TV
  5. KP-41PX1
  6. Service manual
Sony KP-41PX1 Service Manual

Sony KP-41PX1 Service Manual

Hide thumbs Also See for KP-41PX1:
Table of Contents

Advertisement

Quick Links

See also: Instruction Manual
SERVICE MANUAL
MODEL
COMMANDER DEST.
KP-41PX1
RM-892
KP-41PX1K
RM-892
KP-41PX1R
RM-862
CHASSIS NO.
AEP
SCC-P66A-A
OIRT
SCC-P68A-A
Russian SCC-P67A-A
1
2
3
6
4
5
9
7
8
0
OK
RM-892
RE-2A
CHASSIS
PROJECTION TV

Advertisement

Table of Contents
loading

Related Manuals for Sony KP-41PX1

Summary of Contents for Sony KP-41PX1

  • Page 1 SERVICE MANUAL RE-2A CHASSIS MODEL COMMANDER DEST. CHASSIS NO. KP-41PX1 RM-892 SCC-P66A-A KP-41PX1K RM-892 OIRT SCC-P68A-A KP-41PX1R RM-862 Russian SCC-P67A-A RM-892 PROJECTION TV...
  • Page 2 VIEWS AND IN THE PARTS LIST ARE CRITICAL TO REMOVING THE ANODE. SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS AP- PEAR AS SHOWN IN THIS MANUAL OR IN SUPPLE- MENTS PUBLISHED BY SONY. – 2 –...

  • Page 3: Table Of Contents

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 TABLE OF CONTENTS Section Title Page Section Title Page 1. SELF DIAGNOSIS FUNCTION 7. DIAGRAMS ...... 7-1. Block Diagrams ..........2. GENERAL ..............7-2. Frame Schematic Diagram ......... 7-3. Circuit Boards Location ........3. DISASSEMBLY 7-4.

  • Page 4: Self Diagnosis Function

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 SECTION 1 SELF DIAGNOSIS FUNCTION Diagnostic Errors The errors indicated below can be read using an Error Reader Display (Part Number S-188-900-10) connected to the service connector. Once an error has been detected it will then be displayed on the two digit error reader.
  • Page 5 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 Protection Error (Error 2): Once every main loop (approximately 200ms OSD mode, 50ms text or menu mode), the micro checks the protection pin (pin 66). If the protection pin is high 6 successive times, a protection error is diagnosed. The protection pin is not checked during the first 3-4 seconds after AC on.
  • Page 6 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 General I C Device Run-time Errors (Errors 18-22): 18 - No acknowledge from Jungle when attempting to initialize 19 - No acknowledge from Jungle when attempting to read registers 20 - AV Switch cannot complete reset during initialization...
  • Page 7 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 Error Display Mode Error Display Mode is entered by the following sequence of commands: Standby → Information → Digit 5 → Volume Down → TV This mode will display a special menu, which will list all possible errors and the number of occurrences of each error (0 – 255, as stored in the NVM).
  • Page 8 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 TT command table TT Mode is available by pressing the test key twice. It is exited by pressing 0 twice, or by pressing the Test key, or by pressing the TV key or by switching the set into standby.
  • Page 9 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 Code Function Code Function No Function (41PX1/41PX1K) Set Screen Size (41PX1/41PX1K) Auto Picture OFF (41PX1R) MSP BG Filter Disabled (41PX1R) No Function (41PX1/41PX1K) Wide Setup Auto Cut Off Enable (41PX1R) Velocity Modulation ON Set Colour to Minimum and Picture to Maximum...

  • Page 10: General

    VIDEO VIDEO PROGR MENU VTR 1 2 3 4 DVD RM 892 VIDEO PROGR MENU RM 892...
  • Page 11 LANGUAGE English Deutsch LANGUAGE Fran ais English Deutsch Espa ol Fran ais Espa ol Suomi Suomi Nederlands Portugu s Nederlands Suenska Dansk Portugu s Norsk Italiano Suenska Česki Magyar Eλλnvιkά Dansk Select Language: Norsk Confirm: OK Italiano Česki Magyar Eλλnvιkά Select Language: Confirm: OK LANGUAGE...
  • Page 12 PROG SYS CHAN LABEL C 28 BBC-W C 40 MV-CH C 41 TVE-1 VIDEO C 31 TVE-2 C 34 ANT-3 C 27 TELE 5 VIDEO C 47 C PLUS C 44 - - - - - C 23 - - - - - C 35 CNN - Select PROG:...
  • Page 13 MENU PICTURE CONTROL PICTURE CONTROL Picture Mode Personal Picture Mode Personal Contrast Reset Contrast Reset Format Format SOUND CONTROL SOUND CONTROL Sound Mode Personal Sound Mode Personal Balance Reset Balance Reset Dolby Virtual Dolby Virtual Dual Sound Mono Volume Offset Dual Sound Mono Volume Offset...
  • Page 14 PICTURE CONTROL Picture Mode Personal Contrast Reset Format PRESET Auto Programme Manual Programme Preset Further Programme Preset AV Label Preset Programme Sorting Parental Lock Language Convergence PRESET Please confirm that Auto Programme antenna is connected Manual Programme Preset Further Programme Preset AV Label Preset Confirm: OK Programme Sorting...
  • Page 15 PICTURE CONTROL PICTURE CONTROL VIDEO VIDEO Picture Mode Personal Picture Mode Personal Contrast Contrast Reset Reset Format Format PRESET PRESET Auto Programme Auto Programme Manual Programme Preset Manual Programme Preset Further Programme Preset Further Programme Preset AV Label Preset AV Label Preset Programme Sorting Programme Sorting Parental Lock...
  • Page 16 PICTURE CONTROL PICTURE CONTROL VIDEO Picture Mode Personal VIDEO Picture Mode Personal Contrast Contrast Reset Reset Format Format PRESET PRESET Auto Programme Manual Programme Preset Auto Programme Further Programme Preset Manual Programme Preset AV Label Preset Further Programme Preset Programme Sorting AV Label Preset Parental Lock Programme Sorting...
  • Page 17 PICTURE CONTROL PICTURE CONTROL VIDEO VIDEO Picture Mode Personal Picture Mode Personal Contrast Contrast Reset Reset Format Format PICTURE CONTROL PICTURE CONTROL Picture Mode Personal Picture Mode Personal Contrast Reset Contrast Reset Format Format PICTURE MODE Picture Mode Personal Brightness Colour Sharpness PROGR...
  • Page 18 PICTURE CONTROL VIDEO VIDEO Picture Mode Personal Contrast Reset Format SOUND CONTROL Sound Mode Personal Balance Reset Dolby Virtual Dual Sound Mono Volume Offset Volume Dual Sound Mono Speaker Main SOUND MODE Mode Personal Treble Bass PROGR PROGR MENU MENU RM 892 RM 892 Personal...
  • Page 19 PICTURE CONTROL VIDEO VIDEO Picture Mode Personal Contrast Reset Format TIMER Index TELETEXT TELETEXT Programme Index Programme Sleep Timer News News Sport Weather Sport Weather TIMER Sleep Timer 1:00 PROGR PROGR MENU MENU RM 892 RM 892 TELETEXT TELETEXT Index Programme News Sport...
  • Page 20 VIDEO PROGR MENU RM 892...
  • Page 21 PICTURE CONTROL VIDEO Picture Mode Personal Contrast Reset Format VIDEO CONNECTION TV Screen [TV - - - - - - -] Output [AV1 - - - - - - -] PROGR MENU RM 892 VIDEO VTR 1 2 3 4 DVD...
  • Page 22 PICTURE CONTROL VIDEO Picture Mode Personal Contrast Reset Format PRESET Auto Programme Manual Programme Preset Further Programme Preset AV Label Preset Programme Sorting Parental Lock Language Convergence PRESET Auto Programme Manual Programme Preset Further Programme Preset AV Label Preset Programme Sorting Parental Lock Language Convergence...

