Page 1: Table Of Contents
» DESCRIPTION OF MAJOR IC FUNCTIONS ..43 » SPEAKER SYSTEMS ......... 255 » BLOCK DIAGRAM ..........62 This document has been published to be used for after SHARP CORPORATION sales service only. The contents are subject to change without notice.
Page 2: Important Service Safety Precaution
PZ-50HV2, PZ-50HV2E PZ-50HV2U IMPORTANT SERVICE SAFETY PRECAUTION Ë Service work should be perfomed only by qualified service technicians who are thor- oughly familiar with all safety checks and the servicing guidelines which follow: » Use an AC voltmeter having with 5000 ohm per volt, WARNING or higher, sensitivity or measure the AC voltage drop 1.
Page 3 PZ-50HV2, PZ-50HV2E PZ-50HV2U PRECAUTIONS A PRENDRE LORS DE LA REPARATION Ë Ne peut effectuer la réparation qu' un technicien spécialisé qui s'est parfaitement accoutumé à toute vérification de sécurité et aux conseils suivants. Utiliser un voltmètre CA d'une sensibilité d'au moins AVERTISSEMENT 5000 /V pour mesurer la chute de tension en travers 1.
Page 4: Specifications
PZ-50HV2, PZ-50HV2E PZ-50HV2U SPECIFICATIONS Item 50" Plasma Display TV (Panel Unit), 50" Plasma Display TV (Panel Unit), Model: PZ-50HV2E Model: PZ-50HV2U Number of Pixels 2,949,120 dots 2,949,120 dots Audio Amplifier 12 W + 12 W (10 % distortion) 12 W + 12 W (10 % distortion) Surround System —...
Page 5: Safety Information
PZ-50HV2, PZ-50HV2E PZ-50HV2U SAFETY INFORMATION This service manual is intended for qualified service technicians ; it is not meant for the casual do-it- yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty.
Page 6: Product Safety Notice
PZ-50HV2, PZ-50HV2E PZ-50HV2U PRODUCT SAFETY NOTICE Many electrical and mechanical parts in SHARP set have Leakage Current Cold Check special safety related characteristics. These are often not With the AC plug removed from an AC power source, place evident from visual inspection nor the protection afforded by a jumper across the two plug prongs.
Page 7 PZ-50HV2, PZ-50HV2E PZ-50HV2U CHARGED SECTION AND HIGH VOLTAGE GENERATING POINT Ë Charged Section Ë High Voltage Generating Point The places where the commercial AC power is used without The places where voltage is 100V or more except for the passing through the power supply transformer. charged places described above.
Page 8: Operation Manual
PZ-50HV2, PZ-50HV2E PZ-50HV2U OPERATION MANUAL Plasma Display TV (Panel Unit) PZ-50HV2E INPUT ANDBY/ON indicator INPUT button CHANNEL buttons MAIN POWER button STANDBY/ON button VOLUME buttons Remote control sensor PZ-50HV2U MAIN POWER POWER INPUT STANDBY/ON indicator INPUT button CHANNEL buttons MAIN POWER button POWER button VOLUME buttons...
Page 9: Remote Control Unit
PZ-50HV2, PZ-50HV2E PZ-50HV2U Remote control unit (STANDBY/ON) To switch the power on and off. (PZ-50HV2E) (FREEZE/HOLD for TELETEXT) TV/External input mode: Change the still image mode. TELETEXT mode: Freeze a multi-page on screen while other pages are automatically updated. Press again to return to the normal image.
Page 10 PZ-50HV2, PZ-50HV2E PZ-50HV2U Remote control unit Set the mode switch to TV. (PZ-50HV2U) Mode switch : Switch the Plasma Display power on or off. 12 13 FRONT SURROUND: Set SRS and FOCUS Sound System mode. AV MODE:Select an audio or video setting. /SAT (AV mode: STANDARD, DYNAMIC, /DTV...
Page 11: Dimensions
PZ-50HV2, PZ-50HV2E PZ-50HV2U DIMENSIONS (Unit : mm)
Page 12: Removing Of Major Parts
PZ-50HV2, PZ-50HV2E PZ-50HV2U REMOVING OF MAJOR PARTS About detect switch SW Power Supply Module This unit adopt the "Rear Case opened ! detection" system. Remove the Rear Case (P).(Screws Please work in service as follows by all means. Outline and caution Perform video transmission from the AVC System to the plasma display with digital signal in the PZ-50HV2 series.
Page 13 PZ-50HV2, PZ-50HV2E PZ-50HV2U MR INTERFACE, AUDIO AMP SP TERMINAL and DIGITAL VIDEO Assys Insert it and reduce the Clamper. Remove the Rear Case (P). (Screws Insert the SW Power Supply Module into the slit of Sub Frame L and R. Remove the SW Power Supply Module.
Page 14 PZ-50HV2, PZ-50HV2E PZ-50HV2U Y DRIVE, SCAN (A), (B) Assy Remove the three screws. Remove the Rear Case (P). (Screws Remove the Y DRIVE Assy. (Connector, Screws Remove the Front Chassis V. (Screws Y DRIVE Assy Front Case 50 (P) Loosen a rivet. Remove the Lead Cover (P).
Page 15 PZ-50HV2, PZ-50HV2E PZ-50HV2U X DRIVE Assy Remove the Rear Case (P). (Screws Remove the X DRIVE Assy. (Connector, Screws X DRIVE Assy...
Page 16: Adjustment Procedures
PZ-50HV2, PZ-50HV2E PZ-50HV2U ADJUSTMENT PROCEDURES SERVICE FACTORY MODE Service factory mode uses an OSD function of the AVC System. Perform the adjustment and setting in the state that this unit and Media Receiver are connected by the system. Plasma display cannot use a factory mode by being simple. Remote Control Unit Operation in The Service Factory Mode Operate the service factory mode with the remote control unit of accessory of the AVC System.
Page 17 PZ-50HV2, PZ-50HV2E PZ-50HV2U 1. How to Enter the Service Factory Mode Press the " (POWER)" key (POWER OFF) System standby state Confirm that the plasma display and the AVC System turned on together and a system cable is connected properly. Perform the following operation by the remote control unit for less than 3 seconds.
Page 18 11: SHARP 50 inches, 12: SHARP 43 inches AVC System model information AVC System model information 0: All SHARP destinations, Japanese and North America destinations of PDP destination information PIONEER, 3: European and general destinations of PIONEER Temperature information of panel temperature sensor on This is internal temperature information.
Page 19 PZ-50HV2, PZ-50HV2E PZ-50HV2U 3. Adjustment and Setting Item of the Plasma Display Display example of the eleventh page 1 / 1 3 PUT1 No S I G MNTR V5 0 MNTR V6 0 MNTR PC MNTR R H I GH1 2 5 5 MNTR G H I GH1...
