Lincoln Electric Lincolnweld 780 Datasheet

M A T E R I A L S A F E T Y D A T A S H E E T
Conforms to Workplace Hazardous Materials Information System (WHMIS) Rev. November, 1988
The Lincoln Electric Company of Canada LP
179 Wicksteed Avenue
Toronto, Ontario M4G 2B9 CANADA
Phone: (416) 421-2600
I M P O R T A N T !
This section covers the materials from which this product is manufactured. The fumes and gases produced during welding with the normal use of this
product are covered by Section VII; see it for industrial hygiene information.
CAS Number shown is representative for the ingredients listed.
(1) The term "hazardous" in "Hazardous Ingredients" should be interpreted as a term required and defined in the Hazardous Products Act and does
not necessarily imply the existence of any hazard.
Ingredients:
Aluminum oxide and/or Bauxite
Manganese and/or manganese alloys and compounds (as Mn)
Titanium dioxides
Silicates and other binders
Fluorides (as F)
Silicon and/or silicon alloys and compounds (as Si)
Iron
Magnesite
Mineral silicates
Quartz
Crystalline-Silica (cristobalite)
Zirconium alloys and compounds (as Zr)
Notes:
(*) Not listed. Nuisance value maximum is 10 milligrams per cubic
meter. TLV value for iron oxide is 5 milligrams per cubic meter.
(**) As respirable dust. Value for respirable quartz is 0.1 milligrams
per cubic meter.
Physical data such as odor, vapor pressure, density, evaporation rate and freezing or boiling points are not listed as they are not applicable to this product and
its use.
Non Flammable; Welding arc and sparks can ignite combustibles and flammable products. See CSA W117.2 Section 9.7 as referenced in Section VIII.
Product is inert, no special handling or spill procedures required.
Rev 9/07
For Welding Consumables and Related Products
Section I & II - Preparation and Product Information
Section III - Hazardous Ingredients (1)
Section IV - Physical Data
Section V - Hazard Data
Date:
1/5/2009
Trade Name:
Lincolnweld 780
Sizes: ---
Supersedes: 5/1/2007
Product Type:
Representative Classifications:
Prepared by The Lincoln Electric Company, Cleveland, Ohio, USA
(216) 481-8100, on the date shown above.
TLV
mg/m
3
CAS No. Wt. %
1344-28-1 30-60
7439-96-5 10
13463-67-7 5-10
1344-09-8 5-10
7789-75-5 5-10
7440-21-3 1-5
7439-89-6 1-5
1309-48-4 1-5
1332-58-7 1-5
14808-60-7 0.1-1 #0.05**
#0.025*
14464-46-1 0.1-1
12004-83-0 0.1-1
(LDLo, LCLo) Lowest published toxic concentration.
(#) Crystalline silica (quartz) is on the IARC (International
Agency for Research on Cancer) and NTP (National
Toxicology Program) lists as posing a carcinogenic risk
to humans.
MSDS No.:
CAN-F15
Submerged Arc Flux
CSA F49A2-EL12
F49A3-EM12K
LD
50
(Route/Species)
10
Not Available
0.2
9 g/kg (oral/rat)
10
Not Available
10*
1153 mg/kg (oral/rat)
2.5
4250 mg/kg (oral/rat)
10*
Not Available
10*
Not Available
10
Not Available
590 g/kg LDLo (oral/rat)
5**
reproductive
200 mg/kg LDLo
(intratracheal/rat)
10,000 mg/kg (oral/rat)
*
5
Not Available
(CONTINUED ON SIDE TWO)
3
LC mg/m
50
(Route/Species)
Not Available
2.3 LCLo
(inhalation/human)
Not Available
Not Available
Not Available
Not Available
Not Available
Not Available
Not Available
300 LCLo
(inhalation/human)
Not Available
Not Available