GSM TELEPHONE SGH-D600E CONTENTS GSM TELEPHONE Specification Circuit Description Exploded Views and Parts List Electrical Parts List Block Diagrams PCB Diagrams Flow Chart of Troubleshooting...
Page 2
ⓒ Samsung Electronics Co.,Ltd. October. 2005 This Service Manual is a property of Samsung Electronics Co.,Ltd. Any unauthorized use of Manual can be punished under applicable Printed in Korea. International and/or domestic law. Code No.: GH68-08640A BASIC.
5pcl ~ 19pcl 0pcl ~ 15pcl 0pcl ~ 15pcl Sensit ivit y - 102dBm -102dBm - 100dBm - 100dBm TDMA Mux Cell Radius 35Km 35Km SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
LO suppression, quadrature phase error, quadrature amplitude balance and low noise floor specification. Output matching/balun components drive a standard 50 ohms single ended load. SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 8
"FLIP" informs the status of slide (open or closed) to the PCF5213EL1. This uses the hall effect IC, EM-1681 A magnet under LCD enables EM-1681. SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 9
I2S signals from CL8522S5 are decoded with audio analog signals. SAPA1D2-24ELP amplify these signals and deliver to stereo speakers. 2-2-8. Memory This system uses Samsung's memory, KBH10PD00M-D414. The KBH10PD00M is a Multi Chip Package Memory which combines 256Mbit Synchronous Burst Multi Bank NOR Flash Memory and two 1Gbit OneNAND Flash and 256Mbit Synchronous Burst UtRAM.
Page 10
It can save the raw RGB data up to 1600x1200 into its image buffer and allows the host processor to download with scalable sized compressed data. SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 11
QKP02 QMP01 QAU01 QMO01 QCA01 QLC01 QME02 QSP02 QSP01 QAN06 QAN05 QCR32 QAN02 QFL01 QCK01 QCR26 QRE01 QSC11 QIF01 QVO01 QHI01 QCR31 QRF01 QBA01 QPC01 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
QVK01 UNIT-VOLUME KEY;SGH-D600,SGH-D600 V/ GH59-02207A QVO01 PMO-VOLUME KEY;SGH-D600,PC(K2261),BL GH72-22445A QFL01 MEC-SLIDE LOWER;SGH-D600,EU,-,-,-,-, GH75-07210A QCR32 SCREW-MACHINE;CH,+,M1.4,L2,ZPC(BLK), 6001-001700 QHI01 MEC-HINGE MODULE;SGH-D600,EU,-,-,-,- GH75-07211A SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 13
MPR-B TO B CON SIDE EMI;SGH-D600,DTF GH74-16883A MPR-TAPE IF HOLDER;SCH-V740,FABRIC T GH74-17165A MPR-TAPE BASE BTB;SGH-D600,TASA 4962 GH74-18234A AS-INTENNA FRONT GASKET;SGH-D600,-,G GH81-02279A AS-INTENNA REAR GASKET;SGH-D600,-,GA GH81-02280A AS-SPEAKER;SGH-D600,BMS-171210SL08,- GH81-02319A SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 14
3-3. Test Jig (GH80-01909A) (GH39-00283A) 3-3-2. Test Cable 3-3-3. Serial Cable 3-3-4. Power Supply Cable (GH39-00337C) 3-3-5. DATA CABLE 3-3-6. TA 3-3-7. TV-OUT Cable (GH39-00423A] (GH44-00954A) (GH39-00410A) SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
2203-006208 C424,C425 C-CERAMIC,CHIP 2203-006257 C502 C-CERAMIC,CHIP 2203-005503 C504 C-CERAMIC,CHIP 2203-000854 C506 C-TA,CHIP 2404-001268 C602,C604,C617,C706 C-CERAMIC,CHIP 2203-005482 C609 C-CERAMIC,CHIP 2203-002443 C615 C-CERAMIC,CHIP 2203-001405 C616 COMP-SMD NEW-IC002 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 16
2703-002774 L601,L602 CORE-FERRITE BEAD 3301-001438 L603 CORE-FERRITE BEAD 3301-001534 L803,L804,L806,L807 INDUCTOR-SMD 2703-002201 L809,L810,L812,L813 INDUCTOR-SMD 2703-002201 L815,R102,R110,R112 R-CHIP 2007-000171 LED601,LED602,LED603 0601-002055 LED604,LED605,LED606 0601-002055 MIC600 MIC-CONDENSOR 3003-001107 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 17
