Maintenance - Craftsman 315.117120 Owner's Manual

MAINTENANCE
GENERAL
Only the parts shown on parts list. page 11. are intended to
be repaired or replaced by the customer. AH other paris
represent an important part of the double insulation system
and should be serviced only by a qualified Sears service
technician.
Avoid using solvents when cleaning plastk_parts. Never let
liquids get instdethis tool.Alse, never immerse any pad ofthis
tool into a liquid. Most plastics are susceptible to various
types of commemial solvents and may be damaged by their
use. Use clean cloths to remove dirt, carbon dust, etc.
When electrictools are used on fiberglass boats, sportscars,
wallboard, spackling compounds, or plaster, it has been
foundthat they are subject to accelerated wear and possible
premature failure, as the fiberglas_ chips and gpadings are
highly abrasive to bearings, brushes, commutator, etc.
Consequently itis not recommended that this tool be used for
extendedworkon anyfiberglassmatedal, wstlpoard,spacklidg
compounds, or plaster. Dudng any use on these materials, it
is extremely impOdantthat the tool is cleaned frequently by
b_owing with an air jet.
LUBRICATION
All of the bearings in this tool are lubricated with a sufficient amount of high grade lubricant for the life of the unit under normal
operating conditions. Therefore, no fudher lubrication is required,
ELECTRICAL CONNECTION
This tool has a precision built electric motor, g should be connected to a power supply that Is 120 volts, 60 HZ, AC only
(normal household current). Do not operate this tost on direct current (DC). A voltage drop of more than 10 percent will
cause a loss of power and overheating. If your tool does not operate when plugged into an outlet, double-check the power
supply.
_ The °pemti°n °f any sander can resun In f°mign °bJects being thr°wn iat° y°ur eyes' which 1
can result in severe eye damage. Before beginning power tool operation, always wear safety
/
goggles or safety glasses with side shields and a full face shield when needed. We /
:. ; :.;:: e yog,.sas or a ,a.da,. .at , g .e... J
P_e9