Burromax TT350R Owner's Manual
  1. Manuals
  2. Brands
  3. Burromax Manuals
  4. Motorized Toy Car
  5. TT350R
  6. Owner's manual

Burromax TT350R Owner's Manual

Electric minibike
Hide thumbs

Advertisement

Table of Contents

Owners Manual
TT Series Electric Minibike
Read and understand this entire manual before riding!

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the TT350R and is the answer not in the manual?

Questions and answers

Related Manuals for Burromax TT350R

Summary of Contents for Burromax TT350R

  • Page 1 Owners Manual TT Series Electric Minibike Read and understand this entire manual before riding!

  • Page 3: Table Of Contents

    Contents Safety Warnings ..............4-5 Before You Begin ..............6 Assembly and Set-Up ............7-8 Before Riding .................9-12 Safety Reminders ..............13 Repair and Maintenance .............14-20 Troubleshooting Guide ............21-23 TT250 Side View ..............24 TT350R/TT450R/TT750R Side View ........25 TT250 Electrical Diagram ............26 TT350R/TT450R/TT750R Electrical Diagram ....27 Warranty Information ............28 NOTE: Manual illustrations are for demonstration purposes only.

  • Page 4: Safety Warnings

    Burromax others. recommend that you periodically review and reinforce the information in this...
  • Page 5 Do not use Lead-Acid charger with Li-ion battery and vise Never use headphones or a cell phone versa. when riding. • Lead acid Battery use Burromax Charger #LS-018C20-2401500. Never hitch a ride with another vehicle. • Li-ion Battery use Burromax charger...

  • Page 6: Before You Begin

    These vehicles have Because these vehicles are 95 percent assembled been built to certain Burromax and packed at the factory, there should not be any design specifications. The problems, even if the box has a few scars or dents.

  • Page 7: Assembly And Set-Up

    Assembly and Set-Up Attaching the Handlebars WARNING: Failing to properly adjust and Tools required: 6mm Hex Key wrench tighten the bolts that affix the handlebars can cause you to lose control and crash. Turn power switch “OFF” before conducting any maintenance procedures.
  • Page 8 Key Switch Operation bursts to inflate to the correct All TT Series minibikes come with keyed switches PSI. If you inadvertently over- so use can be restricted to owners and parental inflate the tire, release the control is available.

  • Page 9: Before Riding

    Before Riding Safety Speed Limiter Switch WARNING: To avoid a pinch or injury keep All Burromax electric ride on bikes are set on low fingers away from moving speed when they are shipped. You should change sprockets and chain. this setting only when you feel the rider can control the vehicle at higher speeds.
  • Page 10 Before Riding The Lead-Acid Battery WARNING: Rechargeable batteries are Your new electric mini bike is partially charged only to be charged under from the factory. Charge before Riding adult supervision. Always disconnect your electric mini Standard Lead-Acid TT250 bike from the charger before To achieve the best performance and life from your cleaning with liquid.
  • Page 11 50% do together. Do not mix with Lead-acid battery or not store with a full charge. charger. Use only Burromax battery chargers. Discharging and recharging • This battery, when run completely down below the battery every 6 months is cut off voltage, might be necessary to disconnect recommended.
  • Page 12 Charging in extreme temperatures above 110° could result. F and below 32° F can cause damage to battery. Always store in cool dry area with no more than 50% Use only Burromax charge. recommended battery charger for the battery type used!

  • Page 13: Safety Reminders

    Check the brake for proper function. online at: When you squeeze the lever, the brake should provide positive braking action. www.burromax.com When you apply the brake with the speed control on, the brake cut-off switch will Safety Gear stop the motor. When the brake is not in...