  • Page 24: Disassembly

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 SECTION 3 DISASSEMBLY 3-1. REAR BOARD REMOVAL 3-3. SERVICE POSITION 1 Ten screws (+BVTP4 × 16) Chassis assembly 2 Rear board 1 Five screws (+BVTP4 × 16) 3-2. CHASSIS ASSEMBLY REMOVAL 1 Light shield 2 Two screws...

  • Page 25: Terminal Board Removal

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 3-4. TERMINAL BOARD REMOVAL 3 Terminal board (euro) 1 Four screws (+BVTP4 × 16) 2 Two screws (+BVTP3 × 12) 1 Two screws (+BVTP4 × 16) 3-5. U (UE), A (AE) AND D BOARDS REMOVAL 2 Bracket (A)

  • Page 26: E Board Removal

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 3-6. E BOARD REMOVAL 1 Five screws (+BVTP3 × 12) 2 E board 3-7. G BOARD REMOVAL 1 Four claws 2 G board – 26 –...

  • Page 27: Speaker Grille And Resistor Assembly (Focus Pack) Removal

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 3-8. SPEAKER GRILLE AND RESISTOR ASSEMBLY (FOCUS PACK) REMOVAL 5 Resistor assembly (Focus Pack) 4 Screw (+BVTP4 × 16) 1 Four screws (Hexagon head) 2 Three strike 3 Speaker grille assembly 3-9. H1 AND H2 BOARDS REMOVAL...

  • Page 28: Mirror Cover And Beznet Assembly Removal

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 3-10. MIRROR COVER AND BEZNET ASSEMBLY REMOVAL 1 Five screws (+BVTP4 × 16) 1 Six screws (+BVTP4 × 16) 2 Mirror cover 4 Beznet assembly 3 Four screws (Hexagon head) 3-11. HIGH-VOLTAGE 3-12. PICTURE TUBE REMOVAL...

  • Page 29: Set-Up Adjustments

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 SECTION 4 SET-UP ADJUSTMENTS 4-1. SCREEN VOLTAGE ADJUSTMENT 4-3. SCREEN (G2) ADJUSTMENT (ROUGH ALIGNMENT) 1. Connect JIG (A) to 200 V and GND. 1. Receive the Monoscope signal. 2. Select VIDEO1 mode without signals. 3. Connect JIG to the TP701(KR), TP731(KG) or TP761(KB) 2.

  • Page 30: 2-Pole Magnet Adjustment (Green And Red)

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 4-5. 2-POLE MAGNET ADJUSTMENT 4-7. GREEN, RED AND BLUE FOCUS (GREEN AND RED) ADJUSTMENT 4-7-1. Green, Red and Blue Lens Focus Adjustment 1. Receive the Dot signal and set PICTURE to 80%, BRIGHT- NESS to 50%.

  • Page 31: Safety Related Adjustment

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 SECTION 5 SAFETY RELATED ADJUSTMENT When replacing the following components marked with ] on E BOARD the schematic diagram, always check hold-down voltage and if – CONDUCTOR SIDE – necessary re-adjust. CN810 CN505 Part Replaced ([)

  • Page 32: Electrical Adjustments

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 SECTION 6 ELECTRICAL ADJUSTMENTS 3. Press “MENU” on the commander to obtain the following 6-1. HOW TO ENTER THE SERVICE MODE menu on the screen. (With some models, display items may be different from 6-1-1. Adjustment Method with Commander...
  • Page 33 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 Geometry ( : No need to adjust) GEOMETRY ADJUSTMENT MSP ADJUSTMENT CONCCT FAWCTIST 16:9 V Size 0 - 63 AGC On / Off ON/OFF V Position 0 - 63 Constant Gain CDB 0 - 20 S Correction...

