Lenovo Y500 Hardware Maintenance Manual

Hardware maintenance manual.
Hide thumbs
Also See for Y500
User manual - 40 pages
User manual - 90 pages
User manual - 84 pages
Hardware
Maintenance
Manual

   Related Manuals for Lenovo Y500

   Summary of Contents for Lenovo Y500

  • Page 1

    Lenovo Y400/Y500 Hardware Maintenance Manual...

  • Page 2

    First Edition (September 2012) © Copyright Lenovo 2012. All rights reserved. LENOVO products, data, computer software, and services have been developed exclusively at private expense and are sold to governmental entities as commercial items as defined by 48 C.F.R. 2.101 with limited and restricted rights to use, reproduction and disclosure.

  • Page 3: Table Of Contents

    Supervisor password ........24 Power management .......... 25 Screen blank mode ........25 Putting your computer to sleep....25 Shutting down the computer..... 26 Lenovo Y400/Y500 ........27 Specifications ............. 27 Status indicators ..........30 Fn key combinations ......... 32 FRU replacement notices........33...

  • Page 4: About This Manual

    This manual is intended only for trained servicers who are familiar with Lenovo products. Use this manual to troubleshoot problems effectively. Before servicing a Lenovo product, make sure to read all the information under “Safety information” on page 1 and “Important service information”...

  • Page 5: Safety Information

    Safety information Safety information This chapter presents the following safety information that you need to get familiar with before you service a Lenovo computer: • see “General safety” on page 2 • see “Electrical safety” on page 3 • see “Safety inspection guide” on page 5 •...

  • Page 6: General Safety

    Lenovo Y400/Y500 Hardware Maintenance Manual General safety Follow these rules below to ensure general safety: • Observe a good housekeeping in the area where the machines are put during and after the maintenance. • When lifting any heavy object: 1. Make sure that you can stand safely without slipping.

  • Page 7: Electrical Safety

    Safety information Electrical safety Observe the following rules when working on electrical equipments. Important: Use only approved tools and test equipments. Some hand tools have handles covered with a soft material that does not insulate you when working with live electrical currents. Many customers have rubber floor mats near their machines that contain small conductive fibers to decrease electrostatic discharges.

  • Page 8

    Lenovo Y400/Y500 Hardware Maintenance Manual • Always look carefully for possible hazards in your work area. Examples of these hazards are moist floors, nongrounded power extension cables, power surges, and missing safety grounds. • Do not touch live electrical circuits with the reflective surface of a plastic dental mirror.

  • Page 9: Safety Inspection Guide

    4. Check for cracked or bulging batteries. 5. Remove the cover. 6. Check for any obvious non-Lenovo alterations. Use good judgment as to the safety of any non-Lenovo alterations. 7. Check inside the unit for any obvious unsafe conditions, such as metal filings, contamination, water or other liquids, or signs of fire or smoke damage.

  • Page 10: Handling Devices That Are Sensitive To Electrostatic Discharge, Grounding Requirements

    Lenovo Y400/Y500 Hardware Maintenance Manual Handling devices that are sensitive to electrostatic discharge Any computer part containing transistors or integrated circuits (ICs) should be considered sensitive to electrostatic discharge (ESD). ESD damage can occur when there is a difference in charge between objects. Protect against ESD damage by equalizing the charge so that the machine, the part, the work mat, and the person handling the part are all at the same charge.

  • Page 11: Safety Notices: Multilingual Translations

    Safety information Safety notices: multilingual translations The safety notices in this section are provided in English, French, German, Hebrew, Italian, Japanese, and Spanish. Safety notice 1 Before the computer is powered on after FRU replacement, make sure all screws, springs, and other small parts are in place and are not left loose inside the computer.

  • Page 12

    Lenovo Y400/Y500 Hardware Maintenance Manual Safety notice 2 DANGER Some standby batteries contain a small amount of nickel and cadmium. Do not disassemble a standby battery, recharge it, throw it into fire or water, or short-circuit it. Dispose of the battery as required by local ordinances or regulations.

  • Page 13

    Safety information Safety notice 3 DANGER The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack.

  • Page 14

    Lenovo Y400/Y500 Hardware Maintenance Manual Safety notice 4 DANGER The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100°C (212°F), incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regulations.

