Advertisement
This symbol is intended to
alert the user to the pres-
ence of uninsulated "dan-
gerous voltage" within the
RISK OF ELECTRIC SHOCK
product's enclosure that may be of suf-
ficient magnitude to constitute a risk of
electric shock to persons.
IMPORTANT! FOR YOUR PROTECTION, PLEASE READ THE FOLLOWING:
WATER AND MOISTURE: Appliance should not be used near water (near a bathtub, washbowl,
kitchen sink, laundry tub, in a wet basement, or near a swimming pool, etc). Care should be taken
so that objects do not fall and liquids are not spilled into the enclosure through openings.
POWER SOURCES: The product should be connected to a power supply only of the type described
in the operating instructions or as marked on the appliance.
GROUNDING OR POLARIZATION: Precautions should be taken so that the grounding or polar-
ization is not defeated.
POWER CORD PROTECTION: Power supply cords should be routed so that they are not likely
to be walked on or pinched by items placed upon or against them, paying particular attention
to cords at plugs, convenience receptacles, and the point where they exit from the appliance.
SERVICING: The user should not attempt to service the appliance beyond that described in the
operating instructions. All other servicing should be referred to qualified service personnel.
FUSING: If your unit is equipped with a fuse receptacle, replace only with the same type fuse.
Refer to replacement text on the unit for correct fuse type.
SAFETY INSTRUCTIONS (EUROPEAN)
The conductors in the AC power cord are colored in accordance with the following code.
GREEN & YELLOW—Earth
U.K. MAIN PLUG WARNING: A molded main plug that has been cut off from the cord is
unsafe. NEVER UNDER ANY CIRCUMSTANCES SHOULD YOU INSERT A DAMAGED
OR CUT MAIN PLUG INTO A POWER SOCKET.
Parts List for TS100
Carvin P/N
GUARD FAN PLASTIC 80x80mm
03-90080
PWR AC 3/16AWG 8' 2" W/PLUGS
05-01603
CABLE RIBBON 24AWG 4PIN 102MM
05-24102
CABLE RIBBON 24A 8P/16" W/HDR
05-68440
CABLE ASSY, 5C 110MM
05-85611
KNOB CHROME W/BLACK LINE
07-77710
RETAINING CLIP EL34/5881
10-00034
CHASSIS 2 SPACE UNIVERSAL
10-10008E
FRONT PANEL TS100
10-10111A
BRACKET TS100
10-10117B
LID DCM POWER AMPS
10-82005
TRANSFRMER OUTPUT 60W
15-02066
POWER TRANSFORMER 120VAC
15-10714
ROCKER SWITCH 16A 250V AC
25-31351
TUBE POWER EL34
65-00034
12AX7 PRE AMP TUBE
65-00127
FAN DC24V 80mm X 80mm X 25mm 4
70-02408A
MANUAL TS100
76-10111A