  • Page 34: Service List (Convergence)

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 Current TV Status Convergence Depends on the signals TV STATUS RE-2A(TT09) PAL, SECAM : 50 NTSC : 60 Mode Item No. Text System C Text-2 Dolby Enabled DSP Present Text Language Set East/Greek Menu Language Set...
  • Page 35 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 Initial Data Item Adjustment Data Range Mode Name / Description Device Number Item 16 : 9 4 : 3 CENT –127 ~ +127 GREEN V CENTER CXP86213 SKEW –127 ~ +127 –17 –17 GREEN V SKEW –127 ~ +127...
  • Page 36 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 Initial Data Item Adjustment Data Range Mode Name / Description Device Number Item 16 : 9 4 : 3 CENT –95 ~ +96 –19 –19 BLUE V CENTER CXP86213 SKEW –95 ~ +96 BLUE V SKEW –127 ~ +127...

  • Page 37: Registration Adjustment

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 6-2. REGISTRATION ADJUSTMENT CENTER ADJUSTMENT 1. Adjust H Position and V Position. 6-2-1. Registration Adjustment Method 1. Turn on the main power switch of the set and enter into standby mode. H Position 2. Press the following sequence of buttons on the Remote Commander.

  • Page 38: Sub Deflection Adjustment

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 MAIN DEFLECTION ADJUSTMENT 6-2-3. Sub Deflection Adjustment 1. Adjust V Linearity. 1. Receive the PAL SPCB signal. Correct linearity of the horizontal top and bottom lines. 2. Select 16 : 9 mode. (blue key)” : 4 : 3 b 16 : 9 Press “...
  • Page 39 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 GREEN VERTICAL LINE ADJUSTMENT GREEN HORIZONTAL LINE ADJUSTMENT 1. Receive the PAL SPCB signal. 1. Receive the PAL SPCB signal. 2. Carefully watching out for the GH CENT screen center sec- 2. Finely adjust the center position of the vertical line at the tion, adjust GH CENT, GH BOW, GH SKEW.
  • Page 40 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 GREEN VERTICAL SIZE ADJUSTMENT GREEN HORIZONTAL SIZE ADJUSTMENT 1. Receive the Internal pattern (crosshatch) signal. 1. Receive the Internal pattern (crosshatch) signal. 2. Adjust GV MSIZ so that the sizes at the top and bottom and 2.
  • Page 41 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 GREEN HORIZONTAL SYMMETRICAL PIN DISTORTION GREEN HORIZONTAL QUATERNARY ADJUSTMENT ADJUSTMENT 1. Receive the Internal pattern (crosshatch) signal. 1. Receive the Internal pattern (crosshatch) signal. 2. Adjust GH 4PIN, to correct the 4th order distortion. 2. Adjust GH MPIN to correct pin distortion at both edges of 3.
  • Page 42 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 GREEN VERTICAL ASYMMETRICAL PIN DISTORTION GREEN VERTICAL 4TH ORDER DISTORTION (2ND-ORDER DISTORTION) ADJUSTMENT ADJUSTMENT 1. Receive the Internal pattern (crosshatch) signal. 1. Receive the Internal pattern (crosshatch) signal. 2. Correct the asymmetrical pin distortion at the top and bot- 2.

  • Page 43: Horizontal Position Adjustment

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 RED REGISTRATION ADJUSTMENT AUTO CONVERGENCE PRESET 1. Receive the Internal pattern (crosshatch) signal. 1. Set in the TT mode. GH GSEL = “00” (Green + Red) 2. Press “ (AUTO CONVERGENCE)” button on front 2. Adjust so that the red lines lay on the green lines.

  • Page 44: White Balance Adjustment

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 6-5. WHITE BALANCE ADJUSTMENT 6-7. SUB CONTRAST ADJUSTMENT 1. Receive the Monoscope signal. (A or AE Board) 2. Set in the service mode and select “Picture Adjustment”. 1. Receive the PAL video color bar signal. 3. Adjust “Sub Brightness” so that the signal 10 IRE section White 100% barely glows.

  • Page 45: Diagrams

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 SECTION 7 DIAGRAMS 7-1. BLOCK DIAGRAMS IC201 IC103 IC204 IC301 SHADING TU101 VIDEO SW DIGITAL COMB FILTER YC SW BUFF CN301 BUFFER BUFFER BUFFER Y BUFFER VIDEO TV IN CVBS OUT FL102 ADIN Q107,108 SVHS-Y IN...
  • Page 46 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 IC103 IC201 DL SW IC204 TU101 VIDEO SW DIGITAL COMB FILTER Q118 YC SW BUFFER VIDEO BUFFER BUFFER BUFFER LUMINANCE BUFFER Y LPF BUFFER VIDEO TV IN CVBS OUT Q103, A/D IN Q105,106 Q114 Q117 Q201...
  • Page 47 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 IC301 CN301 BUFFER CVBS IN R OUT 1 RED DRIVE Q303 2 GRN DRIVE 3 BLUE DRIVE BUFFER SVHS-Y IN G OUT 4 9V Q334 5 GND TO CR BOARD 6 CUT OFF BUFFER CN703 B OUT...
  • Page 48 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 CN1705 PJERST AUDIO AMP,V DEFRECTION, CN1703 IC1706 PJ ENGINE IC1701 RV WAVE RESET PJ ENGINE CN1702 BV WAVE BUFFER +12V O-YM I-RESETN Q1705 BUFFER O-CLKN Q1706 MUTE BUFFER DATA O-YS O-CEB TO E BOARD Q1704 O-MUTE...
  • Page 49 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 (RED DY) IC814 IC812 CN1404 +12V REG +5V REG HR.IN +12V +15V +15V VR.IN VR.RET IC807 IC813 -12V REG -5V REG HR.RET -12V -15V -15V CN1405 CN804 R-H(+) IC804 IC810 RV WAVE P.ON MUTE B CONV CORR...
  • Page 50 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 (RED AMP) (GREEN AMP) (BLUE AMP) RED AMP V901 V902 V903 Q704,703 GREEN AMP BLUE AMP PICTURE TUBE PICTURE TUBE PICTURE TUBE Q733,732 Q762,763 Q701 HV R HV G HV B CN703 CN706 CN736 CN737 CN765...
  • Page 51 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 41PX1/41PX1K CN4901 S3006 IC3002 IR RECEIVER V IN V OUT CN3003 D3008 CN3001 AC (L) IN TO A BOARD SIRCS AV LINK CN4502 AC (N) IN J4901 MODE STBY 5V STBY 5V (AV3) TO G BOARD...

