SERVICE MANUAL 21A71A 1、 Caution………………………………………………………………………2 2、 Specification…………………………………………………………………6 3、 Alignment Procedure……………… ………………………………… …10 4、 Schematic Diagram………………………… ……… ……………………20 5、 IC Brief Introduction………………………………………………………21 6、 PCB Layout…………………………………………………………………37 7、 Explode View Diagram………… …………………………………………38 8、 BOM list……………………………………………………………………39 This manual is the latest at the time of printing, and does not...
1、 CAUTION: Use of controls, adjustments or procedures other than those specified herein may result in hazardous radiation exposure. CA UTION: TO REDUCE THE RISK OF CAUTION ELECTRICAL SHOCK, DO NOT REMOVE COVER (OR BACK). NO USER SERVICEABLE RISK RISK OF OF ELECTRI ELECTRIC C PARTS INSIDE.
IMPORTANT SAFETY INSTRUCTIONS CAUTION: Read all of these instructions. Save these instructions for later use. Follow all Warnings and Instructions marked on the audio equipment. 1. Read Instructions- All the safety and operating instructions should be read before the product is operated. 2.
Page 4
PROTECTION AND LOCATION OF YOUR SET Do not use this television set near water ... for example, near a bathtub, washbowl, kitchen sink, or laundry tub, in a wet basement, or near a swimming pool, etc. Never expose the set to rain or water. If the set has been exposed to rain or water, unplug the set from the wall outlet and refer servicing to qualified service personnel.
OPERATION OF YOUR SET 18. This television set should be operated only from the type of power source indicated on the marking label. If you are not sure of the type of power supply at your home, consult your television dealer or local power company. For television sets designed to operate from battery power, refer to the operating instructions.
2、 Specification Model 机型 Item 内容 主要数据 Master Data -Customer ID -顾客ID 南美 -Destination SOUTH AMERICA -目的地 -Brand -牌子 -BOM NO. -BOM号 -Assembling Way Unit -走货方式 -Chassis M123SP -机芯号 接收 Reception -Tuning [Channels Amt.] -频道数量 -Tuning [Technology] -调谐技术 -Tuning [Indication] --------- -搜台指示...
Page 7
TCL-Thomson Electronics R D Center (Shen’Zhen Lab) Model 机型 Item 内容 -America SAP -美国SAP -Korea Stereo -韩国立体声 -Thai Bilingual -泰国双语 -Super Woofer -超重低音 -AVL -自动音量平衡 -Sound Control [General] -声音控制(普通的) Volume 音量 静音 Mute -Sound Control [Special] -声音控制(特殊的) 高音 Treble 低音...
Page 8
TCL-Thomson Electronics R D Center (Shen’Zhen Lab) Model 机型 Item 内容 -Number of Local Control(incl.Mains) -本机控制按键孔数量(包括主开关) -Number of Indicator Control(incl.Mains) -本机指示灯数量(包括主开关上的灯) Local Controls Front -正面的控制孔数量 电源开关 -Mains Switch -CH+ CH- VOL+ VOL- 频道+-,音量+- -TV/AV TV / AV -Menu 菜单 -Auto Search 自动搜台...
Page 9
TCL-Thomson Electronics R D Center (Shen’Zhen Lab) Model 机型 Item 内容 Carton Color 纸箱颜色 -Documents and Manuals -文件和手册 说明书 Instruction Book 屏幕贴纸 Screen Sticker 塑料袋 Plastic Bag 保修卡 Warranty Card Guarantee Doc. 保证书 警告标签 Warning Label Approbation Label 认证标签 其他...
3、 Alignment Procedure Table of Content Ⅰ. SUMMARIZE........................... 5 Ⅱ. ALIGNMENT CONTENTS: ....................6 1. A ....................6 DJUSTMENT OF VOLTAGE 2. RF AGC ......................6 ADJUSTMENT 3. S & F ................7 CREEN OCUS VOLTAGE ADJUSTMENT 4. 1 A NSTC DJUSTMENT OF CONTRAST...
