Page 2
If you are an experienced R/C enthusiast you will find it helpful and fast. Thank you again for going with Traxxas. We work hard every day Be sure and read through the rest of the manual to learn to assure you the highest level of customer satisfaction possible.
Traxxas service needs. Maintenance and replacement Traxxas.com identified by the icons below. Be sure to read them! parts may be purchased directly from Traxxas by phone or online E-mail: support@Traxxas.com at www.BuyTraxxas.com. You can save time, along with shipping...
Page 4
SAFETY PRECAUTIONS BELOW TEXT HAS BEEN UPDA All of us at Traxxas want you to safely enjoy your new Revo. Operate The engine can be loud. If the noise makes you uncomfortable, wear your Revo sensibly and with care, and it will be exciting, safe, and fun ear protection.
QUICK START: GETTING UP TO SPEED The following guide is an overview of the procedures for getting your Revo running, from opening the box to breaking in and tuning your engine. Refer to the pages indicated for details on each step. Look for the Quick Start logo on the bottom corners of Quick Start pages. The Quick Start Guide is not intended to replace the 1.
THE TRAXXAS TQ 2.4GHZ RADIO SYSTEM Your Revo is equipped with the TQ 2.4GHz radio system. The TQ 2.4GHz is a 3-channel system that provides control for up to three outputs. Revo is equipped with two high- torque steering servos connected via dual Channel 1 outputs. The TQ 2.4GHz works in conjunction with the OptiDrive ®...
Page 9
Frequency band - The radio frequency used by the transmitter to the face of the transmitter. send signals to your model. Some Traxxas RTR models operate on a 27 MHz frequency band. This model operates on the 2.4GHz digital spread spectrum system.
THE TRAXXAS TQ 2.4GHZ RADIO SYSTEM INSTALLING TRANSMITTER BATTERIES CHARGING THE RECEIVER BATTERY Your TQ 2.4GHz transmitter uses 8 AA batteries. The battery Your model includes an AC charger for the included receiver pack. It Use the Right Batteries compartment is located in the base of the transmitter.
Page 11
Visible Only use approved chargers for NiMH battery packs (such as Part warning signals include #2921 or the Traxxas TRX Power Charger, Part #3030X). Do not exceed sluggish steering response the maximum charge rate of 1 amp.
THE TRAXXAS TQ 2.4GHZ RADIO SYSTEM SETTING UP THE ANTENNA TQ 2.4GHZ RADIO SYSTEM ADjUSTMENTS The receiver antenna has been setup In addition to the electronic throttle and steering trim controls, your radio Spray a little window cleaner and installed from the factory. The system features throttle neutral adjustment and servo reversing switches.
Page 13
For instructions on how to use the OptiDrive with aftermarket radio position, solid blue or off when then adjust the THROTTLE TRIM until the carburetor systems, or to access advanced programming options, visit Traxxas.com. vehicle is at rest. closes. This should require only slight adjustment. If more than 15 degrees of adjustment is required (see Revo 3.3 •...
Page 14
THE TRAXXAS TQ 2.4GHZ RADIO SYSTEM TQ 2.4GHZ RADIO SYSTEM RULES 5. When looking down at model, the front wheels should be pointing straight ahead. If the wheels are turned slightly to the left Remember, always turn the Always turn your TQ 2.4GHz transmitter on first and off last. This...
Page 15
THE TRAXXAS TQ 2.4GHZ RADIO SYSTEM TQ 2.4GHZ BINDING INSTRUCTIONS SETTING THE RECEIVER THROTTLE NEUTRAL The Traxxas TQ 2.4GHz radio system is pre-set at the factory and is For proper operation, the transmitter and receiver must be Don’t attempt to operate electronically ‘bound.’...
INTRODUCTION The TRX ® 3.3 Racing Engine is the next generation of TRX nitro Traxxas strongly discourages power. The larger displacement and advanced porting generate changing or modifying any class-leading horsepower while still maintaining the TRX Racing part of the TRX 3.3 Racing Engine characteristics of broad, linear power delivery and ease of Engine.