  • Page 52: Frame Schematic Diagram

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 7-2. FRAME SCHEMATIC DIAGRAM (1) (41PX1/41PX1K) PHOTO SENSOR AUDIO R OUT UPPER CN4902 L IN L IN AUDIO R OUT AUDIO R IN :S-MICRO R IN R IN CN4501 AUDIO R IN LEFT AUDIO L OUT...
  • Page 53 KP-41PX1/41PX1K/41PX1R FRAME SCHEMATIC DIAGRAM (2) (41PX1R) RM-892 RM-892 RM-862 PHOTO SENSOR (AV1) (AV2) UPPER CN2702 L IN FOR CHECK WHT-L :S-MICRO R IN LEFT (AV3) L OUT (SMART LINK) R OUT RIGHT (AV IN/OUT) CN201 DUAL SCART LOWER CVBS/Y IN...

  • Page 54: Circuit Boards Location

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 7-3. CIRCUIT BOARDS LOCATION 7-4. SCHEMATIC DIAGRAMS AND Reference information Terminal name of semiconductors in silk screen RESISTOR : RN METAL FILM PRINTED WIRING BOARDS printed circuit ( : RC SOLID : FPRD NONFLAMMABLE CARBON Device...

  • Page 55: Schematic Diagram Of A (1/5) Board (41Px1/41Px1K)

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 (1) Schematic Diagram of A (1/5) Board (41PX1/41PX1K) CN102 CN101 CN104 :FASTON :FASTON TO CRT BRACKET TO V.OUT TO G BOARD CN6003 TO A(3/5) FB101 TU101 R366 HM102 DISABLE BTF-FC411 :CHIP :CHIP C147 Q120 Q122 Q121...

  • Page 56: Schematic Diagram Of A (2/5) Board (41Px1/41Px1K)

    KP-41PX1/41PX1K/41PX1R (2) Schematic Diagram of A (2/5) Board (41PX1/41PX1K) RM-892 RM-892 RM-862 R272 D226 D225 TO A1/5,A2/5_1 R273 G AV-1 UDZ-9.1B UDZ-9.1B :CHIP PROT PROT :CHIP TO A(4/5) B AV-1 Q205 Q207 Q208 (2/5) Q206 R AV-1 2SC2142K 2SC2142K 2SC2142K...

  • Page 57: Schematic Diagram Of A (3/5) Board (41Px1/41Px1K)

    KP-41PX1/41PX1K/41PX1R (3) Schematic Diagram of A (3/5) Board (41PX1/41PX1K) RM-892 RM-892 RM-862 (3/5) (VIDEO AUDIO SELECT) IC204 MC14066BF YC-SW TO A(4/5) R268 R207 47k :CHIP R291 R292 :CHIP 2.2k 2.2k :CHIP :CHIP 0.4(8.5) R264 R269 R274 :CHIP :CHIP :CHIP C242 (4.9)

  • Page 58: Schematic Diagram Of A (4/5) Board (41Px1/41Px1K)

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 (4) Schematic Diagram of A (4/5) Board (41PX1/41PX1K) LINK IN AV LINK IN TO A(2/5) LINK OUT AV LINK OUT U-PC DISABLE TO A(1/5) DISABLE PJE TO A(1/5,3/5) TO A4/5,A5/5_13 TO A4/5,A5/5_14 TO A4/5,A5/5_15 TO A4/5,A5/5_16...

  • Page 59: Schematic Diagram Of A (5/5) Board (41Px1/41Px1K)

    KP-41PX1/41PX1K/41PX1R (5) Schematic Diagram of A (5/5) Board (41PX1/41PX1K) RM-892 RM-892 RM-862 STDBY 5V # :CHIP # :CHIP # :CHIP F:CHIP # :CHIP STDBY 5V # :CHIP # :CHIP P4.1 # :CHIP 100 :CHIP # :CHIP # :CHIP STDBY 5V # :CHIP P4.0...
  • Page 60 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 • A (1/5) BOARD WAVEFORMS (41PX1/41PX1K) • A (1/5) BOARD IC103 (41PX1/41PX1K) CXD2064Q PAL/NTSC SECAM PAL/NTSC SECAM PAL/NTSC SECAM VERTICAL 1.1 Vp-p (H) 1.2 Vp-p (H) 1.6 Vp-p (H) 1.8 Vp-p (H) 0.9 Vp-p (H) 1.0 Vp-p (H) 1.2 Vp-p (H)
  • Page 61 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 • A (3/5) BOARD IC4003 (41PX1/41PX1K) • A (4/5) BOARD IC301 (41PX1/41PX1K) CXA2089Q CXA2076Q VOUT1 YIN1 51 50 YOUT1 2Vp-p H SYNC 32fH PHASE VM OFF TRAP1 DGND V SYNC PHASE PHASE SYNC 1/32 H. DRIVE...
  • Page 62 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 µ COM, Y/C JUNGLE, TUNER, AUDIO/VIDEO PROCESS • A BOARD SEMICONDUCTOR LOCATION — A BOARD (Component Side) — (41PX1/41PX1K) (Component Side) Q300 Q308 Q330 Q331 Q333 Q401 IC103 Q402 IC201 Q403 IC202 Q2412 IC206 IC301 DIODE...
  • Page 63 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 µ COM, Y/C JUNGLE, TUNER, AUDIO/VIDEO PROCESS • A BOARD SEMICONDUCTOR LOCATION — A BOARD (Conductor Side) — (41PX1/41PX1K) (Conductor Side) Q1002 Q2414 Q4003 Q4007 IC204 IC205 DIODE IC302 TRANSISTOR D101 D102 D201 Q103 D203 Q105...