LABEL REAR TS100
77-10111A
Parts List for Printed Circuit Card
Ref. Des.Description
Carvin P/N
C1
CAP POLY .1000UF 100VOLT 10%
46-10412
C10
CAP POLY .0010UF 100VOLT 10%
46-10212
C11
CAP POLY .0470UF 400VOLT 10%
41-47343
C12
CAP ELEC 82UF 500V 20%
42-82052
C13
CAP ELEC 2,200 MFD 6.3V 20%
47-22260
C14
CAP ELEC 2,200 MFD 6.3V 20%
47-22260
C15
CAP POLY .0047UF 400VOLT 10%
41-47242
C16
CAP CERM 180PF 500VOLT 5%
45-18152
C17
CAP CERM 82PF 500VOLT 5%
45-82052
C18
CAP POLY .0100UF 100VOLT 10%
46-10312
C19
CAP POLY .0100UF 100VOLT 10%
46-10312
C2
CAP POLY .0010UF 100VOLT 10%
46-10212
C20
CAP POLY .0010UF 100VOLT 10%
46-10212
C21
CAP ELEC 470 MFD 25VOLT 20%
47-47125
C22
CAP ELEC 1,000 MFD 25V 20%
47-10225
C23
CAP ELEC 1,000 MFD 25V 20%
47-10225
c24
CAP CERM 82PF 500VOLT 5%
45-82052
C25
CAP CERM 250PF 500VOLT 5%
45-25152
C26
CAP CERM 250PF 500VOLT 5%
45-25152
C27
CAP CERM 250PF 500VOLT 5%
45-25152
C28
CAP CERM 250PF 500VOLT 5%
45-25152
C3
CAP POLY .0047UF 400VOLT 10%
41-47242
C37
CAP POLY .1000UF 100VOLT 10%
46-10412
C39
CAP POLY .0470UF 400VOLT 10%
41-47343
C4
CAP POLY .1000UF 100VOLT 10%
46-10412
C40
CAP POLY .0470UF 100V 10% PREP
46-47312-1
C41
CAP CERM 56PF 500VOLT 5%
45-56052
C42
CAP MYLR .0470UF 630VOLT 10%
41-47362
C43
CAP MYLR .0470UF 630VOLT 10%
41-47362
C44
CAP ELEC 47 MFD 63VOLT 20%
47-47061
C45
CAP MYLR .0470UF 630VOLT 10%
41-47362
C49
CAP ELEC 82UF 500V 20%
42-82052
C5
CAP CERM 56PF 500VOLT 5%
45-56052
C50
CAP ELEC 82UF 500V 20%
42-82052
C52
CAP ELEC 82UF 500V 20%
42-82052
C53
CAP MYLR .0470UF 630VOLT 10%
41-47362
C6
CAP POLY .0470UF 100V 10% PREP
46-47312-1
C7
CAP MYLR .0470UF 630VOLT 10%
41-47362
C70
CAP CERM 180PF 500VOLT 5%
45-18152
C8
CAP MYLR .0470UF 630VOLT 10%
41-47362
C9
CAP ELEC 47 MFD 63VOLT 20%
47-47061
D1
DIODE RECT GEN 1N4007 1000V 1A
61-10000
D10
DIODE RECT GEN 1N4007 1000V 1A
61-10000
D12
DIODE RECT GEN 1N4007 1000V 1A
61-10000
D14
DIODE RECT GEN 1N4007 1000V 1A
61-10000
D15
DIODE RECT GEN 1N4007 1000V 1A
61-10000
D16
DIODE RECT GEN 1N4007 1000V 1A
61-10000
D2
DIODE RECT GEN 1N4007 1000V 1A
61-10000
D3
DIODE RECT GEN 1N4007 1000V 1A
61-10000
D4
LED BLUE DIFFUSED 3MM T-1.00
60-75350
D5
DIODE RECT GEN 1N4007 1000V 1A
61-10000
D6
DIODE RECT GEN 1N4007 1000V 1A
61-10000
This symbol is
CAUTION
intended to alert the
user to the presence of
important operating
DO NOT OPEN
and maintenance (servicing) instruc-
tions in the literature accompanying
the appliance.