Page 17
THE TRX 3.3 RACING ENGINE TRX 3.3 RACING ENGINE ILLUSTRATED Glow Plug Revo’s fuel tank is equipped Idle Speed Two-Stage with a built-in sintered Screw Air Filter bronze fuel filter. Head Protector PowerTune Head ™ (Cylinder Head) EZ-Start Drive Unit ®...
Page 18
The break-in procedure can be different for Flame-out - Occurs when the engine stops running at high rpm. different makes of engines. Follow the Traxxas directions for break- Usually the fault of an excessively lean fuel mixture or glow in exactly.
Page 19
Leaning the mixture - Turning either the high-speed and/or low- to the tank. On a Traxxas model this is done by holding your finger speed needle(s) clockwise to decrease the amount of fuel the over the exhaust tip for one or two seconds while the engine is engine receives.
Page 20
10% nitro blend is more economical for the sport user. 10% also Top Fuel is the only fuel which is 100% certified for use in Traxxas engines. fuel dispensing bottle on provides greater latitude with the needle settings for easier tuning.
Apply a total of 24 drops of The TRX 3.3 Racing Engine in this model Traxxas air filter oil, evenly distributed between the top, bottom and is equipped with a specially designed sides of the filter element. Squeeze the filter element repeatedly to two-stage air filter to deliver maximum filtering efficiency and help spread the oil throughout.
Page 22
THE TRX 3.3 RACING ENGINE The Carburetor correct air/fuel ratio. Warmer air is less dense (fewer air molecules) and therefore needs less fuel to maintain the correct air/fuel ratio. The See page 29 for more Understanding the Carburetor adjustments information on how air tuning needles are there to adjust how much fuel is made available for The carburetor performs several functions.
Page 23
THE TRX 3.3 RACING ENGINE Slightly lean fuel mixtures deliver stronger, more efficient combustion and more power, but with less lubrication. Richen See Tuning Your TRX 3.3 Water Valve Racing Engine on page 28 (Controls Overall Flow) Slightly rich fuel mixtures deliver cooler running and more for complete information on High Speed Needle lubrication but with slightly less power.
Page 24
THE TRX 3.3 RACING ENGINE THE TRAXXAS EZ-START ELECTRIC STARTING SYSTEM Installing the EZ-Start Battery The Traxxas EZ-Start brings the convenience of push-button electric Using Other Chargers engine starting to your Revo. The EZ-Start consists of a hand-held control 1. Press the tab in the end of the battery Another convenient option unit and an on-board motorized starter.
Page 25
THE TRX 3.3 RACING ENGINE Protection Mode The EZ-Start uses Smart Start technology to monitor the condition ™ When the EZ-Start controller of the system and detect failures. The controller monitors the load is in protection mode, wait being placed on the EZ-Start motor. If the load becomes excessive, at least three minutes before the system shuts off power to the motor to prevent costly damage attempting to start the...
Page 26
THE TRX 3.3 RACING ENGINE BREAKING IN YOUR TRX 3.3 RACING ENGINE Keep extra Traxxas glow plugs handy. The break-in process can cause The TRX 3.3 Racing Engine uses a ringless, aluminum-brass-chrome See Important Points to deposits to form on the plug leading to plug failure.
Page 27
3-second count, hold for 2 more seconds, and then Only use the Traxxas break-in thousand two, and then stop. Repeat this starting and stopping gently apply the brake to stop. Count the five seconds out while procedure.
Page 28
THE TRX 3.3 RACING ENGINE Winter Break-in Tips We do not recommend that you operate your engine below 35° During the break-in process, the piston and sleeve wear into Fahrenheit. If you insist on running your vehicle below 35°F, be aware When tuning for each other to form a precise fit.
Page 29
THE TRX 3.3 RACING ENGINE Before you begin tuning, the engine should be warmed up to its normal 2. Bring the vehicle in and pinch closed the fuel line going into the operating temperature and running slightly rich. All final tuning adjustments carburetor (use the engine shut-off clamp).
Page 30
. If engine temperature is exceeding 270°F with proper cooling optional infrared temperature probe or and no signs of abnormal running, then avoid running the engine at its on-board temperature gauge (Traxxas maximum lean setting. Watch closely for any signs of overheating. on-board digital temperature gauge, part Richen the fuel mixture slightly to provide a safety margin of additional #4091).