  • Page 64: Schematic Diagram Of Ae (1/5) Board (41Px1R)

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 (6) Schematic Diagram of AE (1/5) Board (41PX1R) TU101 TVF01-FR FOR CHECK CN101 VIDEO :FASTON Q110 Q111 Q112 Q113 Q114 Q120 Q122 Q121 Q130 Q124 L111 2SC2412K 2SA1037AK 2SC2412K 2SA1037AK 2SA1037AK 2SC2412K 2SC2412K 2SC2142K 2SA1037AK 2SC2142K...

  • Page 65: Schematic Diagram Of Ae (2/5) Board (41Px1R)

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 (7) Schematic Diagram of AE (2/5) Board (41PX1R) FB AV-1 R AV-1 AE(4/5) G AV-1 (2/5) B AV-1 (AUDIO PROCESSOR) TO AE1/5,AE2/5_1 R270 R271 R272 R273 D223 D224 D225 D226 UDZ-9.1B :CHIP UDZ-9.1B :CHIP UDZ-9.1B :CHIP UDZ-9.1B...

  • Page 66: Schematic Diagram Of Ae (3/5) Board (41Px1R)

    KP-41PX1/41PX1K/41PX1R (8) Schematic Diagram of AE (3/5) Board (41PX1R) RM-892 RM-892 RM-862 PAL/NT C125 FB101 C126 C127 R176 C136 R177 0.01 HM102 0.01 0.01 B:CHIP :CHIP B:CHIP :CHIP B:CHIP :CHIP D.5V R178 :CHIP R159 C128 C129 0.01 B:CHIP CH:CHIP :CHIP...

  • Page 67: Schematic Diagram Of Ae (4/5) Board (41Px1R)

    KP-41PX1/41PX1K/41PX1R (9) Schematic Diagram of AE (4/5) Board (41PX1R) RM-892 RM-892 RM-862 U-PC DISABLE TO AE(1/5) AGC MONI TO AE(1/5,3/5) TO AE(1/5) DISABLE PJE TO AE4/5,AE5/5_9 TO AE4/5,AE5/5_10 TO AE4/5,AE5/5_11 VIDEO TO AE4/5,AE5/5_12 CVBS STDBY 5V TO AE(1/5) CVBS C373...

  • Page 68: Schematic Diagram Of Ae (5/5) Board (41Px1R)

    KP-41PX1/41PX1K/41PX1R (10) Schematic Diagram of AE (5/5) Board (41PX1R) RM-892 RM-892 RM-862 STDBY 5V F:CHIP P4.1 0.9(2.1) 100 :CHIP 5.0(3.0) STDBY 5V P4.0 STDBY 5V 2.5(2.1) 100 :CHIP M27C2001-12C1R STDBY 5V PROGRAM ROM 4.2(1.7) RST2 47 16V RED OUT 4.6(5.0) 11.5MHz...
  • Page 69 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 • AE (1/5) BOARD WAVEFORMS (41PX1R) • AE (3/5) BOARD IC103 (41PX1R) CXD2044Q PAL/NTSC SECAM 1.1 Vp-p (H) 1.2 Vp-p (H) ANALOG VIN NTSC : 1H NTSC : 1H : 2H : 2H A-YOUT – • AE (2/5) BOARD WAVEFORM (41PX1R) ı...
  • Page 70 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 • AE (3/5) BOARD IC102 (41PX1R) • AE (4/5) BOARD IC301 (41PX1R) NJM2240M CXA2076Q PHASE DIVIDER FSC OUT COMPARATOR CIRCUIT 51 50 2Vp-p SEARCH DET FIL CIRCUIT H SYNC 32fH PHASE VM OFF DGND V SYNC...
  • Page 71 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 µ COM, Y/C JUNGLE, TUNER, AUDIO/VIDEO PROCESS • AE BOARD SEMICONDUCTOR LOCATION — AE BOARD (Component Side) — (41PX1R) (Component Side) DIODE D202 D204 D205 IC103 IC201 D212 IC202 D213 IC205 D216 IC206 D217 D218 IC301...
  • Page 72 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 µ COM, Y/C JUNGLE, TUNER, AUDIO/VIDEO PROCESS • AE BOARD SEMICONDUCTOR LOCATION — AE BOARD (Conductor Side) — (41PX1R) (Conductor Side) DIODE IC102 IC204 IC302 D101 TRANSISTOR D102 D201 D203 D206 D207 D208 Q101 D209 Q102...

  • Page 73: Schematic Diagram Of D (1/3) Board

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 41PX1R (11) Schematic Diagram of D (1/3) Board CN1807 CN1808 :S-MICRO :S-MICRO CN1801 :BTOB 41PX1R TO A(4/5)BOARD R1830 * MARK LIST CN1:41PX1/41PX1K IC1805 R1832 LM358D Q1803 C1824 :CHIP C1822 TO AE(4/5)BOARD MIXING :CHIP 2SC2412K C1826 Ref No.