BLUE—Neutral
BROWN—Live
D7
DIODE RECT GEN 1N4007 1000V 1A
D8
DIODE RECT GEN 1N4007 1000V 1A
D9
DIODE RECT GEN 1N4007 1000V 1A
F1
FUSEHOLDER CLIPS 3AG VERT MTG
H1
CONNECT HEADER .086" 9 PIN
H2
CONNECT HEADER .100" 2 PIN
H3A
CONNECT HEADER 8 PIN STRAIGHT
H3B
CONNECT HEADER 8 PIN STRAIGHT
H4A
CONNECT HEADER 4 PIN STRAIGHT
H4B
CONNECT HEADER 4 PIN STRAIGHT
H5A
CONNECT HEADER .086" 5 PIN
H5B
CONNECT HEADER .086" 5 PIN
J1
JACK .250 MONO PLASTIC W/INSER
J2
JACK .250 MONO PLASTIC W/INSER
J3
JACK .250 MONO PLASTIC W/INSER
J4
JACK .250 MONO PLASTIC W/INSER
J5
JACK .250 MONO PLASTIC W/INSER
J6
JACK .250 MONO PLASTIC W/INSER
K1
RELAY DPDT 2AMP@30V/5VDC COIL
P1
POT VERT TRIMMER 20K 20%
P11
POT VERT TRIMMER 20K 20%
P2
POT 16 "R" RX.250-5A500K METAL
P3
POT 16 "R" RX.250-5A500K METAL
P4
POT 16 "R" RX.250-25A25K MTL
P5
POT 16 "R" RX.250-25A25K MTL
PL1
RECEPTACLE AC W/FAST-ON CHASS
Q1
REGULATOR VOLTAGE 5 +V 1 AMP
QC1
TERMINAL VERT MALE PC MTG .250
QC10
TERMINAL 90dg MALE PC MTG .250
QC11
TERMINAL 90dg MALE PC MTG .250
QC12
TERMINAL 90dg MALE PC MTG .250
QC16
TERMINAL VERT MALE PC MTG .250
QC2
TERMINAL VERT MALE PC MTG .250
QC26
TERMINAL 90dg MALE PC MTG .250
QC28
TERMINAL 90dg MALE PC MTG .250
QC3
TERMINAL VERT MALE PC MTG .250
QC31
TERMINAL VERT MALE PC MTG .250
QC32
TERMINAL VERT MALE PC MTG .250
QC33
TERMINAL VERT MALE PC MTG .250
QC4
TERMINAL 90dg MALE PC MTG .250
QC5
TERMINAL 90dg MALE PC MTG .250
QC51
TERMINAL 90dg MALE PC MTG .250
QC52
TERMINAL 90dg MALE PC MTG .250
QC53
TERMINAL 90dg MALE PC MTG .250
QC54
TERMINAL 90dg MALE PC MTG .250
QC6
TERMINAL 90dg MALE PC MTG .250
QC7
TERMINAL VERT MALE PC MTG .250
QC8
TERMINAL 90dg MALE PC MTG .250
QC9
TERMINAL 90dg MALE PC MTG .250
R1
RES 220.00KOHM .25W 5% CARBON
R10
RES 100.00KOHM .25W 5% CARBON
R11
RES 22.00KOHM .25W 5% CARBON
R12
RES 100.00KOHM .25W 5% CARBON
R13
RES 100.00KOHM .25W 5% CARBON
R14
RES 220.00KOHM .25W 5% CARBON
R15
RES 220.00KOHM .25W 5% CARBON
R16
RES 68.00KOHM .25W 5% CARBON
R17
RES 100.00KOHM .25W 5% CARBON
R18
RES 47.00KOHM .25W 5% CARBON
R19
RES 100.00KOHM .25W 5% CARBON
R2
RES 220.00KOHM .50W 5% CARBON
R20
RES 220.00KOHM .25W 5% CARBON
R21
RES 220.00KOHM .50W 5% CARBON
R22
RES 100.00 OHM .25W 1% METAL
R23
RES 1.50KOHM .25W 5% CARBON
R24
RES 100.00KOHM .25W 5% CARBON
R25
RES 100.00 OHM .25W 1% METAL
R26
RES 10.00KOHM .25W 5% CARBON
R27
RES 4.70KOHM .25W 5% CARBON
R28
RES 4.70KOHM .25W 5% CARBON
R29
RES 100.00 OHM .25W 1% METAL
R3
RES 1.50KOHM .25W 5% CARBON
R30
RES 4.70KOHM 1.00W 5% CARBON
R31
RES 220.00KOHM .50W 5% CARBON
R32
RES 100.00KOHM .25W 5% CARBON
LIMITED WARRANTY
Your Carvin product is guaranteed against failure for ONE YEAR unless otherwise stated. Carvin
will service and supply all parts at no charge to the customer providing the unit is under war-
ranty. Shipping costs are the responsibility of the customer. CARVIN DOES NOT PAY FOR PARTS
OR SERVICING OTHER THAN OUR OWN. A COPY OF THE ORIGINAL INVOICE IS REQUIRED
TO VERIFY YOUR WARRANTY. Carvin assumes no responsibility for horn drivers or speakers
damaged by this unit. This warranty does not cover, and no liability is assumed, for damage due
to: natural disasters, accidents, abuse, loss of parts, lack of reasonable care, incorrect use, or
failure to follow instructions. This warranty is in lieu of all other warranties, expressed or implied.
