Table of Contents
Advertisement
Quick Links
FOUR BURNER GAS GRILL
Assembly/Installation Instructions and Use & Care Guide
For questions about features, operation/performance, parts call: 1-800-229-5647 or visit www.sureheat.com
Table of Contents..............................................................................................................................2
IMPORTANT:
Save for local inspector's use.
Installer: Leave installation instructions with the homeowner.
Homeowner: Keep installation instructions for future reference.
MODEL SF34LP
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Surefire SF34LP
Summary of Contents for Surefire SF34LP
- Page 1 Assembly/Installation Instructions and Use & Care Guide For questions about features, operation/performance, parts call: 1-800-229-5647 or visit www.sureheat.com Table of Contents..........................2 IMPORTANT: Save for local inspector’s use. Installer: Leave installation instructions with the homeowner. Homeowner: Keep installation instructions for future reference. MODEL SF34LP...
-
Page 2: Table Of Contents
TABLE OF CONTENTS OUTDOOR GRILL SAFETY ......3 UNPACKING INSTRUCTIONS ......5 ASSEMBLY REQUIREMENTS ......5 Parts Supplied.............5 ASSEMBLY INSTRUCTIONS ......6 INSTALLATION REQUIREMENTS ....11 Location Requirements ..........11 Gas Supply Requirements ........11 Gas Connection Requirements ......... 11 INSTALLATION INSTRUCTIONS ....11 Make Gas Connection .......... -
Page 3: Outdoor Grill Safety
OUTDOOR GRILL SAFETY Your safety and the safety of others are very important. We have provided many important safety messages in this manual and on your appliance. Always read and obey all safety messages. This is the safety alert symbol. This symbol alerts you to potential hazards that can kill or hurt you and others. -
Page 4: Important Safety Instructions
IMPORTANT: This grill is manufactured for outdoor use only. For grills that are to be used at elevations above 2000 ft (609.6 m) orifice conversion is required. See “Gas Supply Requirements” section. It is the responsibility of the installer to comply with the minimum installation clearances specified on the model/serial rating plate. -
Page 5: Unpacking Instructions
UNPACKING INSTRUCTIONS Using a utility knife, cut the tape to open the top flaps of the Remove the plastic bag from the grill head. carton. Remove the Assembly/ Installation Instructions and Use and Care Guide. Remove the cardboard panel on the top. Remove the corner Excessive Weight Hazard supports on the top of the inside of the carton. -
Page 6: Assembly Instructions
Assembly Hardware Supplied Assembled Grill View ■ 43 - Self-Tapping screws ■ 6 - Phillips pan head screws M6 x 10 ■ 8 - Phillips pan head screws M6 x 40 ■ 2 - Phillips sunken head screws ■ 1 - Side burner knob with bezel ■... - Page 7 Assemble cart back Assemble middle bar 1. Place the middle bar between left cart and cart middle, and 1. Tilt the grill cart assembly up. Use six (6) self-tapping scews then tighten the four (4) self-tapping screws to fix it. to secure the cart back to the cart base.
- Page 8 Tilt the top of the door toward the grill while depressing the Assemble the drawers top door pivot pin. Move the door slightly until the pin snaps into place in the Lay the drawer on the floor, and use one Phillips pan head hole at the bottom of the front face.
- Page 9 Assemble side shelf Lay the side shelf left assembly on its side. NOTE: Be careful not to scratch the sides of the shelf. Place a piece of styrofoam from the packaging inside the roll top hood propped open slightly. Loosen four bolts on the left of the grill head assembly by Large holding bracket approximately 1/4”.
- Page 10 Complete grill assembly Place the side burner cap and grate on to the side burner tray. A. Side burner grate Attach the drip pan holder to two holding brackets. Then slide drip pan into place. A. Drip pan holder B. Drip pan Insert the flavor grids into the cutouts with triangle ridges facing up.