Page 20 PZ-50HV2, PZ-50HV2E PZ-50HV2U Display example of the twelfth page 1 / 1 3 PUT1 No S I G ABL V I DE 6 0 PC 1 1 8 ABL V I DE 1 2 2 1 3 1 1 2 8 Item Adjustable Range Shipping Setting...
Page 21 PZ-50HV2, PZ-50HV2E PZ-50HV2U Display example of the thirteenth page 1 / 1 3 PUT1 No S I G VE MO DR VE MO NEGAT BR I GHT ENHAN E MASK FREQ PATTE N MASK FULL MASK Item Adjustable Range Shipping Setting Storage Place Drive mode selection at VIDEO 0 to 5...
Page 22 PZ-50HV2, PZ-50HV2E PZ-50HV2U ADJUSTMENT REQUIRED WHEN THE SET IS REPAIRED OR REPLACED Y DRIVE Assy SW POWER SUPPLY Module When repaired When replaced No adjustment required. 1. VOFS/VH/IC5V voltage adjustment 2. Timing adjustment of pulse module DIGITAL VIDEO Assy When replaced When repaired 1.
Page 23 PZ-50HV2, PZ-50HV2E PZ-50HV2U ADJUSTMENT VOFS/VH/IC5V Voltage Adjustment Adjusting Point Adjusting Method Input Signal VOFS (Offset voltage) adjustment Method 1 1. Write down a adjustment value of VOFS ADJ in the factory mode. 2. Set this adjustment value to center (128). 3.
Page 24 PZ-50HV2, PZ-50HV2E PZ-50HV2U Sustain Pulse Waveform Adjustment Adjusting Point Adjusting Method Input Signal REF_DIG mode in Factory mode X-SUS-B, Y-SUS-B Adjustment White 100% XSUSB ADJ Set to the indicated value with the remote control unit. YSUSB ADJ (Refer to "Timing adjustment of control signal of X and Y Drive Assys".) VRN Voltage Adjustment Adjusting Point Adjusting Method...
Page 25 PZ-50HV2, PZ-50HV2E PZ-50HV2U Timing Adjustment of X and Y DRIVE Assys Control Signal Purpose • Pulse module loads in DRIVE Assy as one of heat measures of DRIVE Assy. Adjust the drive timing of the pulse module driving parallel with VR. •...
Page 26 PZ-50HV2, PZ-50HV2E PZ-50HV2U Measuring Waveform of Pulse Module Timing Adjustment Timing adjustment of the pulse module control signal adjusts with the sustain pulse of eighth pulse (X DRIVE) and the ninth pulse (Y DRIVE) from the back of 6SF. Measuring point of waveform Y DRIVE SUSOUT waveform X DRIVE SUSOUT waveform 2SF 3SF 4SF 5SF 6SF 7SF...
Page 27 PZ-50HV2, PZ-50HV2E PZ-50HV2U SUS-D Adjustment (Y DRIVE) SUS-U Adjustment (Y DRIVE) 1ms/div 1ms/div Magnify 6SF block Magnify 6SF block 5 s/div 5 s/div Magnification Magnification 1ms/div 1ms/div Magnify 6SF block Magnify 6SF block 500ns/div 200ns/div Magnification Magnification 1ms/div 1ms/div Magnify 6SF block Magnify 6SF block Upper PM Caution:...
Page 28 PZ-50HV2, PZ-50HV2E PZ-50HV2U SUS-B Ground Timing Adjustment It is necessary to readjust this adjustment when replaced the X or Y DRIVE Assy and the pulse module. Measurement point and method Measurement point of waveform of X and Y DRIVE Assy in timing adjustment is test pin of SUSOUT of the pulse module of bottom of the main unit.
Page 29 PZ-50HV2, PZ-50HV2E PZ-50HV2U Y DRIVE Assy X DRIVE Assy K2720 K2716 K3708 K3213 (PSUS) (VH) (VRN_OVP) (1/2VSUS) K3214 K2218 K2215 K2217 K3702 K2717 K3707 (1/2 VSUS) (SUSGND) (SUS_B) (SUS_U) (SUS. GND) K3706 (VH CONT) (VRN) (X DC-DC PD) K2214 (SUS_G) K2216 VR3701 K3705...
Page 30 PZ-50HV2, PZ-50HV2E PZ-50HV2U COMMAND RS-232C Command As for PZ-50HV2 system, the 232C control of the panel control item is possible by a single state. However, the following exclusive use communication jig is necessary. Be careful so that can not use a DSUB 9-pin in the rear panel of the AVC System. Connection PDP rear view DVI (Video line):...
Page 31 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë RS-232C Command i n i & t i r & t i r i t l n i l l l u l l u l l u l l u l l u l l u g i l l l u l l u...
Page 32 PZ-50HV2, PZ-50HV2E PZ-50HV2U l l u o l l l l u l l u l l u r r i v i t v i t v i t v i t g i l g i l...
Page 33: Command Description
PZ-50HV2, PZ-50HV2E PZ-50HV2U GET Command Command Description Command Function Output data of an electronic VR adjustment value and a drive system adjustment value Output data to be related to white balance adjustment of the panel Output data such as version information, hour meter and pulse meter GAJ: Output data of an electron VR adjustment value and a drive system adjustment value •...
Page 34 PZ-50HV2, PZ-50HV2E PZ-50HV2U GS1: Output data such as version information, hour meter and pulse meter • Output it according to transmission order and size of the table below. Order Data Contents Size Remarks Display information 3 byte See below Module microcomputer model number 4 byte 5691 or F691 Module microcomputer version...
Page 35: Trouble Diagnosis
PZ-50HV2, PZ-50HV2E PZ-50HV2U TROUBLE DIAGNOSIS SHUT DOWN/POWER DOWN DIAGNOSIS BY LED DISPLAY When internal circuit abnormality and other operation abnormality occurred from this unit, self-diagnose display function by STANDBY/ON (LED) indicator is loaded. Each NG point by LED blinking and a PD (power down) point are as follows. Shut Down •...
Page 36 PZ-50HV2, PZ-50HV2E PZ-50HV2U Block Diagram of Shut Down Signal System DIGITAL VIDEO ASSY IC1101 IC1191 Panel UCOM Panel UCOM THERMAL SENSOR external Flash ROM ASSY IC8351 DDC_SCL *PU_CE BUSY Thermal DDC_SDA REQ_PU Sensor 1 TEMP1 Y DRIVE ASSY IC1207 Module UCOM DEW_DET Moisture Sensor...
Page 37 PZ-50HV2, PZ-50HV2E PZ-50HV2U Shut down diagnosis 1 Panel microcomputer NG When a module microcomputer failed in communication with a panel microcomputer, this NG occurs. Shut down after OSD display for 30 seconds from the NG detection. Abnormality to expect Open / Short of communication line in the Assy 2 DIGITAL-IIC communication NG When a module microcomputer failed in communication with outside EEPROM or EXPANDER, this NG occurs.