No representative or person is authorized to represent or assume for Carvin any liability in con-
nection with the sale or servicing of Carvin products. CARVIN SHALL NOT BE LIABLE FOR INCI-
DENTAL OR CONSEQUENTIAL DAMAGES.
SERVICE
In the USA, please call 800-235-2235 for a RMA # (return authorization number). Write this number
on the box and enclose a description of the problem. Prepay to Carvin 12340 World Trade Drive, SD,
CA 92128.
Outside the USA, contact your dealer or go to http://www.carvinworld.com for your nearest service
center. Include a written description of the problem with serial number and date of purchase.
HELP SECTION
1) AMP WILL NOT TURN ON
Check the power to the amp. Check for tripped circuit breakers, unplugged extension cords or power-
strip switches that may be turned off. Check the fuse. If a dark brownish color or no wire can be
seen within the glass tube, then replace. The amp may be perfectly fine but occasionally a fuse may
blow because of high AC voltage surges. After the fuse has been replaced with the proper Slow Blow
value and if the fuse fails again, the amp will require servicing.
2) NO OUTPUT with POWER LIGHT ON
Tubes damaged in shipping will be the primary reason for your amp to not function properly. Please
give us a call to help guide you through this simple repair.
3) KEEP YOUR AMP LOOKING NEW
Use a damp cloth to wipe the controls on the front & rear chassis panels. Wipe the black vinyl cov-
ering with a damp cloth.
CAUTION
RISK OF ELECTRIC SHOCK
61-10000
R33
RES 100.00KOHM .25W 5% CARBON
61-10000
R35
RES 220.00 OHM .25W 5% CARBON
61-10000
R36
RES 0.00 OHM .35X.20" JUMPER
23-03529
R37
RES 100.00KOHM .25W 5% CARBON
23-08609
R38
RES 100.00KOHM .25W 5% CARBON
23-10002
R39
RES 470.00KOHM .25W 5% CARBON
23-11008
R4
RES 100.00KOHM .25W 5% CARBON
23-11008
R40
RES 220.00KOHM .25W 5% CARBON
23-11004
R41
RES 47.00KOHM .25W 5% CARBON
23-11004
R42
RES 10.00KOHM .25W 5% CARBON
23-08605
R43
RES 22.00KOHM .25W 5% CARBON
23-08605
R44
RES 22.00KOHM .25W 5% CARBON
21-51346
R45
RES 100.00KOHM .25W 5% CARBON
21-51346
R46
RES 560.00 OHM .25W 5% CARBON
21-51346
R47
RES 100.00KOHM .25W 5% CARBON
21-51346
R48
RES 100.00KOHM .25W 5% CARBON
21-51346
R49
RES 100.00KOHM .25W 5% CARBON
21-51346
R5
RES 220.00KOHM .25W 5% CARBON
70-05305
R50
RES 220.00KOHM .25W 5% CARBON
71-22012
R51
RES 220.00KOHM .25W 5% CARBON
71-22012