-
Page 11: Installation Requirements
INSTALLATION REQUIREMENTS Location Requirements Gas Supply Requirements Observe all governing codes and ordinances. IMPORTANT: This installation must conform with all local codes and ordinances. In the absence of local codes, installation must conform with American National Standards Institute, National Fuel Gas Code ANSI Z223.1 - latest edition. Explosion Hazard IMPORTANT: Grill must be connected to a regulated gas supply. -
Page 12: Installation Instructions
INSTALLATION INSTRUCTIONS Gas Connection Requirements Check the Burners The burners are tested and factory-set for most efficient operation. However, variations in gas supply and other conditions may make minor adjustments to air shutter or low flame setting necessary. It is recommended that a qualified person make burner adjustments. -
Page 13: Outdoor Grill Use
OUTDOOR GRILL USE This manual covers several different models. The grill you have purchased may have some or all of the features listed. The locations and appearances of the features shown here may not match those of your model. Control Panel Main Burner Control Knob 1 Igniter Button Main Burner Control Knob 2... -
Page 14: Using Your Side Burner
Remove match and replace manual lighting extension. Turn the Gas Supply On IMPORTANT: If burner does not light immediately, turn the burner knob to OFF For outdoor grills using a 20 lb. LP gas fuel tank: Slowly open and wait 5 minutes before relighting. the tank valve. -
Page 15: Tips For Outdoor Grilling
Using Your Side Burner Manually lighting the side burner Do not lean over the grill. Remove the manual lighting extension and attach a match to the split ring. Strike the match to light it. Guide the match to the burner Burn Hazard Do not let the burner flame extend beyond the edge of the pan. -
Page 16: Outdoor Grill Care
OUTDOOR GRILL CARE GRILL GRATES Replacing the Igniter Battery IMPORTANT: Do not use a steel or fiber scraper on grill grates. If igniters stop sparking, the battery should be replaced. Immediately after you are finished cooking, loosen food soil with Unscrew igniter button cap counter-clockwise to remove. -
Page 17: Troubleshooting
TROUBLESHOOTING SIDE BURNER CAPS AND GRATE ■ Grill will not light Cleaning Method: ■ Clean with a brass bristle brush. ■ Wash grate using mild detergent, warm water and degreaser. ■ Is the 20 lb LP gas fuel tank valve turned off? ■... -
Page 18: Replacement Parts
REPLACEMENT PARTS Manifold & Valve Hood Assembly Assembly SASCD00534B RCOZZ00532A 1 set 1 set Hood Handle Assembly Side Burner Shelf SASQG00005A SASCD00530B 1 set 1 set Temperature Gauge Large Bezel RCOZZ00029A RCOAG00003A 1 piece 1 piece Bread Warming Rack Large Knob RCORC00011A RCOFE00001A 1 piece... - Page 19 REPLACEMENT PARTS Side Shelf Cart Back SASCD00526B SBNCD00545A 1 set 1 set Igniter Right with 5 Poles Tank Fixing Ring RCOZZ00027A RCOZE00015A 1 piece 1 piece Regulator Drawer RCOZZ00125A SASCD00541A 1 set 1 set Drip Pan Middle bar RCOCC00004A SBNJB00213A 1 piece 1 set Cart left...
-
Page 20: Not Shown
Main Burner Igniter w/ wire 400mm RCOZZ00213A Main Burner Igniter w/ wire 540mm RCOZZ00214A Main Burner Igniter w/ wire 740mm Caster Swivel With Lock RCOZZ00218A RCOZZ00215A Main Burner Igniter w/ wire 920mm 1 set RCOZZ00316A “Surefire” Logo Caster Swivel RCOZZ00219A 1 set... -
Page 21: Warranty
LIMITED WARRANTY Sure Heat Manufacturing warrants that for 2 years from the date of purchase, the stainless panels will not break due to defects in material or workmanship. All other components of this grill are warranted free from defects in material and workmanship for one year from the date of purchase. Sure Heat Manufacturing at its option, will repair or replace this product or any component of the product found to be defective during the warranty period.
Need help?
Do you have a question about the SF34LP and is the answer not in the manual?
Questions and answers