1. Manuals
  2. Brands
  3. Samsung Manuals
  4. Cell Phone
  5. SGH-D600
  6. Service manual

Samsung SGH-D600 Service Manual

Gsm telephone
Hide thumbs Also See for SGH-D600:
Table of Contents

Advertisement

Quick Links

See also: User Manual
GSM TELEPHONE
GSM TELEPHONE
SGH-D600
1.
2.
3.
4.
5.
6.
7.
CONTENTS

Advertisement

Table of Contents
loading

Related Manuals for Samsung SGH-D600

Summary of Contents for Samsung SGH-D600

  • Page 1: Table Of Contents

    GSM TELEPHONE SGH-D600 CONTENTS GSM TELEPHONE Specification Circuit Description Exploded Views and Parts List Electrical Parts List Block Diagrams PCB Diagrams Flow Chart of Troubleshooting...
  • Page 2 ⓒ Samsung Electronics Co.,Ltd. September. 2005 This Service Manual is a property of Samsung Electronics Co.,Ltd. Any unauthorized use of Manual can be punished under applicable Printed in Korea. International and/or domestic law. Code No.: GH68-08500A BASIC.

  • Page 3: Specification

    0pcl ~ 15pcl 0pcl ~ 15pcl Sensit ivit y - 102dBm -102dBm -102dBm -100dBm - 100dBm TDMA Mux Cell Radius 35Km 35Km 35Km SAMSUNG Proprietary-Contents may change without notice This Document can not be used with out Samsung' s authorization...

  • Page 4: Gsm Tx Power Class

    9±5 dBm 6±4 dBm 7±3 dBm 4±4 dBm 7±5 dBm 4±4 dBm 5±3 dBm 2±5 dBm 5±5 dBm 2±5 dBm 0±5 dBm 0±5 dBm SAMSUNG Proprietary-Contents may change without notice This Document can not be used with out Samsung' s authorization...

  • Page 5: Circuit Description

    LO suppression, quadrature phase error, quadrature amplitude balance and low noise floor specification. Output matching/balun components drive a standard 50 ohms single ended load. SAMSUNG Proprietary-Contents may change without notice This Document can not be used with out Samsung' s authorization...
  • Page 6 "FLIP" informs the status of slide (open or closed) to the PCF5213EL1. This uses the hall effect IC, EM-1681 A magnet under LCD enables EM-1681. SAMSUNG Proprietary-Contents may change without notice This Document can not be used with out Samsung' s authorization...
  • Page 7 I2S signals from CL8522S5 are decoded with audio analog signals. SAPA1D2-24ELP amplify these signals and deliver to stereo speakers. 2-2-8. Memory This system uses Samsung's memory, KBH10PD00M-D414. The KBH10PD00M is a Multi Chip Package Memory which combines 256Mbit Synchronous Burst Multi Bank NOR Flash Memory and two 1Gbit OneNAND Flash and 256Mbit Synchronous Burst UtRAM.
  • Page 8 It can save the raw RGB data up to 1600x1200 into its image buffer and allows the host processor to download with scalable sized compressed data. SAMSUNG Proprietary-Contents may change without notice This Document can not be used with out Samsung' s authorization...
  • Page 9 QMP01 QAU01 QMO01 QCA01 QLC01 QME02 QSP02 QSP01 QAN06 QAN05 QCR32 QAN02 QFL01 QCK01 QCR26 QRE01 QSC11 QIF01 QVO01 QHI01 QCR31 QRF01 QBA01 QPC01 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung' s authorization...