  • Page 74: Schematic Diagram Of D (2/3) Board

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 (12) Schematic Diagram of D (2/3) Board (AUDIO OUT) CN1601 TB1601 :S-MICRO (CENTER SP IN) J1601 TO H2 BOARD CN3204 VARIABLE OUT Q1612 IC1602 DTC143TKA 41PX1/41PX1K TDA7264 41PX1/ AUDIO R C1601 MUTE AUDIO MAIN AMP 41PX1K C1608 0.001...

  • Page 75: Schematic Diagram Of D (3/3) Board

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 (13) Schematic Diagram of D (3/3) Board * MARK LIST Ref No. 41PX1/41PX1K 41PX1R R1509 5.6k 6.8k R1527 2.2M R1528 2.2M R1544 JW(5) R1762 3.9k 4.7k R1763 3.3k 4.3k R1764 3.9k 4.7k +15V C1516 0.1 25V B:CHIP H.SHIFT...
  • Page 76 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 • D (3/3) BOARD WAVEFORMS 0.5 Vp-p (V) 4.7 Vp-p (H) 4.7 Vp-p (V) 3.6 Vp-p (8 MHz) 57.5 Vp-p (V) 0.5 Vp-p (V) 4.7 Vp-p (V) 4.7 Vp-p (H) 1.3 Vp-p (V) 1.3 Vp-p (V)
  • Page 77 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 AUDIO AMP, V DEFRECTION, PJ ENGINE — D BOARD (Component Side) — • D BOARD SEMICONDUCTOR LOCATION (Component Side) IC1501 IC1602 IC1603 IC1701 IC1801 IC1802 IC1803 IC1804 DIODE D1501 D1502 D1503 D1504 D1601 D1603 D1604 D1606...
  • Page 78 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 AUDIO AMP, V DEFRECTION, PJ ENGINE — D BOARD (Conductor Side) — • D BOARD SEMICONDUCTOR LOCATION (Conductor Side) Q1804 Q1805 Q1806 IC1501 Q1807 IC1502 Q1808 IC1503 Q1809 IC1602 IC1603 IC1701 DIODE IC1702 IC1703 IC1704 D1501 –...

  • Page 79: Schematic Diagram Of E (1/4) Board

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 (14) Schematic Diagram of E (1/4) Board TO E1/4,E2/4_1 TO E1/4,E2/4_2 TO E1/4,E2/4_3 CN508 :FASTON TO E1/4,E2/4_4 TO E1/4,E2/4_5 R809 R823 TO D(3/3)BOARD Q801 Q803 4.7k R867 CN1502 2SC3311A 2SC3311A BUFF BUFF R878 100k Q812 R704...

  • Page 80: Schematic Diagram Of E (2/4) Board

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 (15) Schematic Diagram of E (2/4) Board TO E1/4,E2/4_1 TO E1/4,E2/4_2 C880 R999 R979 4.7k 4.7k TO E1/4,E2/4_3 Q810 2SC3311A -13.5 MUTE R989 4.7k D510 R995 -13.5 JW(5) 1SS133 TO E1/4,E2/4_4 R974 -14.5 -14.5 -15V TO E1/4,E2/4_5...

  • Page 81: Schematic Diagram Of E (3/4) Board

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 (16) Schematic Diagram of E (3/4) Board (3/4) (HV) CN507 :S-MICRO TO PICTURE HV(R) TUBE R HV.REG TO E2/4,E3/4_21 TO PICTURE HV(G) STDBY 7V TO E2/4,E3/4_22 TUBE G STDBY 7V TO E2/4,E3/4_23 TO PICTURE HV(B) TUBE B <HV.BLOCK>...

  • Page 82: Schematic Diagram Of E (4/4) Board

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 (17) Schematic Diagram of E (4/4) Board (4/4) (H DEFRECTION, DY) TO E3/4,E4/4_26 CN805 TO E3/4,E4/4_27 :MINI R586 R557 R558 R559 R585 TO E3/4,E4/4_28 Q503 R836 R556 D517 2SA1309A TO E(4/4)BOARD T504 R921 RGP02-20EL R919 1/2W...
  • Page 83 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 • E (1/4) BOARD WAVEFORMS 4.7 Vp-p (H) 2.5 Vp-p (H) 2.5 Vp-p (H) 2.4 Vp-p (H) 2.2 Vp-p (H) 4.7 Vp-p (V) 2.5 Vp-p (V) 2.4 Vp-p (V) 2.4 Vp-p (V) 2.3 Vp-p (V) 2.3 Vp-p (V) •...
  • Page 84 KP-41PX1/41PX1K/41PX1R NOTE: RM-892 RM-892 RM-862 The circuit indicated as left contains high voltage of over 600 Vp-p. Care must be paid to prevent an electric shock in H DEFRECTION, inspection or repairing. HV, DY DRIVE — E BOARD — • E BOARD SEMICONDUCTOR...

  • Page 85: Schematic Diagram Of Zg Board

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 VM, GREEN/BLUE DY (18) Schematic Diagram of ZG Board CN1434 — ZG BOARD — T0 E(4/4) BOARD CN503 G-H(+) H(MID) DY(H) G-H(-) H.IN V.IN CN1433 SUB DY V.RET :S-MICRO R1435 R1436 H.RET HG.IN V.DEF VG.IN V(MID)

  • Page 86: Schematic Diagram Of Zr Board

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 RED DY (19) Schematic Diagram of ZR Board CN1405 — ZR BOARD — TO E(4/4) BOARD CN504 R-H(+) H(MID) DY(H) R-H(-) H.IN V.IN CN1404 SUB DY V.RET :S-MICRO H.RET R1415 R1418 TO E(2/4) BOARD CN801 V.DEF V(MID) HR.IN...