2007-000138 R616,R617,R704,R705 R-CHIP 2007-000138 R619 R-CHIP 2007-001339 R712 R-CHIP 2007-008964 R803,R804,R805,R806 R-CHIP 2007-007313 R811,R812,R813 R-CHIP 2007-000170 SIM400 CONNECTOR-CARD EDGE 3709-001357 U101 OSCILLATOR-VCTCXO 2809-001294 U102 1205-002819 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 18
1405-001138 V707,V708,V709,V710 VARISTOR 1405-001138 V711,V712,V713 VARISTOR 1405-001138 V717,V718,V721 VARISTOR 1405-001082 ZD500 DIODE-ZENER 0403-001547 ZD501 DIODE-ZENER 0403-001427 ZD600 DIODE-TVS 0406-001190 ZD601 DIODE-TVS 0406-001104 ZD701,ZD702,ZD703 DIODE-TVS 0406-001208 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
5. Block Diagrams 5-1. RF Solution Block Diagram UAA3587EHN FAR-F5EA-897M50-D27CH LMSP54HA-350 FAR-F5EA-897M50-D27CH FAR-F5EA-897M50-D27CH FESW1 FESW2 FESW3 Tx(GSM900) Tx(DCS1800/1900) L(H) Rx(GSM900) Rx(DCS1800) Rx(DCS1900) FAR-F5EA-897M50-D27CH BGY290E SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 20
Block Diagrams 5-2. BT Solution Block Diagram SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 21
(26MHz) VINT IOVDD MV319DNQ RAMP VDD_RX_TX VCC_SYN 1G OneNAND MEMORY MIC_BIAS CPVDD Li-Ion Battery (Slim,Standard) SIMEN KEY_BOARD VCHG RTC_CLOCK Charging Circuit SIM CARD (32.768KHz) VSAVE SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 22
Block Diagrams SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
6. PCB Diagrams 6-1. PCB Top Diagram SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung' s authoriz a tion...
Page 24
PCB Diagrams 6-2. PCB Bottom Diagram SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung' s authoriz a tion...
Check f o r the clock at C116 = 26MHz (related to U100) Check the initial operation 7- 1 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Page 26
NC 53 2.9V +VDD_IO_HIGH C424 1.8V +VDD_IO_LOW C425 C424(VDD_IO_HIGH) C425(VDD_IO_LOW) R408 2.15V MIC_BIAS C426 RSTON IT_PMU SIMIO 7- 2 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Page 27
VCCMASH CLK2CONT VCCLNA RF_CLK VCCCLK CAPQB R106 VCCBUF CAPQ 26MHz Cl o c k C120 VCCBB CAPIB 7- 3 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Page 28
Is U200 R211 , R212 OK ? Check the U200 Check the 16b i t data signal & memory CE 7- 4 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Page 29
KROW2 KEY_ROW(3) KROW3 KEY_ROW(4) KROW4 KEY_COL(0) KCOL0 KEY_COL(1) KCOL1 KEY_COL(2) KCOL2 KEY_COL(3) KEY_ROW(0:4) KCOL3 KEY_COL(4) KCOL4 KEY_COL(0:4) 7- 5 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
U501 pin 8 = " L " ? AUX _ ON signal Check the U501 pin 10 Resolder or replace U501 ¡ Ö 4.2V 7- 6 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Page 31
3 _PPR GND 8 AUX_ON USBON 7 _CHG END_OF_CHG USB_CHG_ON IMIN CHG_ON R517 R518 C507 BATTERY CHARGING 7- 7 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
A f t er SIM card insert , Replace PBA CN400 pin 2 = " H (SIM_RST) " ? Check the SIM Card 7- 8 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Page 33
Flow Chart o f Trou b l eshooting SIM400 2-292292-7 SIM_VCC SIM_IO SIM_CLK SIM_RST C418 C419 C422 7- 9 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Resolder the C602 , C604 , L600 and L601 U601 is OK? Check the U601 Check the MIC Replace the MIC 7- 10 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Page 35