R52
RES 220.00KOHM .25W 5% CARBON
71-14060
R53
RES 68.00KOHM .25W 5% CARBON
71-14060
R54
RES 100.00KOHM .25W 5% CARBON
71-14050
R55
RES 220.00KOHM .50W 5% CARBON
71-14050
R56
RES 2.20KOHM 1.00W 5% CARBON
21-31100
R57
RES 350.00 OHM 10W 10% SB SDOF
60-78050-1
R58
RES 1.00KOHM .25W 5% CARBON
06-40050
R59
RES 1.00KOHM .25W 5% CARBON
06-40060
R6
RES 220.00KOHM .25W 5% CARBON
06-40060
R7
RES 22.00KOHM .25W 5% CARBON
06-40060
R70
RES 4.70KOHM .25W 5% CARBON
06-40050
R71
RES 4.70KOHM .25W 5% CARBON
06-40050
R72
RES 350.00 OHM 5W 5% SB SDOF
06-40060
R73
RES 350.00 OHM 5W 5% SB SDOF
06-40060
R74
RES 4.70KOHM .25W 5% CARBON
06-40050
R75
RES 4.70KOHM .25W 5% CARBON
06-40050
R76
RES 350.00 OHM 5W 5% SB SDOF
06-40050
R77
RES 350.00 OHM 5W 5% SB SDOF
06-40050
R78
RES 100.00 OHM .25W 1% METAL
06-40060
R79
RES 100.00 OHM .25W 1% METAL
06-40060
R8
RES 100.00KOHM .25W 5% CARBON
06-40060
R9
RES 560.00 OHM .25W 5% CARBON
06-40060
R91
RES 10.00KOHM .25W 5% CARBON
06-40060
S1
SWITCH DP3T PC MTG EXT PC LEGS
06-40060
S2
SWITCH DPDT SELECT PC EXT LEGS
06-40060
S3
SWITCH DPDT SELECT PC EXT LEGS
06-40050
S4
SWITCH DP3T PC MTG EXT PC LEGS
06-40060
S5, S7 SWITCH DPDT PUSH PC MTG LOCKNG
06-40060
S6
SWITCH DPDT SELECT PC EXT LEGS
50-22055
S8
TERMINAL VERT FEML PC MTG .250
50-10055
V1
SOCKET TUBE 9PIN 12AX7/EL84
50-22045
V2
SOCKET TUBE 9PIN 12AX7/EL84
50-10055
V3
SOCKET TUBE 9PIN 12AX7/EL84
50-10055
V4
SOCKET TUBE 9PIN 12AX7/EL84
50-22055
V6
SOCKET TUBE 8PIN EL34/5881/6L6
50-22055
V7
SOCKET TUBE 8PIN EL34/5881/6L6
50-68045
V8
SOCKET TUBE 8PIN EL34/5881/6L6
50-10055
V9
SOCKET TUBE 8PIN EL34/5881/6L6
50-47045
50-10055
52-22055
50-22055
52-22055
50-10021
50-15035
50-10055
50-10021
50-10045
50-47035
50-47035
50-10021
50-15035
53-47035
52-22055
50-10055
REFER SERVICING TO QUALIFIED SER-
VICE PERSONNEL! THIS UNIT CON-
TAINS HIGH VOLTAGE INSIDE!
50-10055
50-22025
50-00035
50-10055
50-10055
50-47055
50-10055
50-22055
50-47045
50-10045
50-22045
50-22045
50-10055
50-56025
50-10055
50-10055
50-10055
50-22055
50-22055
50-22055
50-22055
50-68045
50-10055
52-22055
53-22035
56-35010
50-10035
50-10035
50-22055
50-22045
50-47035
50-47035
56-35025
56-35025
50-47035
50-47035
56-35025
56-35025
50-10021
50-10021
50-10055
50-56025
50-10045
25-76286
25-62656
25-62656
25-76286
25-02201
25-62656
06-40040
23-91632
23-91632
23-91632
23-91632
23-26400
23-26400
23-26400
23-26400
Advertisement
