Volvo C30 Wiring Diagram
  1. Manuals
  2. Brands
  3. Volvo Manuals
  4. Automobile
  5. C30 - ANNEXE 798
  6. Wiring diagram

Volvo C30 Wiring Diagram

2007
Hide thumbs Also See for C30:
Table of Contents

Advertisement

Quick Links

Download this manual See also: Owner's Manual, Wiring Diagram
VOLVO C30
WIRING DIAGRAM
2007
TP 39103202

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the C30 and is the answer not in the manual?

Questions and answers

Andrew
March 17, 2025

have replaced maf sensor following a dtc, but still have the same code as a permanent code. How is this permanent code removed. C30 d2 diesel.

0
1 comments:
Mr. Anderson
March 17, 2025

To remove the permanent DTC code from a Volvo C30 D2 diesel after replacing the MAF sensor, follow these steps:

1. Ensure Proper Installation – Verify that the new MAF sensor is correctly installed and securely connected.
2. Clear Codes with a Scanner – Use an OBD-II scanner to clear any stored codes from the Engine Control Module (ECM).
3. Drive Cycle Completion – Drive the vehicle through a complete cycle, allowing the ECM to run its self-diagnostic checks and confirm that the issue is resolved.
4. Check for Pending Codes – If the code persists, ensure there are no vacuum leaks, weak turbo issues, or other related faults.
5. Reset ECM (if needed) – Disconnect the battery for a few minutes to reset the ECM, though this may not always remove permanent codes.
6. Verify Readiness Monitors – Ensure all monitors pass, as permanent codes require successful drive cycles to be cleared.

If the code remains after these steps, further diagnosis may be needed to check for underlying issues related to airflow or engine performance.

This answer is automatically generated

0

Subscribe to Our Youtube Channel

Related Manuals for Volvo C30

Summary of Contents for Volvo C30

  • Page 1 VOLVO C30 WIRING DIAGRAM 2007 TP 39103202...

  • Page 2: Vehicles With Srs (Airbag)/Sips Bag/Ic (Inflatable Curtain)

    2. Damage or malfunction of the SRS/SIPS bag/IC system. Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo workshop. In case of doubt, consult the SRS and SIPS bag/IC service manual.

  • Page 3: Table Of Contents

    Data communication, High speed CAN ..... 42 Follow-me-home lighting..........85 Data communication MOST ........43 Interior lighting 1:2 ............86 Data communication LIN 1:2 ........44 Instrument and control illumination ......88 Start Control Module (SCU) ........46 Auxiliary lights .............. 89 TP 39103202 C30 2007...
  • Page 4 Group 88 Internal equipment Automatic transmission AW55-51......119 Auto-dimming rearview mirror........147 Transmission M66 ............. 120 Supplemental Restraint System (SRS) 1:2....148 Group 59 Brake system Connectors..........150 Brake control system & DSTC ........121 Branching points ........175 TP 39103202 C30 2007...
  • Page 5 Floor harness, RHD ............ 191 Roof harness .............. 192 Tunnel harness ............192 Driver’s door harness..........193 Passenger door harness..........193 Trunk lid harness ............194 Component images ........195 Index 1:2 ............239 List of components 1:5 ......241 TP 39103202 C30 2007...
  • Page 6 TP 39103202 C30 2007...

  • Page 7: Abbreviations

    EU/OS = Markets outside USA and Canada YE, Y = Yellow = Finland = Great Britain = Israel = Japan = Korea = Norway = Netherlands = Sweden = United States of America = Western Europe TP 39103202 C30 2007...

  • Page 8: How To Use The Wiring Diagrams 1:2

    Audio There is a section at the end of the manual in which Service/diagnostics the appearance and location of components is Contact reel described in numerical order. Meter Ignition component/shunt Optics Ground connection Branching point Connector TP 39103202 C30 2007...
  • Page 9 = Data communication 2 RHD 63/108 = CAN communication 31/110 31/10 31/84 = MOST communication = MOST communication = Connection with distribution = Further connection to... = Connector between cable harnesses = Connector connected in com- ponent 7_209 TP 39103202 C30 2007...

  • Page 10: Electrical Distribution 1:2

    RD-OG B:17 4/110 B:33 4/31 5 CYL B:11 B:29 64/90= 15/31A 64/90 GN-BU 2/35 64/90=15/31A BK-RD RD-GN GN-YE 7/51:6 2/32 64/90=15/31A BK-BU RD-OG GN-BU GN-BU GN-YE RD-OG 8/84:1 I4 Diesel 64/90=15/31A GN-YE GN-YE GN-YE GN-BU GN-YE TP 39103202 C30 2007...
  • Page 11 16/10 OG-BU 16/11 RD-OG 64/111 RD-OG 64/90=15/31A 64/90=15/31A RD-YE 2/22 BK-YE GN-YE 64/90=15/31A RD-BU 4/56 2/34 E:20 BK-YE RD-OG E:29 E:23 10/5:1 GN-WH 10/6:1 E:22 E:21 2/182 RD-GN E:30 G:11 BK-RD RD-BK GN-YE 6/104:1 RD-WH 64/861 TP 39103202 C30 2007...

  • Page 12: Fuses

    Glow plug control module, 5-cyl. Diesel 4/16 Brake Control Module (BCM), pump 4/16 Brake Control Module (BCM), valves 2/32 Main relay, engine management system F32-F36 Fuses in the engine compartment distribution box 2/32 4/31 Fan control module continues TP 39103202 C30 2007...

  • Page 13: Engine Compartment Distribution Box F11-F18

    F46-F47 Fuses in the Central Electronic Module (CEM) 2/89 F56-F57 Fuses in the Central Electronic Module (CEM) Fuse in the Central Electronic Module (CEM) 2/80 F81-F83 Fuses in the Central Electronic Module (CEM) Fuse in the Central Electronic Module (CEM) 2/89 continues TP 39103202 C30 2007...

  • Page 14: Engine Compartment Distribution Box F20-F31

    Fuse in the Central Electronic Module (CEM) Electromagnetic clutch, climate control system 2/22 2/34 Relay, front fog lights 10/5 Fog light, front left 2/34 10/6 Fog light, front right 2/34 4/46 Engine control module (ECM), 4-cyl. 1.6l/2.0l Diesel 6/26 Alternator, 4-cyl. continues TP 39103202 C30 2007...

  • Page 15: Engine Compartment Distribution Box F32-F34

    Fuel flow control valve, 4-cyl. 1.6l Diesel 8/113 Fuel pressure bypass valve, Man 8/119 Pressure monitor, climate control system, 5-cyl. 8/120 EGR valve 8/133 Control valve fuel pressure 20/3 -20/7 Spark plug and ignition coil 20/17 Transformer, ignition coils, 1.6l continues TP 39103202 C30 2007...

  • Page 16: Engine Compartment Distribution Box F35-F36

    Solenoid, variable turbo geometry, 4-cyl. Diesel 8/114 Valve mixing air/fuel, 4-cyl. 1.8l & 2.0l. 8/132 Control valve inlet 9/32 PTC-resistor, crankcase ventilation 5-cyl. Gasoline 4/46 Engine Control Module (ECM) 7/15 Heated oxygen sensor, front 7/51 Accelerator pedal sensor TP 39103202 C30 2007...

  • Page 17: Distribution Box In Engine Compartment Fh1

    Fuses Distribution box in engine compartment FH1 G017864 FH1 Fuse in holder Fuse function 10/65 Auxiliary lights, front right 2/64 10/69 Auxiliary lights, front left 2/64 TP 39103202 C30 2007...

  • Page 18: Central Electronic Module (Cem) F43-F49

    Relay, rear window wiper 2/92 Relay, windshield washer motor 2/93 Relay, rear window washer motor Washer pump 2/92 Washer pump 2/93 6/32 Rear window wiper motor 2/16 Supplemental Restraint System Module (SRS) 7/93 Occupant Weight Sensor (OWS), USA/CDN continues TP 39103202 C30 2007...

  • Page 19: Central Electronic Module (Cem) F51-F63

    Lamp housing, front right 4/112 Gas Discharge Lamp Module (GDL), master, left 10/1 Lamp housing, front left 9/12 Seat Heating Module (SHM), driver’s side 9/13 Seat Heating Module (SHM), passenger side 4/33 Sunroof control module continues TP 39103202 C30 2007...

  • Page 20: Central Electronic Module (Cem) F64-F74

    3/217 Belt buckle contact, left rear 3/219 Belt buckle contact, right rear 4/33 Sunroof control module 8/48 Auto-dimming rearview mirror 10/22 Ceiling light 4/83 Fuel pump control module, Gasoline 2/23 6/33 Fuel pump 2/23, 26/5 continues TP 39103202 C30 2007...

  • Page 21: Central Electronic Module (Cem) F79-F86

    Passenger Door Module (PDM) 3/126 Driver Door Module (DDM) 4/54 Power Seat Module (PSM) 4/52 Power Seat Module (PSM) 4/52 Power Seat Module (PSM) 4/54 Power Seat Module (PSM) 10/24 Cargo compartment lighting 26/5 DC/AC converter, fuel tank TP 39103202 C30 2007...

  • Page 22: Battery Pf1-Pf2

    F16-F18 Fuses in the engine compartment distribution box F20-F21 Fuses in the engine compartment distribution box F23-F24 Fuses in the engine compartment distribution box F26-F27 Fuses in the engine compartment distribution box F29-F31 Fuses in the engine compartment distribution box TP 39103202 C30 2007...

  • Page 23: Fuses In Holder

    Fuses Fuses in holder 11K/1-2 11K Fuses in holder Fuse function Alcolock Alcolock TP 39103202 C30 2007...

  • Page 24: Relays

    (wiring side) B = Corresponds to the position on the relay. C = An old designation that may be found on 1(86) 3(30) 1(86) 3(30) the relay 2(85) 5(87) 4(87a) 2(85) 5(87) 4(87a) TP 39103202 C30 2007...

  • Page 25: Distribution Box In Engine Compartment R2-R14

    Relay, horn 2/34 Relay, front fog lights 2/142 Fuel filter preheater relay 2/182 Relay, headlight washer motor 2/82 Relay, heated rear window 2/22 Relay, climate control system 2/35 Relay, starter motor 2/32 Main relay, engine management system TP 39103202 C30 2007...

  • Page 26: Central Electronic Module (Cem) R15-R18

    Relays Central Electronic Module (CEM) R15-R18 4/56 Central Electronic Module (CEM) Relay function 2/23 Fuel pump relay, Gasoline 2/193 Relay, comfort functions TP 39103202 C30 2007...

  • Page 27: Central Electronic Module (Cem) R1 - R11B

    4/56 Central Electronic Module (CEM) Relay function 2/89 Relay, interior lighting 2/80 Relay, reversing light 2/92 Relay, windshield washer motor 2/93 Relay, rear window washer motor 2/63 Relay, high beam R11A 2/16 Relay, rear window wiper R11B 2/159 Relay, infotainment TP 39103202 C30 2007...

  • Page 28: Relays - Accessories

    Relays Relays - accessories G017857 Relays accessories Relay function 2/64 Auxiliary light relay accessory TP 39103202 C30 2007...

  • Page 29: Ground Connections

    Ground connections Overview TP 39103202 C30 2007...
  • Page 30 Auto-dimming rearview mirror 8/134 Solenoid, reverse interlock, manual Front 12V outlet 9/25 Rear 12V outlet 10/22 Ceiling light 10/29 Glove compartment lighting 10/114 Vanity mirror lighting, left 10/115 Vanity mirror lighting, right 16/1 Integrated Audio Module (IAM) TP 39103202 C30 2007...
  • Page 31 Transmission Control Module (TCM) 4/46 Engine Control Module (ECM) 7/24 Front knock sensor, Gasoline 7/192 Water detection sensor, Diesel Electromagnetic clutch, climate control system, 4-cyl. 9/32 PTC resistor, crankcase ventilation 9/38 Heated fuel filter, 4-cyl. Diesel TP 39103202 C30 2007...
  • Page 32 8/51 Igniter, side airbag, driver’s side, RHD 8/52 Igniter, side airbag, passenger side, LHD 8/92 Driver’s lap belt tensioner, RHD 9/12 Seat Heating Module (SHM), driver’s side, RHD 9/13 Seat Heating Module (SHM), passenger side, LHD TP 39103202 C30 2007...
  • Page 33 PTC resistor, crankcase ventilation 20/3 Spark plug and ignition coil 20/4 Spark plug and ignition coil 31/89 Engine 20/5 Spark plug and ignition coil 20/6 Spark plug and ignition coil 20/7 Spark plug and ignition coil TP 39103202 C30 2007...
  • Page 34 Passenger Door Module (PDM), LHD 4/83 Fuel pump control module, LHD, Gasoline 4/111 Additive Dosing Module (ADM), LHD 6/33 Fuel pump, LHD 9/38 Heated fuel filter, LHD, 5-cyl. Diesel 31/119 Left MacPherson strut tower 4/16 Brake Control Module (BCM) TP 39103202 C30 2007...