  • Page 15

    Safety information Safety notice 5 If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands, immediately wash the affected areas with water at least for 15 minutes. Seek medical care if any symptoms caused by the fluid are present after washing.

  • Page 16

    Lenovo Y400/Y500 Hardware Maintenance Manual Safety notice 6 DANGER To avoid shock, do not remove the plastic cover that protects the lower part of the inverter card. Afin d’éviter tout risque de choc électrique, ne retirez pas le cache en plastique protégeant la partie inférieure de la carte d’alimentation.

  • Page 17

    Safety information Safety notice 8 DANGER Before removing any FRU, turn off the computer, unplug all power cords from electrical outlets, remove the battery pack, and then disconnect any interconnecting cables. Avant de retirer une unité remplaçable en clientèle, mettez le système hors tension, débranchez tous les cordons d’alimentation des socles de prise de courant, retirez la batterie et déconnectez tous les cordons d’interface.

  • Page 18: Laser Compliance Statement

    Lenovo Y400/Y500 Hardware Maintenance Manual Laser compliance statement Some models of Lenovo computer are equipped from the factory with an optical storage device such as a CD-ROM drive or a DVD-ROM drive. Such devices are also sold separately as options. If one of these drives is installed, it is certified in the U.S.

  • Page 19

    Safety information A CD-ROM drive, a DVD-ROM drive, or any other storage device installed may contain an embedded Class 3A or Class 3B laser diode. Note the following: DANGER Emits visible and invisible laser radiation when open. Do not stare into the beam, do not view directly with optical instruments, and avoid direct exposure to the beam.

  • Page 20: Important Service Information, Strategy For Replacing Frus

    To download software fixes, drivers, and BIOS, follow the steps below: 1. Go to http://consumersupport.lenovo.com/. 2. Enter the serial number or select a product or use Lenovo smart downloading. 3. Select the BIOS/Driver/Applications and download.

  • Page 21: Strategy For Replacing A Hard Disk Drive, Important Notice For Replacing A System Board

    Important service information Use the following strategy to prevent unnecessary expense for replacing and servicing FRUs: • If you are instructed to replace an FRU, but the replacement does not solve the problem, reinstall the original FRU before you continue. •...

  • Page 22: Important Information About Replacing Rohs Compliant Frus

    Electronic Equipment Directive (2002/95/EC) is a European Union legal requirement affecting the global electronics industry. RoHS requirements must be implemented on Lenovo products placed on the market after June 2006. Products on the market before June 2006 are not required to have RoHS compliant parts.

  • Page 23: General Checkout

    General checkout General checkout This chapter presents the following information: • see “What to do first” on page 20 • see “Power system checkout” on page 21 Before you go to the checkout, make sure to read the following important notes: Important notes: •...

  • Page 24: What To Do First

    Lenovo Y400/Y500 Hardware Maintenance Manual What to do first When you do return an FRU, you must include the following information in the parts exchange form or parts return form that you attach to it: 1. Name and phone number of servicer 2.

  • Page 25: Power System Checkout, Checking The Ac Adapter, Checking Operational Charging

    4. If the voltage is acceptable, do the following: • Replace the system board. • If the problem persists, go to see “Lenovo Y400/Y500” on page 27. Note: Noise from the AC adapter does not always indicate a defect. Checking operational charging...

  • Page 26: Checking The Battery Pack

    Lenovo Y400/Y500 Hardware Maintenance Manual Perform operational charging. If the battery status indicator or icon does not light on, remove the battery pack and let it return to room temperature. Reinstall the battery pack. If the charge indicator or icon is still off, replace the battery pack.

  • Page 27: Related Service Information, Restoring The Factory Contents By Using Recovery Disc Set

    1. Insert the bootable Start Recovery Disc into the optical drive. 2. Start the computer. When the Lenovo logo comes up, immediately press F12; on the boot sequence menu, select the optical drive as the first boot-up device.

  • Page 28: Passwords, Power-on Password, Hard-disk Password, Supervisor Password

    Windows screen is displayed. Follow the instructions on the screen to complete the Windows setup. Passwords As many as three passwords may be needed for any Lenovo computer: the power-on password (POP), the hard disk password (HDP), and the supervisor password (SVP).