  • Page 14: Repair And Maintenance

    Repair and Maintenance WARNING: WARNING: Turn power switch “OFF” before The brake can cause the conducting any maintenance procedures. electric motorbike to skid the tire throwing an unsuspecting rider. Practice in an open area Adjusting the Brakes free from obstacles until you Tools required: 5mm Hex Key wrench are familiar with the brake function.
  • Page 15 Repair and Maintenance Chain Adjustment, Rear Tire and WARNING: Chain Replacement Make sure power switch is in off position before performing Tools required: Screwdriver, 5mm hex key any maintenance. wrench, 10mm, 12mm and 17mm wrench 1. Loosen screws and remove chain guard. WARNING: To avoid a pinch or injury keep fingers away from moving...
  • Page 16 Repair and Maintenance Chain Adjustment, Rear Tire and Chain Replacement 3. With 12mm and 17mm wrenches, loosen the axle. Remove the rear axle and remove the chain from the sprocket--pull the wheel out. WARNING: Make sure power switch is in off position before performing any maintenance.
  • Page 17 Repair and Maintenance Note the sequence of the hardware for assembly TT250 - TT250R – TT350R B-1 Rear Wheel Axle B-2 Rear Axle Adjuster (2) B-3 Mounting Plate-Brake Caliper B-4 Spacer (2) 4. Install the new chain or wheel by slipping B-5 Flat Washer the chain around the axle.
  • Page 18 Repair and Maintenance Adjust chain tension to have approx. 1/2” of free Chain and Sprocket Notes: play. Free play is not forced! The chain should The chain will typically have move this amount with very little force. Using a “loose spot” and “tight 12mm and 17mm wrenches tighten axle securely.
  • Page 19 Battery Replacement interchanged in the TT250 models but you must use Lead-Acid batteries (2-12v 7ah) should be replaced in the correct charger with the sets only and with original Burromax Batteries! battery used. Li-ion battery (24V and 36V). Non-replaceable internal breaker only use the Burromax Li-ion battery and Li-ion Battery charger together.
  • Page 20 F or below 32° F. Always store with no more than a WARNING: 50% charge. Keep away from extreme heat as it will Lithium-Ion Batteries diminish the performance and life of your Burromax • Do not charge or discharge Li-ion Battery. Return exhausted batteries to a federal the battery in extreme or state approved lead-acid battery recycler or a temperatures.

  • Page 21: Troubleshooting Guide

    Correct the conditions that caused the fuse to burn out and avoid repeatedly burning out fuse. Contact your local Burromax Motor or electrical authorized dealer for diagnosis and switch damage repair.
  • Page 22 Average SLA battery life, 1 to 2 years-300 cycles Li-ion battery life, 3 to 4 years-500 cycle Replace only with OEM Burromax replacement battery. The tires are inflated when shipped Tires are not properly but they invariably will lose some...
  • Page 23 Troubleshooting Guide Problem Possible Cause Solution Charger gets warm Normal response to No action required. This is normal during use charger use and is no cause for concern. If your charger does not get warm during use, it does not mean that it is not working properly.

  • Page 24: Tt250 Side View

    TT250 Side View TT250 Main...

  • Page 25: Tt350R/Tt450R/Tt750R Side View

    TT250R - TT350R Side View TT250R – TT350R Main Note: The TT350/450R has (2)-24V accessory plugs located under the plastic body shown below. The total circuit amperage available is 2.8 Amps--Do not over load!! We recommend max of 1.4 Amps per plug. This is not a fused circuit and overloading or shorting this circuit will cause Controller Failure! See page 27 for more information.

  • Page 26: Tt250 Electrical Diagram

    TT250 Electrical Diagram Electrical Schematics Speed Control Battery Charge Indicator...

  • Page 27: Tt350R/Tt450R/Tt750R Electrical Diagram

    Never attempt to work on this circuit with the Key on! This circuit is designed for accessories such as USB Ports and Extra LED Lighting. Accessories from Burromax are designed to plug in and are correctly matched for this cicuit--others may not be. This circuit is NOT...

  • Page 28: Warranty Information

    Warranty Burromax Limited Warranty The manufacturer warranties this product Burromax does not offer an extended to be free of manufacturing defects for a warranty. If you have purchased an period of 1 year from date of purchase. This extended warranty, it must be honored Limited Warranty does not cover normal by the store at which it was purchased.
  • Page 29 Other similar product owned before How did you hear about the product? PLEASE FILL OUT AND MAIL TO: Burromax LLC. 1200 Reco Ave Crestwood, MO 63126 OR REGISTER ONLINE AT www.BURROMAX.com We welcome your comments and suggestions for Burromax products...
  • Page 30 TT Series Electric Minibike Burromax LLC 1200 Reco Ave Crestwood, Mo. 63126 BURROMAX WWW. .COM Email us: info@Burromax.com CUSTOMER SERVICE & SUPPORT Hours: 9a-5p M-F CST 1-800-742-1189 FOLLOW US #BURROMAX 091218...

Table of Contents

Save PDF