Page 38 PZ-50HV2, PZ-50HV2E PZ-50HV2U Block Diagram of Power Down Signal System...
Page 39 PZ-50HV2, PZ-50HV2E PZ-50HV2U Kind and function of the various protection circuit (P.D. circuit) Red LED Kind of P.D. Assy Name Number of Remarks Function Circuit Blinks VCP OCP P.D. by VCP overcurrent VOFS OVP P.D. by VOFS overvoltage VOFS UVP P.D.
Page 40 PZ-50HV2, PZ-50HV2E PZ-50HV2U...
Page 41 PZ-50HV2, PZ-50HV2E PZ-50HV2U Block diagram for Power supply section SW POWER SUPPLY MODULE Y DRIVE ASSY VOFS VOFS DC/DC -45V Converter +B395V VSUS AC IN Power Factor VSUS DC/DC 100 - 240V Control Converter 225V VH DC/DC 130V Converter VADR DC/DC VADR ST-BY Converter...
Page 42: Chassis Layout
PZ-50HV2, PZ-50HV2E PZ-50HV2U CHASSIS LAYOUT Ë PWB LOCATION CLAMP A Assy ADR CONNECT A Assy DIGITAL VIDEO Assy BRIDGE A Assy ADR CONNECT B Assy SENSOR SUB ADDRESS A Assy Assy ADR RESONANCE Assy SCAN (A) Assy ADR CONNECT C Assy Y DRIVE SW POWER SUPPLY...
Page 43: Description Of Major Ic Functions
PZ-50HV2, PZ-50HV2E PZ-50HV2U DESCRIPTION OF MAJOR IC FUNCTIONS » The information shown in the list is basic information and may not correspond exactly to that shown in the schematic diagrams. » List of IC SN755860PJ, HD64F2328VF, PE1013B, M30624FGAFP, PD6358A, PST9246N, FS781BZB, STK795-460 Ë...
Page 44 PZ-50HV2, PZ-50HV2E PZ-50HV2U » Block Diagram 64 bit Shift Register 64 bit Latch Selector Selector HVO33 - 64 HVO1 - 32 » Pin Function Name Pin No. Num. Function Shift clock (start edge partial response) The serial data input of shifting register The serial data output of shifting register It output data done a latch of by "L"...
Page 45 PZ-50HV2, PZ-50HV2E PZ-50HV2U HD64F2328VF (DIGITAL VIDEO ASSY : IC1101) • Panel Microcomputer Pin Function Pin Name Function PE5064 (IC1703) control output CS_23 NC Terminal 3.3V power supply Address bus Address bus Address bus Address bus Address bus Address bus Address bus Address bus Address bus Address bus...
Page 46 PZ-50HV2, PZ-50HV2E PZ-50HV2U Pin Name Function Data bus UD10 UD11 Data bus UD12 Data bus UD13 Data bus UD14 Data bus UD15 Data bus 3.3V power supply D_TXD Communication with IC1207 (module microcomputer) EXT_TXD Communication with the outside (program notes) D_RXD Communication with IC1207 (module microcomputer) EXT_RXD...
Page 47 PZ-50HV2, PZ-50HV2E PZ-50HV2U Pin Name Function NC terminal NC terminal AVCC 3.3V power supply VREF A/D, D/A reference voltage input (unused) STOPB The drive control input from IC1703 (PE5064) NC terminal RYBY The flash memory note ready input ADR_K_EMG_L1 The emergency input from panel bottom address resonance block ADR_K_EMG_U1 The emergency input from panel upper address resonance block ADR_K_EMG_L2...
Page 48 PZ-50HV2, PZ-50HV2E PZ-50HV2U PE1013B (X DRIVE ASSY : IC3003) • Drive Protect PLD Pin Assignment (Top View) I/CLK I/O/Q I/O/Q I/O/Q I/O/Q I/O/Q I/O/Q I/O/Q I/O/Q I/O/Q I/O/Q XSUS_BI 1_50 XSUS_BO 1_24 1_40 XSUS_UI 1_49 XSUS_UO 1_23 1_39 XSUS_DI 1_48 XSUS_DO 1_22 1_40...
Page 49 PZ-50HV2, PZ-50HV2E PZ-50HV2U GAL22V10 (Y DRIVE ASSY : IC3003) • Drive Protect PLD Pin Assignment (Top View) I/CLK I/O/Q I/O/Q I/O/Q I/O/Q I/O/Q I/O/Q I/O/Q I/O/Q I/O/Q I/O/Q sus_mute_in 1_64 1_63 ysusbin ysusbout 1_39 1_62 1_20 ysusuin ysusuout 1_48 1_61 1_19 1_23 ysusdin...
Page 50 PZ-50HV2, PZ-50HV2E PZ-50HV2U M30624FGAFP (DIGITAL VIDEO ASSY : IC1207) • Module Microcomputer Pin Function l a i n i l l a i n i l n i l , y l l l u l l u t i s c t i x i f t s i...
Page 51 PZ-50HV2, PZ-50HV2E PZ-50HV2U a l l g i l g i l t s i l a i n i l...
Page 52 PZ-50HV2, PZ-50HV2E PZ-50HV2U PD6358A (DIGITAL VIDEO ASSY : IC1301) • Picture Improved IC Pin Function ) t r ) t i...
Page 53 PZ-50HV2, PZ-50HV2E PZ-50HV2U ) t r ) t i ) t i ) t i ) t i ) t i f i f ) t i ) t i ) t i ) t i ) t i ) t i ) t i ) t i ) t i...
Page 54 PZ-50HV2, PZ-50HV2E PZ-50HV2U ) t r ) t i...
Page 55 PZ-50HV2, PZ-50HV2E PZ-50HV2U ) t r ) t i f i f ) t i ) t i r i f ) t i ) t i ) t i r i f ) t i ) t i f i f ) t i ) t i ) t i...
Page 56 PZ-50HV2, PZ-50HV2E PZ-50HV2U ) t i r i f ) t i ) t r...
Page 57 PZ-50HV2, PZ-50HV2E PZ-50HV2U ) t i ) t i ) t i ) t i ) t i ) t i ) t i r i f ) t i ) t i ) t i ) t i ) t i f i f ) t i r i f...
Page 58 PZ-50HV2, PZ-50HV2E PZ-50HV2U ) t i ) t i ) t i ) t i ) t i ) t i ) t i...
Page 59 PZ-50HV2, PZ-50HV2E PZ-50HV2U PST9246N (DIGITAL VIDEO ASSY : IC1208) • Reset IC Pin Assignment (Top View) Block Diagram SOT-25 (TOP VIEW) Pin Function Pin No. Pin name Functions control pin Substate pin GND pin Reset signal output pin pin / voltage detect pin...