C608 MIC_SEL ZD600 MIC_BIAS C601 R601 L601 C602 MIC_SEL_P MIC_P C604 R604 C605 MIC_SEL_N MIC_N L602 R605 7- 11 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Page 36
4, 6 , 1 6, 1 8 of U804 Check the Speaker Peplace Speaker inside Intena contact pins 7- 12 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Page 37
R811 C815 C816 R812 R813 R805 R806 C821 C822 STEREO SPEAKER Same Routing to SPK_L / SPK_R 7- 13 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
W h en one of the keys is pushed, Replace the PBA KEY_ROW ( 0.4) KEY_COL(0.4) signal is OK ? 7- 14 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Resoldering of the wire SPK+ , S PK- PAD o f the LCD Module change Receiver Is it working? 7- 15 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Page 40
Flow Chart of Troub l eshooting 7- 16 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Check the b o ard to b o ard Change the b o ard to b o ard FPC Check LCD Module Is it working? 7- 17 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Page 42
Flow Chart of Troub l eshooting 7- 18 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Check the 5 , 7 pins clock Check the related circuit o f U301 of CN701 Is it working ? Change Camera Module 7- 19 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Check the 2 pin of Check the related circuit CN500 is high Is it working ? Change T-Flash Card 7- 20 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Page 45
NTSC or ¡ æ DISPLAY -> TV out Other multimedia f u nction Change the PBA work well? 7- 21 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Page 46
STROBE SOUT0 TESTMODE R313 ENABLE TP312 C_PWDN XCTS0 C_PWDN R314 TP315 TV_OUT +VDD_TV XRTS0 M_RESET_N IMAGE_RST C320 7- 22 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Check the contact o f Check the contact pin Bluetooth Intenna Is it working ? Change the Bluetooth Module 7- 23 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Page 48
HOST_WAKE TP316 PCM_IN EEPROM_DATA|GPIO_6 TP317 RXD2 UART_TXD LPO_IN 32KHz_DIGIT VDD_CORE USB_DETACH|GPIO_7 XTAL_PD|COEX_1 C322 +VDD_IO_LOW R315 TXD2 TP310 7- 24 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Check the U602 is high Check the R612, R 613, R 614, R 615, Is it working ? 7- 25 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
> = 2 .7V RF26MH z , RF PSU Part Resolder U102 C144 , C145 > = 1V Check U200 7- 26 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
U102 , R103 , R 105 , R 106 > = 2 .7V RF26MH z , RF PSU Part Resolder U102 Check U200 7- 27 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
RF26MH z , RF PSU Part Resolder U102 C144 , C 145 > = 1V Check U200 7- 28 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
RF26MH z , RF PSU Part Resolder U102 C144 , C 145 > = 1V Check U200 7- 29 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Page 54
U102 , R103 , R 105 , R 106 > = 2 .7V RF26MH z , RF PSU Part Resolder U102 Check U200 7- 30 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Page 55
Flow Chart o f Trou b l eshooting 7- 31 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...
Page 56
Flow Chart of Troub l eshooting 7- 32 SAMSUNG Proprietary-Contents may change without notice This Document can not b e used without Samsung ' s authori z a tion...