M123SP Alignment Procedure Ⅰ. Summarize M123SP,is NTSC-PAL system model developed for TCL market specially. In trial run, burn the software to TMPA8873PSNG IC by OTP method. After the trial run, make the mask,please take care in production. T o solve the probable problems in production, for the workers participate in alignment, please be familiar with the Alignment Procedure, and be master of the features.
TCL-THOMSON Electronics R&D Center (Shen’Zhen Lab) Ⅱ. Alignment contents: 1. Adjustment of B+ voltage Receive Philips standard testing pattern to RF input. If the VR800 exists in the board, adjust it in STANDARD mode until voltage at following value: Model B+ (v) 110±2.0...
TCL-THOMSON Electronics R&D Center (Shen’Zhen Lab) 3. Screen & Focus voltage adjustment ① Apply pattern signal in normal status, enter Factory mode,press“INPUT” button to stop vertical scan. Note:(the RC/GC/BC is preset to be 40,GD/BD is 40) Adjust the SCRREEN switch on the flyback transformer to make a horizontal shining ②...
TCL-THOMSON Electronics R&D Center (Shen’Zhen Lab) equipment, white balance can be adjusted automatically as following: Press “BUS OFF” button under factory mode, the TV set will adjust automatically. standard: Warm X=310+8, Y=314+8 Cool X=278+8, Y=282+8 Remark: 1) Provided the production line is equipped with the self- White balance adjusting equipment, white balance of M123SP chassis can be adjusted automatically as following: Press “I2C BUS”...
TCL-THOMSON Electronics R&D Center (Shen’Zhen Lab) 8. PS line polartities test : Connect follow the graphic below: DC PS Sound reminder 2.2k PS socket M TO F801 Plug the PS line onto the PS socket M, then touch any pin of F801 with the probe, the LED DX will shine at the moment, with sound reminder, or it is disqualification.
TCL-THOMSON Electronics R&D Center (Shen’Zhen Lab) 10. High voltage and Ib value limit test( random test ) Instruments: High voltage meter, Ib meter. Input signal pattern: White vertical Input signal intensity: 60dBuv (1 Mv rms) Test means: Connect High voltage meter and Ib meter. Test voltage of different Ib separately, It should meet the requirements below:...
Page 17
TCL-THOMSON Electronics R&D Center (Shen’Zhen Lab) FAC 03 Data STRAP Model BLACK* BLACK* STRAP F0 SIF FREQ HL QG PIF FREQ HPOS6 HPOS5 南美 M123SP 20E10 Data FAC 04 Model CNTX CNTN BRTX BRTN COLX COLN TNTX TNTN 南美 M123SP...
Page 18
TCL-THOMSON Electronics R&D Center (Shen’Zhen Lab) Data FAC 10 Model CURTCEN VOLX PWTM MODE4 MODE5 MODE6 MODE7 MODE8 MODE9 南美 M123SP 20E10 Data FAC 11 Model CON1 CON2 CON3 STSADJ ALI 1 ALI 2 ALI3 南美 M123SP 20E10 Data FAC 12...
Page 19
TCL-THOMSON Electronics R&D Center (Shen’Zhen Lab) Data FAC 18 FAC 19 Model S-COL S-BRI S-CON S-SHP M-COL M-BRI M-CON M-SHP 南美 M123SP 20E10 Data FAC 20 Model SEG-POINT1 SEG-POINT2 DATA-VL DATA-VH DATA-UF SPE-POS1 SPE-DATA1 SENSI-ON SENSI-OFF 南美 M123SP 20E10 Data...
5、 IC Brief Introduction TOSHIBA Integrated Circuit TMPA8873PSNG TMPA8873CMNG /CPNG /CRNG /CSNG MCU and Signal Processor for a PAL/NTSC TV The TMPA8873CPNG is an integrated circuit for a PAL/NTSC TV. A MCU and a TV signal processor are integrated in a 64-pin shrink DIP package.
Page 22
Confidential TMPA8873PSNG /CMNG /CPNG /CRNG /CSNG Features CCD Decoder • High speed 8-bit CPU (TLCS-870/X series) • Digital data slicer for NTSC Instruction execution time: 0.5 µs (at 8 MHz) • (TMPA8873CPNG) • Clock generation for OSD display • 48-Kbytes ROM, 2-Kbytes RAM •...