  • Page 29: Power Management, Screen Blank Mode, Putting Your Computer To Sleep

    Related service information Power management Note: Power management modes are not supported for APM operating system. To reduce power consumption, the computer has three power management modes: screen blank, sleep (standby), and hibernation. Screen blank mode If the time set on the “Turn off monitor” timer in the operating system expires, the LCD backlight turns off.

  • Page 30: Shutting Down The Computer

    Lenovo Y400/Y500 Hardware Maintenance Manual Shutting down the computer If you are not going to use your computer for a long time, shut it down. To shut down your computer: 1. Open the charms, select Settings → Shut down. 2. Select Power...

  • Page 31: Lenovo Y400/y500, Specifications

    • see “Removing and replacing an FRU” on page 34 • see “Locations” on page 73 • see “Parts list” on page 76 Specifications The following table lists the specifications of the Lenovo Y400/Y500: Table 1. Specifications Feature Description Processor •...

  • Page 32

    • Intel 802.11 a/b/g/n WIFI WWAN • N/A Bluetooth • Built-in antenna with min-USB interface, select Models wireless Keyboard • 6 Row, ISO Full Size Keyboard,backlit (optional) (Y400) • 6 Row, ISO Full Size Keyboard,backlit (Y500) Touch pad • One-piece Touch pad...

  • Page 33

    Lenovo Y400/Y500 Table 1. Specifications (continued) Feature Description Finger Print • N/A Reader Integrated • HD Camera camera Battery • 6 cells, 72WH/62WH AC adapter • 120W/170W Pre-installed • Win8/Linpus operating system...

  • Page 34: Status Indicators

    Lenovo Y400/Y500 Hardware Maintenance Manual Status indicators The system status indicators below show the computer status:...

  • Page 35

    Lenovo Y400/Y500 Table 2. Status indicators Indicator Meaning Power on White: System is enabled. Blinking white: System is in sleep mode. off: System is in hibernate mode or shut down. Battery Blinking amber: (500ms off/1s on) status The remaining power of the battery is less than 5% of its capacity.

  • Page 36: Fn Key Combinations

    Lenovo Y400/Y500 Hardware Maintenance Manual Fn key combinations The following table shows the function of each combination of Fn with a function key. Table 4. Fn key combinations Fn + Esc: Cancel hotkey. Fn + F1: Enter sleep mode. Fn + F2: Turn on/off the backlight of the LCD screen.

  • Page 37: Fru Replacement Notices, Screw Notices

    This section presents notices related to removing and replacing parts. Read this section carefully before replacing any FRU. Screw notices Loose screws can cause a reliability problem. In the Lenovo computer, this problem is addressed with special nylon-coated screws that have the following characteristics: •...

  • Page 38: Removing And Replacing An Fru

    Before touching it, establish personal grounding by touching a ground point with one hand or using an electrostatic discharge (ESD) strap (P/N 6405959) to remove potential shock reasons. Note: The illustrations used in this section are of the Lenovo Y580, unless otherwise stated.

  • Page 39: Battery Pack

    Lenovo Y400/Y500 1010 Battery pack DANGER Only use the battery specified in the parts list for your computer. Any other battery could ignite or explode. Figure 1. Removal steps of battery pack Unlock the manual battery latch . Holding the spring-loaded battery latch in...

  • Page 40: Dummy Card

    Lenovo Y400/Y500 Hardware Maintenance Manual 1020 Dummy card For access, remove this FRU: • see “1010 Battery pack” on page 35 Figure 2. Removal steps of dummy cards Remove the dummy card in the direction shown by arrows...

  • Page 41: Optical Drive

    Lenovo Y400/Y500 1030 Optical drive For access, remove this FRU: • see “1010 Battery pack” on page 35 Figure 3. Removal steps of optical drive Push the latch in the direction shown by arrow . Hold the spring-loaded latch in the unlocked position .

  • Page 42: Mini Pci Express Card Slot Compartment Cover

    Lenovo Y400/Y500 Hardware Maintenance Manual 1040 Hard disk drive(HDD)/Memory/Mini PCI Express Card slot compartment cover For access, remove these FRUs in order: • see “1010 Battery pack” on page 35 • see “1030 Optical drive” on page 37 Figure 4. Removal steps of HDD/Memory/Mini PCI Express Card slot compartment...