Page 31
DRIVING YOUR REVO INTRODUCTION Driving Tips Your TRX 3.3 Racing Engine is broken in, the fuel mixture is balanced, Monster trucks by design have a high center of gravity that and the idle is set…now it’s time to have some fun! Before you go on, requires a different driving technique.
Make sure you fully understand the basic adjustments before experimenting Optional springs available from Traxxas are listed below. Refer to your with the advanced adjustments. Improper combinations of parts list for a complete part number listing. Higher rate springs are adjustments can adversely affect the performance of the truck, stiffer.
Page 33
BASIC TUNING ADjUSTMENTS push rod comes installed in the inner hole of the lower suspension viscosity of shock oil is affected by extremes in operating temperature; arm’s push rod mount. If the push rod is mounted in the outer hole, an oil of certain viscosity will become less viscous at higher Important: The shocks are the ride height decreases.
Page 34
Decrease turnbuckles. The lengths of the toe Length links can be adjusted by turning Left Front them with the included 5mm Traxxas wrench. Positive camber Front of Truck Toe Base Factory Settings Front: 0-degrees Left Hand Thread...
Page 35
BASIC TUNING ADjUSTMENTS Maximum Alignment Limits (using stock push rod length) TRANSMISSION TUNING Revo’s maximum toe and camber alignment settings can be limited Adjusting the Slipper Clutch by the ride height setting. Do not exceed the maximum limits or you Your Revo is equipped with could experience interference between suspension components.
Page 36
BASIC TUNING ADjUSTMENTS Adjusting the Two-Speed Transmission Adjusting the Spur Gear/Clutch Bell Gear Mesh The ideal spur gear/clutch bell gear mesh for Revo comes equipped with an adjustable two-speed transmission. When the shift point on the transmission is adjusted correctly, it will Revo is 0.1mm.
Page 37
(see parts list for details). Do not use this However, if the brake pads wear down close to the metal pad holders, spring with standard Traxxas high-torque servos. they should be replaced. Any more wear than this could cause damage to the brake parts and improper operation of the brake system.
Page 38
You must perform after-run maintenance on your components such as the Perform after-run maintenance on the engine. This clears the engine Traxxas engine whenever the model will be stored for crankcase, crankshaft, and of destructive moisture and other corrosive deposits. This is extremely longer than a few hours.
Page 39
A 5/16 or 8mm nut driver will also work. 3. Turn the model upside down and plug in the EZ-Start controller. If you have questions or need technical assistance, call Traxxas at 1-888-TRAXXAS 4. Push the EZ-Start button for several seconds to clear the engine of excess fuel.
ADVANCED TUNING ADjUSTMENTS This advanced tuning guide will take you one step further into the Roll Center cutting edge technology that has been designed into Revo. Follow There are two holes on the Upper Control Arm the instructions provided here to take advantage of Revo’s maximum bulkheads to mount each upper Upper Mounting Holes performance potential.
Page 41
ADVANCED TUNING ADjUSTMENTS Bump Steer Elimination Chart Rocker Arm Total Travel Progressive Rate The illustrations and the following table detail the position of the outer 90mm toe link end for various caster and roll center settings to eliminate bump When using Long Travel Progressive 1 (60mm up / 30mm down) rockers, A correspondingly...
Page 42
Revo is equipped to allow adjustment to the two-speed by installing out through the top of the shock body. optional close and wide-ratio gearsets. This requires transmission removal and disassembly (see www.Traxxas.com for detailed Shock assembly instructions). The close ratio gearsets will reduce top speed slightly 1.
Page 43
(Wide) 15.45 16.31* 17.17 Using lower viscosity silicone oil. Only use silicone oil in the differentials. Traxxas sells SAE 10,000W With 15T Clutch Bell # of Spur Gear Teeth (thinner) oil for: (standard) and SAE 50,000W viscosity oil (see your parts list). The differentials have to be...
Page 44
MODEL 5309 1100 Klein Road, Plano Texas 75074 1-888-TRAXXAS 090625 KC1185-R01...
Need help?
Do you have a question about the Revo 3.3 5309 and is the answer not in the manual?
Questions and answers