COZY CF354C-R Installation And Operating Instructions Manual

COZY CF354C-R Installation And Operating Instructions Manual

Counterflow wall furnace

Advertisement

INSTALLATION
AND
OPERATING
INSTRUCTIONS
P/N 78111
REV. 05/03
MODEL
NUMBERS
_.4VOLT SYSTEM
NATURAL
GAS
CF353C-R
CF503C-R
CF653C-R
vVITH LOW-BTU
_ILOT
L.P. GAS
CF354C-R
CF504R
CF654C-R
_.4VOLT SYSTEM
NATURAL
GAS
_ITH INTERMITTENT
IGNITION (I.I.D.)
L.P. GAS
CF357C-R
CF358C-R
CF557C-R
CF558C-R
This appliance is equipped
with a blocked flue switch
designed to protect against
improper venting of
combustion products.
THIS UNIT IS NOT TO
I WARNING:
If the information in this manual is not followed exactly, a I
fire or explosion may result causing property damage, personal injury or
I
loss of life.
Do not store or use gasoline or other flammable
vapors and
liquids in the vicinity of this or any other appliance.
WHAT TO DO IF YOU SMELL
GAS:
Do not try to light any appliance.
Do not touch any electrical
switch; do not use any phone in
your building.
\
)_ Immediately
call your gas supplier
from a neighbor's
phone.
Follow the gas supplier's
instructions.
)_ If you cannot
reach your gas supplier,
call the fire department.
INSTALLATION
AND SERVICE
MUST BE PERFORMED
BY A QUALIFIED
INSTALLER,
SERVICE
AGENCY
OR
BE INSTALLED
IN
THE GAS SUPPLIER.
MOBILE HOMES.
WARNING:
Operation
of this furnace when not connected
to a properly
installed
and main-
tained venting system can result in Carbon
Monoxide
(C.O.) poisoning
and possible death.
For
your safety, this furnace
and the venting
system should be inspected
at least annually
by a quali-
fied service person.
The coating selected to provide longer life to the heat exchanger may smoke slightly upon initial firing Please
)rovide adequate ventilation if this occurs.
This unit is not approved
for installation
in mobile homes, greenhouses,
or environments
involving
dusK, wet, corrosive,
or explosive conditions.
Such conditions
_411 invalidate
the warran
D"and may create unsafe conditions.

Advertisement

Table of Contents
loading

Summary of Contents for COZY CF354C-R

  • Page 1 INSTALLATION OPERATING INSTRUCTIONS P/N 78111 REV. 05/03 MODEL NUMBERS _.4VOLT SYSTEM NATURAL CF353C-R CF503C-R CF653C-R vVITH LOW-BTU _ILOT L.P. GAS CF354C-R CF504R CF654C-R _.4VOLT SYSTEM NATURAL CF357C-R CF557C-R _ITH INTERMITTENT CF358C-R CF558C-R IGNITION (I.I.D.) L.P. GAS fire or explosion may result causing property damage, personal injury or I WARNING: If the information in this manual is not followed exactly, a I loss of life.
  • Page 2: Specifications

    CONTENTS Contents.............. Lighting & Re-Lighting Instructions ....10,11 Introduction ..........Operation............Specifications ..........Terminal Block Wiring Diammn ......MmmalReset........... Safety Rules ..........Maintenance Instructions ........Helpful Installation hR'onnation ....... Connecting the Vent..........WS-illg Diagrmn..........14,15 Combustion and Ventilation Air........Side & Rear Discharge Kits ......... 16,17 Furnace Location ..........
  • Page 3: Safety Rules