  • Page 43: Hard Disk Drive

    Lenovo Y400/Y500 1050 Hard disk drive For access, remove these FRUs in order: • see “1010 Battery pack” on page 35 • see “1040 Hard disk drive(HDD)/Memory/Mini PCI Express Card slot compartment cover” on page 38 Attention: • Do not drop the hard disk drive or apply any physical shock to it.

  • Page 44

    Lenovo Y400/Y500 Hardware Maintenance Manual Figure 5. Removal steps of hard disk drive (continued) Pull the tab in the direction shown by arrow Take out the hard disk drive secured in a metal frame When installing: Make sure that the HDD connector is attached firmly.

  • Page 45: Dimm

    Lenovo Y400/Y500 1060 DIMM For access, remove these FRUs in order: • see “1010 Battery pack” on page 35 • see “1040 Hard disk drive(HDD)/Memory/Mini PCI Express Card slot compartment cover” on page 38 Figure 6. Removal steps of DIMM...

  • Page 46: Pci Express Mini Card For Wireless Lan/wan

    Lenovo Y400/Y500 Hardware Maintenance Manual 1070 PCI Express Mini Card for wireless LAN/WAN For access, remove these FRUs in order: • see “1010 Battery pack” on page 35 • see “1040 Hard disk drive(HDD)/Memory/Mini PCI Express Card slot compartment cover” on page 38 Figure 7.

  • Page 47

    Lenovo Y400/Y500 Figure 7. Removal steps of PCI Express Mini Card for wireless LAN/WAN (continued) When installing: • In models with a wireless LAN card that has two antenna connectors, plug the black cable (1st) (MAIN) into the jack labeled 1, and the white cable (2nd) (AUX) into jack labeled 2 on the card.

  • Page 48: Keyboard

    Lenovo Y400/Y500 Hardware Maintenance Manual 1080 Keyboard For access, remove these FRUs in order: • see “1010 Battery pack” on page 35 • see “1030 Optical drive” on page 37 • see “1040 Hard disk drive(HDD)/Memory/Mini PCI Express Card slot compartment cover”...

  • Page 49

    Lenovo Y400/Y500 Figure 8. Removal steps of keyboard (continued) Push the back of the keyboard in the direction shown by arrow . Loosen the keyboard with fingers in the direction shown by arrow . Lift the keyboard a little , and then detach the connectors in the direction shown by arrows...

  • Page 50

    Lenovo Y400/Y500 Hardware Maintenance Manual Figure 8. Removal steps of keyboard (continued)

  • Page 51: Keyboard Bezel

    Lenovo Y400/Y500 1090 Keyboard bezel For access, remove these FRUs in order: • see “1010 Battery pack” on page 35 • see “1020 Dummy card” on page 36 • see “1030 Optical drive” on page 37 • see “1040 Hard disk drive(HDD)/Memory/Mini PCI Express Card slot compartment cover”...

  • Page 52

    Lenovo Y400/Y500 Hardware Maintenance Manual Figure 9. Removal steps of keyboard bezel (continued) Y500: Remove four screws , three screws on the bottom. Step Screw (quantity) Color Torque M2.5 × 10 mm, flat-head, nylok-coated(4) Black 1.5 ~ 2.0 kgfcm M2 × 3 mm, flat-head, nylok-coated (3) Black 1.0 ~ 1.5 kgfcm...

  • Page 53

    Lenovo Y400/Y500 Figure 9. Removal steps of keyboard bezel (continued) Y500: Remove the screw . Detach the power board connector and TouchPad cable in the direction shown by arrows . IO board connector in the direction shown by arrow Step...

  • Page 54

    Lenovo Y400/Y500 Hardware Maintenance Manual Figure 9. Removal steps of keyboard bezel (continued) Remove the keyboard bezel in the direction shown by arrow...

  • Page 55: System Board

    Lenovo Y400/Y500 1100 System board Important notices for handling the system board: When handling the system board, bear the following in mind. • Be careful not to drop the system board on a bench top that has a hard surface, such as metal, wood, or composite.