  • Page 35: Ground Connections In Chassis

    Igniter, right rear belt tensioner 8/128 Driver’s belt force limiter 8/129 Passenger belt force limiter 16/16 Amplifier window antenna, right 16/49 Traffic Message Channel Module (TMC) 16/150 Amplifier window antenna, left 18/4 Contact reel 20/22-25 Glow plug TP 39103202 C30 2007...

  • Page 36: Control Modules

    Control modules Overview of locations TP 39103202 C30 2007...

  • Page 37: Overview Of Designations

    Seat Heating Module (SHM), passenger side Supplemental Restraint System Module (SRS) 3/254 Steering Wheel Module (SWM) 4/28 Transmission Control Module (TCM) 16/49 Traffic Message Channel Module (TMC) 4/110 Trailer Module (TRM) Wiper Motor Module (WMM) 17/13 17/13 Data link connector TP 39103202 C30 2007...

  • Page 38: Central Electronic Module (Cem)1:2

    F:24 C:13 G:28 C:12 E:10 H:21 B:19 E:25 G:27 E:37 B:23 A:41 B:22 B:21 F:31 F:28 A:15 C:14 G:23 A:25 G:12 G:21 F:19 F:18 H:22 F:21 G:11 F:20 B:27 G:18 A:34 A:32 B:26 B:11 B:12 F:12 TP 39103202 C30 2007...
  • Page 39 C:21 2/63 E:27 E:11 G:30 C:41 C:27 A:21 A:29 2/159 E:20 30+ (3) C:40 R11B C:17 E:28 2/23 C:16 E:23 30+ (4) E:36 A:18 C:25 C:31 C:24 C:44 C:30 C:29 D:14 C:23 A:19 C:32 31/10 31/84 TP 39103202 C30 2007...

  • Page 40: Data Communication, Low Speed Can 1:2

    F:30 F:15 F:30 F:15 A:12 A:12 GY-OG GY-OG B:24 B:24 GY-BK GY-BK A:11 A:11 B:25 B:25 BU-YE BU-YE BU-BK BU-BK G:16 G:16 GY-RD GY-RD G:32 G:32 BU-RD BU-RD B:15 B:15 BU-RD BU-RD GY-RD GY-RD B:16 B:16 TP 39103202 C30 2007...
  • Page 41 Control modules Data communication, Low speed CAN 2:2 BU-WH GY-VT 16/1.2 3/112 A:10 C°/F° GY-RD BU-WH GY-BK BU-YE TP 39103202 C30 2007...

  • Page 42: Data Communication, High Speed Can

    64/112 64/112 BU-RD BU-RD G:15 G:15 GY -RD GY -RD G:14 G:14 BU-RD BU-RD 4/111 4/111 GY-RD GY-RD 64/51 64/51 F:14 F:14 BU-RD BU-RD BU-RD BU-RD B:12 B:12 GY-RD GY-RD GY-RD GY-RD F:16 F:16 B:11 B:11 TP 39103202 C30 2007...

  • Page 43: Data Communication Most

    Control module Data communication MOST 16/1 16/1.2 16/60 16/108 64/97 64/978 16/139 16/145 RDAR 64/978 16/105 16/105 16/139 16/145 RDAR 64/978 64/978 64/978 16/139 16/49 16/105 16/105 16/105 TP 39103202 C30 2007...

  • Page 44: Data Communication Lin 1:2

    WH-BK WH-BK WH-GN WH-GN WH-GN WH-GN B:17 B:17 63/339 63/339 WH-RD WH-RD G:26 G:26 6/1 LHD 6/1 LHD 6/1 RHD 6/1 RHD 4/103 4/103 WH-GN WH-GN A:35 A:35 WH-GN WH-GN 7/149 7/149 H:23 H:23 WH-GN WH-GN TP 39103202 C30 2007...
  • Page 45 A:46 A:46 WH-RD WH-RD 5 CYL 5 CYL 2,5 L T 2,5 L T 3/126 3/126 3/127 3/127 A:13 A:13 3/81 3/81 WINDOW WINDOW CONTROL CONTROL 64/35 64/35 4/127 4/127 SWITCH SWITCH 64/333 64/333 4/126 4/126 TP 39103202 C30 2007...

  • Page 46: Start Control Module (Scu)

    PATS MODULE MODULE 63/5 63/5 63/5 4/102 4/102 4/102 WH-GN WH-GN WH-GN 4/56 4/56 4/56 A:10 C:39 E:29 C:38 A:16 C:18 A:10 A:10 C:39 C:39 E:29 E:29 C:38 C:38 A:16 A:16 C:18 C:18 31/83 31/83 31/83 TP 39103202 C30 2007...

  • Page 47: Group 23 Fuel System

    GLOW P5 GLOW P4 GLOW P3 GLOW P2 GLOW P1 7/162 BN-GN A:64 WH-GN A:65 YE-GN A:19 7/165 A:87 64/90 WH-GN A:85 BK-GN A:82 A:15 GN-YE 64/90 20/22 20/23 20/24 20/25 20/26 GN-BU GN-BU GN-RD GN-OG TP 39103202 C30 2007...
  • Page 48 63/53 BK-YE BK-WH BK-YE 9/32 63/85 GN-WH 63/120 WH-BK BK-WH 64/51 GN-RD GN-OG 31/52 9/38 B:23 B:22 7/51 6/33 64/90 B:47 GN-BU BK-YE GN-BU 63/65 64/111 63/12 GN-YE BK-OG 63/33 GN-BU 31/115 31/116 31/114 31/10 31/84 TP 39103202 C30 2007...
  • Page 49 WH-VT 2,4 L D YE-RD 8/98 YE-RD A:23 BN-RD A:93 7/166 A:34 A:36 A:42 6/118 GN-OG A:81 WH-BK YE-BK A:40 BN-YE A:52 6/120 GN-RD A:24 BN-BU A:72 A:67 BK-OG WH-BU A:18 YE-BU A:11 8/111 A:47 A:94 TP 39103202 C30 2007...

  • Page 50: Engine Management System, 4-Cyl. 1.6L 1:2

    B:36 B:13 7/16 8/65 B:29 BN-WH GN-WH 20/17 GN-WH 63/52 20/3 BK-OG 20/6 20/4 BK-GN 20/5 GN-RD BK-OG B:35 63/74 A:16 63/SH7 63/SH8 7/24 A:32 A:31 7/165 A:20 BN-GN A:52 WH-VT YE-GN WH-GN B:17 GN-OG GN-YE TP 39103202 C30 2007...
  • Page 51 GN-BU GN-BU B:21 7/51 1,6 L G:22 A:47 G:31 C:16 E:41 E:28 64/111 B:31 64/51 63/25 B:19 63/12 BK-YE A:42 BK-YE 63/53 B:40 BK-YE BK-YE 6/33 I4 PETROL 2 WD GN-OG 31/52 31/115 31/84 31/116 31/10 TP 39103202 C30 2007...

  • Page 52: Engine Management System, 4-Cyl. 1.8L & 2.0L 1:2

    B:41 7/24 B:29 GN-RD GN-YE 20/3 B:11 GN-BU 20/4 B:46 WH-RD 63/95 GN-RD 20/5 B:23 WH-BU GN-BK 20/6 B:34 WH-GN 6/120 B:22 GN-RD BK-OG B:10 B:37 WH-BU BN-BU B:38 B:25 WH-BU B:26 YE-BU GN-OG GN-YE BK-BU TP 39103202 C30 2007...
  • Page 53 WH-VT 6/26 B:20 B:15 63/25 64/51 26/5 A:41 DC/AC FlexiFuel A:30 63/12 64/54 GN-OG 6/33 Flexi fuel A:23 BK-YE 63/53 A:11 BK-YE A:10 BK-YE 6/33 A:34 1.8l/ 2.0l GN-OG GN-YE BK-BU 31/115 31/52 31/116 31/10 31/84 TP 39103202 C30 2007...

  • Page 54: Engine Management System, 5-Cyl. 1:2

    20/6 YE-RD WH-BU A:34 GN-BU 20/7 YE-RD A:35 WH-GN 31/89 6/120 63/121 A:75 GN-RD BK-OG A:74 A:24 BN-BU A:72 A:15 WH-BU A:96 YE-BU 8/18 63/120 GN-BU A:53 8/19 BK-OG GN-BU BK-OG A:78 GN-BU GN-YE 31/1 14 TP 39103202 C30 2007...
  • Page 55 WH-BK WH-BK 64/51 63/33 A:58 63/25 64/956 A:45 A:57 4/83 A:44 63/12 BK-YE BK-YE BK-RD 63/53 BK-YE GN-BU GN-BU 6/33 6/33 63/65 I5 PLASTIC I5 PZEV GN-BU AWD 2WD METAL TANK 31/115 31/116 31/10 31/52 31/84 TP 39103202 C30 2007...

  • Page 56: Engine Management System, 5-Cyl. Turbo 1:2

    A:57 WH-RD 31/88 GN-BU 63/103 20/5 A:34 WH-BK GN-BU 20/6 63/121 A:82 WH-BU GN-NU 20/7 A:58 WH-GN 31/89 6/120 A:75 GN-RD 63/120 BK-OG A:14 WH-BU A:19 BN-BU A:74 A:88 WH-BU A:65 YE-BU GN-BU GN-YE 31/1 14 TP 39103202 C30 2007...
  • Page 57 WH-BK WH-BK 64/51 B:54 63/33 B:41 63/25 B:57 64/956 B:44 4/83 63/12 BK-YE BK-YE 63/53 BK-YE BK-RD GN-BU GN-BU 63/65 6/33 6/33 I5 PLASTIC I5 PZEV AWD 2WD METAL TANK GN-BU 31/84 31/52 31/115 31/10 31/116 TP 39103202 C30 2007...

  • Page 58: Engine Management System Diesel, 4-Cyl. 1.6L 1:2

    GLOW P1 B:C4 BN-GN B:B4 YE-GN 63/121 64/90 YE-VT 7/21 YE-VT YE-RD B:F4 63/41 WH-VT B:D1 64/600 BN-WH B:A1 63/120 8/120 WH-GN C:D4 BN-GN C:D3 20/23 20/24 20/25 20/26 YE-GN B:A4 BK-GN B:D2 B:C2 GN-BK 31/1 31/52 TP 39103202 C30 2007...
  • Page 59 B:L1 63/12 8/122 64/51 BN-GN B:J2 WH-GN YE-RD WH-GN B:F4 BK-GN B:M1 63/41 4/111 BK-YE A:G4 A:H4 BK-YE A:H1 BK-YE 63/53 GN-OG B:M2 GN-OG 6/33 A:G1 GN-OG 64/90 GN-BU BK-RD GN-BK GN-BU 31/52 31/115 31/116 31/84 TP 39103202 C30 2007...

  • Page 60: Engine Management System Diesel, 4-Cyl. 2.0L 1:2

    GLOW P1 YE-RD C:F4 WH-RD C:B4 63/121 BN-RD C:F1 64/90 7/77 B:A2 WH-VT BN-WH B:G3 63/120 64/600 BK-YE A:G4 BK-YE A:H4 B:K2 BK-YE 63/53 C:H4 BK-YE C:J4 BK-YE C:K4 20/23 20/24 20/25 20/26 BK-YE 31/52 31/114 TP 39103202 C30 2007...
  • Page 61 BN-BU 7/174 B:C2 YE-VT B:B2 WH-VT B:D3 BN-WH 4/111 8/120 B:E2 YE-GN B:D2 WH-GN B:C3 BN-GN B:L2 BK-GN B:M2 GN-BK GN-OG C:K2 GN-YE 63/65 6/33 C:K3 GN-YE C:J3 GN-YE 64/90 BK-RD GN-BU GN-OG 31/115 31/116 31/84 TP 39103202 C30 2007...