Confidential TMPA8873PSNG /CMNG /CPNG /CRNG /CSNG Block Diagram P61/LED1/ADC8bit P63/LED2 P60/ADC8bit P30/Int3/RXIN P53/ADC8bit/TC1/Int2 P31/Int4/TC3 uP DVss P20/Int5/Stop Reset P40/PWM14bit P50/PWM7bit/TC2/Int0 P51/SCL TEST P52/SDA uP DVDD 5V uP VVss uP AVdd 5V TV DEF GND uP MPAGND TV Dig GND Hout Bout HAFC 1 Gout...
Page 24
Confidential TMPA8873PSNG /CMNG /CPNG /CRNG /CSNG Basic Structure 1. Internal Connections TMPA8873 has two pieces of IC chip in one package, using Multi-Chip-Package (MCP) technology. One is a micro controller (MCU) and the other one is a signal processor (SP) for a color TV. There are some internal connections between these two ICs for handling below signals.
Page 25
Confidential TMPA8873PSNG /CMNG /CPNG /CRNG /CSNG TERMINAL INTERFACE MCU BLOCK Pin Name Function Interface Circuit (/KWU5) (Input) Key on wake up input (AIN5) (Input) A/D converter analog input (LED1) (Output) LED output (/KWU4) (Input) Key on wake up input (AIN4) (Input) A/D converter analog input (/KWU0)
Page 26
Confidential TMPA8873PSNG /CMNG /CPNG /CRNG /CSNG Pin Name Function Interface Circuit Xout Output X’tal connecting pins Input TEST Input Test pin for out-going test Power up DVdd Supply Supply 5V Power ⎯ up VVss GND for Slicer circuit Supply Power ⎯...
Page 27
Confidential TMPA8873PSNG /CMNG /CPNG /CRNG /CSNG Pin Name Function Interface Circuit (SCL) (I/O) IIC bus serial clock input / output SIO serial data input (SI1) (Input) (/PWM8) (Output) 7-bit D/A conversion (PWM) output (TC2) (Input) Timer/Counter input (INT0) (Input) External interrupt input 14/12-bit D/A conversion (PWM) (/PWM0) (Output)
Page 28
Confidential TMPA8873PSNG /CMNG /CPNG /CRNG /CSNG Pin Name Function Interface Circuit External interrupt input (INT3) (Input) Remote control signal (RXIN) (Input) preprocessor input (LED2) (Output) LED output 2005/03/29...
Page 29
Confidential TMPA8873PSNG /CMNG /CPNG /CRNG /CSNG SIGNAL PROCESSOR BLOCK Pin Name Function Interface Circuit I/O Signal TV DEF GND terminal for TV DEF ⎯ ⎯ AGND block. FBP in Input terminal for FBP. 200Ω 10kΩ Output terminal for 50Ω H out Horizontal driving pulse.
Page 30
Confidential TMPA8873PSNG /CMNG /CPNG /CRNG /CSNG Pin Name Function Interface Circuit I/O Signal 1.5kΩ Y in Input terminal for Y signal. 1.5kΩ 11kΩ 5kΩ Cr in Input terminal for Cr signal. 5kΩ 35kΩ Input terminal for Audio Ext Au1 signal 1. 1.5kΩ...
Page 31
Confidential TMPA8873PSNG /CMNG /CPNG /CRNG /CSNG Pin Name Function Interface Circuit I/O Signal Output terminal 1 for Audio Au out 1 signal. Output terminal 2 for Audio Au out 2 signal. Output terminal for detected TV out PIF signal. 1bit DAC Output terminal for 1bit /SIF out DAC or detected SIF signal.
Page 32
Confidential TMPA8873PSNG /CMNG /CPNG /CRNG /CSNG Pin Name Function Interface Circuit I/O Signal Terminal to be connected 5kΩ Reg Fil capacitor for stabilizing 5kΩ internal bias. Output terminal for External AUDIO audio signal or TV audio Monitor out signal selected by BUS (Audio SW).
