Before You Start; What To Do If You Smell Gas - KitchenAid KGCT305E Installation Instructions Manual

30" (76.2cm) Cooktop
21-3/4'_dth- 30-3/4" (78.1cm)
(65 2cm)___
30" (76.2cm) min. base cabinet is required. If
cabinet has a drawer, a 3-1/2" (8.9cm) depth
clearance from the countertop to the top of the
drawer (or other obstruction) in base cabinet is
required,
36" (91.4cm) Cooktop
Depth --
21-3/4"
36" (91.4cm) min. base cabinet is required. If
cabinet has a drawer, a 3-1/2" (8.9cm) depth
clearance from the countertop to the top of the
drawer (or other obstruction) in base cabinet is
required.
It is the customer's responsibility:
• To contact a qualified electrical installer.
• To assure that electrical installation is
adequate and in conformance with
National Electrical Code, ANSI/NFPA 70
m latest edition**, or Canadian Electrical
Code, C22.1 -1982 and C22.2 No. 01982
(or latest edition)*** and all local codes
and ordinances.
Fire Hazard
Do Not obstruct the flow of combustion
and ventilation air.
injury Hazard
To eliminate the risk of burns or fire, avoid
installing cabinet storage above the
cooking surface, if cabinets are already
installed, reduce the hazard of reaching
over a heated cooking surface by installing
a range hood. The range hood should
extend a minimum of 5 inches (12.7cm) out
from the bottom front of the cabinets.
Reaching over a heated cooking surface
could result in a serious burn or other
personal injury.
Electrical Shock Hazard
Take special care when drilling holes into
the wall for electrical wiring. Electrical
wires may be concealed behind the wall
covering.
Failure to follow this instruction could
result in death, fire, or electrical shock.
For 30" (76.2cm) cooktop - 30" (76.2cm)
min. cabinet width above cooktop
For 36" (91.4cm) cooktop - 36" (91,4cm)
-41--_ min, cabinet width above cooktop
See Note * for
minimum
clearances
_F_ 13"
(33.Ocm)
up%
cabinet
depth
18" (45.7cm) min, clearance
upper cabinet to countertop
-t.
314"
(1.gcm)
min.
Burner box
height -- 2-112"
(6.4cm)
Wall _as line
opening -- 5"
(12.7cm) below
countertop and
centered with
cooktop
Do Not pinch the power
supply cord between the
cook'top and cabinets.
Wall
receptacle
12" (30.5cm)
max. from
right side of
cooktop
i
16" (38,1cm) max.
from bottom of
countertop
Note: 30" (76.2cm) min. when bottom of wood or
metal cabinet is protected by not less than 1/4"
(.6cm) flame retardant millboard covered with
not less than No. 28 MSG sheet steel, 0.015"
(.04cm) stainless steel, 0.024" (.06cm) aluminum
or 0.020" (.05cm) copper.
36" (91.4cm) min. clearance between the top of
the cooking platform and the bottom of an
unprotected wood or metal sheet.
\
A
B
C
D
30" (76.2cm)
Cooktop:
18-15/16" (48.1cm)
min. opening depth
27-3/16" (69.1cm)
min. opening width
2-518" (6.7cm) min.
cabinet space to
backsplash or
vertical wall
5-1/4" (13.3cm)
min. cabinet space
both sides of
cooktop from a
combustible
surface
36" (91.4cm)
Cooktop:
A 18-15/16..
(48.1cm)
rain. opening depth
B
33-7/16" (84.9cm)
min. opening width
C 2-5/8" (6.7cm) min.
cabinet space to
backsplash or
vertical wall
D 5-1/4"
( 13.3cm)
min. cabinet
space both sides
of cooktop from a
combustible
surface
Minimum distance
to nearest side and
rear combustible
surface above
countertop
Before you start,,,
WARNING: If the information
in this manual is not followed
exactly, a fire or explosion
may result causing property
damage, personal injury or
death.
Do Not store or use gasoline
or other flammable vapors
and liquids in the vicinity of
this or any other appliance.
m WHAT TO DO IF YOU SMELL
GAS
• Do Not try to light any
appliance.
• Do Not touch any electrical
switch; do not use any phone
in your building.
• Immediately call your gas
supplier from a neighbor's
phone. Follow the gas
supplier's instructions.
• If you cannot reach your gas
supplier, call the fire
department.
Installation and service must
be performed by a qualified
installer, service agency or
the gas supplier.
Important: Observe all governing codes and
ordinances.
Proper installation is your responsibility Make
sure you have everything necessary for correct
installation. It is the responsibility of the installer
to comply with the installation clearances
specified on the model/serial rating plate. The
model/serial rating plate can be found on the
underside of the cooktop burner box.
Check location where cooktop will be installed.
The location should be away from strong draft
areas, such as windows. The cooktop should be
located for convenient use in the kitchen.
ALL OPENINGS IN THE WALL OR FLOOR
WHERE THE COOKTOP IS TO BE INSTALLED
MUST BE SEALED.
Grounded electrical outlet is required. See
"Electrical requirements."
Proper gas supply connection must be
available. See "Gas supply requirements."
Note: The sealed gas cooktop is manufactured
for use with NATURAL gas. Conversion to L.P.
gas can be made with Kit No. 4173627, available
from your KitchenAid dealer or authorized parts
distributor.
Countertop opening dimensions that are
shown must be used. Given dimensions provide
required 0" (0cm) clearance.
Cabinet construction: This appliance is
designed for use in a base cabinet with a depth
of 24" (61cm). The maximum depth for overhead
cabinets is 13" (33cm). The minimum vertical
clearance between the cooking surface and the
overhead cabinets is 30" (76.2cm). Overhead
cabinets installed at either side of the appliance
must be a minimum of 18" (45.7cm) above the
cooking surface. The minimum distance between
the front edge of the countertop and the front
edge of the cooktop is 3/4" (1.9cm). The
minimum horizontal distance between the
overhead cabinets above the appliance are
shown for your model number.
New installations -- follow minimum
dimensions given.
Replacement installations -- Be sure that front
edge of cooktop is at least 1-1/2" (3.8cm) back
from front edge of countertop.
When installing cooktop over a built-under
oven. Do Not fasten cooktop to countertop with
clamps. Cooktop then will be easy to remove if
servicing is ever necessary.
** National Fire Protection Association
Batterymarch Park
Quincy, Massachusetts 02269
***Canadian Standard Association
178 Rexdale Boulevard
Etobicoke, Ontario M9W 1 R3
Panel A