  • Page 62: Emission Control, 4-Cyl. 1.6L

    64/90 39 32 4/46.7 8/18 B:16 BK-OG 4 CYL 1,6 L A:41 7/15 A:30 64/60 BK-OG 7/163 B:38 WH-VT WH-VT A:49 WH-BU B:27 BN-WH BN-WH BN-BU 7/25 B:37 WH-RD B:26 BN-RD 7/82 B:39 BK-YE A:38 B:14 TP 39103202 C30 2007...

  • Page 63: Emission Control 4-Cyl. 1.8L & 2.0L

    GN-RD B:33 8/18 B:45 BK-OG B:32 BN-RD B:44 4 CYL 1,8 L GN-RD A:41 7/15 A:30 BK-GN BN-BU A:26 WH-BU 7/163 GN-YE B:18 WH-VT 63/63 BN-WH 7/25 7/82 WH-RD A:25 BK-GN B:17 BN-RD A:27 WH-GN BN-RD TP 39103202 C30 2007...

  • Page 64: Emission Control, 5-Cyl

    B:57 A:76 B:44 A:48 A:47 BK-YE 7/172 GN-YE A:17 YE-BK 7/186 A:19 BN-RD A:63 WH-VT A:49 BN-RD A:68 WH-RD 7/173 A:39 A:11 YE-RD BN-BU A:64 WH-BK A:43 BN-BU BN-BU GN-YE 7/187 63/94 A:50 BN-RD A:95 WH-RD TP 39103202 C30 2007...

  • Page 65: Emission Control, 5-Cyl. Turbo

    B:23 BN-WH B:54 7/15 B:41 A:73 BK-YE B:57 GN-YE B:44 A:91 A:67 A:92 7/172 A:68 A:16 YE-RD A:36 BN-WH 7/82 BN-RD A:49 A:83 WH-VT GN-YE A:90 7/173 WH-RD A:17 YE-BK A:95 BN-RD A:37 BN-YE A:59 WH-BK TP 39103202 C30 2007...

  • Page 66: Group 26 Cooling System

    WH-RD 5 CYL B:53 BN-RD BN-RD B:47 BN-RD W/O T YE-RD B:31 YE-RD WH-VT B:51 WH-VT B:58 A:67 YE-VT W/O T 7/16 B:45 A:42 BN-WH 6/29 A:22 BN-WH W/O T B:57 A:12 WH-VT B:44 63/120 31/114 TP 39103202 C30 2007...

  • Page 67: Cooling Fan, Diesel

    1,6 L B:F2 A:B2 WH-RD B:H1 6/29 4/46.4 64/90 A:B2 WH-RD 4 CYL 8/119 A:H2 BK-YE DIESEL 7/16 2,0 L A:D2 BK-BU C:A2 BK-YE BK-YE C:G1 BK-RD 8/127 WH-VT/ BK-BU BK-BU BK-BU 63/109 63/120 63/108 31/114 31/110 TP 39103202 C30 2007...

  • Page 68: Group 27 Engine Control

    B:22 BK-OG B:10 A:41 B:37 WH-BU 1.8L B:38 BN-BU A:30 B:25 WH-BU B:26 YE-BU A:A3 DIESEL (1.6/2.0L) A:A4 4/56 7/51 3/39 G:21 GN-YE G:31 GN-YE G:24 G:22 BK-YE G:15 G:14 F:16 64/111 F:14 63/12 31/83 31/84 TP 39103202 C30 2007...

  • Page 69: Cruise Control, 5-Cyl

    5CYL T Diesel A:67 BK-BO 5CYL T Diesel A:18 WH-BU 2.4L.D B:23 5CYL Diesel YE-BU A:11 4/56 7/51 7/123 Petrol G:12 G:22 GN-YE Petrol G:23 G:31 Petrol G:21 BK-YE G:15 G:14 64/111 F:16 F:14 63/12 31/83 31/84 TP 39103202 C30 2007...

  • Page 70: Group 32 Alternator And Voltage Regulator

    Group 32 Alternator and voltage regulator Power supply, 4-cyl. 31/4 31/3 6/25 15/31 64/90 4/46.7 6/26 A:33 1.6 L 4/46.6 VOLT. REG. B:15 B:20 1.8/2.0 L 4/46.4 A:A1 B:H4 DIESEL 2,0 L 4/46.5 C:B1 B:A3 DIESEL 1,6 L TP 39103202 C30 2007...

  • Page 71: Power Supply, 5-Cyl

    Group 32 Alternator and voltage regulator Power supply, 5-cyl. 31/4 31/3 6/25 6/26 VOLT. REG. 4/46.3 2.4L Diesel A:88 WH-RD 4/46.1 2.4L A:88 WH-RD 4/46.2 2.5L Turbo WH-RD A:46 TP 39103202 C30 2007...

  • Page 72: Group 33 Starting System

    Starting system, 4-cyl. 64/120 2/35 6/25 RD-GN BK-RD 64/90 4/46.4 2,0 L D A:1D BK-RD 4/46.7 1,6 L B:30 BK-RD 4/56 A:42 4/46.5 1,6 L D C:1A BK-RD G:21 GN-YE 4/46.6 3/39 1,8 L BK-RD G:24 31/3 31/4 TP 39103202 C30 2007...

  • Page 73: Starting System, 5-Cyl

    6/25 B:17 B:15 B:11 B:13 2,5 L T 4/56 A:17 A:42 GN-YE 4/46.1 B:30 B:15 B:17 B:11 2,4 L 7/123 G:21 G:23 G:12 4/28 WH-RD 64/113 3/271 4/93 B:20 63/109 63/53 63/108 31/3 31/4 31/110 31/52 TP 39103202 C30 2007...

  • Page 74: Starting System, 5-Cyl. Diesel

    Group 33 Starting system Starting system, 5-cyl. Diesel 64/111 2/35 3(30) 1(86) GN-BU BK-RD 5(87) 2(85) 64/90 6/25 4/46.3 B:41 B:33 B:29 2,4 L D B:44 B:34 4/56 A:42 7/123 G:12 G:23 G:21 4/28 63/53 31/4 31/3 31/52 TP 39103202 C30 2007...

  • Page 75: Group 35 Lighting

    E:27 E:11 A:28 10/1 10/2 PARK PARK TURN HIGH TURN HIGH GN-OG GN-BK GN-WH 63/121 63/109 GN-VT 3/111 63/25 FF = FRONT FOG LIGHTS ON RF = REAR FOG 63/120 63/108 63/6 31/6 31/114 31/10 31/110 TP 39103202 C30 2007...

  • Page 76: High And Low Beam (Bi-Xenon)

    MAIN MAIN ELEC. ELEC. BALLAST LEVELING HI DRTL BALLAST LEVELING HI DRTL GN-OG 63/93 GN-BK 63/92 4/113 4/112 63/121 63/109 A:10 A:10 SLAVE MASTER A:11 A:11 WH-BK A:12 63/6 63/25 63/120 63/108 31/6 31/114 31/10 31/110 TP 39103202 C30 2007...

  • Page 77: Manual Beam Length Adjustment

    15/31 3/111 FF = FRONT FOG LIGHTS ON RF = REAR FOG 4/56 E:21 E:22 2/89 10 13 A:40 A:38 63/139 64/111 10/2 10/1 6/38 6/39 HIGH PARK TURN HIGH PARK TURN 63/124 64/111 63/6 31/6 TP 39103202 C30 2007...

  • Page 78: Automatic Beam Length Adjustment (Bi-Xenon)

    LEVELING LEVELING HI DRTL HI DRTL 11 2 12 11 63/92 63/93 4/112 4/113 GN-BK MASTER SLAVE 63/91G GN-YE GN-YE A:11 A:11 WH-BK A:10 A:10 A:12 63/121 63/109 63/120 63/108 64/113 64/50 7/120 7/121 31/114 31/110 TP 39103202 C30 2007...

  • Page 79: Position/Parking Lights, Tail Lights

    C:14 C:12 C:13 HIGH PARK TURN HIGH PARK TURN OG-BU 64/791 OG-GN OG-WH 10/3 10/18 10/17 OG-BU GY-OG C1:1 C3:3 C4:4 C2:3 C1:4 C3:2 C4:1 C2:2 BK-BU BU-GY 64/791 63/174 63/175 31/11 31/12 31/110 31/114 31/6 TP 39103202 C30 2007...

  • Page 80: Position/Parking Lights, Tail Lights (Bi-Xenon)

    ELEC. BALLAST BALLAST LEVELING LEVELING HI DRTL HI DRTL 64/791 OG-GN OG-WH 10/3 10/18 10/17 OG-BU GY-OG C1:1 C3:3 C4:4 C2:3 C1:4 C3:2 C4:1 C2:2 BK-BU BU-GY 64/791 63/174 63/175 31/11 31/12 31/110 31/114 31/1 31/6 TP 39103202 C30 2007...

  • Page 81: Fog Lights

    LIGHTS ON RF = REAR FOG A:32 GN-BU B:23 BK-YE B:22 BK-YE GN-OG GN-YE 63/109 GN-YE 63/121 63/6 10/18 10/17 C1:2 C2:1 63/108 63/120 C1:4 C3:2 C4:1 C2:2 BK-BU BU-GY 63/175 63/174 31/114 31/11 31/12 31/6 31/110 TP 39103202 C30 2007...

  • Page 82: Fog Lights Lhd Japan

    LIGHTS ON RF = REAR FOG A:32 GN-BU B:23 BK-YE B:22 BK-YE GN-OG 10X/18C1 63/109 63/121 GN-YE 63/6 10/18 10/17 C2:1 63/108 63/120 C1:4 C3:2 C4:1 C2:2 10X/18C1 10X/17C2 63/175 63/174 31/12 31/114 31/6 31/11 31/110 TP 39103202 C30 2007...

  • Page 83: Brake Light

    4/56 E:22 E:21 E:28 64/90 OG-WH G:14 G:15 F:16 E:41 F:14 E:40 GN-WH 64/48A OG-YE 10/19 OG-BK 64/48A 63/26 C5:1 C6:1 10/18 10/17 C5:2 C6:2 BK-WH C1:4 C3:2 C4:1 C2:2 BK-BU BU-GY 63/174 63/175 31/11 31/12 TP 39103202 C30 2007...

  • Page 84: Reversing Light

    AW55-51 15/31 4/56 E:22 RD-BU E:21 RD-YE 2/80 G:14 G:15 F:16 F:14 64/90 GN-BU E:14 C:45 3/10 2 / 3 10/17 10/18 C3:1 C2:1 C1:4 C4:1 C2:2 C3:2 BK-BU BU-GY 63/53 63/174 63/175 31/52 31/11 31/12 TP 39103202 C30 2007...

  • Page 85: Follow-Me-Home Lighting

    Group 35 Lighting Follow-me-home lighting 15/31 4/56 E:21 C:31 C:24 64/43 64/41 3/126 3/127 A:18 A:18 GN-YE GN-YE B:13 B:13 B:12 B:12 A:12 A:12 64/35 64/333 6/62 6/63 10/148 10/149 64/43 64/41 31/115 31/116 TP 39103202 C30 2007...

  • Page 86: Interior Lighting 1:2

    OG-BU OG-BU A:38 10/97 10/102 63/174 63/139 A:25 10/29 10/115 BK-BU 63/10 3/117 D:12 A:28 1 On 2 Off 10/114 3 Ctsy MAP READING 10/22 A:10 10/150 OG-YE 63/211 OG-YE OG-YE OG-YE 63/213 OG-YE OG-YE 63/25 TP 39103202 C30 2007...
  • Page 87 Group 35 Lighting Interior lighting 2:2 64/41 3/126 A:18 4/56 64/41 A:11 BN-OG 63/198 C:31 C:24 3/74 64/41 64/43 F:19 F:18 64/43 3/75 3/127 A:18 A:12 A:11 BN-WH 63/195 64/43 31/115 31/116 TP 39103202 C30 2007...

  • Page 88: Instrument And Control Illumination

    3/126 3/127 A:12 A:12 A:13 A:13 4/56 E:22 E:21 2/89 F:15 3/111 F:30 FF = FRONT FOG LIGHTS ON RF = REAR FOG B:21 A:38 63/139 BK-RD OG-BU 64/25G OG-BU OG-BU 3/286 63/6 63/25 31/6 31/10 TP 39103202 C30 2007...

  • Page 89: Auxiliary Lights

    Group 35 Lighting, Accessories Auxiliary lights 15/31 4/56 E:22 2/63 A:28 3/60 GN-RD 63/25 2/64 10/69 10/65 31/52 31/10 TP 39103202 C30 2007...