Page 33
Confidential TMPA8873PSNG /CMNG /CPNG /CRNG /CSNG Pin Name Function Interface Circuit I/O Signal Vcc terminal for Y/C circuit. ⎯ ⎯ YC Vcc 5V Supply 5V. Output terminal for Sync pulse. A pull up resister is required 5kΩ Sync out because of its open collector output.
Page 34
Confidential TMPA8873PSNG /CMNG /CPNG /CRNG /CSNG Signal Processor Descriptions 1. Tank-Coil-Less PIF VCO TMPA8873 adopts a tank-coil-less PIF VCO circuit, which has advantages of cost, performance of weak IF input and easy to design PCB layout. The PIF PLL system has self-alignment circuit, so that the micro controller needs only to order the PIF PLL system to start self-alignment through the IIC bus.
Page 35
Confidential TMPA8873PSNG /CMNG /CPNG /CRNG /CSNG 6. AV Switch The audio switch has two inputs for an external audio, and one for internal demodulated audio signal. The two external audio inputs can use as audio stereo input. The switched audio signal goes into the audio attenuator, which has controllability of audio gain from 0dB to –80dB or less with near log curve characteristic.
Page 36
Confidential TMPA8873PSNG /CMNG /CPNG /CRNG /CSNG 13. Signal Detection Flags There are some flags on the READ BUS registers. They indicate that a certain signal is detected at the moment. But reliability of a detection result is not so accurate if checking only one flag, so that confirming several flags, which means similar result by each other, at the same time is recommended.
PART NO. SEPC UNIT LOCATION 76-002091-0AT CARTON BOX LWH 624X384X556MM 0.006 PC 76-326350-01A CARTON SHEET 61X37X0.3CM 0.062 PC 11-0BC337-0BX TRANSISTOR (NPN) BC337-40 1 PC Q1501 13-C73C03-02B IC SC73C0302 1 PC IC1501 14-IRE05B-XX0 IR EMITTING DIODE TSAL6200 1 PC D1501 18-CB0221-JNX RES.
Page 40
10-1N4148-ABX DIODE 1N4148 (SWITCHING) 0.005 PC 10-1N4148-ABX DIODE 1N4148 (SWITCHING) 0.005 PC 10-1N4148-ABX DIODE 1N4148 (SWITCHING) 0.005 PC 10-1N4148-ABX DIODE 1N4148 (SWITCHING) 0.005 PC 10-1N4148-ABX DIODE 1N4148 (SWITCHING) 0.005 PC 10-1N4148-ABX DIODE 1N4148 (SWITCHING) 0.005 PC 10-79C18V-DBX DIODE ZENER 18V 1/2W 5% 0.005 PC 10-79C3V9-DBX DIODE ZENER 3V9 1/2W 5%...
Page 41
26-AKA221-KRX CAP. CER 220 PF 1KV +/-10% 0.005 PC 26-AKM221-KRX CAP. CER 220 PF 1KV +/-10% 0.005 PC 26-AMM102-KBX CAP. CER 1000 PF 2KV +/-10% B 0.005 PC 26-AMM561-KRX CAP. CER 560PF 2KV +/-10% 0.005 PC 26-APK222-MEX CAP. CER 2200PF 400VAC+/-20% E 0.005 PC 26-APK471-KBX CAP.
Page 42
T8-HS36R3-M123A M123SP REMOTE HANDSET ASS'Y(W/MSP) 1 PC 10-CW574C-DJX DIODE CW574CD 1 PC D101 11-4508DZ-0CX TRANSISTOR BU450DZ 1 PC Q402 13-TDA486-4AS IC TDA4864AJ 1 PC IC301 13-TEA202-5BP IC TEA2025B2X2W 1 PC IC601 18-EE0109-JS2 RES. FUS. 1 OHM 1/2W +/-5% 1 PC R405 18-EE0109-JS2 RES.