Page 60 PZ-50HV2, PZ-50HV2E PZ-50HV2U FS781BZB (DIGITAL VIDEO ASSY : IC1802) • Low EMI Clock IC Pin Assignment (Top View) Xout FS78x FSOUT 8 Pin SOIC Package Block Diagram Loop Filter 4(6) 250 K Reference 1(3) Divider Phase 8 pF Detector 10 pF. Modulation Control Xout...
Page 61 PZ-50HV2, PZ-50HV2E PZ-50HV2U STK795-460 (X DRIVE ASSY : IC3200, IC3201) (Y DRIVE ASSY : IC2206, IC2214) • PDP Pulse Module IC Block Diagram V SUS V SUS V SUS V SUS N.C. N.C. SIG GND SIG GND 40 OUT H N.C.
Page 62: Block Diagram
PZ-50HV2, PZ-50HV2E PZ-50HV2U BLOCK DIAGRAM Ë OVERALL DIAGRAM Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver Driver...
Page 63 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë MR INTERFACE ASSY CN4003 (DVI) IC4204 TMDS_RXCORE CONTENT_PROTECTION SCALING 8bit_DIGITAL TMDS IC4203 (CONF_ROM) Q4201, Q4202 3.3V I2C_LEVEL_SHIFT) Q4005, Q4006 3.3V IC4201 (DDC_ROM) I2C_LEVEL_SHIFT) IC4012 (IC2_SW) DDC_SCL DDC_SCL DDC_SDA DDC_SDA DDC5V IC4013 (STB_DET) Q4014 (REM_CUT) PMST IC4010 (NON_SYSTEM_DET) Q4018 (INV) C4043...
Page 64 PZ-50HV2, PZ-50HV2E PZ-50HV2U Voltages CN4002 (MDR Connector) ( AVC System) CN4003 (DVI Connector) ( AVC System) Name Description Voltage at INPUT4 NTSC Input Name Description Voltage at INPUT4 NTSC Input M_RXD 232C bus (PDP 0-5V swing square wave RX2- DVI signal DVI signal RX2+ DVI signal...
Page 65 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë DIGITAL VIDEO ASSY MR INTERFACE DIGITAL VIDEO ASSY 3.3V 2.5V ASSY 3.3V IC1301 (IC31 L) (PD6358) Address Data RGB 2 phase 8 bit DRAM ADR CONNECT A - D Assy (Left section) Line Buffer IC4204 IC1401 (IC31 R) SiI861 (PD6358) Address Data...
Page 66 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë X DRIVE ASSY...
Page 67 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë Y DRIVE ASSY IC5V IC2504 Photo Coupler TC74ACT540FT Photo Coupler Photo Coupler OC2-1 To SCAN ASSY Photo Coupler (Lower) Photo Coupler Photo Coupler Photo Coupler Photo Coupler IC2501,IC2502, IC2001 IC2505,IC2510, TC74ACT541FT IC2512,IC2513, VSUS IC2514,IC2525, Q2204 YPR-U1 HCPL-M611 To SCAN ASSY YPR-U2...
Page 68 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë SUB ADDRESS A and B ASSYS +60V Current - Voltage Over Current DET. Block Convert Block ADRGND CN8801 R8801 - R8805 Q8801 H : V MID CLAMP OFF L : V MID CLAMP ON ADR Output P.D.
Page 69 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë ADR RESONANCE ASSY CAUTION : FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE ONLY WITH SAME TYPE NO. ICP-S1.0 MFD +60V BY ROHM CO., LTD. FOR IC6704. +60V +60V ICP-S1, 0 +60V CN6702 IC6704 C6703 - C6708 Address Resonance Output Block ADROUT ADRGND...
Page 70 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë ADR CONNECT A, B, C and D ASSYS Address Module Address Module Address Module Address Module Address Module (TCP) (TCP) (TCP) (TCP) (TCP) ADR OUT BRIDGE ASSY ADR PD OPEN PD Q6502, Q6503 LBLK HBLK DATA_R DATA_R DATA_R DATA_R...
Page 71 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë AUDIO AMP and SP TERMINAL ASSYS AUDIO AMP ASSY IC5202 (CXA2021S) IC5201 (NJM2193L) IC5002 (LA4628) No. Voltage (V) No. Voltage (V) No. Voltage (V) No. Voltage (V) No. Voltage (V) 5.25 5.95 11.91 1.73 5.94 5.95 5.95 5.84 5.94...
Page 72: Overall Wiring Diagram
PZ-50HV2, PZ-50HV2E PZ-50HV2U OVERALL WIRING DIAGRAM Large size SCH diagram...
Page 73 PZ-50HV2, PZ-50HV2E PZ-50HV2U Large size SCH diagram...
Page 74: Waveforms
PZ-50HV2, PZ-50HV2E PZ-50HV2U WAVEFORMS DIGITAL VIDEO ASSY K1327 (VDI) K1326 (DEI) K1308 (VDRB) K1328 (HDI) K1333 (VCLKL) IC1501 - pin 15 (LBLK) V: 2V/div. H: 4msec/div. V: 2V/div. H: 4 sec/div. V: 2V/div. H: 2msec/div. K1327 (VDI) K1326 (DEI) K1308 (VDRB) K1328 (HDI) K1333 (VCLKL) IC1501 - pin 13 (LE)
Page 75 PZ-50HV2, PZ-50HV2E PZ-50HV2U ADR CONNECT A - D SUB ADDRESS A, B ADR RESONANCE ASSY ASSY ASSY CH1 : IC6702 - pin 2 CH1 : IC6501 - pin 8 (CLK) CH1 : IC8801 - pin 3 CH2 : IC6701 - pin 2 CH2 : IC6501 - pin 6 (LE) CH2 : IC8801 - pin 7 CH3 : IC6703 - pin 2...
Page 76 PZ-50HV2, PZ-50HV2E PZ-50HV2U AUDIO SECTION Measurement condition Caution in the measurement Video Input Signal : FULL FIELD COLOR-BAR Audio Power Amp. (IC5002: LA4628) on the AUDIO AMP Assy is BTL system, and, Audio Input Signal : 1kHz Sine Carve 0.2Vrms as for the power amplifier and the speaker output, poles becomes hot for the Volume...
Page 77 PZ-50HV2, PZ-50HV2E PZ-50HV2U Sustain Waveforms Drive Pulse Waveforms Sustain Waveform (1 field) Sustain Waveform (1 sub-field) Y Drive Pulse Control Waveform (1 field) ch 1 : K3107 (X.PSUS) - K3201 (SUSGND) ch 1 : K3107 (X.PSUS) - K3201 (SUSGND) V: 100V/div. H: 2msec/div. V: 100V/div.
Page 78 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë SCAN (A) ASSY Large size SCH diagram...
Page 79 PZ-50HV2, PZ-50HV2E PZ-50HV2U Large size SCH diagram...
Page 80 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë SCAN (B) ASSY Large size SCH diagram...
Page 81 PZ-50HV2, PZ-50HV2E PZ-50HV2U Large size SCH diagram...