  • Page 90: Group 36 Additional Electrical Equipment

    E:39 10/16 6/62 6/63 10/15 10/2 10/1 PARK HIGH LOW HIGH PARK TURN TURN 63/5 10/18 10/17 C3:4 C4:3 64/41 64/43 C1:4 C3:2 C4:1 C2:2 BK-BU BU-GY 63/175 63/174 31/11 31/12 31/83 31/115 31/114 31/110 31/116 TP 39103202 C30 2007...

  • Page 91: Direction Indicator And Hazard Warning Flashers (Bi-Xenon)

    MAIN ELEC. ELEC. BALLAST BALLAST LEVELING LEVELING HI DRTL HI DRTL 63/5 10/18 10/17 63/121 63/109 C4:3 C3:4 64/41 C1:4 C3:2 C4:1 C2:2 BK-BU BU-GY 63/120 63/174 63/175 63/108 31/110 31/115 31/116 31/114 31/11 31/83 31/12 TP 39103202 C30 2007...

  • Page 92: Wiper/Washer

    6/1 RHD 63/108 GN-WH 4/56 A:17 E:20 2/193 64/79V YE-BK R7 A R7 B 2/92 2/93 Petrol 5cyl E:12 WH-BK Petrol 5cyl 64/79V F:16 F:14 A:28 A:45 WH-BK 3/254 OG-BK 63/25 BK-WH 63/5 31/110 31/10 31/83 TP 39103202 C30 2007...

  • Page 93: Headlight Washer

    Group 36 Additional electrical equipment Headlight washer 15/31 2/182 1(86) 3(30) 4/56 5(87) 2(85) G:11 BK-RD BK-GN A:40 OG-BK 64/79V 3/111 FF = FRONT FOG LIGHTS ON RF = REAR FOG 14 6 64/79V 63/6 31/6 31/110 TP 39103202 C30 2007...

  • Page 94: Rear Window Wiper/Washer

    YE-BK R7 A R7 B 2/92 2/93 5cyl E:12 5cyl WH-BK F:16 F:14 64/79V R11 A 2/193 2/16 WH-BK C:33 C:34 A:28 A:45 3/254 6/32 OG-BK C:1 64/48 63/25 BK-WH 63/5 63/174 63/196 31/11 31/83 31/10 TP 39103202 C30 2007...

  • Page 95: Rain Sensor

    Group 36 Additional electrical equipment Rain sensor 15/31 64/111 3/254 4/56 E:20 A:17 2/193 7/149 OG-BK H:23 WH-GN 63/214 D:10 W/O KVM A:28 A:14 63/25 63/12 1 LHD 4 RHD 3 LHD 2 RHD 63/108 31/110 31/10 31/84 TP 39103202 C30 2007...

  • Page 96: Horn

    Group 36 Additional electrical equipment Horn 15/31 3/254 2/17 3/37 18/4 63/30 4/56 B:26 G:18 16/10 OG-BU 16/11 OG-BU 63/5 63/121 63/120 31/83 31/1 1 4 TP 39103202 C30 2007...

  • Page 97: Immobilizer/Steering Column Lock Module (Scl)

    1,8 L G:15 A:15 RD-GN F:16 63/88 F:14 B:13 4/46.7 B:10 4 CYL B:30 1,6 L 4/102 OG-BK 4/46.5 WH-GN 4 CYL 1,6 L D 63/6 63/5 C:A1 4/46.3 5 CYL 2,4 L D B:44 31/83 31/6 TP 39103202 C30 2007...

  • Page 98: Keyless Vehicle 1:2

    C:41 OG-WH A:15 C:26 RD-BK 64/112 B:17 RD-GN RD-GN RD-GN 63/88 64/48 BK-YE D:14 10/3 3/35 BK-WH 63/172 BK-WH 63/171 63/5 63/196 64/113 B:20 WH-RD WH-RD 3/271 64/48 63/174 63/109 63/108 31/83 31/11 31/66 31/67 31/110 TP 39103202 C30 2007...
  • Page 99 16/129 A:11 DRIVER DOOR 3/258 64/41 BN-OG A:15 3/262 A:14 BN-OG 3/74 63/198 D:11 CLUTCH UNLOCK RELEASE LOCK D:20 A:11 16/128 16/132 E:14 WH-BK E:15 GY-BK 16/133 E:18 WH-GN GY-OG 16/134 E:20 WH-VT GY-WH E:22 16/135 TP 39103202 C30 2007...

  • Page 100: Rear Parking Assistance

    WH-RD 63/421 A:14 GY-RD GY-RD 15 1 7/133 63/415 63/422 YE-RD RR/I BU-RD BU-RD BU-RD 15 2 WH-RD 15 3 BN-RD 63/416 7/132 YE-RD LR/I WH-BU BN-RD 7/131 YE-RD 4/110 LR/O WH-GN BN-RD BN-RD 63/174 31/11 TP 39103202 C30 2007...

  • Page 101: Front Parking Assistance

    RF/O LF/O C:38 4/86 64/1400 64/1300 7/206 64/322 15 5 RF/I LF/I 63/420 15 4 63/421 A:14 GY -RD GY-RD 15 1 63/422 BU-RD BU-RD BU-RD 15 2 7/205 LF/I RF/I 4/110 7/204 LF/O RF/O 31/11 TP 39103202 C30 2007...

  • Page 102: Anti-Theft Alarm

    63/174 63/214 3/74 CLOCK UNLOCK DLOCK 3/75 64/43 AJAR 3/127 LOCK A:18 FEEDBACK 64/41 LOCK FEEDBACK AJAR 63/198 DLOCK 3/126 A:12 A:18 UNLOCK 63/25 A:11 A:11 CLOCK BN-WH 63/195 A:12 63/120 31/114 31/11 31/115 31/10 31/116 TP 39103202 C30 2007...

  • Page 103: Alcolock

    Group 36 Additional electrical equipment, Accessories Alcolock 15/31 64/111 3X/1B 11K/2 11K/1 INHIBIT KEY IN PATS MODULE GN-WH GY-BK GY-BK 3X/1B 3X/1B 63/88 4/56 E:21 E:22 B:13 A:15 A:30 A:17 2/89 A:42 10X/97 A:25 10/97 A:36 63/139 A:28 63/25 TP 39103202 C30 2007...

  • Page 104: Group 37 Wiring And Fuses

    Group 37 Wiring and fuses 12V outlet 15/31 4/56 E:22 E:20 A:28 2/193 C:22 A:23 63/25 64/25G 9/25 31/10 TP 39103202 C30 2007...

  • Page 105: Diagnostics System

    Group 37 Wiring and fuses Diagnostics system 15/31 4/56 E:21 B:15 B:16 B:11 B:12 LOSPEED 63/5 BK-OG 63/6 BU-RD BU-RD 31/83 31/6 TP 39103202 C30 2007...

  • Page 106: Tow Hitch Cable Harness, 4-Pin

    Tow hitch cable harness, 4-pin 15/31 4/56 E:22 E:21 64/113 OG-WH E:28 F:30 F:15 E:41 63/26 C5:1 10/18 C5:2 17/37 BK-WH 64/322 63/421 GY-RD GY-RD BU-RD BU-RD 63/422 A:12 C1:4 C3:2 BK-BU 63/420 4/86 A:14 GY-RD BU-RD 63/174 31/11 31/12 TP 39103202 C30 2007...

  • Page 107: Tow Hitch Cable Harness, 7-Pin

    E:22 E:21 64/113 OG-WH E:28 F:30 F:15 4/110 E:41 A:10 17/38 63/421 64/322 GY-RD GY-RD BU-RD BU-RD 63/422 A:12 OG-BK 63/26 63/420 4/86 A:14 GY-RD C5:1 BU-RD 10/18 C5:2 BK-WH C1:4 C3:2 BK-BU 63/174 31/11 31/12 TP 39103202 C30 2007...

  • Page 108: Tow Hitch Cable Harness, 13-Pin

    F:30 E:41 F:15 4X/110C OG-BK FUSE 63/26 4/110 C5:1 10/18 63/421 64/322 C5:2 BK-WH GY-RD GY-RD A:12 BU-RD BU-RD A:10 63/422 C1:4 C3:2 BK-BU 63/420 17/39 4/86 A:14 GY-RD BU-RD 63/174 RESERVE: INDICATION TRAILER 31/12 31/11 TP 39103202 C30 2007...

  • Page 109: Group 38 Instruments

    6/62 LHD 6/63 RHD GN-WH 63/173 7/69 64/51 4/111 WH-RD WH-BU 26/5 μ WH-RD WH-BU 64/54 WH-BU BN-BU Plastic I5 I5 PZEV Additive tank Metal tank I4_Diesel only 1.8l Flexifuel 6/33 6/33 6/33 6/33 6/33 31/116 TP 39103202 C30 2007...

  • Page 110: Seat Belt Reminder

    Group 38 Instruments Seat belt reminder 15/31 64/111 3/46 4/56 A:30 E:22 E:21 64/31 BK-GN F:13 BN-RD F:17 YE-RD 63/25 A:28 BK-RD GN-BU 3/217 3/219 C:18 D:12 63/211 OG-GN 63/170 3/117 1 On 2 Off 3 Ctsy 31/10 TP 39103202 C30 2007...

  • Page 111: Group 39 Other

    2/159 R11B F:16 F:14 3/254 A:29 A:21 C:44 16/1.2 OG-GN 63/29 WH-BU 7/182 GN-OG OG-YE OG-YE 16/46 16/108 OG-YE 63/28 RD-YE 63/27 RD-YE OG-YE 16/139 B:10 B:10 63/12 BK-BU BK-BU BK-BU 63/171 16/47 31/10 31/67 31/84 TP 39103202 C30 2007...

  • Page 112: Audio 1:2

    Group 39 Other Audio 1:2 15/31 16/1 4/56 E:23 2/159 R11B F:16 F:14 A:21 C:40 RD-YE RD-YE 63/27 OG-GN 63/29 3/254 16/1.2 WH-BU OG-GN BK-BU 63/12 64/190 16/138 16/16 16/50 16/150 31/84 31/10 TP 39103202 C30 2007...
  • Page 113 Group 39 Other Audio 2:2 16/1 16/5 64/112 A:10 16/3 64/43 A:11 GY-RD WH-RD 16/56 WH-RD GY-RD 16/6 A:13 GY-WH GY-WH WH-VT WH-VT 16/4 64/41 A:12 GY-BK WH-BK 16/55 WH-BK GY-BK TP 39103202 C30 2007...

  • Page 114: Audio High Performance/Premium Sound 1:2

    C:44 C:23 A:21 C:40 63/135 GN-BU GN-BU RD-WH 16/1.2 OG-GN 63/29 RD-YE RD-YE BK-BU 63/27 WH-BU 16/49 16/1 3/254 64/21 BK-BU 64/190 USA (NO TMC) 63/12 A:14 16/138 16/16 63/171 16/50 17/40 16/150 31/10 31/84 31/67 TP 39103202 C30 2007...
  • Page 115 Group 39 Other Audio High Performance/Premium Sound 2:2 16/105 16/26 64/112 B:10 WH-RD WH-RD GY-RD GY-RD 16/5 B:13 16/3 64/43 B:11 16/56 WH-RD GY-RD 16/6 GY-WH B:12 WH-VT 16/4 64/41 16/55 WH-BK GY-BK 16/98 64/179 B:16 TP 39103202 C30 2007...

  • Page 116: Cellular Phone 1:2

    A:28 F:12 A:11 2/159 R11B F:16 F:14 F:30 F:15 B:24 B:25 C:23 C:40 A:21 A:33 A:17 GY-VT RD-OG 16/105 GN-BU 63/135 B:16 16/98 64/179 63/171 16/1.2 OG-GN 63/29 3/254 63/12 BK-BU BK-BU WH-BU 31/10 31/67 31/84 TP 39103202 C30 2007...
  • Page 117 Cellular phone 2:2 16/60 16/62 A:18 BN-BU WH-BU A:19 WH-RD A:20 HANDSET 16/140 WH-BU DETECT WH-GN DATA BK-GN RESET RD-YE POWER GY-WH GY-OG CLOCK 3/267 WH-BU WH-GN OG-BK A:13 BN-BU A:14 BN-RD A:15 WH-RD 16/47 64/40 TP 39103202 C30 2007...

  • Page 118: Satellite Radio

    Group 39 Other, Accessories Satellite radio 15/31 4/56 E:23 2/159 R11B F:16 F:14 C:44 16/145 16/47 RDAR WH-RD 63/175 31/12 TP 39103202 C30 2007...