  • Page 56

    Lenovo Y400/Y500 Hardware Maintenance Manual Figure 10. Removal steps of system board Y400: Remove screws . Detach camera connector in the direction shown by arrow , unplug DC-IN connector in the direction shown by arrow , LCD connector in the direction shown by arrow...

  • Page 57

    Lenovo Y400/Y500 Figure 10. Removal steps of system board Y500: Loosen three screws . Unplug LCD, speakers cable connector, DC-IN, camera connectors in the direction shown by arrows...

  • Page 58

    Lenovo Y400/Y500 Hardware Maintenance Manual Figure 10. Removal steps of system board When installing: Make sure that all the connectors are attached firmly. Step Screw (quantity) Color Torque M2.5 × 4 mm, flat-head, nylok-coated (3) Black 1.5 ~2.0 kgfcm Remove the system board in the direction shown by arrow...

  • Page 59: Lcd Unit

    Lenovo Y400/Y500 1110 LCD unit For access, remove these FRUs in order: • see “1010 Battery pack” on page 35 • see “1020 Dummy card” on page 36 • see “1030 Optical drive” on page 37 • see “1040 Hard disk drive(HDD)/Memory/Mini PCI Express Card slot compartment cover”...

  • Page 60

    Lenovo Y400/Y500 Hardware Maintenance Manual Figure 11. Removal steps of LCD unit (continued) Y500: Release the antenna cables from the cable guides in the direction shown by arrows . Remove four screws Step Screw (quantity) Color Torque M2.5 × 5 mm, flat-head, nylok-coated Silver 1.5 ~ 2.0 kgfcm...

  • Page 61

    Lenovo Y400/Y500 Figure 11. Removal steps of LCD unit (continued) Remove the LCD unit in the direction shown by arrows...

  • Page 62: Fan Assembly And Heat Sink Assembly

    Lenovo Y400/Y500 Hardware Maintenance Manual 1120 Fan assembly and Heat Sink assembly For access, remove these FRUs in order: • see “1010 Battery pack” on page 35 • see “1020 Dummy card” on page 36 • see “1030 Optical drive” on page 37 •...

  • Page 63

    Lenovo Y400/Y500 Figure 12. Removal steps of fan assembly and heat sink assembly Detach the fan connector in the direction shown by arrow and loosen six screws to lift the fan assembly. When installing: Make sure that the fan connector is attached firmly to the...

  • Page 64

    Lenovo Y400/Y500 Hardware Maintenance Manual 1130 CPU For access, remove these FRUs in order: • see “1010 Battery pack” on page 35 • see “1020 Dummy card” on page 36 • see “1030 Optical drive” on page 37 • see “1040 Hard disk drive(HDD)/Memory/Mini PCI Express Card slot compartment cover”...

  • Page 65: Base Cover, Speakers And Power Assembly

    Lenovo Y400/Y500 1140 Base cover, speakers and power assembly For access, remove these FRUs in order: • see “1010 Battery pack” on page 35 • see “1020 Dummy card” on page 36 • see “1030 Optical drive” on page 37 •...

  • Page 66

    Lenovo Y400/Y500 Hardware Maintenance Manual Figure 14. Removal steps of base cover, speakers and power assembly (continued) Y500: Step Screw (quantity) Color Torque M2.0 × 3 flat-head, nylok-coated (4) Black 1.0 ~ 1.5 kgfcm...

  • Page 67

    Lenovo Y400/Y500 Figure 14. Removal steps of base cover, speakers and power assembly (continued) Y400: Loosen the screws , then remove the power assembly in the direction shown by arrow When installing: Make sure that the power connector is attached firmly.

  • Page 68

    Lenovo Y400/Y500 Hardware Maintenance Manual Figure 14. Removal steps of base cover, speakers and power assembly (continued) Y500: Loosen the screw , then remove the power assembly in the direction shown by arrow Step Screw (quantity) Color Torque M2.0 × 3 mm, flat-head, nylok-coated (1) Black 1.0 ~ 1.5 kgfcm...

  • Page 69

    Lenovo Y400/Y500 Note: Applying labels to the base cover The new base cover FRU is shipped with a kit containing labels of several kinds. When you replace the base cover, you need to apply the following label: The following labels need to be peeled off from the old base cover, and need to be put on the new base cover.

