Scheduled Maintenance - Hummer Oreion HX-T Owner's Manual

OREION™ HUMMER HX-T™ OWNERS MANUAL
Scheduled Maintenance Procedures
Daily Inspection By Owner
Weekly Inspection By Owner
Monthly Inspection By The
Owner or a Qualified
Technician
Quarterly Inspection
Items By The Owner or a
Qualified Technician
Semi – Annual Inspection
Items To Be Carried Out By a
Qualified Technician Only
Annual Inspection Items to
be Carried Out By a Qualified
Technician Only
Accelerator Pedal Check for normal operation
Battery Pack Check the batteries as per page 15 of this manual and fill
them to the proper levels as described on page 15 of this
manual
Brake System Check for normal operation – have your dealer service if
required
Parking Brake Check for normal operation – have your dealer service if
required
Reverse Check for normal operation – have your dealer service if
required
Key Switch & Check for normal operation – have your dealer service if
Drive Selection required
Tires/Tyres Check the tire pressures and look for any damage or
wear – replace if required
Battery Pack Check the batteries as per page 15 of this manual
Wiring Check all wiring is secure and consult a technician to
replace any damaged wires
Entire Cart Check for any damaged, loose or missing parts
Check all items included in the above mentioned daily checks
Battery Pack Clean the top areas of the battery pack with soda water
(WARNING - do not allow this into the battery)
Service the Brake Check the brake fluid level, if required use DOT 3 rated
System fluid to replenish
Check the brake lines and park brake lines for any
damage – have your dealer service if required
Check all the items included in the above mentioned daily/weekly checks
Rear Axle Check and fill if required with hypoid gear oil
Entire Cart Lubricate as per the chart on page 20 of this manual
Check all the items included in the above mentioned daily, weekly and
monthly checks
Battery Pack Check the specific gravity level, the electrolyte level and
general state of the battery pack after performing an
equalization charge
Service Brake Inspect the fluid reservoir as required (DOT 3)
System
Check the brake pads, discs, shoes and drums – replace
them if necessary
Wires Inspect all wiring and connections
Switches Inspect all switches for full operation
Front Wheel Check and adjust if needed
Alignment
Entire Cart Lubricate as per the chart on page 17 of this manual
Check all the items included in the above mentioned daily, weekly, monthly
and quarterly checks
Battery Pack Carry out discharge, test and full recharge
Motor Check the motor brushes and replace if necessary
Front Wheel Adjust and repack bearings if required
Bearings
19