Page 82 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë X CONNECTOR (A), (B), BRIDGE A - D and CLAMP A - D ASSYS...
Page 83 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë ADR CONNECT A ASSY...
Page 84 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë ADR CONNECT B ASSY...
Page 85 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë ADR CONNECT C ASSY...
Page 86 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë ADR CONNECT D ASSY...
Page 87 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë ADR RESONANCE ASSY CAUTION : FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE ONLY WITH SAME TYPE NO. ICP-S1.0 MFD BY ROHM CO., LTD. FOR IC6704.
Page 88 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë X DRIVE ASSY (1/3) » X LOGIC BLOCK...
Page 89 PZ-50HV2, PZ-50HV2E PZ-50HV2U Large size Ë X DRIVE ASSY (2/3) SCH diagram » X SUS BLOCK...
Page 90 PZ-50HV2, PZ-50HV2E PZ-50HV2U Large size SCH diagram...
Page 91 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë X DRIVE ASSY (3/3) » X D-D CON BLOCK...
Page 92 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë Y DRIVE ASSY (1/4) » Y LOGIC DRIVE BLOCK...
Page 93 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë Y DRIVE ASSY (2/4) » Y DRIVE SUS BLOCK Large size SCH diagram...
Page 94 PZ-50HV2, PZ-50HV2E PZ-50HV2U Large size SCH diagram...
Page 95 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë Y DRIVE ASSY (3/4) » Y DRIVE SCAN BLOCK...
Page 96 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë Y DRIVE ASSY (4/4) » Y DRIVE D-D CON BLOCK...
Page 97 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë SUB ADDRESS A ASSY...
Page 98 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë SUB ADDRESS B ASSY...
Page 99 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë DIGITAL VIDEO ASSY (1/10) » DIGITAL BLOCK...
Page 100 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë DIGITAL VIDEO ASSY (2/10) » PANEL UCOM BLOCK Large size SCH diagram...
Page 101 PZ-50HV2, PZ-50HV2E PZ-50HV2U Large size SCH diagram...
Page 102 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë DIGITAL VIDEO ASSY (3/10) » MODULE UCOM BLOCK Large size SCH diagram...
Page 103 PZ-50HV2, PZ-50HV2E PZ-50HV2U Large size SCH diagram...
Page 104 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë DIGITAL VIDEO ASSY (4/10) » IC31 L BLOCK Large size SCH diagram...
Page 105 PZ-50HV2, PZ-50HV2E PZ-50HV2U Large size SCH diagram...
Page 106 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë DIGITAL VIDEO ASSY (5/10) » IC31 R BLOCK Large size SCH diagram...
Page 107 PZ-50HV2, PZ-50HV2E PZ-50HV2U Large size SCH diagram...
Page 108 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë DIGITAL VIDEO ASSY (6/10) » ADDRESS CONNECTOR U BLOCK Large size SCH diagram...
Page 109 PZ-50HV2, PZ-50HV2E PZ-50HV2U Large size SCH diagram...
Page 110 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë DIGITAL VIDEO ASSY (7/10) » ADDRESS CONNECTOR D BLOCK Large size SCH diagram...
Page 111 PZ-50HV2, PZ-50HV2E PZ-50HV2U Large size SCH diagram...
Page 112 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë DIGITAL VIDEO ASSY (8/10) » IC23 BLOCK Large size SCH diagram...
Page 113 PZ-50HV2, PZ-50HV2E PZ-50HV2U Large size SCH diagram...
Page 114 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë DIGITAL VIDEO ASSY (9/10) » CLK GENERATOR BLOCK...
Page 115 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë DIGITAL VIDEO ASSY (10/10) » D-D CONV BLOCK...
Page 116 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë MR INTERFACE ASSY (1/3) » INTERFACE BLOCK Large size SCH diagram...
Page 117 PZ-50HV2, PZ-50HV2E PZ-50HV2U Large size SCH diagram...
Page 118 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë MR INTERFACE ASSY (2/3) » TMDS RECEIVER BLOCK EDID ROM SiI861 Initialize Data ROM DVI RECEIVER with SCALER...
Page 119 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë MR INTERFACE ASSY (3/3) » AUDIO BLOCK...
Page 120 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë LED, FRONT KEY, FRONT KEY CONN, IR RECEIVE (P) and SENSOR ASSYS TEMP1 Panel Temp. Voltage...
Page 121 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë AUDIO AMP ASSY IC5202 (CXA2021S) IC5201 (NJM2193L) IC5002 (LA4628) No. Voltage (V) No. Voltage (V) No. Voltage (V) No. Voltage (V) No. Voltage (V) 5.25 5.95 11.91 1.73 5.94 5.95 5.95 5.84 5.94 5.92 5.98 5.98 3.37 5.98 5.91...
Page 122 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë SP TERMINAL ASSY...
Page 123 PZ-50HV2, PZ-50HV2E PZ-50HV2U...
Page 124 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë V MID CLAMP ASSY...
Page 125 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë SW POWER SUPPLY MODULE (1/2) Refer to "SW POWER SUPPLY MODULE (2/2)
Page 126 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë SW POWER SUPPLY MODULE (2/2)
Page 127: Printed Wiring Board Assemblies
PZ-50HV2, PZ-50HV2E PZ-50HV2U PRINTED WIRING BOARD ASSEMBLIES NOTE FOR PWB DIAGRAMS : 1. Part numbers in PWB diagrams match those in the schematic 3. The parts mounted on this PWB include all necessary parts for diagrams. several destinations. 2. A comparison between the main parts of PWB and schematic For further information for respective destinations, be sure to diagrams is shown below.
Page 128 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë X CONNECTOR A and B ASSYS X CONNECTOR B X CONNECTOR A ASSY ASSY SIDE B SIDE B (ANP1980-C)
Page 129 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë SCAN (A) ASSY SCAN (A) ASSY SIDE A (ANP1980-C) SCAN (A) ASSY (ANP1980-C) SIDE B...
Page 130 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë SCAN (B) ASSY SIDE A SCAN (B) ASSY (ANP1980-C) SCAN (B) ASSY SIDE B (ANP1980-C)
Page 131 Ë BRIDGE A - D and CLAMP A - D ASSYS BRIDGE A BRIDGE B BRIDGE C BRIDGE D ASSY ASSY ASSY ASSY (ANP1980-C) (ANP1980-C) (ANP1980-C) (ANP1980-C) CLAMP A CLAMP B CLAMP C CLAMP D ASSY ASSY ASSY ASSY (ANP1980-C) (ANP1980-C) (ANP1980-C) (ANP1980-C)
Page 132 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë ADR RESONANCE ASSY ADR RESONANCE ASSY (ANP1982-C) SIDE A...