  • Page 87: Schematic Diagram Of Cr Board

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 RED AMP (20) Schematic Diagram of CR Board 4 10 — CR BOARD — V901 PICTURE HV.BLOCK TUBE TO FOCUS BLOCK SG703 CN705 FGND CN706 (RED AMP) R719 R714 1/2W :S-MICRO 1/2W TO CG BOARD CN736...

  • Page 88: Schematic Diagram Of Cg Board

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 GREEN AMP (21) Schematic Diagram of CG Board 4 10 — CG BOARD — V902 PICTURE HV.BLOCK TUBE TO FOCUS BLOCK (GREEN AMP) SG733 CN735 FGND CN737 R740 :S-MICRO 1/2W TO CB BOARD CN765 H(+) CN734...

  • Page 89: Schematic Diagram Of Cb Board

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 BLUE AMP (22) Schematic Diagram of CB Board 4 10 — CB BOARD — V903 PICTURE HV.BLOCK TUBE TO FOCUS BLOCK CN766 (BLUE AMP) SG763 CN764 FGND R771 :S-MICRO R769 1/2W TO E(4/4)BOARD 1/2W CN501 H(+)

  • Page 90: Schematic Diagram Of U Board (41Px1/41Px1K)

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 AV IN/OUT (23) Schematic Diagram of U Board (41PX1/41PX1K) — U BOARD — (41PX1/41PX1K) R4902 C4901 D4901 0.01 :CHIP AUDIO(R) CN4902 L4900 4.7µH R4901 :CHIP :S-MICRO L4901 R4915 :CHIP 4.7µH R4904 L IN :CHIP :CHIP AUDIO(R)

  • Page 91: Schematic Diagram Of Ue Board (41Px1R)

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 AV IN/OUT (24) Schematic Diagram of UE Board (41PX1R) — UE BOARD — (41PX1R) CN2703 SCART (AV IN/OUT) CN2701 VIDEO/Y RED-L :S-MICRO R2706 C2705 D2701 :CHIP UDZ-9.1B TO D BOARD CN1808 CVBS IN VIDEO CVBS OUT...

  • Page 92: Schematic Diagram Of H1 Board

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 USER CONTROL, MAIN SWITCH (25) Schematic Diagram of H1 Board — H1 BOARD — IC3002 SBX3081-51(20) IR RECEIVER USER CONTROL, R3004 MAIN SWITCH 220 1/10W STBY 5V D3002 D3003 CN3003 MTZJ-5.6B C3003 C3004 TO G BOARD...

  • Page 93: Schematic Diagram Of H2 Board

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 AV INPUT, HP OUT, (26) Schematic Diagram of H2 Board USER CONTROL — H2 BOARD — CN3202 :S-MICRO TO D(1/3)BOARD CN1802 D3213 D3214 C3204 D3201 D3216 0.022 D3202 R3218 MTZJ-6.8A B:CHIP CN3204 D3215 L3203 L3201 C3205 0.022...

  • Page 94: Schematic Diagram Of G Board

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 (27) Schematic Diagram of G Board CN6007 CN6006 TO H1 BOARD TO H1 BOARD CN3003 CN3004 CN6011 :MINI +12V D6017 +12V RBV-406B AUDIO+ TO E(3/4)BOARD R6006 T6001 PS6002 L6004 CN806 3.15A 10µH :LHL08 IC6002 R6010 C6042...
  • Page 95 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 POWER SUPPLY • G BOARD SEMICONDUCTOR LOCATION IC6001 IC6002 IC6003 IC6004 IC6005 TRANSISTOR Q6001 – Q6002 – Q6003 – Q6004 – Q6005 Q6006 Q6007 – Q6008 Q6009 DIODE D6001 – D6002 – D6003 – D6004 D6005 –...

  • Page 96: Semiconductors

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 7-5. SEMICONDUCTORS AN77L12-TA CXA2089Q-T6 MSP3410D-C5-PS-B4 PST593C-MMP-4P TDA8395T/N3 2SA1091-O 2SK2251-01-F19 D10SC6M-4012 MTZJ-13 NJM78L12A-T3 CXD2064Q-T6 MSP3411G-PS-B8 2SA1091O-TPE2 MTZJ-13B 2SA1208 MTZJ-7.5B NJM79L12A SDA5273-3CP-C55-22- 2SA1208T-TP NJM79L12A-T3 MTZJ-T-77-13 MTZJ-T-77-13B MTZJ-T-77-22 MTZJ-T-77-3.6 MTZJ-T-77-5.1 TOP VIEW MTZJ-T-77-5.1B TOP VIEW MTZJ-T-77-5.6 4pin CHIP 20pin SOP MTZJ-T-77-6.8B...

  • Page 97: Exploded Views

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 SECTION 8 EXPLODED VIEWS NOTE: • Items marked " * " are not stocked since The components identified by shading they are seldom required for routine • Items with no part number and no ¡ and mark are critical for safety.

  • Page 98: Cabinet Block

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 8-2. CABINET BLOCK The components identified by shading ¡ : 7-685-663-71 SCREW +BVTP 4X16 and mark are critical for safety. Replace only with part number specified. : 7-685-663-79 SCREW +BVTP 4X16 MECHASEAL BLOCK CHASSIS BLOCK REF.NO. PART NO.

  • Page 99: Main Bracket Block

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 8-3. MAIN BRACKET BLOCK The components identified by shading ¡ and mark are critical for safety. : 7-685-648-71 SCREW +BVTP 3X12 Replace only with part number specified. : 7-685-663-71 SCREW +BVTP 4X16 : 7-685-663-79 SCREW +BVTP 4X16 REF.NO.

