Equipment Description; Safety Rules - Generac Power Systems 6500XL 09779-2 Owner's Manual

Generac Portable P roducts 6500XL E xtended LifeGenerator
EQUIPMENT
DESCRIPTION
This generator is an engine-driven, revolving field,
alternating current (AC) generator. It was designed to
supply electrical power for operating compatible electrical
lighting, appliances,tools and motor loads.This manual
contains informationfor a generator that operates
120 and/or 240 Volt, single phase,60 Hz devices that
require up to 6,500 watts (6.5 kW) of power that pull up
to 54.2 Amps at 120Volts or 27.1Amps at 240Volts.
CAUTION! Do Not exceed the generator's
wattage/amperage capacity.Add up the rated watts of all
devices you are
connecting to
generator
receptacles at one
time.This total should not be greater than 6,500 watts. See
"Don't Overload the Generator" on page 10.
The generator's revolving field is driven at about 3,600 rpm
by a single-cylinder engine.
Every effort has been made to ensure that informationin
this manual is accurate and current However, Generac
reserves the right to change,alter or otherwise improve the
product and this document at any time without prior
notice.
_ AUTION! Do Not tamper with engine
governed speed. High operating speeds are
dangerous and increaserisk of personal injuryor
damageto equipment.The generator supplies
correct rated frequency and voltage only when
running at proper governed speed. Incorrect
frequency and/or voltage can damagesome
connected electrical loads. Operating at excessively
low speeds imposesa heavy load.When adequate
engine power is not availableengine life may be
shortened.
SAFETY RULES
This generator set was designed and manufactured for
specific applications. Do Not attempt to modify the unit or
use it for any application it was not designed for. If you have
any questions about your generator's application, ask your
dealer or consult the factory.
The manufacturer could not possibly anticipate every
circumstance that might involvea hazard. For that reason
warnings in the manual and warnings on tags or decals
affixed to the unit are not all-inclusive. If you intend to
handle, operate or service the unit by a procedure or
method not specifically recommended by the manufacturer,
first make sure that such a procedure or method will not
render this equipment unsafe or pose a threat to you and
others.
Read this manual carefully and become familiar
with your generator set. Know its applications, its
limitations and any hazards involved.
_ ANGER! You must isolatethe generator from
the electric utility using approved transfer
equipment if this unit is used for backup power.
Failure to isolate the generator from the
power utility may result in injury or death to
electric utility workers and damage to the
generator due to a backfeed of electrical energy.
Whenever unit is providing backup power, the
electric utility must be notified.
_ DANGER! Generator exhaust gases contain
DEADLY carbon monoxide gas. If breathed in
sumcient concentrations, carbon monoxide
can cause unconsciousness or death. Operate
this equipment outdoors where adequate ventilation
is available.
The Emission Control System for this generator is
warranted for standards set by the Environmental
Protection Agency.For warranty information refer to the
engine owner's manual.
/
2