Electrolux E23BC68JPS Service Data Sheet

PERFORMANCE DATA NO LOAD & NO DOOR OPENINGS AT 37°/0°
CONTROL SETTING (2500++ V4 CONTROLS)
Variable Speed Compressor 65°F (18°C) Ambient
Operating Time 32 to 40%
-6° to 6° F
Freezer Temperature
-21° to -14° C
33° to 46° F
Refrigerator Temperature
0.5° to 8° C
Low Side Pressure 5 to 12 psig
(cut-in) 34 to 83 kPa
Low Side Pressure -2 to 2 psig
(cut-out) -14 to 14 kPa
85 to 95 psig
High Side Pressure
586 to 655 kPa
Wattage 40 to 55
Amps (running) .5 to 1.1
Base Voltage 115 vac (127 vac max)
DEFROST SPECiFiCATiONS
Thermostat
Cabinet Size
Cut-in Cut-out
25° F 47° F
23' SD, 28' SD, 23' CD
(-4° C) (8° C)
Electronic Timer - (ADC) Defrost 24 minutes every 6-96 hours of compressor run time.
CONDENSER FAN MOTOR
Watts RPM
3.1 1100 CW
(Energy Star, some models) Opposite Shaft
iCE MAKER SPECiFiCATiONS
Electrical 115 vac (127 vac max)
Thermostat Opens at 48° F (9° C), Closes at 15° F (-9° C)
Heater Voltage 85 vac
iCE MAKER CONNECTOR PLUG CONNECTiONS
Wire Number Wire Color
1 Green/Yellow
2 Yellow
3 Black
4 Light Blue
SERViCE DATA SHEET - 242062500
FREEZER iCE MAKER - AUTOMATiC DEFROST
BOTTOM FREEZER - R134a
90°F (32°C) Ambient
100% iMPORTANT SAFETY NOTE
-6° to 6° F
-21° to -14° C
The information provided herein is designed to assist qualified
repair personnel only. Untrained persons should not attempt to
33° to 46° F
0.5° to 8° C
make repairs due to the possibility of electrical shock. Disconnect
power cord before servicing this appliance.
N/A
iMPORTANT
-2 to 2 psig
-14 to 14 kPa
If any green grounding wires are removed during servicing, they
120 to 135 psig must be returned to their original position and properly secured.
827 to 931 kPa
60 to 70
CAUTiON
.7 to .9
All electrical parts and wiring must be shielded from torch
flame. DO NOT allow torch to touch insulation; it will char
Heater
at 200°F and flash ignite (burn) at 500°F. Excessive heat
Watts Ohms
will distort the plastic liner.
500 26

NOTE
This product comes equipped with an Adaptive Defrost Control
Amps
(ADC). To activate manual defrost, simultaneously press and
hold the Fresh Food up (+) and Fresh Food down (-) keys for 5
0.03 Running
seconds. A "d" in the freezer temperature window and "F" in the
refrigerator temperature window will display when the heater is
activated. To deactivate manual defrost, simultaneously press and
hold the Fresh Food up (+) and Fresh Food down (-) keys for 5
seconds. A "d" and "F" will be displayed until the defrost cycle is
complete.
Connects to:
Ground iMPORTANT
Water Valve
PLEASE RETURN THiS SHEET TO iT'S ORiGiNAL
Line
LOCATiON
Neutral
iCE MAKER iNFORMATiON
Test Cycling
Remove cover by inserting screwdriver in notch at bottom and
prying cover from housing. Use screwdriver to rotate motor gear
counterclockwise until holding switch circuit is completed. All
components of ice maker should function to complete the cycle.
Water Fill
Water Fill Volume
Adjustment
The water fill adjustment
Motor
Gear
screw will change the fill
time. One full turn is equal
to 20cc (.68 oz.). The
correct fill is 102 to 130cc
(3.4 to 4.3 oz.). When a
water valve is replaced, Mounting
Plate
the fill volume must be
Screw
checked.
LINE POWER
ICE MAKER
BRN
BLK
P-3
THERMAL
CUT-OUT
MOTOR
HOLD
SWITCH
NO
RED
THERMOSTAT
NC
C
BLK
MOLD HEATER
165 WATTS
GRN / YEL
P-1
WATER FILL
MOLD MOUNTING
SWITCH
PLATE
ICE MAKER
Mounting
Plate
Screws
Timing
Gear
NEUTRAL
RED
LT. BLUE
P-4
NO
BLU
NC
C
SHUT-OFF
NO
SWITCH
NC YEL
C
P-2