  • Page 100: Mechaseal Block

    KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 8-4. MECHASEAL BLOCK The components identified by shading ¡ and mark are critical for safety. : 7-685-648-71 SCREW +BVTP 3X12 Replace only with part number specified. : 7-685-663-71 SCREW +BVTP 4X16 REF.NO. PART NO. DESCRIPTION REMARK REF.NO.

  • Page 101: Electrical Parts List

    KP-41PX1/41PX1K/41PX1R The components identified by shading SECTION 9 ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. ELECTRICAL PARTS LIST The components identified by [ in this REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO.
  • Page 102 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK C217 1-162-970-11 CERAMIC CHIP 0.01µF C279 1-126-965-91 ELECT 22µF...
  • Page 103 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK C355 1-126-965-91 ELECT 22µF C4101 1-164-217-11 CERAMIC CHIP 150pF C356 1-162-970-11 CERAMIC CHIP 0.01µF...
  • Page 104 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK D370 8-719-047-16 DIODE BAS216 D401 8-719-069-60 DIODE UDZSTE-179.1B...
  • Page 105 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK Q106 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q107 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R...
  • Page 106 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK 1-216-809-11 RES-CHIP 1/16W R151 1-216-809-11 RES-CHIP 1/16W 1-216-809-11 RES-CHIP...
  • Page 107 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK R272 1-218-285-11 RES-CHIP 1/16W R213 1-218-285-11 RES-CHIP 1/16W...
  • Page 108 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. A AE REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK R345 1-216-864-11 SHORT R4029 1-216-833-11 RES-CHIP...
  • Page 109 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK C205 1-126-965-91 ELECT 22µF 1-163-017-00 CERAMIC CHIP 0.0047µF 10%...
  • Page 110 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK C277 1-164-505-11 CERAMIC CHIP 2.2µF C356 1-164-232-11 CERAMIC CHIP 0.01µF C278 1-164-505-11 CERAMIC CHIP 2.2µF...
  • Page 111 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK D214 8-719-069-60 DIODE UDZSTE-179.1B D215 8-719-069-60 DIODE UDZSTE-179.1B D216 8-719-069-55 DIODE UDZSTE-175.6B...
  • Page 112 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK Q113 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R 1-216-025-00 RES,CHIP 1/10W Q114...
  • Page 113 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK R117 1-216-057-00 RES,CHIP 2.2K 1/10W R179 1-208-788-11 METAL CHIP 1.8K...
  • Page 114 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK R236 1-216-113-00 RES,CHIP 470K 1/10W R310 1-216-033-00 RES,CHIP...
  • Page 115 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. AE G REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK R1017 1-216-295-00 SHORT C6029 1-164-625-11 CERAMIC...
  • Page 116 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK D6016 8-719-052-91 DIODE D4SBS4-F Q6002 8-729-056-60 TRANSISTOR SPA07N60C2...
  • Page 117 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. G CB CG REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK R6051 1-216-366-00 METAL OXIDE 0.56...
  • Page 118 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. CG CR REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK C737 1-107-662-11 ELECT 22µF 250V * A-1638-152-ACR BOARD, COMPLETE...
  • Page 119 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. CR D REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK R711 1-216-487-11 METAL OXIDE C1602 1-163-009-11 CERAMIC CHIP 0.001µF...
  • Page 120 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK C1727 1-164-004-11 CERAMIC CHIP 0.1µF CN1804 * 1-564-508-11 PLUG, CONNECTOR 5P C1802 1-164-232-11 CERAMIC CHIP 0.01µF...
  • Page 121 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK Q1612 8-729-027-56 TRANSISTOR DTC143TKA-T146 IC1701 8-752-908-27 IC CXP86213-003S...
  • Page 122 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK R1645 1-216-041-00 RES-CHIP 1/10W R1527 1-216-129-00 RES-CHIP 2.2M...
  • Page 123 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK R1749 1-216-033-00 RES-CHIP 1/10W R1807 1-216-295-91 SHORT (41PX1/41PX1K)
  • Page 124 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK R1841 1-216-049-00 RES-CHIP 1/10W C529 1-109-844-11 FILM 0.68µF...
  • Page 125 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK C838 1-104-665-11 ELECT 100µF <CONNECTOR> C839 1-137-374-11 MYLAR 0.047µF...
  • Page 126 • The components identified by [ in this manual KP-41PX1/41PX1K/41PX1R The components identified by shading have been carefully factory-selected for each set ¡ RM-892 RM-892 RM-862 and mark are critical for safety. in order to satisfy regulations regarding X-ray Replace only with part number specified.
  • Page 127 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK R546 1-249-377-11 CARBON 0.47 1/4W R810 1-247-807-31 CARBON...
  • Page 128 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK R871 1-249-417-11 CARBON 1/4W R931 1-215-445-00 METAL 1/4W...
  • Page 129 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. E H1 H2 REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK R3002 1-216-073-91 RES-CHIP 1/10W R990...
  • Page 130 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. H2 U UE REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK <RESISTOR> R4915 1-216-043-91 RES-CHIP 1/10W...
  • Page 131 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. ZG ZR REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK * A-1652-078-AZG BOARD, COMPLETE Q1434 8-729-423-33 TRANSISTOR 2SC3311A-QRSTA...
  • Page 132 KP-41PX1/41PX1K/41PX1R The components identified by shading ¡ RM-892 RM-892 RM-862 and mark are critical for safety. Replace only with part number specified. REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK <RESISTOR> R1401 1-249-414-11 CARBON 1/4W R1402 1-249-414-11 CARBON...
  • Page 133 KP-41PX1/41PX1K/41PX1R RM-892 RM-892 RM-862 English Sony Corporation 2001FA71-1 9-965-429-01 HNC. HVC. Projection Display Business Div © 2001. 6 – 133 –...

This manual is also suitable for:

Kp-41px1rKp-41px1k

Table of Contents