Page 43
18-KF0825-JHX RES. GLASS GLAZE 8.2M OHM 1W 1 PC R829 18-RG0108-JHX RES. WIRE ROUND 0.1 OHM 2W +/-5% 1 PC R815 22-NTC479-XX0 NTC 4.7 OHM +/-18% NTC4.7D2-14 1 PC R803 22-PTC909-3A5 PTC 9 OHM 1 PC RT801 25-BDA222-M1S CAP. ELEC 25V/2200UF/+/-20% 1 PC C843 25-BMJ151-M1X...
Page 44
57-FGPA71-XX2 SHINE AUREOLE 1 PC 59-312160-000 SPEAKER RUBBER CUSHION 8 PC MTG SPK MTG KEY BD & PUSH 63-B30100-AB4G S/T SCREW B 3 X 10 AB 4 PC BUTTON 63-B30100-AB4G S/T SCREW B 3 X 10 AB 2 PC MTG KEY BD & F. CAB. MTG CRT METAL &...
Page 45
47-RCA003-XX0G RCA SOCKET AV-8.4-6 (YELLOW) 1 PC P1101 47-RCA017-XX0G RCA JACK RED (RCA-101P) (THREE FEET) 1 PC P1103 02-IRR001-XX1S TCL02-IRR001-XX1S= 02-IRR001-XX1S = IR R 1 PC IR1101 P1101C FOR M. BD 46-31788H-02XG HS 2P22 350 TJC3-2Y/SCN-2Y 1 PC P001 P1101E FOR KEY BD 46-33079W-04XG PIN BASE *4 TJC3-4A 1 PC...
Page 46
10-79C5V1-DBX DIODE ZENER 5V1 1/2W 5% 1 PC D216 10-79C6V2-DBX DIODE ZENER 6V2 1/2W 5% 1 PC D207 +TO GND,""-""TO 10-79C8V2-DBX DIODE ZENER 8V2 1/2W 5% 1 PC J405&R406" 11-KTD863-0BX TRANSISTOR KTD863 1 PC Q401 18-CB0101-JNX RES. C.F. 100 OHM 1/6W +/-5% 1 PC R009 18-CB0102-JNX...
Page 47
25-BDB102-M1X CAP.ELEC 1000UF 25V+/-20%13*22 1 PC C413 25-BDB470-M1X CAP. ELEC 47 UF 25V +/-20% 1 PC C419 25-BEB100-M1X CAP. ELEC 10 UF 35V +/-20% 1 PC C441 25-BEB101-M1X CAP. ELEC 100 UF 35V +/-20% 1 PC C302 25-BFB101-M1X CAP. ELEC 100 UF 50V +/-20% 1 PC C106 25-BFB109-M1X...
Page 48
41-WJ0075-B00 WIREBAREJUMPER7.5MM 1 PC J903 41-WJ0075-B00 WIREBAREJUMPER7.5MM 1 PC J913 41-WJ0075-B00 WIREBAREJUMPER7.5MM 1 PC J920 41-WJ0075-B00 WIREBAREJUMPER7.5MM 1 PC J201 41-WJ0075-B00 WIREBAREJUMPER7.5MM 1 PC J005 41-WJ0075-B00 WIREBAREJUMPER7.5MM 1 PC J021 41-WJ0075-B00 WIREBAREJUMPER7.5MM 1 PC J911 41-WJ0075-B00 WIREBAREJUMPER7.5MM 1 PC J203 41-WJ0075-B00 WIREBAREJUMPER7.5MM 1 PC...
Page 49
41-WJ0150-B00 WIREBAREJUMPER15MM 1 PC R027 41-WJ0150-B00 WIREBAREJUMPER15MM 1 PC J008 41-WJ0150-B00 WIREBAREJUMPER15MM 1 PC J102 41-WJ0150-B00 WIREBAREJUMPER15MM 1 PC J215 41-WJ0150-B00 WIREBAREJUMPER15MM 1 PC J412 41-WJ0150-B00 WIREBAREJUMPER15MM 1 PC J908 41-WJ0150-B00 WIREBAREJUMPER15MM 1 PC J1002 41-WJ0150-B00 WIREBAREJUMPER15MM 1 PC JP402 41-WJ0150-B00 WIREBAREJUMPER15MM 1 PC...