  • Page 119: Group 43 Transmission

    55-51 B:45 2,4 L 8/39 B:15 GY-WH 8/72 C:17 8/73 C:22 B:57 B:44 8/74 C:21 GY-RD GY-RD GY-RD BU-RD HISPEED BU-RD BU-RD A:13 GY-OG A:16 RD-YE BK-YE 63/53 64/90 3/156 3/155 64/111 RD-YE GY-OG 8/36 31/52 TP 39103202 C30 2007...

  • Page 120: Transmission M66

    Group 43 Transmission Transmission M66 15/31 4/56 E:22 A:39 8/134 63/25 WH-BK BK-OG 31/10 TP 39103202 C30 2007...

  • Page 121: Group 59 Brake System

    Group 59 Brake system Brake control system & DSTC 15/31 3/254 4/56 A:17 4/16 GN-YE DSTC 7/124 7/31 7/32 WH-RD BN-RD 64/816 64/113 7/56 64/817 7/57 YE-GN YE-GN WH-GN WH-GN YE-RD BN-RD 7/164 YE-RD BN-RD 31/80 31/119 TP 39103202 C30 2007...

  • Page 122: Group 64 Steering

    B:54 64/111 B:41 4/46.3 4/46.6 B:49 A:41 5 CYL 4 CYL B:50 2,4 L D 1,8 L A:30 B:22 B:23 X 15 4/46.7 A:41 4 CYL 1,6 L A:30 4/56 A:17 3/254 4/16 6/71 GY-BU 31/114 TP 39103202 C30 2007...

  • Page 123: Group 83 Doors And Openings

    UNLOCK LOCK LOCK F:12 A:14 3/126 3/127 63/12 A:28 C:31 C:24 63/25 A:12 A:12 64/41 64/43 A:18 A:18 A:13 A:13 A:11 A:11 BN-WH BN-OG A:15 63/198 A:15 A:10 A:10 63/195 3/75 3/74 31/115 31/116 31/10 31/84 TP 39103202 C30 2007...

  • Page 124: Central Locking, Trunk Lid/Tailgate

    Group 83 Doors and openings Central locking, trunk lid/tailgate 15/31 4/56 E:21 E:22 63/25 A:28 63/12 A:14 BK-RD BK-YE 10/3 3/35 7/101 63/174 63/196 3/78 31/11 31/84 31/10 TP 39103202 C30 2007...

  • Page 125: Central Locking, Fuel Filler Flap

    Group 83 Doors and openings Central locking, fuel filler flap 15/31 4/56 E:21 E:22 A:28 63/25 A:14 63/12 A:34 3/111 FF = FRONT FOG LIGHTS ON RF = REAR FOG 6/37 63/175 63/6 31/12 31/6 31/84 31/10 TP 39103202 C30 2007...

  • Page 126: Signal Receiver, Remote-Control, Central Locking

    Group 83 Doors and openings Signal receiver, remote-control, central locking 15/31 4/56 E:21 E:22 A:35 A:41 4/103 63/5 BK-YE 31/83 TP 39103202 C30 2007...

  • Page 127: Power Windows

    Group 83 Doors and openings Power windows 15/31 3/80 4/56 E:21 C:31 C:24 3/126 3/127 A:12 A:16 GN-RD 64/41 64/43 3/83 63/195 63/198 3/82 3/81 Window Control Switch 31/115 31/116 TP 39103202 C30 2007...

  • Page 128: Power Sunroof

    Group 83 Doors and openings Power sunroof 15/31 64/111 5 4/56 E:20 E:22 E:21 A:30 3/25 CLOSE SLIDE OPEN OPEN TILT CLOSE F 31 3/117 D:14 H:18 H:20 A:28 D:12 C:11 63/10 63/211 BK-BU 10/22 BK-BU WH-GN 4/33 63/25 31/10 TP 39103202 C30 2007...

  • Page 129: Group 84 Exterior Decorative Elements, Etc

    Power rear view mirrors 15/31 4/56 E:21 C:31 C:24 64/41 64/43 3/127 3/126 A:12 A:18 A:18 A:11 A:12 A:14 64/43 64/41 64/35 64/333 16 14 16 14 6/62 6/63 3/81 WINDOW GN-YE POWER CONTROL SWITCH 63/198 31/115 31/116 TP 39103202 C30 2007...

  • Page 130: Heated Door Mirrors

    Group 84 Exterior decorative elements, etc. Heated door mirrors 15/31 3/112 4/56 E:21 C°/F° C:31 C:24 64/43 64/41 3/127 3/126 A:18 A:18 B:11 B:11 B:12 B:12 A:12 A:12 64/333 64/35 6/62 6/63 9/34 9/33 64/43 64/41 31/115 31/116 TP 39103202 C30 2007...

  • Page 131: Heated Rear Window

    Group 84 Exterior decorative elements, etc. Heated rear window 15/31 2/82 3/112 4/56 E:30 C°/F° A:17 GN-WH A:42 GY-BK A:14 64/113 GN-BU GN-BU 64/48 64/48 63/196 63/174 63/12 31/11 31/84 TP 39103202 C30 2007...

  • Page 132: Blind Spot Information System

    15/31 4/56 E:21 C:31 C:24 64/25G 64/43 64/41 OG-BU 3/286 3/127 3/126 A:18 A:18 B:12 B:12 GN-WH GN-WH 64/25G 64/25G BU-RD BU-RD 3/112 C°/F° 64/333 64/35 4/126 4/127 10/255 10/256 64/43 64/41 63/25 31/116 31/10 31/115 TP 39103202 C30 2007...

  • Page 133: Group 85 Interior Equipment

    GN-RD 31 S GN-BK 6/19 BK-YE GY-RD CAN + B:11 PK-RD BU-RD CAN - GN-BK 3/287 BK-YE 3/26 UNLOCK GN-BK LOCK 6/18 BK-YE B:13 YE-RD GN-BK 7/230 6/17 RD-WH B:10 BK-YE B:14 BU-RD BK-WH GN-BK 31/66 TP 39103202 C30 2007...

  • Page 134: Power Driver's Seat With Memory Function, Rhd

    GN-RD 31 S GN-BK 6/19 BK-YE GY-RD CAN + B:10 PK-RD BU-RD CAN - GN-BK 3/288 BK-YE 3/26 UNLOCK B:14 GN-BK LOCK 6/18 BK-YE YE-RD GN-BK 7/231 6/17 RD-WH B:11 BK-YE BU-RD BK-WH B:12 GN-BK 31/67 TP 39103202 C30 2007...

  • Page 135: Power Passenger Seat With Memory Function, Lhd

    GN-RD 31 S GN-BK 6/20 BK-YE GY-RD CAN + B:10 PK-RD BU-RD CAN - GN-BK 3/288 BK-YE 3/27 UNLOCK B:14 GN-BK LOCK 6/66 BK-YE YE-RD GN-BK 7/231 6/65 RD-WH B:11 BK-YE BU-RD BK-WH B:12 GN-BK 31/67 TP 39103202 C30 2007...

  • Page 136: Power Passenger Seat With Memory Function, Rhd

    GN-RD 31 S GN-BK 6/20 BK-YE GY-RD CAN + B:11 PK-RD BU-RD CAN - GN-BK 3/287 BK-YE 3/27 UNLOCK GN-BK LOCK 6/66 BK-YE B:13 YE-RD GN-BK 7/230 6/65 RD-WH B:10 BK-YE B:14 BU-RD BK-WH GN-BK 31/66 TP 39103202 C30 2007...

  • Page 137: Heated Seats

    Heated seats 15/31 3/112 64/111 64/545 WH-GN 4/56 A:17 E:20 A:42 C:42 C:43 64/112 64/112 2/193 WH-GN 64/30 64/31 9/12 9/13 9/16 9/17 7/110 7/111 9/18 9/19 64/31 64/30 63/171 63/172 63/172 63/171 31/67 31/66 31/66 31/67 TP 39103202 C30 2007...

  • Page 138: Group 87 Climate Control System

    A:14 64/35 RHD 4 CYL A:13 1,8 L A:28 A:25 63/63 A:35 64/545 A:41 3/112 A:30 OG-GN C°/F° WH-GN 6/28 YE-GN 4/31 BN-GN BU-WH GN-YE 63/25 6/117 64/114 YE-RD 63/53 63/108 BN-GN WH-GN 31/10 31/110 31/52 TP 39103202 C30 2007...
  • Page 139 Group 87 Climate control system Climate control system, 4-cyl. Gasoline 2:2 6/95 6/96 6/102 6/48 6/103 7/159 64/545 7/41 BU-YE GN-OG TP 39103202 C30 2007...

  • Page 140: Climate Control System, 5-Cyl.1:2

    64/333 LHD 64/35 RHD B:28 B:51 B:31 B:47 B:16 B:58 5 CYL 2,4 L B:45 64/545 3/112 OG-GN 64/114 GN-OG C°/F° WH-GN YE-GN BU-WH BN-GN GN-YE 6/28 63/25 4/31 6/117 63/108 YE-RD BN-GN WH-GN 31/10 31/110 TP 39103202 C30 2007...
  • Page 141 Group 87 Climate control system Climate control system, 5-cyl. 2:2 6/95 6/96 6/102 6/48 6/103 7/159 64/545 7/41 BU-YE GN-OG TP 39103202 C30 2007...

  • Page 142: Climate Control System, Diesel 1.6L & 2.0L 1:2

    64/35 RHD 4/46.5 C:E2 A:C4 4 CYL 1,6 L D A:G3 B:E1 A:A3 A:A4 3/112 64/545 OG-GN GN-OG C°/F° WH-GN 6/28 YE-GN 4/31 BN-GN BU-WH GN-YE 63/25 6/117 63/108 YE-RD 64/114 63/53 BN-GN WH-GN 31/10 31/110 31/52 TP 39103202 C30 2007...
  • Page 143 Group 87 Climate control system Climate control system, Diesel 1.6l & 2.0l 2:2 6/95 6/96 6/102 6/48 6/103 7/159 64/545 7/41 BU-YE GN-OG TP 39103202 C30 2007...

  • Page 144: Climate Control System Ptc Element

    Group 87 Climate control system Climate control system PTC element 15/31 64/111 64/861 4/56 A:17 E:22 E:21 9/41 GN-OG WH-BK 64/862 1 31/112 TP 39103202 C30 2007...

  • Page 145: Parking Heater, Auxiliary Heater

    Group 87 Climate control system Parking heater, auxiliary heater 15/31 4/56 3/112 C°/F° G:32 G:16 RD-OG C:11 6/73 C:10 C:14 C:13 64/113 64/51 C:12 RD-OG RD-OG 6/35 BK-OG BK-OG 9/30 FLAME COOLANT GLOW TEMP OVERHEAT 63/172 63/109 63/108 31/110 31/66 TP 39103202 C30 2007...

  • Page 146: Electric Engine Heater Flexifuel

    Group 87 Climate control system, Electric engine heater Flexifuel 9/41.1 31/102 TP 39103202 C30 2007...

  • Page 147: Group 88 Internal Equipment

    Group 88 Internal equipment Auto-dimming rearview mirror 15/31 64/111 5 4/56 E:22 E:21 A:30 2/80 A:28 D:12 8/48 63/10 63/211 63/25 31/10 TP 39103202 C30 2007...

  • Page 148: Supplemental Restraint System (Srs) 1:2

    A:55 RD-BN A:64 BK-OG WH-BN BN-RD A:65 BN-GN USA/CDN USA/CDN 7/93 3/255 A:51 BU-YE WH-RD A:57 A:52 GY-BK BN-RD BN-RD A:54 GN-BK RD-GN 63/130 BK-GN 63/171 31/10 31/66 LHD, 31/67 RHD 31/67 31/67 LHD, 31/66 RHD TP 39103202 C30 2007...
  • Page 149 7/195 7/194 A:73 A:70 YE-BK BU-YE A:72 A:71 GY-YE BU-BK USA/CDN USA/CDN 8/67 8/66 A:40 A:37 A:39 BK-RD A:38 BK-BU 7/228 7/229 64/41 64/43 A:60 WH-RD WH-RD A:59 WH-RD WH-RD A:61 BN-RD BN-RD A:58 BN-RD BN-RD TP 39103202 C30 2007...