Page 133 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë ADR CONNECT A - D ASSYS ADR CONNECT A ASSY SIDE A (ANP1982-C) ADR CONNECT B ASSY SIDE A (ANP1982-C) ADR CONNECT C ASSY SIDE A (ANP1982-C) ADR CONNECT D ASSY SIDE A (ANP1982-C)
Page 134 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë X DRIVE ASSY X DRIVE ASSY (ANP1983-D) SIDE A...
Page 135 PZ-50HV2, PZ-50HV2E PZ-50HV2U X DRIVE ASSY (ANP1983-D) SIDE B...
Page 136 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë Y DRIVE ASSY Y DRIVE ASSY (ANP1984-C) SIDE A...
Page 137 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë DIGITAL VIDEO ASSY DIGITAL VIDEO ASSY (ANP1985-C) SIDE A...
Page 138 PZ-50HV2, PZ-50HV2E PZ-50HV2U DIGITAL VIDEO ASSY (ANP1985-C) SIDE B...
Page 139 Ë SUB ADDRESS A and B ASSYS SUB ADDRESS A ASSY SUB ADDRESS B ASSY (ANP1984-C) (ANP1984-C) SIDE A SIDE A...
Page 140 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë LED, FRONT KEY, FRONT KEY CONN, IR RECEIVE (P) and SENSOR ASSYS...
Page 141 Ë MR INTERFACE ASSY MR INTERFACE ASSY (ANP1997-B) SIDE A...
Page 142 PZ-50HV2, PZ-50HV2E PZ-50HV2U MR INTERFACE ASSY (ANP1997-B) SIDE B...
Page 143 Ë AUDIO AMP and SP TERMINAL ASSYS SIDE A AUDIO AMP ASSY (ANP2001-B) SP TERMINAL ASSY SIDE A (ANP2001-B)
Page 144 PZ-50HV2, PZ-50HV2E PZ-50HV2U Ë V MID CLAMP ASSY V MID CLAMP ASSY (ANP2000-B) SIDE A...
Page 145: Parts List
For location of SHARP Parts Distributor, Please call Toll-Free; 1-800-BE-SHARP To have your order filled promptly and correctly, please furnish the following informations. in CANADA: Contact SHARP Electronics of Canada Limited Phone (416) 890-2100. 1. MODEL NUMBER 2. REF. NO.
Page 146 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6616 9GJAWZ6617 SCAN (A) ASSY (Continued) SCAN (B) ASSY INTEGRATED CIRCUITS C6046 9GJCCSRCH181J5 J 180p 50V Ceramic C6047 9GJCCSRCH181J5 J 180p 50V Ceramic IC6201 9GJSN755860PJ J Scan IC...
Page 147 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6617 MISCELLANEOUS PARTS CN6421 9GJB4B-PH-SM3 J PH Connector (SMT) SCAN (B) ASSY (Continued) C6228 9GJCKSRYF104Z1 J 0.1 16V Ceramic 9GJAWZ6621 C6241 9GJCKSRYF104Z1 J 0.1 16V Ceramic C6247 9GJCKSRYF104Z1 J 0.1...
Page 148 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6651 C6516 9GJACG1094 J 330p 100V Ceramic C6517 9GJACG1094 J 330p 100V Ceramic CLAMP B ASSY C6518 9GJACG1094 J 330p 100V Ceramic C6519 9GJACG1094 J 330p 100V Ceramic DIODES...
Page 149 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6627 R6650 9GJRS1/16S0R0J 1/16W Chip R6651 9GJRS1/16S0R0J 1/16W Chip ADR CONNECT B ASSY R6652 9GJRS1/16S0R0J 1/16W Chip R6653 9GJRS1/16S0R0J 1/16W Chip INTEGRATED CIRCUIT R6623 9GJRS1/16S100J J 10...
Page 150 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6628 CAPACITORS C6911 9GJACG1094 J 330p 100V Ceramic ADR CONNECT C ASSY (Continued) C6912 9GJACG1094 J 330p 100V Ceramic C6913 9GJACG1094 J 330p 100V Ceramic RESISTORS C6914 9GJACG1094...
Page 151 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6629 RESISTORS R6743 9GJRS1/16S0R0J 1/16W Chip ADR CONNECT D ASSY (Continued) R6702 9GJRS1/16S100J J 10 1/16W Chip R6707 9GJRS1/16S104J J 100k 1/16W Chip R6911 9GJRS1/16S472J J 4.7k 1/16W Chip...
Page 152 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1901 D3207 9GJD1FL40 J Diode D3208 9GJD1FL40 J Diode X DRIVE ASSY (Continued) D3210 9GJD1FL40 J Diode D3211 9GJD1FL40 J Diode K3001 9GJAKX9002 J Test Point (Chip1608) D3212 9GJD1FL40...
Page 153 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1901 R3207 9GJRS1/16S100J J 10 1/16W Chip R3208 9GJRS1/16S100J J 10 1/16W Chip X DRIVE ASSY (Continued) R3209 9GJRS1/16S100J J 10 1/16W Chip R3224 9GJRS1/16S100J J 10...
Page 154 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1901 R3720 9GJRS1/16S822J J 8.2k 1/16W Chip R3722 9GJRS1/16S822J J 8.2k 1/16W Chip X DRIVE ASSY (Continued) COIL 9GJAWV6645 L3701 9GJATH1110 J Inductor Y DRIVE ASSY TRANSFOMER T3701...
Page 155 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6645 D2208 9GJD1FL40 J Diode D2210 9GJD1FL40 J Diode Y DRIVE ASSY (Continued) D2212 9GJD1FL40 J Diode D2214 9GJD1FL40 J Diode MISCELLANEOUS PARTS D2215 9GJD1FL40 J Diode...
Page 156 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV6645 R2272 9GJRS1/16S100J J 10 1/16W Chip R2285 9GJRS1/16S100J J 10 1/16W Chip Y DRIVE ASSY (Continued) R2290 9GJRS1/16S100J J 10 1/16W Chip R2295 9GJRS1/16S100J J 10...
Page 157 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV6645 DIODES D2712 9GJ1SS355 J Diode Y DRIVE ASSY (Continued) D2717 9GJ1SS355 J Diode D2718 9GJ1SS355 J Diode C2501 9GJCKSRYF104Z5 J 0.1 50V Ceramic D2732 9GJ1SS355 J Diode...
Page 158 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV6645 R2730 9GJRS1/16S103J J 10k 1/16W Chip R2739 9GJRS1/16S103J J 10k 1/16W Chip Y DRIVE ASSY (Continued) R2755 9GJRS1/16S103J J 10k 1/16W Chip R2758 9GJRS1/16S103J J 10k 1/16W Chip...
Page 159 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6690 9GJAWZ6689 SUB ADDRESS B ASSY SUB ADDRESS A ASSY (Continued) INTEGRATED CIRCUITS C8810 9GJCKSRYF104Z1 J 0.1 16V Ceramic C8811 9GJCKSRYF104Z1 J 0.1 16V Ceramic IC8901 9GJM5223AFP...