  • Page 10: Exploded Views And Parts List

    SPEAKER;0.7W,8.0ohm,87dB±2dB,700Hz, 3001-001788 ¡ ¡ QAN02 INTENNA-SGHD600;EWPADG006A,SGH-D600, GH42-00596A ¡ ¡ QFL01 MEC-SLIDE LOWER;SGH-D600,EU,-,-,-,-, GH75-07210A ¡ ¡ QCR32 SCREW-MACHINE;CH,+,M1.4,L2,ZPC(BLK), 6001-001700 ¡ ¡ QHI01 MEC-HINGE MODULE;SGH-D600,EU,-,-,-,- GH75-07211A SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung' s authorization...
  • Page 11 MPR-B TO B CON SIDE EMI;SGH-D600,DTF GH74-16883A MPR-TAPE IF HOLDER;SCH-V740,FABRIC T GH74-17165A MPR-TAPE BASE BTB;SGH-D600,TASA 4962 GH74-18234A AS-INTENNA FRONT GASKET;SGH-D600,-,G GH81-02279A AS-INTENNA REAR GASKET;SGH-D600,-,GA GH81-02280A SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung' s authorization...
  • Page 12 3-3. Test Jig (GH80-01909A) (GH39-00283A) 3-3-2. Test Cable 3-3-3. Serial Cable 3-3-4. Power Supply Cable (GH39-00337C) 3-3-5. DATA CABLE 3-3-6. TA 3-3-7. TV-OUT Cable (GH39-00423A] (GH44-00954A) (GH39-00410A) SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung' s authorization...

  • Page 13: Electrical Parts List

    C508, C 701, C 702, C 703 C-CERAMIC, C HIP 2203-000679 C601 C-TA, C HIP 2404-001392 C602, C 604, C 617, C 706 C-CERAMIC, C HIP 2203-005482 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung' s authorization...
  • Page 14 LED604, L ED605, L ED606 0601-002055 MIC600 MIC-CONDENSOR 3003-001107 OSC300 CRY S TAL-UNIT 2801-004340 OSC400 CRY S TAL-UNIT 2801-004339 Q401, U 201, U 202, U 203 TR-DIGITAL 0504-001151 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung' s authorization...
  • Page 15 2007-008964 R806 R-CHIP 2007-007313 R811, R 812, R 813 R-CHIP 2007-000170 SIM400 CONNECTOR-CARD EDGE 3709-001357 U100 1205-002709 U102 OSCILLATOR-VCTCXO 2809-001302 U103 1201-002223 U200 1205-002751 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung' s authorization...
  • Page 16 DIODE-Z E NER 0403-001427 Z D 600 DIODE-TVS 0406-001190 Z D 601 DIODE-TVS 0406-001104 Z D 701, Z D 702, Z D 703 DIODE-TVS 0406-001208 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung' s authorization...

  • Page 17: Block Diagrams

    TXON 60/114 MHz GSM Tx SYNON FESWON Br y c e P a r k HC . K I M DCS/PCS APC Block SAMSUNG Proprietary-Contents may change without notice This Document can not be used with out Samsung' s authorization...
  • Page 18 KE Y _ BOA RD GP O VCHG RTC _CLOCK Char gi ng Circ ui t SIM CARD (32. 768KH z) VSAV E SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...

  • Page 19: Pcb Diagrams

    6. PCB Diagrams 6-1. PCB Top Diagram SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung' s authorization...
  • Page 20 PCB Diagrams 6-2. PCB Bottom Diagram SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung' s authorization...

  • Page 21: Flow Chart Of Troubleshooting

    Check for the clock at C116 = 26MHz (related to U100) Y e s Check the initial operation Y e s 7- 1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...
  • Page 22 _REC2 GND 51 C423 NC 53 2.9V +VDD_IO_HIGH C424 1.8V +VDD_IO_LOW C425 C424(VDD_IO_HIGH) C425(VDD_IO_LOW) R408 2.15V MIC_BIAS C426 RSTON IT_PMU SIMIO 7- 2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...
  • Page 23 TP100 VCCMIX CLKOUT1 D_REF_CLK VCCMASH CLK2CONT VCCLNA RF_CLK VCCCLK CAPQB R106 VCCBUF CAPQ 26MHz Cl o c k C120 VCCBB CAPIB 7- 3 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...
  • Page 24 Is U200 R211 , R212 OK ? Check the U200 Y e s Check the 16bit data signal & memory CE Y e s 7- 4 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...
  • Page 25 KEY_ROW(1) R214 KROW1 KEY_ROW(2) KROW2 KEY_ROW(3) KROW3 KEY_ROW(4) KROW4 KEY_COL(0) KCOL0 KEY_COL(1) KCOL1 KEY_COL(2) KCOL2 KEY_COL(3) KEY_ROW(0:4) KCOL3 KEY_COL(4) KCOL4 KEY_COL(0:4) 7- 5 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...