  • Page 70: Lcd Front Bezel

    Lenovo Y400/Y500 Hardware Maintenance Manual 1150 LCD front bezel For access, remove these FRUs in order: • see “1010 Battery pack” on page 35 • see “1020 Dummy card” on page 36 • see “1030 Optical drive” on page 37 •...

  • Page 71

    Lenovo Y400/Y500 Figure 15. Removal steps of LCD front bezel (continued) Remove the LCD front bezel in the direction shown by arrows...

  • Page 72: Lcd Panel, Lcd Cable And Hinges

    Lenovo Y400/Y500 Hardware Maintenance Manual 1160 LCD panel, LCD cable and hinges For access, remove these FRUs in order: • see “1010 Battery pack” on page 35 • see “1020 Dummy card” on page 36 • see “1030 Optical drive” on page 37 •...

  • Page 73

    Lenovo Y400/Y500 Figure 16. Removal steps of LCD panel, LCD cable and hinges (continued) Y500: Remove two screws , six screws . Lift the LCD panel in the direction shown by arrows When installing: Make sure that the connector is attached firmly.

  • Page 74

    Lenovo Y400/Y500 Hardware Maintenance Manual Figure 16. Removal steps of LCD panel, LCD cable and hinges (continued) Y400: Remove four screws , four screws and the hinges in the direction shown by arrows Step Screw (quantity) Color Torque M2.0 × 3 mm, flat-head, nylok-coated (4) Black 1.0 ~ 1.5 kgfcm...

  • Page 75

    Lenovo Y400/Y500 Figure 16. Removal steps of LCD panel, LCD cable and hinges (continued) Y500: Remove six screws . Lift the LCD panel with hinges in the direction shown by arrows Step Screw (quantity) Color Torque M2.0 × 3 mm, flat-head, nylok-coated (6) Black 1.0 ~ 1.5 kgfcm...

  • Page 76: Integrated Camera

    Lenovo Y400/Y500 Hardware Maintenance Manual 1170 Integrated camera For access, remove these FRUs in order: • see “1010 Battery pack” on page 35 • see “1020 Dummy card” on page 36 • see “1030 Optical drive” on page 37 • see “1040 Hard disk drive(HDD)/Memory/Mini PCI Express Card slot compartment cover”...

  • Page 77: Locations, Front View

    Lenovo Y400/Y500 Locations Front view Integrated camera Built-in microphone (with noise reduction) Computer display Power button JBL speakers Touchpad Numeric keypad (Y500) System status indicators Memory card slot...

  • Page 78: Right-side View

    Lenovo Y400/Y500 Hardware Maintenance Manual Right-side view Kensington slot Optical drive USB port Microphone jack Headphone jack Y400: Y500:...

  • Page 79: Bottom And Left-side View

    Lenovo Y400/Y500 Bottom and Left-side view Novo button AC power adapter jack Ventilation slots VGA port RJ-45 port HDMI port USB port Battery latch - manual Removable module lock Battery pack Battery latch - spring loaded Louvers...

  • Page 80: Parts List

    Lenovo Y400/Y500 Hardware Maintenance Manual Parts list This section presents the following service parts: • see “Overall” on page 77 • see “LCD FRUs” on page 83 • see “Keyboard” on page 86 • see “Miscellaneous parts” on page 92 •...

  • Page 81: Overall

    Lenovo Y400/Y500 Overall Y400 Y500 Y400 Y500 Y400 Y500 Y400 Y500...

  • Page 82

    Lenovo Y400/Y500 Hardware Maintenance Manual Table 5. Parts list—Overall FRU no. CRU ID LCD unit (see “LCD FRUs” on page 83) Keyboard (see “Keyboard” on page 86) QIQY5 Function Board 90001122 QIQY6 Function Board W/Cable 90001160 QIQY5 Power Board 90001123...

  • Page 83

    Lenovo Y400/Y500 Table 5. Parts list—Overall (continued) FRU no. CRU ID Processor, Ivy bridge core Quad-Core 35W Intel 102500290 I7-3612QM 2.1G E1 6M 4cPGA processor Processor, Ivy bridge core Quad-Core 35W Intel 102500437 I7-3632QM 2.2G E1 6M 4cPGA CPU Processor, Ivy bridge core Dual Core 35W Intel 102500295 I7-3520M 2.9G L1 4M 2cPGA processor...

