Related Manuals for Classen RA-21H
Summary of Contents for Classen RA-21H
- Page 1 RECIPROCATING AERATOR MODELS: RA-21H Reciprocating Aerator Honda GX160 RA-21B Reciprocating Aerator B&S Intek 850...
- Page 2 CALIFORNIA Proposition 65 Warning WARNING Diesel engine exhaust and some The engine exhaust from this product of its constituents are known to the contains chemicals known to the State State of California to cause cancer, of California to cause cancer, birth birth defects and other reproductive defects or other reproductive harm.
-
Page 3: Table Of Contents
Your safe use of this Classen product is one of our prime design objectives. Many safety features are built in, but we also rely on your good sense and care to achieve accident-free operation. -
Page 4: Safety
SAFETY RA-21 This symbol means: NOTICE !!! ATTENTION! Unauthorized modifications may present extreme BECOME ALERT! safety hazards to operators and bystanders and could also result in product damage. Your safety and the safety of others is involved. Schiller Grounds Care, Inc. strongly warns against, Signal word definitions rejects and disclaims any modifications, add-on accessories or product alterations that are not... - Page 5 SAFETY RA-21 OPERATOR PREPARATION & TRAINING SITE PREPARATION & CIRCUMSTANCES • Evaluate the terrain to determine how to safely READ THE OPERATION & SAFETY MANUAL perform the job. Only use accessories and • attachments approved by the manufacturer. If an operator or mechanic •...
- Page 6 SAFETY RA-21 OPERATING SAFELY repairs made as needed before restarting; IN GENERAL - except for repairs or adjustments as specifically • Use extra care when loading or unloading the noted, such as for carburetor adjustment, where machine into a trailer or truck. the engine must be running.
-
Page 7: Maintenance Safety
SAFETY RA-21 MAINTENANCE SAFETY FUEL SAFETY WARNING • Gasoline is flammable; gasoline IN GENERAL vapors are explosive. Use extra care • Maintain machine according to manufacturer's when handling. schedule and instructions for maximum safety and • Store only in containers specifically best results. -
Page 8: Specifications
32" (813 mm) Net Weight: Weight........261 lbs. (119 Kg) Removable weights..... Speed: Aerate....up to 305 f.p.m. (2.84 km/h) Engines: Model RA-21H Model.......... GX160 Honda, 4.0 h.p., 4 cycle Starter......... Recoil, on/off switch Governor........3900 RPM, no load Idle Speed........ -
Page 9: Labels
LABELS RA-21 WARNING LABELS Warning labels are an important part of the safety system incorporated in this machine. Replace labels if damaged or illegible “IMPORTANT EMMISIONS INFORMATION” THIS EQUIPMENT CONFORMS TO 2009 CALIFORNIA EVP REGULATIONS FOR SMALL OFF ROAD ENGINES KEEP HANDS AND FEET AWAY UNDER 13CCR SECTION 2766(b) SCHILLER GROUNDS CARE, INC. -
Page 10: Controls / Assembly Instructions
CONTROLS / ASSEMBLY INSTRUCTIONS RA-21 SET-UP INSTRUCTIONS NOTE: Units ship with no gas or oil. 1. Cut banding and roll aerator off pallet. 2. Unfold by pulling up on handle 1. Slide lock rings down 3. Add oil to the engine with the engine resting in a level position. -
Page 11: Operation
OPERATION RA-21 PRE-OPERATION CHECK LIST BEFORE STARTING THE ENGINE OWNER’S RESPONSIBILITY • Read the operator manual and engine manual. • Review and follow all safety rules and safety decal • Be familiar with all controls, how each functions and instructions. what each operates. -
Page 12: Maintenance/ Storage
(for When replacement parts are required, use genuine example, a furnace or water heater pilot). Classen parts or parts with equivalent characteristics, including type, strength and material. Failure to do so Before the equipment is put into storage for any may result in product malfunction and possible injury to period exceeding 30 days. -
Page 13: Troubleshooting
TROUBLESHOOTING RA-21 TROUBLESHOOTING GUIDE PROBLEM POSSIBLE CAUSE CORRECTIVE ACTION Engine will not start. Out of gasoline. Fill gasoline tank. Spark plug lead wire loose or Reconnect spark plug lead wire. disconnected. Defective spark plug. Replace spark plug. Throttle control lever not in proper Move throttle control lever to start position. -
Page 14: Epa Fuel Information
EPA FUEL INFORMATION RA-21... - Page 15 EPA FUEL INFORMATION RA-21...
- Page 16 EPA FUEL INFORMATION RA-21...
-
Page 17: Epa Fuel Information
EPA FUEL INFORMATION RA-21 ITM PART NO. DESCRIPTION ITM PART NO. DESCRIPTION... -
Page 18: Warranty
Effective April 1, 2007 For the period of two years from the date of purchase, CLASSEN MFG., INC. will repair or replace for the original purchaser free of charge, any part or parts found upon the examination of our factory authorized service station, or by the factory in Norfolk, Nebraska, to be defective in material or workmanship. - Page 20 SCHV-18/8.0 60RT Classen reserves the right to make changes or add improvements to its products at any time without incurring any obligation to make such changes to products manufactured previously. Classen, or its dis- tributors and dealers, accept no responsibility for variations which may be evident in the actual specifi- cations of its products and the statements and descriptions contained in this publication.
Need help?
Do you have a question about the RA-21H and is the answer not in the manual?
Questions and answers