  • Page 150: Connectors

    Lap belt tensioner, driver BK-RD System Module (SRS) 63/130 Branching point, USA/CDN BN-RD 3/255:2 Driver’s seat position sensor, USA/CDN 4/9A:33 Supplemental Restraint 8/51:1 Igniter side airbag, driver’s System Module (SRS) side 4/9A:36 Supplemental Restraint System Module (SRS), RHD continues TP 39103202 C30 2007...
  • Page 151 4/52B:6 Power Seat Module (PSM), memory, LHD 4/9A:64 Supplemental Restraint Sys- WH-BN 3/93:1 Belt buckle contact, driver’s BK-OG tem Module (SRS) seat 4/9A:65 Supplemental Restraint Sys- BN-GN 3/93:2 Belt buckle contact, driver’s tem Module (SRS) seat TP 39103202 C30 2007...
  • Page 152 Branching point OG-BU 4/54B:6 Power Seat Module (PSM) RD-GN 4/54B:1 Power Seat Module (PSM), 4/56C:29 Central Electronic Module OG-YE 4/54A:1 Power Seat Module (PSM), RD-BU (CEM) 4/56C:30 Central Electronic Module 4/54A:7 Power Seat Module (PSM) (CEM) continues TP 39103202 C30 2007...
  • Page 153 Lock unit, driver’s door 4/56F:18 Central Electronic Module (CEM), RHD 4/56F:19 Central Electronic Module (CEM), LHD 16/128:5 Antenna, front left door lock 4/93D:20 Keyless Vehicle Module (KVM) 16/128:4 Antenna, front left door lock 4/93D:2 Keyless Vehicle Module (KVM) continues TP 39103202 C30 2007...
  • Page 154 16/105 B:9 Audio Module (AUD) 64/112:9 Connector 7/228:1 Side impact sensor, left door WH-RD 4/9A:60 Supplemental Restraint Sys- WH-RD tem Module (SRS) 7/228:2 Side impact sensor, left door BN-RD 4/9A:61 Supplemental Restraint Sys- BN-RD tem Module (SRS) TP 39103202 C30 2007...
  • Page 155 16/105B:11 Audio Module (AUD) 64/112:11 Connector 7/229:1 Side impact sensor, right door WH-RD 4/9A:59 Supplemental Restraint Sys- WH-RD tem Module (SRS) 7/229:2 Side impact sensor, right door BN-RD 4/9A:58 Supplemental Restraint Sys- BN-RD tem Module (SRS) TP 39103202 C30 2007...
  • Page 156 OG-YE 4/56C:7 Central Electronic Module OG-YE (CEM) 64/50 12-pin black Rear axle harness Floor harness 7/120:1 Angle sensor, Bi-Xenon rear 64/113:27 Connector 7/120:4 Angle sensor, Bi-Xenon rear 64/113:19 Connector 7/120:5 Angle sensor, Bi-Xenon rear 64/113:20 Connector TP 39103202 C30 2007...
  • Page 157 BK-WH 6/67:4 Pump, fuel leakage control GN-BU 64/113:13 Connector GN-BU 6/35B:2 Fuel pump, auxiliary heater BK-OG 63/172 Branching point BK-OG 4/83:1 Control module fuel pump WH-BK 64/113:7 Connector WH-BK 9/38:1 Heated fuel filter, 5-cyl. Diesel GN-RD TP 39103202 C30 2007...

  • Page 158: Engine Compartment Harness

    8/7:2 Injection valves BK-YE 4/46.7A:13 Engine Control Module (ECM), BK-YE 4-cyl. 1.6l 8/8:2 Injection valves BK-BU 4/46.7A:28 Engine Control Module (ECM), BK-BU 4-cyl. 1.6l 8/9:2 Injection valves 4/46.7A:12 Engine Control Module (ECM), BK-OG BK-OG 4-cyl. 1.6l TP 39103202 C30 2007...
  • Page 159 4/46.4B:E1 Engine control module (ECM), 4/109:8 Glow plug control module, 4- BK-YE 4-cyl. 2.0l Diesel cyl. Diesel 4/46.5C:F2 Engine control module (ECM), 4-cyl. 1.6l Diesel 4/28A:11 Transmission Control Module GN-YE 4/56E:3 Central Electronic Module GN-YE (TCM), 5-Cyl. (CEM) continues TP 39103202 C30 2007...
  • Page 160 5-Cyl. 2.5l T. 4/46.4A:E2 Engine control module (ECM), WH-GN 4/56G:30 Central Electronic Module WH-GN 4-cyl. 2.0l Diesel (CEM), Diesel 4/46.5C:B3 Engine control module (ECM), 4-cyl. 1.6l Diesel 64/51:14 Connector WH-BK 2/142:5 Fuel filter preheater relay WH-BK continues TP 39103202 C30 2007...
  • Page 161 5-cyl. 2.4l 4/46.2B:15 Engine Control Module (ECM), 5-cyl. 2.5l T 4/46.4B:G4 Engine control module (ECM), 2/142:5 Relay, 5-Cyl. 2.4l Diesel 4-cyl. 2.0l Diesel F30:2 Fuse 4/46.7B:9 Engine Control Module (ECM), 4-cyl. 1.6l 63/85 Branching point continues TP 39103202 C30 2007...

  • Page 162: Engine Harness

    Engine Control Module (ECM), 4-cyl. 1.8l 4/46.7A:9 Engine Control Module (ECM), 4-cyl. 1.6l 8/3:1 Electromagnetic clutch, climate GN-YE 2/22:5 Relay, climate control system GN-YE control system, 4-Cyl. 8/3:2 Electromagnetic clutch, climate control system, 4-Cyl. Diesel continues TP 39103202 C30 2007...
  • Page 163 Branching point 4/46.1B:20 Engine Control Module (ECM), WH-BK 64/113:7 Connector WH-BK 5-cyl. 4/46.2B:21 Engine Control Module (ECM), 5-cyl. 2.5l T 64/600:1 Connector, 4-Cyl. Diesel GN-OG 4/109:1 Glow plug control module, Die- GN-OG 20/26:1 Glow plug WH-RD continues TP 39103202 C30 2007...
  • Page 164 YE-RD 5-cyl. 2.4l trol system 4/46.2B:31 Engine Control Module (ECM), 5-cyl. 2.5l T 4/46.3B:16 Engine control module (ECM), 5-cyl. 2.4l Diesel 4/46.6A:28 Engine Control Module (ECM), 4-cyl. 1.8l 4/46.7A:17 Engine Control Module (ECM), 4-cyl. 1.6l continues TP 39103202 C30 2007...
  • Page 165 4/46.7A:10 Engine Control Module (ECM), 4-cyl. 1.6l 4/46.3A:32 Engine control module (ECM), GN-BU 4/109:10 Glow plug control module, Die- YE-GN 5-cyl. 2.4l Diesel 7/82:1 Rear heated oxygen sensor, GN-YE 63/13 Branching point, Turbo GN-YE Turbo continues TP 39103202 C30 2007...
  • Page 166 4-cyl. 1.6l Diesel 4/46.5B:M2 Engine control module (ECM), 4-cyl. 1.6l Diesel 4/46.6A:34 Engine Control Module (ECM), 4-cyl. 1.8l 4/46.7B:8 Engine Control Module (ECM), 4-cyl. 1.6l 7/15:4 Side impact sensor, front left GN-YE 63/65 Branching point GN-BU TP 39103202 C30 2007...
  • Page 167 Lamp housing, front left 63/139 Branching point 10/2:12 Lamp housing, front right 7/178:1 Front impact sensor, right 4/9B:5 Supplemental Restraint Sys- tem Module (SRS) 7/178:2 Front impact sensor, right 4/9B:9 Supplemental Restraint Sys- tem Module (SRS) TP 39103202 C30 2007...
  • Page 168 Integrated Audio Module (IAM) WH-VT 16/6:1 Speaker, rear left WH-VT 16/1A:13 Integrated Audio Module (IAM) GY-WH 16/6:2 Speaker, rear left GY-WH 16/1A:3 Audio Module (AUD) 16/5:1 Loudspeaker, rear right 16/1A:10 Integrated Audio Module (IAM) 16/5:2 Loudspeaker, rear right TP 39103202 C30 2007...
  • Page 169 64/50:9 Connector 4/112A:3 Gas Discharge Lamp Module (GDL), master, left 7/121:5 Angle sensor, Bi-Xenon front 4/110C:2 Trailer Module (TRM) F14:2 Fuse 64/50:7 Connector 4/112A:4 Gas Discharge Lamp Module (GDL), master, left 7/121:1 Angle sensor, Bi-Xenon front TP 39103202 C30 2007...
  • Page 170 Igniter, airbag stage 2, passenger side 4/9B:11 Supplemental Restraint Sys- 8/32:1 Igniter, airbag stage 2, tem Module (SRS) passenger side 4/9B:10 Supplemental Restraint Sys- BK-YE 8/32:2 Igniter, airbag stage 2, BK-YE tem Module (SRS) passenger side TP 39103202 C30 2007...
  • Page 171 6/117:3 Interior temperature sensor 3/112:7 Climate Control Module (CCM) WH-GN 6/48:2 Damper Motor Module (DMM), 64/112:6 Connector recirculation 6/96:2 Damper Motor Module (DMM), right-hand side 6/102:2 Damper Motor Module (DMM), defroster 7/159:2 Air Quality Sensor (AQS) TP 39103202 C30 2007...
  • Page 172 Floor harness ABS Rear, right harness 64/113:3 Connector YE-GN 7/57:1 Sensor ABS, rear right 64/113:4 Connector WH-GN 7/57:2 Sensor ABS, rear right 64/861 1-pin black PTC-element, climate control system Engine compartment harness harness 9/41A:2 PTC-element F5:2 Fuse TP 39103202 C30 2007...
  • Page 173 Branching point 64/1400:1 Connector 7/207:2 Front parking assistance sensor 64/1400:2 Connector 7/206:2 Front parking assistance sensor 64/1400:3 Connector 7/205:2 Front parking assistance sensor 64/1400:4 Connector 7/204:2 Front parking assistance sensor 64/1400:5 Connector 63/616 Branching point 64/1400:6 Connector TP 39103202 C30 2007...
  • Page 174 (PAM) 4/86B:8 Parking Assistance Module 64/1300:2 Connector (PAM) 4/86B:7 Parking Assistance Module 64/1300:3 Connector (PAM) 4/86B:6 Parking Assistance Module 64/1300:4 Connector (PAM) 4/86B:5 Parking Assistance Module 64/1300:5 Connector (PAM) 4/86B:1 Parking Assistance Module 64/1300:6 Connector (PAM) TP 39103202 C30 2007...