  • Page 84

    Lenovo Y400/Y500 Hardware Maintenance Manual Table 5. Parts list—Overall (continued) FRU no. CRU ID WLAN, WiFi 2x2 ABGN+BT4.0 Liteon WB222 20200225 2x2ABGN+BT4.0 HMC WLAN, WiFi 1x1 BGN+BT4.0 Cbt BCM943142HM 20200222 1x1BGN+BT4.0 HMC WLAN, WiFi 1x1 BGN+BT4.0 Liteon WB225 20200224 1x1BGN+BT4.0 HMC...

  • Page 85

    Lenovo Y400/Y500 Table 5. Parts list—Overall (continued) FRU no. CRU ID QIQY6 2ND VGA Upper Case 90201993 QIQY5 2ND VGA Thermal Module 90201966 QIQY6 2ND VGA Thermal Module 90201966 QIQY5 2ND Fan 90201968 QIQY6 2ND Fan 90201968 QIQY5 Module Frame For ODD...

  • Page 86

    Lenovo Y400/Y500 Hardware Maintenance Manual Table 5. Parts list—Overall (continued) FRU no. CRU ID QIQY5 Thermal Door 90201951 QIQY6 Thermal Door 90201985 QIQY5 2ND VGA Board 90001120 QIQY6 2ND VGA Board 90001120...

  • Page 87: Lcd Frus

    Lenovo Y400/Y500 LCD FRUs In Lenovo Y400/Y500, there are following types of LCDs. • “14.0-in. HD TFT” Y400 • “15.6-in. HD TFT” Y500...

  • Page 88

    Lenovo Y400/Y500 Hardware Maintenance Manual 14.0-in. HD TFT (Y400) Table 6. Parts list—14.0-in. HD TFT FRU no. CRU ID QIQY5 LCD Bezel 90201975 QIQY6 LCD Bezel 90202003 QIQY5 LCD Bezel Mylar 90201946 QIQY5 TP Tape 90201947 QIQY6 TP Tape 90201982 Panel, 14.0W Glare AUO B140XTN03.0 9A HD G F...

  • Page 89

    20200332 Y500 2.4/2.5 Hinge ANT L Hinge Antenna 2.3/2.7GHz Sinher Acon Sinher Y500 20200334 2.4/2.5 Hinge ANT L Hinge Antenna 2.4/2.5GHz SZS Acon SZS Y500 2.4/2.5 20200343 Hinge ANT L Hinge Antenna 2.3/2.7GHz Chengjun Acon Chengjun 20200333 Y500 2.4/2.5 Hinge ANT R Hinge Antenna 2.3/2.7GHz Sinher Acon Sinher Y500...

  • Page 90

    Lenovo Y400/Y500 Hardware Maintenance Manual Keyboard Table 8. Parts list—Keyboard Language CRU ID English 25205228 U.K. English 25205229 Italian 25205230 Spanish 25205231 Turkish 25205232 Thai 25205233 Portuguese 25205234 Latin 25205235 Canadian English&French 25205236 Korean 25205237 Traditional Chinese 25205238 Russian 25205239...

  • Page 91

    Lenovo Y400/Y500 Table 8. Parts list—Keyboard Language CRU ID Greek 25205336 Hebrew 25205337 Hungarian 25205338 Four Nordic countries 25205339 Belgian 25205340 Chicony Icelandic 25205341 (Backlight) Slovenian 25205342 (continued) Swiss 25205343 International English 25205344 Czechoslovakian 25205345 Bulgarian 25205346 Indian 25205347 English 25205258 U.K.

  • Page 92

    Lenovo Y400/Y500 Hardware Maintenance Manual Table 8. Parts list—Keyboard Language CRU ID English 25205348 U.S. English 25205514 U.K. English 25205349 Italian 25205350 Spanish 25205351 Turkish 25205352 Thai 25205353 Portuguese 25205354 Latin 25205355 Canadian English&French 25205356 Korean 25205357 Traditional Chinese 25205358...