    SAFETY RULES hnproper installation, adjustment, alteration, service or maintenance can cause property damage, bodily injury or death. If you do not understand these instructions or your local codes, call local authorities, a qualified installer, selMce agency, gas supplier, or the manufacturer. Do not install this fan type wall furnace in a recreational vehicle trailer or mobile home.
  • Page 4 VENTING- CONTINUED More Height above any than 10' roof surface within 10' horizontally _,,__ 2 Min. '1 : 3' Min. Chimney-- FIGURE This appliance is equipped with a blocked flue switch. Listed 2' Min. WARNING: Do not bypass the blocked flue switch.
  • Page 5 COMBUSTION AND VENTILATION ALL COMBUSTION AIR FROM ADJACENT INDOOR SPACES THROUGH INDOOR COMBUSTION AIR OPENINGS When installed, this gas appliance must be provided with fiesh Listed Vent Cap air for combustion, ventilation, and dilution of hot flue gases. The minimum required volume of the area where the appliance is installed should be 50 cubic feet per 1,000 btu/hr.
  • Page 6 USING ADJACENT STUD SPACE FOR ALL LOCATION AND SPECIAL PRECAUTIONS COMBUSTION AIR FROM OUTSIDE The wall furnace should be located near the center of HOLES CONNECTING TO VENTILATED ATTIC the house for best heat distribution. If the area where the appliance is to be installed contains PLATE carpeting, tile or combustible materials, other than wood flooring, the appliance shall be installed on a metal plate,...
  • Page 7: Check For Leaks

    ROUGH-IN Check local codes t\_rrequirements as to the size and type of gas line required. See Figure 5 for location of gas inlet holes in furnace cabinet. Compounds used on threaded joints of gas pipe should be resistant to the action of liquefied petroleum gases. The gas line joints must be checked t\_r leaks.
  • Page 8: Installation

    INSTALLATION / WHEN RECESSED INSTALLATION (UP TO 9-1/4") WHEN INSTALLED FLUSH TO WALL STEP 1.Cut out floor plate between 2x4 studs, so heater STEP 1. After locating furnace, cut 3-1/2"xl 2" rectangular hole will set flat on floor. in ceiling between ceiting joists. Make sure gasket is in STEP 2.
  • Page 9: Natural Gas

    Installation of B&V Gas Vent Installation of B-W Gas Vent Firestop spacels supplied %1 one-stray buildings ol %1 Ceiling plate spacexs to centel manut'actm el of B-W fol each subsequent ceiling or firs flooof -so T B-W Gas Vent m stud space - Ga s _n_ floor level ofmultistory buildings¸...
  • Page 10: For Your Safety

    CF353C, CF354C, CF503C, CF504C, CF653C, CF654C STANDING PILOT FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. If you cannot reach your gas supplier, call the fire This appliance has a pilot, which must be lighted by department.
  • Page 11 CF357C, CF358C, CF557C, CF558C - I.I.D. PILOT FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. This appliance is equipped with an ignition device •...
  • Page 12: Operation

    PROPER BURNER FLAME OPERATION This unit uses a "step open" valve. When heat is A proper flame will have a dark blue inner mantle called for the gas valve opens at a reduced manifold that sits right on top of the burners with a lighter (outlet) pressure to insure a safe, quiet ignition.
  • Page 13: Maintenance