  • Page 26: Charging Part

    U501 pin 8 = " L " ? AUX_ON signal Y e s Check the U501 pin 10 Resolder or replace U501 ¡ Ö 4.2V Y e s 7- 6 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...
  • Page 27 C505 C506 +VBUS ZD501 3 _PPR GND 8 AUX_ON USBON 7 _CHG END_OF_CHG USB_CHG_ON IMIN CHG_ON R517 R518 C507 BATTERY CHARGING 7- 7 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...

  • Page 28: Sim Part

    Replace PBA CN400 pin 2 = " H (SIM_RST) " ? Y e s Check the SIM Card Y e s 7- 8 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...
  • Page 29 Flow Chart of Troubleshooting SIM400 2-292292-7 SIM_VCC SIM_IO SIM_CLK SIM_RST C418 C419 C422 7- 9 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...

  • Page 30: Microphone Part

    Y e s U601 is OK? Check the U601 Y e s Check the MIC Replace the MIC Y e s 7- 10 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...
  • Page 31 C607 MIC_IN_N MIC_IN_N MIC_IN_P C608 MIC_SEL ZD600 MIC_BIAS C601 R601 L601 C602 MIC_SEL_P MIC_P C604 R604 C605 MIC_SEL_N MIC_N L602 R605 7- 11 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...
  • Page 32 4, 6 , 1 6, 1 8 of U804 Y e s Check the Speaker Peplace Speaker inside Intena contact pins Y e s 7- 12 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...
  • Page 33 C814 C811 C812 R810 R811 C815 C816 R812 R813 R805 R806 C821 C822 STEREO SPEAKER Same Routing to SPK_L / SPK_R 7- 13 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...

  • Page 34: Key Data Input

    When one of the keys is pushed, Replace the PBA KEY _ ROW(0.4) KEY _ COL(0.4) signal is OK ? Y e s 7- 14 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...

  • Page 35: Receiver Part

    SPK + , S PK- PAD of the LCD Module Y e s change Receiver Is it working? Y e s 7- 15 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...
  • Page 36 Flow Chart of Troubleshooting 7- 16 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...

  • Page 37: Lcd Part

    Check the board to board Change the board to board FPC Y e s Check LCD Module Is it working? Y e s 7- 17 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...
  • Page 38 Flow Chart of Troubleshooting 7- 18 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...

  • Page 39: Camera Part

    Check the related circuit of U301 of CN701 Y e s Is it working ? Change Camera Module Y e s 7- 19 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...

  • Page 40: Trans Flash Card Part

    Check the 2 pin of Check the related circuit CN500 is high Y e s Is it working ? Change T-Flash Card Y e s 7- 20 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...
  • Page 41 NTSC or ¡ æ DISPLAY -> TV out Y e s Other multimedia function Change the PBA work well? Y e s 7- 21 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...
  • Page 42 V+ 6 T_OUT SIN0 STROBE SOUT0 TESTMODE R313 ENABLE TP312 C_PWDN XCTS0 C_PWDN R314 TP315 TV_OUT +VDD_TV XRTS0 M_RESET_N IMAGE_RST C320 7- 22 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...

  • Page 43: Bluetooth Part

    Check the contact of Check the contact pin Bluetooth Intenna Y e s Is it working ? Change the Bluetooth Module Y e s 7- 23 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...
  • Page 44 TP308 CTS2 BT_HOST_WAKE UART_RTS_N HOST_WAKE TP316 PCM_IN EEPROM_DATA|GPIO_6 TP317 RXD2 UART_TXD LPO_IN 32KHz_DIGIT VDD_CORE USB_DETACH|GPIO_7 XTAL_PD|COEX_1 C322 +VDD_IO_LOW R315 TXD2 TP310 7- 24 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...

  • Page 45: Main Key Led Part

    Y e s Check the R612, R 613, R 614, R 615, Y e s Is it working ? Y e s 7- 25 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...
  • Page 46 Flow Chart of Troubleshooting 7- 26 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung ' s authorization...

Table of Contents