  • Page 175: Branching Points

    4/33:7 8/48:1 63/10 31/10 63/11 63/26 RD-BK 10/3A:1 4/56C:3 OG-BK BU-BK 64/791 10/3B:1 OG-BK 10/18C5:1 64/322 63/11 63/26 63/11G 63/27 4/56 BK-YE 10/3A:2 BK-GN 64/791 10/3B:2 RD-YE 16/1A:1 63/11G OG-YE RD-YE 16/108A:1 16/46A:1 63/27 RD-YE 16/46A:2 TP 39103202 C30 2007...
  • Page 176 BK-YE Turbo 2,5L 4/46.2B:2 BK-YE Turbo 2,5L 4/46.2B:4 YE-RD 4/46.5B:4 Turbo 2,5L BK-YE 3/10:1 4/46.2B:6 AW55-51 2,4L BK-YE BK-YE 4/28A:9 4/46.1B:1 YE-RD 6/99:1 63/53 BK-YE 2,4L 4/46.1B:2 YE-VT 7/21:1 BK-YE 2,4L 4/46.1B:3 WH-GN 8/122:1 63/41 31/52 TP 39103202 C30 2007...
  • Page 177 GN-BU GN-OG 6/143:1 7/17:1 Diesel Turbo GN-BU GN-BU 4/46.3B:5 4/46.2B:3 63/54 GN-BU Diesel GN-BU 4/46.1B:4 64/90 GN-BU 64/90 GN-BU 4/46.1B:6 63/56 63/67 GN-BK 7/165:4 64/90 7/16:2 AW55-51 5-Cyl Turbo 4/46.6B:30 4/28A:1 4/46.2B:16 63/67 63/56 5-Cyl 4/46.1B:54 TP 39103202 C30 2007...
  • Page 178 GN-RD 64/90 20/5:2 RD-GN RD-GN 3/1B:5 4/56A:15 GN-YE GN-BK 20/3:2 20/6:2 63/88 63/95 GN-BU 20/4:2 63/91G 63/97 4/56 YE-RD YE-RD 20/6:2 20/3:2 YE-RD YE-RD 20/7:2 20/4:2 63/97 YE-RD YE-RD 4/46.1A:12 20/5:2 GN-YE GN-YE 4/112A:6 4/113A:6 63/91G TP 39103202 C30 2007...
  • Page 179 BK-BU 7/4:1 4/7A:2 4-cyl Diesel BK-BU 10/6:2 8/127:1 4-cyl Diesel BK-BU Bi-X 4/113A:10 8/127:3 BK-OG 4-cyl Bi-X C:40 8/119:1 10/2:9 63/109 5-cyl 3/271:2 10/2:4 4-cyl BU-BK 64/79V WH-RD GN-BU 16/105B:6 16/150 BU-BK 5-cyl 63/108 63/135 7/5:1 TP 39103202 C30 2007...
  • Page 180 64/51 4/93C:5 64/48 63/172 64/31 64/30 9/2B:1 3/35:2 63/196 31/66 63/173 63/198 4/56 BN-OG 3/126A:11 BN-OG 3/74:1 3/258:2 BN-OG 3/74:8 3/262:6 63/198 C:20 3/80:1 3/74:4 OG-BU OG-BU 10/24:2 64/31 3/81:3 3/74:1 OG-BU GN-WH 64/51 64/30 63/173 TP 39103202 C30 2007...
  • Page 181 63/214 63/222 63/215 63/223 GY-RD BU-RD BU-RD 4/56G:15 64/90 4/56G:14 GY-RD GY-RD BU-RD BU-RD 6/71A:3 63/222 4/16:15 63/216 63/215 63/223 63/216 63/228 GY-RD BU-RD 4/56G:14 63/232 GY-RD GY-RD BU-RD BU-RD 6/71A:2 63/223 64/322 63/220 63/216 63/228 TP 39103202 C30 2007...
  • Page 182 63/229 63/339 63/422 WH-GN BU-RD 3/1A:2 4/110B:2 WH-GN WH-GN BU-RD 4/102:4 BU-RD 4/56B:17 4/86A:7 64/322 63/339 63/422 63/415 63/615 YE-RD 7/134:1 7/207:1 YE-RD 7/133:1 7/206:1 YE-RD YE-RD 64/53 7/205:1 64/1300 7/132:1 63/415 63/615 YE-RD 7/131:1 7/204:1 TP 39103202 C30 2007...
  • Page 183 Branching points 63/616 - 63/SH8 63/616 7/207:3 7/206:3 64/1300 7/205:3 63/616 7/204:3 63/SH8 63/74 63/SH7 63/SH8 TP 39103202 C30 2007...

  • Page 184: Engine Harness, Gasoline 4-Cyl 1.6

    Engine harness, Gasoline 4-Cyl 1.6 63/74 63/SH8 64/90 63/53 64/60 64/120 Routing of the cable harnesses in the vehicle Engine harness, Gasoline 4-Cyl 1.8 63/99 63/74 63/H03 63/54 31/52 63/US02 63/67 63/95 63/63 64/90 63/53 63/226 64/120 63/227 TP 39103202 C30 2007...

  • Page 185: Routing Of The Cable Harnesses In The Vehicle

    31/89 63/61 31/52 63/98 63/94 64/90 4/28 63/53 63/65 63/54 64/120 63/56 Routing of the cable harnesses in the vehicle Engine harness, Gasoline 5-Cyl Turbo 63/103 31/88 31/52 63/98 4/46 64/90 4/28 63/53 63/65 63/54 63/56 TP 39103202 C30 2007...

  • Page 186: Engine Harness, Diesel 1.6L

    Engine harness, Diesel 1.6l 64/600 63/42 64/120 64/90 4/56 C 63/41 4/56 B 4/56 A Routing of the cable harnesses in the vehicle Engine harness, Diesel 2.0l 64/600 31/52 64/90 63/53 64/120 63/54 63/65 4/46C 4/46B 4/46A TP 39103202 C30 2007...

  • Page 187: Engine Harness, Diesel 2.4L

    Routing of the cable harnesses in the vehicle Engine harness, Diesel 2.4l 31/52 63/85 64/90 63/53 63/54 4/46B 4/46A 63/65 TP 39103202 C30 2007...

  • Page 188: Engine Compartment Harness, 4-Cyl

    63/121 63/215 Routing of the cable harnesses in the vehicle Engine compartment harness, 5-Cyl. 63/131 & 64/113 64/114 64/111 63/132 63/93 63/124 4/56E 63/108 63/222 31/110 63/223 63/131 & 63/132 63/92 63/215 63/109 63/216 63/120 63/121 TP 39103202 C30 2007...

  • Page 189: Dashboard Harness, Lhd

    63/5 64/545 63/6 64/40 64/97 Routing of the cable harnesses in the vehicle Dashboard harness, RHD 63/28 63/339 63/27 63/29 64/25G 63/5 63/139 63/88 63/6 64/40 64/97 64/190 63/25 64/545 64/114 4/56A 4/56B 64/111 63/12 64/112 TP 39103202 C30 2007...

  • Page 190: Floor Harness, Lhd

    64/48A 64/48 63/175 63/26 64/322 63/229 64/978 64/43 64/791 63/228 64/31 63/174 64/817 64/112 63/171 64/113 63/130 64/50 4/56F 63/173 63/170 63/135 63/233 63/232 64/816 4/56C 64/51 64/190 64/30 64/41 63/172 63/221 63/220 64/97 64/179 G017208 TP 39103202 C30 2007...

  • Page 191: Floor Harness, Rhd

    Floor harness, RHD 64/48A 63/175 63/26 63/229 64/978 64/322 64/48 63/228 64/791 64/43 63/174 64/30 63/171 64/817 64/97 64/179 64/50 63/221 63/220 63/170 64/31 64/190 64/816 64/51 4/56F 4/56C 63/172 64/41 64/113 63/173 63/135 63/232 64/112 63/233 G017209 TP 39103202 C30 2007...

  • Page 192: Roof Harness

    Routing of the cable harnesses in the vehicle Roof harness 63/213 63/10 63/214 63/211 4/56H 4/56D G017207 Routing of the cable harnesses in the vehicle Tunnel harness 64/25G TP 39103202 C30 2007...

  • Page 193: Driver's Door Harness

    Routing of the cable harnesses in the vehicle Driver’s door harness 63/198 G017210 64/41 Routing of the cable harnesses in the vehicle Passenger door harness 63/195 G017672 64/43 TP 39103202 C30 2007...

  • Page 194: Trunk Lid Harness

    Routing of the cable harnesses in the vehicle Trunk lid harness 64/48 63/198 G017211 TP 39103202 C30 2007...

  • Page 195: Component Images

    R10 - R7 - R12 - R3 - R1 - R11 - R8 - R5 - R4 - R2 - R14 - R13 - 2-22 2-63 2/23 Relay, fuel pump 2/64 Auxiliary light relay accessory 2-23 2-64 TP 39103202 C30 2007...
  • Page 196 2/182 Relay, headlight washer motor R 10 R 12 R 11 R 13 R 14 2-182 2-89 2/92 Relay, windshield washer motor 2/193 Relay, comfort functions 2-193 2-92 2/93 Relay, rear window washer motor Ignition switch 2-93 TP 39103202 C30 2007...
  • Page 197 Switch unit, power driver’s seat 3-26 Switch, heated rear window/exterior rearview mirrors 3/27 Switch unit, power passenger seat 3-27 Contact brake light 3/35 Switch, handle, trunk lid/tailgate G017600 3/10 Reversing light contact 3/37 Contact horn 3-10 3-37 TP 39103202 C30 2007...
  • Page 198 3-46 3-75 3/47 Parking brake contact 3/78 Lock unit, trunk lid/tailgate 3-47 3-78 3/60 Switch, auxiliary lights 3/80 Switch, central locking driver’s door 3-60 3/62 Hood alarm contact 3/81 Power window switches, driver’s door 3-62 G017159 TP 39103202 C30 2007...
  • Page 199 Belt buckle contact, driver’s seat 3/126 Driver Door Module (DDM) 3-93 3-126 3/94 Belt buckle contact, passenger seat 3/127 Passenger Door Module (PDM) 3-94 3-127 3/155 Program selector, automatic trans- mission 3/111 Switch unit, lights 3-111 3-155 TP 39103202 C30 2007...
  • Page 200 3/174 Switch, reduced alarm 3/256 Position sensor, passenger seat 3-174 3-256 3/217 Belt buckle contact, left rear 3/258 Contact, locking front left 3-217 3-285 3/219 Belt buckle contact, right rear 3/259 Contact, locking, front right 3-259 3-219 TP 39103202 C30 2007...
  • Page 201 3/288 Rear seat entry switch, right 3-263 3-288 3/267 Switch unit, telematics Combustion Preheater Module (CPM) 3-267 Supplemental Restraint System Mod- ule (SRS) 3/271 Contact, immobilizer, clutch pedal 3-271 3/286 BLIS switch 4/16 Brake Control Module (BCM) 3-286 4-16 TP 39103202 C30 2007...
  • Page 202 Sunroof control module 4-33 4-46_5 4/46.6 Engine Control Module (ECM), 4-cyl. 1.8l 4/46.1 Engine Control Module (ECM), 5-cyl. 4-46_1 4-46_6 4/46.2 Engine Control Module (ECM), 5-cyl. 4/46.7 Engine Control Module (ECM), 4-cyl. Turbo 1.6l 4-46_2 4-46_7 TP 39103202 C30 2007...
  • Page 203 Central Electronic Module (CEM) 4/93 Keyless Vehicle Module (KVM) 4-93 4-56 4/56 A-H Central Electronic Module (CEM) 4/102 Steering Column Lock Module (SCL) 4-102 4-56_A-H 4/71 Cooling fan control module 4/103 Remote Receiver Module (RRX) 4-71 4-103 TP 39103202 C30 2007...
  • Page 204 4/126 Left Camera Module (LCM) 4-109 4-126 4/110 Trailer Module (TRM) 4/127 Right Camera Module (RCM) 4-110 4-127 4/111 Additive Dosing Module (ADM) Driver Information Module (DIM) 4-111 4/112 Gas Discharge Lamp Module, master, left Wiper Motor Module (WMM) 4-112 TP 39103202 C30 2007...
  • Page 205 Motor driver’s seat, up/down front edge 6/26 Alternator 6-17 6-26 6/18 Motor driver’s seat, up/down rear edge 6/28 Motor, passenger compartment fan 6-18 6-28 6/19 Motor driver’s seat, fore/aft 6/29 Motor, electric cooling fan 6-19 6-29 TP 39103202 C30 2007...
  • Page 206 Fuel pump, auxiliary heater 6/62 Power rear-view mirror driver’s door 6-35 6-62 6/63 Power passenger door mirror 6/37 Lock motor, fuel filler flap G017217 6-63 6/64 Motor, passenger seat backrest angle 6/38 Motor, left headlight adjustment 6-38 6-64 TP 39103202 C30 2007...
  • Page 207 Pump, fuel leakage control 6/99 Engine EGR 6-67 6-99 6/71 Electrical Power Steering Module 6/102 Damper Motor Module (DMM), (EPS) defroster 6-71 6-102 6/103 Damper Motor Module (DMM), floor/ventilation 6/73 Coolant pump, auxiliary heater 6-73 6-103 TP 39103202 C30 2007...
  • Page 208 6/114 Vacuum pump Brake fluid level sensor 6-114 6/117 Interior temperature sensor Washer fluid level sensor 6-117 6/118 Regulator motor, swirl throttle Oil pressure monitor, 4-cyl. 6-118 7-6_4CYL 6/120 Engine throttle body Oil pressure monitor, 5-cyl. 6-120 7-6_5CYL TP 39103202 C30 2007...
  • Page 209 Pressure sensor, climate control sys- 7/17 Mass airflow sensor MAF, Turbo 7-17_T 7/12 Solar sensor, twilight sensor and indi- cator alarm 7/21 Camshaft position sensor 7-12 7-21 7/15 Heated oxygen sensor, front 7/24 Front knock sensor, 4-cyl. 7-15 7-24 TP 39103202 C30 2007...
  • Page 210 Sensor ABS, front left 7-24_T 7-31 7/25 Impulse sensor, 4-cyl. 7/32 Sensor ABS, front right 7-25 7-32 7/25 Impulse sensor, 5-cyl. 7/41 Temperature sensor evaporator 7-25_S 7-41 7/25 Impulse sensor, Turbo 7/51 Accelerator pedal sensor 7-25_T 7-51 TP 39103202 C30 2007...
  • Page 211 7-74 7/61 Sensor input speed 7/77 Temperature sensor, intake air 1 7-61 7-77_1 7/62 Sensor output speed 7/77 Temperature sensor, intake air 2 7-62 7-77_2 7/69 Sensor outdoor temperature 7/81 Pressure sensor, intake manifold 7-69 7-81 TP 39103202 C30 2007...
  • Page 212 7-111 7/93 Occupant Weight Sensor (OWS) 7/115 Side impact sensor, left B-post 7-93 7-115 7/100 Level sensor, alarm 7/116 Side impact sensor, right B-post 7-100 7-116 7/101 Glass-break sensor 7/120 Angle sensor, Bi-Xenon rear G017219 7-120 TP 39103202 C30 2007...
  • Page 213 7/123 Clutch pedal sensor 7/149 Rain Sensor Module (RSM) 7-123 7-149 7/124 Sensor brake pedal 7/154 Sensor fuel temperature 7-124 7-154 7/156 Fuel pressure and temperature sen- sor, 5-Cyl. 7/130 Fuel level sensor, ejector side 7-130 7-156_S TP 39103202 C30 2007...
  • Page 214 7/172 Position sensor camshaft, intake side 7-162 7-172 7/173 Position sensor camshaft, exhaust side 7/163 Camshaft position sensor 2 7-163 7-173 7/164 Body Sensor Cluster Stability Sensor 7/174 Differential pressure sensor, particle (BSC) filter 7-174 7-164 TP 39103202 C30 2007...
  • Page 215 7-191 7/182 Remote control IR sensor, RTI 7/192 Water detection sensor 7-182 7-192 7/186 Heated oxygen sensor, rear 7/193 Position sensor turbo 7-193 7-186 7/187 Center heated oxygen sensor 7/194 Sensor belt roller, driver 7-187 7-194 TP 39103202 C30 2007...
  • Page 216 7/228 Side impact sensor, left door 8/19 Solenoid, variable valve timing, intake 7-228 8-19 7/229 Side impact sensor, right door 8/28 Turbocharger control valve 7-229 8-28 Electromagnetic clutch, climate con- trol system 8/30 Airbag igniter, driver’s side 8-30 TP 39103202 C30 2007...
  • Page 217 Shift solenoid 1 8-32 8-38 8/33 Igniter, belt tensioner, driver’s side 8/39 Shift solenoid 2 8-33 8-39 8/34 Igniter, belt tensioner, passenger side 8/40 Lock-up solenoid 8-34 8-40 8/36 Solenoid shift lock 8/41 Pressure solenoid 8-36 8-41 TP 39103202 C30 2007...
  • Page 218 Igniter side airbag, driver’s side 8/66 Igniter, left inflatable curtain 8-51 8-66 8/52 Igniter side airbag, passenger side 8/67 Igniter, right inflatable curtain 8-52 8-67 8/55 Igniter, left rear belt tensioner 8/71 Throttle solenoid 8-55 8-71 TP 39103202 C30 2007...
  • Page 219 8-84 8/74 Shift solenoid 5 8/92 Lap belt tensioner, driver 8-74 8-92 8/77 Control valve, fuel volume 8/98 Control valve fuel pressure 8-77 8-98 8/81 Solenoid, variable valve timing outlet 8/99 Igniter, steering column 8-81 8-99 TP 39103202 C30 2007...
  • Page 220 8-122 8/127 Pressure switch, climate control sys- 8/114 Valve mixing air/fuel 8-114 8-127 8/119 Pressure monitor, climate control system 8/128 Driver’s belt force limiter 8-119 8-128 8/120 EGR valve 8/129 Passenger belt force limiter 8-120 8-129 TP 39103202 C30 2007...
  • Page 221 8-133 9-13 9/16 Heating element, driver’s seat back- rest 8/134 Solenoid, reverse interlock, manual 8-134 9-16 9/17 Heating element, passenger seat backrest Front 12V outlet 9-17 9/18 Heating element, driver’s seat cush- Heated rear window 9-18 TP 39103202 C30 2007...
  • Page 222 Electrically heated fuel filter 9-25 9-38 9/30 Auxiliary heater 9/41 PTC-element 9-30 9-41 9/32 PTC resistor, crankcase ventilation 9/41.1 Electric engine heater 9-32 9-41-1 9/33 Electrically heated rear-view mirror, driver’s door 10/1 Lamp housing, front left 9-33 10-1 TP 39103202 C30 2007...
  • Page 223 Fog light, front left 10/14 Direction indicator, front right 10-5 10-14 10/15 Direction indicator, rear-view mirror driver’s door 10/6 Fog light, front right 10-6 10-15 10/11 Position/parking light, front 10/16 Direction indicator, passenger left door mirror 10-11 10-16 TP 39103202 C30 2007...
  • Page 224 10/43 Brake light, right G017302 10/19 Brake light extra 10/44 Tail light 1, right 10-19 G017306 10/22 Ceiling light 10/45 Tail light 2, right 10-22 G017307 10/24 Cargo compartment lighting 10/46 Fog light, right rear 10-24 G017308 TP 39103202 C30 2007...
  • Page 225 10/54 Direction indicator, left rear G017310 G017314 10/50 Brake light, left 10/55 Reversing light, left G017304 G017315 10/51 Tail light 1, left 10/64 High beam, right G017311 10-64 10/52 Tail light 2, left 10/65 Auxiliary lights, front right G017312 10-65 TP 39103202 C30 2007...
  • Page 226 10/69 Auxiliary lights, front left 10/115 Vanity mirror lighting, right 10-115 10-69 10/148 Lighting, rear-view mirror driver’s door 10/70 Low beam, left 10-148 10-70 10/149 Lighting, rear-view mirror passenger door 10/97 Courtesy lighting, left 10-97 10-149 TP 39103202 C30 2007...
  • Page 227 16-3 10/256 Warning lights BLIS right 16/4 Speaker, driver’s door 10-256 16-4 15/31 Distribution box in engine compart- ment 16/5 Loudspeaker, rear right 15-31 16-5 16/1 Integrated Audio Module (IAM) 16/6 Speaker, rear left 16-1 16-6 TP 39103202 C30 2007...
  • Page 228 16/45 Road traffic information module (RTI) 16-10 16-45 16/11 Horn 2 16/46 RTI Display 16-11 16-46 16/16 Amplifier window antenna, right 16/47 GSM/GPS/RDAR antenna 16-16 16-47 16/49 Traffic Message Channel Module (TMC) 16/26 Speaker, dashboard middle 16-26 16-49 TP 39103202 C30 2007...
  • Page 229 16-55 16-98 16/56 Treble speaker, passenger door 16/105 Audio Module (AUD) 16-56 16-105 16/60 Phone Module (PHM) 16/108 Multimedia Module (MMM) 16-60 16-108 16/62 Hand unit, cellular phone 16/128 Antenna, front left door lock 16-62 16-128 TP 39103202 C30 2007...
  • Page 230 16/133 Antenna door lock cabin 1 rear 16/140 SIM card reader 16-133 16-140 16/145 Remote Digital Audio Receiver (RDAR) 16/134 Antenna door lock cabin 2 16-134 16-145 16/135 Antenna door lock cabin 3 16/150 Amplifier window antenna, left 16-135 16-150 TP 39103202 C30 2007...
  • Page 231 7-pin outlet, tow hitch cable harness 20/17 Transformer, ignition coils 17-38 20-17 17/39 13-pin outlet, tow hitch cable har- ness 20/22-26 Glow plug 17-39 20-22_26 17/40 External equipment input (AUX) 26/5 DC/AC converter, fuel tank 17-40 26-5 TP 39103202 C30 2007...
  • Page 232 31-6 31-66 31/10 Ground connection, A-post passen- 31/67 Ground connection, Front seat sup- ger side port right side 31-10 31-67 31/80 Ground connection, Left MacPherson strut tower 31/11 Ground connection, Rear left side 31-11 31-11 31-80 TP 39103202 C30 2007...
  • Page 233 MacPherson strut tower 31/88 Ground connection, Engine 31-112 31-88 31/114 Ground connection, Left MacPher- son strut tower 31/89 Ground connection, Engine 31-89 31-114 31/102 Ground connection, Front member 4-Cyl. 31/115 Ground connection, A-post left 31-102 31-115 TP 39103202 C30 2007...
  • Page 234 31-116 64-40 31/119 Ground connection, Left MacPher- son strut tower 64/41 Connector 24 26 31-119 64-41 64/25G Connector 64/43 Connector 24 26 64-25G 64-43 64/30 Connector 64/48 Connector 64-30 64-48 64/31 Connector 64/48A Connector 64-31 G000000 TP 39103202 C30 2007...
  • Page 235 Component images 64/50 - 64/114 64/50 Connector 64/90 Connector 64-50 64-90 64/51 Connector 64/111 Connector 64-51 64-111 64/53 Connector 64/112 Connector 64-112 64-53 64/60 Connector 64/113 Connector 64-113 64-60 64/79V Connector 64/114 Connector 64-79V 64-114 TP 39103202 C30 2007...
  • Page 236 64/816 Connector 1 1 1 1 1 1 1 1 64-120 64-816 64/322 Connector 64/817 Connector 64-322 64-817 64/425 Connector 64/861 Connector 64-425 64-861 64/545 Connector 64/862 Connector 64-545 64-862 64/600 Connector 64/956 Connector 64-600 G017383 TP 39103202 C30 2007...
  • Page 237 F14 F12 F10 R 9- R 6- R 10- R 7- R 12- R 3- R 1- R 11- R 13- R 8- R 5- R 4- R 2- F28 F27 F26 F23 R 14- R-nr_E F-nr_E TP 39103202 C30 2007...
  • Page 238 10X/17C Connector interface, original car 10X/18C Connector interface, original car 10X/97 Connector interface, original car 16X/1A Connector interface, original car 16X/105A Connector interface, original car 16X/105B Connector interface, original car 64X/322 Connector interface, original car TP 39103202 C30 2007...

  • Page 239: Index 1:2

    Internal equipment, Group 88 ........147 Electronic power steering .......... 122 Emission control 4-cyl. 1.8l & 2.0l ....... 63 Emission control, 4-cyl. 1.6 ......... 62 Emission control, 5-cyl..........64 Keyless Vehicle Module (KVM) ........98 TP 39103202 C30 2007...

  • Page 240: Table Of Contents

    ........... 100 Rear window wiper/washer ......... 94 Relays ................. 24 Wiper/washer .............. 92 Relays in Engine compartment distribution box ..25 Wiring and fuses, Group 37 ........104 Relays in the Central Electronic Module (CEM) ..26 TP 39103202 C30 2007...

  • Page 241: List Of Components 1:5

    Climate Control Module (CCM) 4/113 Control module, gas discharge lamp slave, 3/117 Switch unit, ceiling light right 3/126 Driver Door Module (DDM) 4/126 Left Camera Module (LCM) 3/127 Passenger Door Module (PDM) 4/127 Right Camera Module (RCM) TP 39103202 C30 2007...
  • Page 242 Angle sensor, Bi-Xenon rear 6/120 Engine throttle body 7/121 Angle sensor, Bi-Xenon front 6/143 Regulator motor, Turbo 7/122 Mass Movement Sensor Module (MMS), front 7/123 Clutch pedal sensor Brake fluid level sensor 7/124 Sensor brake pedal TP 39103202 C30 2007...
  • Page 243 8/37 Automatic transmission 9/34 Electrically heated rear-view mirror, passen- 8/38 Shift solenoid 1 ger door 8/39 Shift solenoid 2 9/38 Electrically heated fuel filter 8/40 Lock-up solenoid 9/41 PTC-element 8/41 Pressure solenoid 9/41.1 Electric engine heater TP 39103202 C30 2007...
  • Page 244 17/38 7-pin outlet, tow hitch cable harness 10/150 Rear reading light 17/39 13-pin outlet, tow hitch cable harness 10/255 Warning lights BLIS left 17/40 External equipment input (AUX) 10/256 Warning lights BLIS right 18/4 Contact reel TP 39103202 C30 2007...
  • Page 245 64/40 Connector 16X/1A Connector interface, 64/41 Connector original car 64/43 Connector 16X/105A Connector interface, 64/48 Connector original car 64/48A Connector 16X/105B Connector interface, 64/50 Connector original car 64/51 Connector 64X/322 Connector interface, 64/53 Connector original car TP 39103202 C30 2007...

Table of Contents

Save PDF