Page 160 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV6690 CAPACITORS C1001 9GJCKSRYF104Z1 J 0.1 16V Ceramic SUB ADDRESS B ASSY (Continued) C1002 9GJCKSRYF104Z1 J 0.1 16V Ceramic C1003 9GJCKSRYF104Z1 J 0.1 16V Ceramic R8901 9GJRS1/2S1R5J...
Page 161 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1903 R1127 9GJRAB4C472J Resistor Array AL R1129 9GJRAB4C472J Resistor Array AL DIGITAL VIDEO ASSY (Continued) R1128 9GJRD1/4PU473J Resistor Array AL R1109 9GJRS1/16S0R0J 1/16W Chip R1061 9GJRS1/16S470J J 47...
Page 162 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1903 R1227 9GJRS1/16S222J J 2.2k 1/16W Chip R1228 9GJRS1/16S222J J 2.2k 1/16W Chip DIGITAL VIDEO ASSY (Continued) R1230 9GJRS1/16S472J J 4.7k 1/16W Chip R12260 9GJRS1/16S473J J 47k 1/16W Chip...
Page 163 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1903 C1705 9GJCKSRYF104Z1 J 0.1 16V Ceramic C1706 9GJCKSRYF104Z1 J 0.1 16V Ceramic DIGITAL VIDEO ASSY (Continued) C1707 9GJCKSRYF104Z1 J 0.1 16V Ceramic C1708 9GJCKSRYF104Z1 J 0.1 16V Ceramic...
Page 164 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1903 R1402 9GJRS1/16S103J J 10k 1/16W Chip R1710 9GJRS1/16S103J J 10k 1/16W Chip DIGITAL VIDEO ASSY (Continued) R1711 9GJRS1/16S103J J 10k 1/16W Chip R1801 9GJRS1/16S103J J 10k 1/16W Chip...
Page 165 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1903 R1929 9GJRS1/16S472J J 4.7k 1/16W Chip R1932 9GJRS1/16S472J J 4.7k 1/16W Chip DIGITAL VIDEO ASSY (Continued) R1910 9GJRS1/16S473J J 47k 1/16W Chip [D-D CONVERTER BLOCK] MISCELLANEOUS PARTS TRANSISTORS...
Page 166 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6694 R4050 9GJRS1/16S0R0J 1/16W Chip R4061 9GJRS1/16S0R0J 1/16W Chip MR INTERFACE ASSY (Continued) R4071 9GJRS1/16S0R0J 1/16W Chip R4081 9GJRS1/16S0R0J 1/16W Chip C4030 9GJCCSRCH471J5 J 470 50V Ceramic R4082 9GJRS1/16S0R0J...
Page 167 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV6694 Q4202 9GJHN1C01FU J HN1C01FU MR INTERFACE ASSY (Continued) DIODES D4201 9GJ1SS184 J Diode R4017 9GJRS1/16S223J J 22k 1/16W Chip D4203 9GJ1SS226 J Diode R4030 9GJRS1/16S223J J 22k 1/16W Chip...
Page 168 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6694 R4277 9GJRS1/16S222J J 2.2k 1/16W Chip R4201 9GJRS1/16S223J J 22k 1/16W Chip MR INTERFACE ASSY (Continued) R4203 9GJRS1/16S223J J 22k 1/16W Chip R4204 9GJRS1/16S223J J 22k 1/16W Chip...
Page 169 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6694 DIODE MR INTERFACE ASSY (Continued) D4951 9GJ1SS355 J Diode R4428 9GJRS1/16S473J J 47k 1/16W Chip CAPACITORS R4434 9GJRS1/16S473J J 47k 1/16W Chip C4951 9GJCEV470M6R3 J 47...
Page 170 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6687 R5078 9GJRD1/4PU101J J 100 1/4W Carbon Film AL R5213 9GJRD1/4PU101J J 100 1/4W Carbon Film AL AUDIO AMP ASSY (Continued) R5214 9GJRD1/4PU101J J 100 1/4W Carbon Film AL R5229...
Page 171 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6688 SP TERMINAL ASSY (Continued) MISCELLANEOUS PARTS CN5301 9GJAKE1058 J Speaker Terminal, 4-pin AN 9GJAWV1934 V MID CLAMP ASSY TRANSISTORS Q9003 9GJ2SA1162 J 2SA1162 Q9004 9GJ2SA1162 J 2SA1162...
Page 172 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAEC1878 J Wire Saddle UNDER LAYER SECTION (1) PARTS LIST 9GJAEC1872 J Circuit Board Spacer 9GJAEC1873 J Circuit Board Spacer NSP 9 9GJAEC1253 –...
Page 173 PZ-50HV2, PZ-50HV2E PZ-50HV2U UNDER LAYER SECTION (2) 11 11 5 or 6 Upper side 7 or 8 11 11...
Page 174 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code UNDER LAYER SECTION (2) PARTS LIST NSP 1 9GJAWZ6626 – ADR CONNECT A Assy — NSP 2 9GJAWZ6627 – ADR CONNECT B Assy —...
Page 175 PZ-50HV2, PZ-50HV2E PZ-50HV2U UNDER LAYER SECTION (3) Upper side 7 (Upper Side) 8 (Bottom Side) Upper side...
Page 176 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code UNDER LAYER SECTION (3) PARTS LIST 9GJAWV1903 J DIGITAL VIDEO Assy NSP 2 9GJAWV1934 – V MID CLAMP Assy — 9GJAWV1901 J X DRIVE Assy NSP 4 9GJAWZ6618 –...
Page 177 PZ-50HV2, PZ-50HV2E PZ-50HV2U UNDER LAYER SECTION (4) Upper side Upper side...
Page 178 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code UNDER LAYER SECTION (4) PARTS LIST 9GJAWV1903 J DIGITAL VIDEO Assy 9GJAWZ6645 J Y DRIVE Assy NSP 3 9GJAWZ6617 – SCAN (A) Assy —...
Page 179 PZ-50HV2, PZ-50HV2E PZ-50HV2U UNDER LAYER SECTION (5) 1 22 16 29 23 SA1 SA2 CN9002 CN9001 SA2 SA1 30 22...
Page 180 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code UNDER LAYER SECTION (5) PARTS LIST NSP 1 9GJAWZ6626 – ADR CONNECT A Assy — NSP 2 9GJAWZ6627 – ADR CONNECT B Assy —...
Page 181 PZ-50HV2, PZ-50HV2E PZ-50HV2U MIDDLE LAYER SECTION (1)
Page 182 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code MIDDLE LAYER SECTION (1) PARTS LIST 9GJAWZ6658 J IR RECEIVE (P) Assy 9GJAWZ6655 J LED Assy 9GJAWZ6657 J FRONT KEY CONN Assy 9GJANG2455 J Sub Frame L 9GJANG2456 J Sub Frame R...