  • Page 93

    Lenovo Y400/Y500 Table 8. Parts list—Keyboard Language CRU ID Greek 25205306 Hebrew 25205307 Hungarian 25205308 Four Nordic countries 25205309 Belgian 25205310 Darfon Icelandic 25205311 (continued) Slovenian 25205312 Swiss 25205313 International English 25205314 Czechoslovakian 25205315 Bulgarian 25205316 Indian 25205317 English 25205378 U.K.

  • Page 94

    Lenovo Y400/Y500 Hardware Maintenance Manual Table 8. Parts list—Keyboard Language CRU ID English 25205408 U.S. English 25205516 U.K. English 25205409 Italian 25205410 Spanish 25205411 Turkish 25205412 Thai 25205413 Portuguese 25205414 Latin 25205415 Canadian English&French 25205416 Korean 25205417 Traditional Chinese 25205418...

  • Page 95

    Lenovo Y400/Y500 Table 8. Parts list—Keyboard Language CRU ID Greek 25205456 Hebrew 25205457 Hungarian 25205458 Four Nordic countries 25205459 Belgian 25205460 Icelandic 25205461 (Backlight) Slovenian 25205462 (continued) Swiss 25205463 International English 25205464 Czechoslovakian 25205465 Bulgarian 25205466 Indian 25205467 English 25205474 U.S.

  • Page 96: Miscellaneous Parts

    Lenovo Y400/Y500 Hardware Maintenance Manual Miscellaneous parts Table 9. Parts list—Miscellaneous parts CRU ID System miscellaneous parts: • 90201952 (a) QIQY5 HDD Bracket • 90201952 (a) QIQY6 HDD Bracket • 90201953 (b) QIQY5 TP Sheet • (b) QIQY6 TP Bracket 90201994 •...

  • Page 97: Ac Adapters

    Lenovo Y400/Y500 AC adapters Table 10. Parts list—3-pin AC adapters CRU ID 90W, Delta ADP-90DD BD 20V4.5A adapter 36001941 90W, Delta ADP-90DD BD 20V4.5A adapter-CCC 36200397 90W, Liteon PA-1900-56LC 20V4.5A adapter (330PF) 36001927 90W, Liteon PA-1900-56LC 20V4.5A adapter-CCC 36200404 90W, Chicony CPA-A090 20V4.5A adapter (330PF) 36001942 90W, Chicony CPA-A090 20V4.5A adapter-CCC...

  • Page 98: Power Cords

    Lenovo Y400/Y500 Hardware Maintenance Manual Power cords A Lenovo power cord for a specific country or region is usually available only in that country or region: Table 11. Parts list—3-pin power cords Region CRU ID China 145000600 • LINETEK PC323+RVV300/300+LS15 1m...

  • Page 99

    Lenovo Y400/Y500 Table 11. Parts list—3-pin power cords (continued) Region CRU ID Brazil 145000564 • Longwell LP-46+H03VV-F+LS-18 1m Israel 145000563 • Longwell LP-41+H03VV-F+LS-18 1m 145000562 • Longwell LP-30B+SPT-2 18AWG+LS-18 1m 145000561 • Longwell LP-61L+H03VV-F+LS-18 1m India 145000560 • Longwell LP-67+BIS+LS-18 1m...

  • Page 100

    Lenovo Y400/Y500 Hardware Maintenance Manual Table 11. Parts list—3-pin power cords (continued) Region CRU ID Argentina 145000528 • VOLEX VA2073+H03VV-F+VAC5S 1m Brazil 145000527 • VOLEX CH10S3+H03VV-F+VAC5S 1m Israel 145000526 • VOLEX SI16S3+H03VV-F+VAC5S 1m 145000525 • VOLEX M2511+HO3VV-F+VAC5S 1m Switzerland 145000524 •...

  • Page 101: Notices

    The result obtained in other operating environments may vary. Lenovo may use or distribute any of the information you supply in any way it believes appropriate without incurring any obligation to you.

  • Page 102: Trademarks

    Actual results may vary. Users of this document should verify the applicable data for their specific environment. Trademarks The following terms are either registered trademarks or trademarks of Lenovo in the United States and/or other countries: ® Lenovo ®...

  • Page 103

    Notices...

This manual also for:

Y400

Comments to this Manuals

Symbols: 0
Latest comments: