Electrolux EI23BC60KS Service Data Sheet

PERFORMANCE DATA NO LOAD & NO DOOR OPENINGS AT 37°/0°
CONTROL SETTING (2500 ++ V4 CONTROLS)
Variable Speed Compressor 65°F (18°C) Ambient
Operating Time 32 to 40%
-6° to 6°F
Freezer Temperature
-21° to -14°C
33° to 46°F
Refrigerator Temperature
0.5° to 8°C
Low Side Pressure 5 to 12 psig
(cut-in) 34 to 83 kPa
Low Side Pressure -2 to 2 psig
(cut-out) -14 to 14 kPa
85 to 95 psig
High Side Pressure
586 to 655 kPa
Wattage 40 to 55
Amps (running) 0.5 to 1.1
Base Voltage 115 vac (127 vac max)
DEFROST SPECIFICATIONS
Thermostat
Cabinet Size
Cut-in Cut-out
25°F 47°F
23' SD, 28' SD, 23' CD
(-4°C) (8°C)
Electronic Timer - (ADC) Defrost 24 minutes every 6-96 hours of compressor run time.
CONDENSER FAN MOTOR
Watts RPM
3.1 1100 CW
(Energy Star, some models) Opposite Shaft
FREEZER ICE MAKER SPECIFICATIONS
Electrical 115 vac (127 vac max)
Thermostat Opens at 48°F (9°C), Closes at 15°F (-9°C)
Heater Voltage 85 vac
FREEZER ICE MAKER CONNECTOR PLUG CONNECTIONS
Wire Number Wire Color
1 Green / Yellow
2 Yellow / Blue
3 Black / Orange
4 Light Blue
SERVICE DATA SHEET - 242173700
FREEZER ICE MAKER - AUTOMATIC DEFROST
90°F (32°C) Ambient
IMPORTANT SAFETY NOTE
100%
-6° to 6°F
The information provided herein is designed to assist qualified repair personnel
-21° to -14°C
only. Untrained persons should not attempt to make repairs due to the possibility
33° to 46°F
of electrical shock. Disconnect power cord before servicing this appliance.
0.5° to 8°C
IMPORTANT
N/A
If any green grounding wires are removed during servicing, they must be
returned to their original position and properly secured.
-2 to 2 psig
-14 to 14 kPa
120 to 135 psig
827 to 931 kPa
60 to 70
CAUTION
0.7 to 0.9
All electrical parts and wiring must be shielded from torch flame. DO
NOT allow torch to touch insulation; it will char at 200°F and flash
ignite (burn) at 500°F. Excessive heat will distort the plastic liner.
Heater
Watts Ohms
500 26
NOTE
This product comes equipped with an Adaptive Defrost Control (ADC). To activate
manual defrost, simultaneously press and hold the Fresh Food up (+) and Fresh
Amps
Food down (-) keys for 5 seconds. A "d" in the freezer temperature window
and "F" in the refrigerator temperature window will display when the heater
0.03 Running
is activated. To deactivate manual defrost, simultaneously press and hold the
Fresh Food up (+) and Fresh Food down (-) keys for 5 seconds. A "d" and "F"
will be displayed until the defrost cycle is complete.
Connects to:
IMPORTANT
Ground
Water Valve
PLEASE RETURN THIS SHEET TO ITS ORIGINAL
Line
LOCATION.
Neutral
BOTTOM FREEZER - R134a
ICE MAKER INFORMATION
Test Cycling:
Remove cover by inserting screwdriver in notch at bottom
and prying cover from housing. Use screwdriver to rotate motor gear counter-
clockwise until holding switch circuit is completed. All components of ice maker
should function to complete the cycle.
Water Fill Volume:
The water fill adjust-
ment screw will change the fill time. One full
turn is equal to 20cc (.68 oz.). The correct
fill is 102 to 130cc (3.4 to 4.3 oz.). When a
water valve is replaced, the fill volume must
be checked.
LINE
POWER
ICE MAKER
BRN
BLK
P-3
THERMAL
CUT-OUT
MOTOR
HOLD
SWITCH
NO
RED
NC
C
BLK
MOLD HEATER
165 WATTS
GRN / YEL
P-1
WATER FILL
MOUNTING
MOLD
PLATE
ICE MAKER
Water Fill
Adjustment
Motor
Gear
Mounting
Plate
Screws
Mounting
Plate
Screw
Timing
Gear
NEUTRAL
RED
YEL
P-2
THERMOSTAT
NO
BLU
NC
C
SHUTOFF
NO
SWITCH
NC LT. BLUE
C
P-4
SWITCH