Page 50
10-1N4148-ABX DIODE 1N4148 (SWITCHING) 1 PC D814 10-1N4148-ABX DIODE 1N4148 (SWITCHING) 1 PC D819 10-79C18V-DBX DIODE ZENER 18V 1/2W 5% 1 PC D821 10-79C7V5-DBX TCL10-79C7V5-DBX= DIODE ZENER 7V5 1/2W 5 1 PC D844 11-CA8550-DBX TRANSISTOR 8550D-TO-92(PNP) 1 PC Q846 11-SA1015-YBX TRANSISTOR ST2SA1015Y (PNP) 1 PC Q801...
Page 51
41-WJ0075-B00 WIREBAREJUMPER7.5MM 1 PC J917 10-1N4004-EBX DIODE IN4004 (RECTIFIER) 1 PC D504 10-1N4148-ABX DIODE 1N4148 (SWITCHING) 1 PC D501 10-1N4148-ABX DIODE 1N4148 (SWITCHING) 1 PC D502 11-SA1015-YBX TRANSISTOR ST2SA1015Y (PNP) 1 PC Q510 11-TC3207-0BX TRANSISTOR KTC3207 1 PC Q503 11-TC3207-0BX TRANSISTOR KTC3207 1 PC Q502...
Page 52
41-WJ0060-B00 WIREBAREJUMPER6MM 1 PC R1103 41-WJ0060-B00 WIREBAREJUMPER6MM 1 PC R1115 41-WJ0090-B00 WIRE BARE JUMPER 9MM 1 PC J1105 66-382330-0B7 RIVET 2.0X3.7X3.5 2 PC FOR P802 66-382330-0B7 RIVET 2.0X3.7X3.5 2 PC FOR P801 41-WJ0080-B00 WIREBAREJUMPER8MM 1 PC JP801 41-WJ0080-B00 WIREBAREJUMPER8MM 1 PC JP802 71-BAR004-XX0 BAR CODE LABEL 102X51 MM...
Page 53
19-AB0102-JTX RES SMD 1K OHM 1/10W 0603 0 PC R901 19-AB0102-JTX RES SMD 1K OHM 1/10W 0603 0 PC R609 19-AB0102-JTX RES SMD 1K OHM 1/10W 0603 0 PC R920 19-AB0102-JTX RES SMD 1K OHM 1/10W 0603 0 PC R922 19-AB0102-JTX RES SMD 1K OHM 1/10W 0603 0 PC...
Page 54
28-AB0101-JCX SMD. CAP 100 PF 50VDC +/-5% 0 PC C002 28-AB0101-JCX SMD. CAP 100 PF 50VDC +/-5% 0 PC C103 28-AB0101-JCX SMD. CAP 100 PF 50VDC +/-5% 0 PC C107 28-AB0101-JCX SMD. CAP 100 PF 50VDC +/-5% 0 PC C001 28-AB0102-KBX SMD.
Page 55
28-AB0103-KBX SMD. CAP 0.01 UF 50V +/-10% 0603 0 PC C1033 28-AB0103-KBX SMD. CAP 0.01 UF 50V +/-10% 0603 0 PC C1031 28-AB0103-KBX SMD. CAP 0.01 UF 50V +/-10% 0603 0 PC C1011 28-AB0104-KBX SMD. CAP 50VDC 0.1UF +/-10% 06 0 PC C1012 28-AB0104-KBX...
Page 56
28-AB0473-KBX SMD CAP 0.047UF 50V +/-10%0603 0 PC C811 12-BC847A-0BX SMD TRANSISTOR BC847A (NPN) 0 PC Q951 19-AB0103-JTX RES SMD 10K OHM 1/10W 0603 0 PC R911 19-AB0103-JTX RES SMD 10K OHM 1/10W 0603 0 PC R952 19-AB0472-JTX RES SMD 4.7K OHM 1/10W 0603 0 PC R900 28-AB0102-KBX...
Need help?
Do you have a question about the 21A71A and is the answer not in the manual?
Questions and answers