Page 183 PZ-50HV2, PZ-50HV2E PZ-50HV2U MIDDLE LAYER SECTION (2)
Page 184 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code MIDDLE LAYER SECTION (2) PARTS LIST 9GJAWZ6687 J AUDIO AMP Assy 9GJATX1042 J Toroidal Core (L2) 9GJABA1294 J Screw 9GJAEC1571 J Edge Saddle 9GJAEC1745 J Wire Saddle 9GJAMR3298...
Page 185 PZ-50HV2, PZ-50HV2E PZ-50HV2U UPPER LAYER SECTION (1) J5002 J201 J202 Caution in the MR INTERFACE Assy Replacement Set the slide switches in accordance with applicable model when replacing the MR INTERFACE Assy. S4001 S4004 CBIT_1 CBIT_0 PZ-50BD3 S4001 (PZ-50HV3) (CBIT_1) PZ-50HV2E PZ-50HV2U S4004...
Page 186 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code UPPER LAYER SECTION (1) PARTS LIST 9GJAWZ6694 J MR INTERFACE Assy 9GJAMZ30P060FZ J Screw 9GJTBZ40P080FZ J Screw 9GJANG2510-B J Terminal Panel P 9GJPMZ26P030FZ J Screw 9GJBBA1051 J Hexagonal Head Screw 9GJADD1194...
Page 187 PZ-50HV2, PZ-50HV2E PZ-50HV2U UPPER LAYER SECTION (2) PZ-50HV2U Only J5003 100V SW101 200V...
Page 188 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code UPPER LAYER SECTION (2) PARTS LIST 9GJAWZ6688 J SP TERMINAL Assy 9GJAXY1055 J SW Power Supply Module å 9GJBPZ30P080FZ J Screw 9GJAKP1223 J AC Inlet with Noise å...
Page 189 PZ-50HV2, PZ-50HV2E PZ-50HV2U FRONT CASE SECTION Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code FRONT CASE SECTION PARTS LIST 9GJAWZ6656 J FRONT KEY Assy 9GJAMB2731 J Front Case Assy (PZ-50HV2) 9GJAMB2709 J Front Case Assy (PZ-50HV2E) 9GJAMB2728 J Front Case Assy...
Page 190 PZ-50HV2, PZ-50HV2E PZ-50HV2U REAR SECTION Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code REAR SECTION PARTS LIST 9GJANE1599 J Rear Case (50P) 9GJANK1688 J Gascket A 9GJAMZ30P060FZ J Screw 9GJTBZ40P080FZ J Screw NSP 6 9GJAAL2379 –...
Page 191 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAMR3308 J Stand Read Cover STAND SECTION PARTS LIST 9GJTMZ50P150FC J Screw, x4 9GJTMZ50P080FC J Screw, x4 9GJTPZ40P100FC J Screw, x20 9GJAMZ30P060FC J Screw, x4 9GJANG2515 J Stand pipe-L 9GJANG2516...
Page 192 PZ-50HV2, PZ-50HV2E PZ-50HV2U PDP SERVICE ASSY 503 (9GJAWU1040) PDP Service Assy 503 (9GJAWU1040) consists of the following parts. Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code Mark Ref. No. Part No.
Page 193 PZ-50HV2, PZ-50HV2E PZ-50HV2U Caution in Replacement of Panel Chassis (50) Assy (9GJAWU1037) Pase order the Panel Chassis (50) Assy (9GJAWU1037) when replacing the Chassis block. Panel Chassis (50) Assy is all common use parts of for business, public use and module. Supply it by the state that installed Circuit Board Spacer (9GJAEC1872) and Wire Saddle (9GJAEC1878) as follows.
Page 194: Ë Packing Parts
PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code PACKING PARTS LIST SUPPLIED ACCESSORIES 9GJAHD3098 J Packing Case 9GJAHG1303 – Poly Bag (Power Cord) — (PZ-50HV2E) 9GJAED1197 J Wiping Cloth 9GJAHD3122 J Packing Case 9GJAEC1916 J Adjust Clamp (PZ-50HV2U)
Page 195: Packing Of The Set
PZ-50HV2, PZ-50HV2E PZ-50HV2U PACKING OF THE SET...
Page 196: Speaker Systems
PZ-50HV2, PZ-50HV2E PZ-50HV2U SPEAKER SYSTEMS SPEAKER SET RSP-ZA008WJN2 MODEL OUTLINE Speaker System for the PLASMA DISPLAY TV [Appropriate Model] This speaker system is for exclusive use with models PA-50HV2/50HV2E/50HV2U...
Page 197 For location of SHARP Parts Distributor, Please call Toll-Free; 1-800-BE-SHARP To have your order filled promptly and correctly, please furnish the following informations. in CANADA: Contact SHARP Electronics of Canada Limited Phone (416) 890-2100. 1. MODEL NUMBER 2. REF. NO.
Page 198 PZ-50HV2, PZ-50HV2E PZ-50HV2U SCHEMATIC DIAGRAM Network Assy (9GJSWN1688) Gray Gray 1.0mH Woofer Gray with White Line Gray with White Line Gray Tweeter 1.8 F Gray with White Line CABINET PARTS AND DIMENSIONS 103.5 (108) White Line White Line White Line (Unit : mm)
Page 199 PZ-50HV2, PZ-50HV2E PZ-50HV2U Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code PACKING PARTS SUPPLIED ACCESSORIES 9GJSEA1585 J Spacer Set 9GJSEA1581 J Speaker Wire Set (PZ-50HV2/50HVU) 9GJSDS1129 Speaker Wire 9GJSEC1602 – Spacer — 9GJSDS1130 Speaker Wire 9GJSHC1784 –...
Page 200 PZ-50HV2, PZ-50HV2E PZ-50HV2U PACKING OF THE SET Spacer (9GJSHD1050) Side Pad Assy (9GJSME3280) Protection Shest S4 (PZ-50HV2E) (9GJSHC1782) Protection Shest S5 (PZ-50HV2/50HV5U) (9GJSHC1783) Side Pad Assy (9GJSME3280) Speaker Set Spacer (9GJSHD1050) Spaker Wire Set Spacer Set (PZ-50HV2/50HV2U) (9GJSEA1581) (9GJSEA1585) Accsessories Assy (9GJSEA1582) Paking Case (9GJSHG2405)
Page 201 PZ-50HV2, PZ-50HV2E PZ-50HV2U COPYRIGHT © 2002 BY SHARP CORPORATION ALL RIGHTS RESERVED. No part of this publication may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, without prior written permission of the publisher.

This manual is also suitable for:

Pz-50hv2 Pz-50hv2e

Sharp PZ-50HV2U Service Manual

Quick Links

Related Manuals for Sharp PZ-50HV2U

Summary of Contents for Sharp PZ-50HV2U

This manual is also suitable for:

Table of Contents