    TERMINAL BLOCK WIRING DIAGRAM -FAN/LIMIT SWITCH (Brown) I--FAN LIMIT SWITCH (Brown) SELECTOR [-POWER CORD (Black) FPOWER CORD (Black) IFTRANSF°R-_ER IF TRANSF°RMER(Black) SWITCH J L (Black) LIMIT II r7 LIMIT Ek--i ii!: _,_OTOR- _L_ q II _--- SWlTC. MOTOR (White) (Red) MOTOR.L (White) (Blue) POWER...
  • Page 14 CF353C, CF354C STANDING PILOT CF503C, 504C, 653C, 654C POWER CF503C, CF504C CF353C, CF354C THEtLMO STAT POWER THERMOSTAf CF653C, CF654C PICTORIAL SCHEMATIC PICTORIAL SCHEMATIC BLACK /LACK I TRANSFORMER BLL_ BL_CK SPILL SWITCH SPILL 7ITCH LIMIT S_TCH SWITCH LIMIT SELECTO SWITCH AUXILIARY LIMIT SWITCH __ ! AUXILIAR,_ AMPS...
  • Page 15 I.I.D. CF557C, CF558C CF357C, CF358C CF357C, CF358C CF357C, CF358C THERMOSTAT PICTORIAL SCHEMATIC TEIEPcMOSTAT PICTORIAL SCHEmaTIC CORD POWER V_IITE ,., , ,T_-%II ' .._ j IT_ANSP°_'IER I Illl _ ..B2 UE _. _ BLACK SWITCH SPILL _TCH VtTCH {rF?_ XA_cH LIMIT SWITCH SELECTOR _wJLI_._LIMIT SV,_TCH...
  • Page 16 ROUGH-INS REAR OR SIDE DISCHARGE Install plastergrounds as shown in Figure 12 and Figure NOTE: When side discharge is being used, furnace should be set exactly 4" from side wall. Plaster f--a 1/2 ,, (;round REAR FIGURE 12 FIGURE 13 OPTIONAL ACCESSORY KITS...
  • Page 17 OPTIONAL KITS - CONTINUED SIDE DISCHARGE ON CASING SIDE DISCHARGE (With Extension Boot) Use optional kit No. 306SR-A. Use optional kit No. 30SRB-A. Cut out and remove embossed area on casing side. Cut opening in drywall as shown in Fig. 17. Remove knockout from inner liner.
  • Page 18 TROUBLE SHOOTING CHART for qualified serviceman - MAIN BURNER SYMPTOM POSSIBLE CORRECTIVE ACTION Flame too large i. Defective operator section of'gas valve, i. Replace complete valve. 2. Burner orifice too large. 2. Check with local gas company for proper orifice size and replace.
  • Page 19 TROUBLE SHOOTING CHART - PILOT AND VALVE - CONTINUED _YMPTOM POSSIBLE CAUSES CORRECTIVE ACTION 1. Air in line. 1. Bleed line. ?ilot won't light, 3r stay lit 2. Defective thennocouple. 2. Replace thermocouple. 3. Pilot flame too low. 'STANDING PILOT) 3.
  • Page 20 ?'our comenience. For prompt parts service, contact the wholesaler from which you purchased yonr Cozy heater. NOTE: Parts & schematic drawings on current models are REVI 04/97 I Page20 (_(_...
  • Page 21 72020 $22.70 72020 $22.70 72021 $22.70 72021 $22.70 72021 $22.70 Pilot, L.P.. 0.140.502 84003 $2.30 84003 $2.30 84003 $2.30 Cozy Handle Power Cord 78213 $4.70 78213 $4.70 78213 $4.70 78058 $4.70 78058 $4.70 78058 $4.70 Snap-in Outlet Thermostat Wire 74518 $1.30...
  • Page 22 For prompt parts service, contact the wholesaler from which you purchased your Cozy heater. NOTE: Parts & schematic drawings on current I REV. 04/97 Page 22 models are shown at www.cozyheaters.com...
  • Page 23 PROPERLY ORDER PARTS: In addition to part description and part number, please give model number, serial number, and type of gas used. This information can be found on the rating plate that is attached to heater. 24 VOLT SYSTEM WITH INTERMITTENT NATURAL CF357C-R...
  • Page 24 VENT NO. 31300-A ENCLOSURE TRIM KIT KIT NO. 406RR-A 16VE-A REAR REGISTER 36VE-A KIT NO. 407RR-A REAR REGISTER RECESS KIT NO. 306SR-A For description of above 30SRB-A reference numbers, SIDE <. SIDE REGISTER see reverse side. REGISTER _ W/BOOT FLUSH "_--/ REV.
  • Page 25 Harness Contractor, we only sell parts through our wholesalers, but the prices listed are for your convenience. For prompt parts service, purchased your Cozy drawings contact the wholesaler from which heater. NOTE: Parts & schematic on current models are shown at _v.cozyheatel_.com.
  • Page 26 IMPORTANT SAFETY BULLETIN ON YOUR GAS CONTROL AND PILOT LIGHT SYSTEM HEATING EQUIPMENT WHAT DON'T KNOW HURT YOU. Your pilot light system has been designed for safe and reliable operation. Although safety mechanisms are built-in, the potential for hazard exists. This information is intended to help you avoid these hazards.
  • Page 27 10 Years Cozy Gas Fired Counterflow Furnace 10 Years Cozy Gas Fired Counterflow Direct Vent Furnace 10 Years Cozy Gas Fired Mobile Home Direct Vent Furnace 10 Years Cozy Gas Fired Hi-Efficient Direct Vent Wall Furnace LOUISVILLE TIN AND STOVE COMPANY P.O.

Table of Contents