Dura Heat DH2304 Owner's Manual

Dura Heat DH2304 Owner's Manual

Portable kerosene-heater

Advertisement

KEROSENE-HEATER
"OWNER'S MANUAL"
Before the first use of this heater, please read this OWNER'S MANUAL very
carefully. This OWNER'S MANUAL has been designed to instruct you as to the
proper manner in which to assemble the heater, maintain the heater, store the
heater, and most importantly, how to operate the heater in a safe and efficient
manner, please keep this manual for future reference.
WORLD MARKTING OF AMERICA, INC.
4221 - 0048-02
06/04 Rev. 00
PO RTA BL E
DuraHeat
MODEL:
DH 2304
RT. 22 WEST, P.O. BOX 192
MILL CREEK, PA 17060
1- 800 - 776 - 9425 (9AM - 4PM EST)
MON.- FRI. ONLY
www.yourheater.com
®

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the DH2304 and is the answer not in the manual?

Questions and answers

Summary of Contents for Dura Heat DH2304

  • Page 1 PO RTA BL E KEROSENE-HEATER “OWNER’S MANUAL” DuraHeat Before the first use of this heater, please read this OWNER'S MANUAL very carefully. This OWNER'S MANUAL has been designed to instruct you as to the proper manner in which to assemble the heater, maintain the heater, store the heater, and most importantly, how to operate the heater in a safe and efficient manner, please keep this manual for future reference.
  • Page 2: Cautions-Safety Guide

    NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING! - SAFETY GUIDE - WARNING!! RISK OF EXPLOSION / RISK OF FIRE use any fuel other than water-clear 1-K ! NEVER kerosene. use fuel such as gasoline, benzene, paint ! NEVER thinners or other oil compounds in this heater. refill heater fuel tank when heater is operating ! NEVER or still hot.
  • Page 3: Table Of Contents

    CONTENTS OF OWNER'S MANUAL ITEM CAUTIONS-SAFETY GUIDE ¢ INTRODUCTION ¢ FEATURES ¢Ł UNPACKING AND ASSEMBLY ¢Ø KEROSENE (1-K ONLY) ¢Œ FUELING YOUR HEATER ¢º AUTOMATIC IGNITION SYSTEM ¢ CHECKING THE IGNITION SYSTEM ¢ ADJUSTING THE WICK ¢ WICK MAINTENANCE ¢ ¢ INTRODUCTION Please read this OWNER'S MANUAL carefully.
  • Page 4: Ł Unpacking And Assembly

    NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING! ¢Ł UNPACKING AND ASSEMBLY CAUTION: "RISK OF BURNS" DO NOT OPERATE HEATER WITHOUT INSTALLING THE PROTECTIVE GUARD OR GRILLE. 1. REMOVE THE HEATER AND ALL PACKING MATERIALS FROM THE BOX.(Fig. 2) NOTE : Save the shipping carton and packing materials for future storage.
  • Page 5: Ø Kerosene (1-K Only)

    D) INSTALLING CARRYING HANDLE:(Fig. 6) Insert the carrying handle into the holes on the cabinet by aligning holes on brackets of top plate. E) INSTALLING TOP GUARD:(Fig. 7) •Align the 2 brackets on the top guard with the 2 mounting brackets on the front and rear guards.
  • Page 6: Œ Fueling Your Heater

    NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING! It is normal for a kerosene heater to give off a slight odor upon start-up and shut-down. After 5-10 minutes of operation, the heater should have reached its normal operating temperature and any odor should be very slight.
  • Page 7: º Automatic Ignition System

    ¢º AUTOMATIC IGNITION SYSTEM For safety and convenience, this heater features an automatic ignition system. 2 "C" cell batteries, included with the heater, provide the power for the igniter which lights the wick once it has been raised to its maximum height. To use the automatic ignition system: ¡'Make sure the batteries have been installed.
  • Page 8: Checking The Ignition System

    NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING! ¢ CHECKING THE IGNITION SYSTEM If the automatic ignition system fails to operate properly, perform the following checks: ¡'BATTERIES -2 "C" cell batteries are located at the rear of the heater. Replace with new batteries. ¡' IGNITER PLUG - If the automatic ignition system still doesn't work after replacing the batteries, check the igniter plug.
  • Page 9: Carbon Removal / Dry Burning

    NOTE : During start-up, small adjustments to the flame can be performed by using the burner knob on the front of the burner and MOVING THE BURNER FROM SIDE TO SIDE until the flame at the top of burner is as even as possible.
  • Page 10: Wick Replacement

    NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING! ¢ WICK ASSEMBLY- Check at least once a month!! The burner assembly sits on top of the wick guide. Over time, tar deposits can accumulate on the wick guide, and this can prevent the burner assemby from seating properly.
  • Page 11 . Remove the four wing nuts which hold Wick Assembly to the heater and carefully lift the Wick Assembly from the heater. . Remove the Wick while folding it to the inside. Remove the Wick Sleeve together with the Wick. NOTE : DO NOT DISASSEMBLE THE STAINLESS STEEL WICK HOLDER.
  • Page 12 NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING! .Turn the Wick Assembly upside down to replace the Wick Cover. . Align the tabs on the wick cover with the four screw holes on the Bottom of the Assembly, as shown, and snap it into place.
  • Page 13: Automatic Safety Shut-Off Device

    ¢ EXTINGUISHING THE HEATER To extinguish the heater, push down on the manual shut-off knob(Fig. 18) with one hand while holding the wick adjuster knob in the other hand. You will feel the pressure of spring action attempting to turn the wick adjuster knob in a counter- clockwise direction in your hand.
  • Page 14: Long Term Storage Of Your Heater

    NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING! TESTING THE SAFETY SHUT-OFF DEVICE : At least once a week during the heating season, it is important to test the safety shut-off device to be sure that it is operating properly. WITH THE HEATER TURNED OFF, raise the wick using the wick adjuster knob to the fully raised position.
  • Page 15: I Trouble Shooting Guide

    ¢ı TROUBLE SHOOTING GUIDE TROUBLE Heater Will Not Light ; 1. Fuel tank is empty 2. Water present in kerosene 3. Igniter plug fails to glow 4. Igniter plug makes contact with side of wick Heater Produces Smoke or Odor ; 1.
  • Page 16: Specifications

    NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING! ¢ EXPLODED PARTS DRAWING PARTS LIST NOTE : DRAWING PART DESCRIPTION NUMBER NUMBER TOP GRILLE 08-5404 CARRYING HANDLE 08-5697 TOP PLATE 08-5123 BURNER ASS'Y 08-0123 08-9622 WICK COVER REAR GRILLE 08-5405 CABINET BASE 08-5323 WIND COVER 08-9624...

Table of Contents

Save PDF