Mercury Bravo Three Series User Manual

Diesel sterndrives
Table of Contents

Advertisement

CA741
The product you have purchased comes with a limited warranty from Mercury Marine; the
terms of the warranty are set forth in the Warranty Sections of this manual. The warranty state-
ment contains a description of what is covered, what is not covered, the duration of coverage,
how to best obtain warranty coverage, important disclaimers and limitations of damages,
and other related information. Please review this important information.
CB785
The operator (driver) is responsible for the correct and safe operation of the boat, the
equipment aboard and the safety of all occupants aboard. We strongly recommend
that the operator read this Operation, Maintenance and Warranty Manual and
thoroughly understand the operational instructions for the power package and all
related accessories before the boat is used.
The description and specifications contained herein were in effect at the time this guide was
approved for printing. Mercury Marine, whose policy is one of continuous improvement,
reserves the right to discontinue models at any time, or to change specifications or designs,
without notice and without incurring obligation.
1999, Mercury Marine
The following are registered trademarks of Brunswick Corporation:
Autoblend, Jet-Prop, Mariner, Merc, MerCathode, MerCruiser,
Mercury, Mercury Marine, Quicksilver, Ride-Guide, and Thruster.
Warranty Message
WARNING
Mercury Marine Fond du Lac, Wisconsin, U.S.A.
Printed in U.S.A.

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Bravo Three Series and is the answer not in the manual?

Questions and answers

Summarization of Contents

Identification Record
Serial Numbers
Manufacturer's keys to engineering details; specify model and serial numbers for service.
Warranty Information
Owner Warranty Registration
Dealer fills out card, factory issues plastic card; required for service.
International Owner Registration
Dealer mails card to distributor/service center; purchaser receives copy.
Recreational Use Diesel Sterndrive Limited Warranty
Covers defects for 1 year; commercial use voids warranty.
Warranty Coverage and Exclusion
Details what is covered (defects) and what is not covered (e.g., neglect, accident).
Transferable Warranty
Warranty is transferable to a subsequent purchaser for remaining term.
General Information
Lanyard Stop Switch
Turns off engine when operator moves away; safety warning about accidental activation.
Safe Boating Suggestions
Familiarize with regulations, check safety equipment, know weather, load limits.
Protecting People In The Water
Slow down near people; stop engine before allowing swimmers near the boat.
Conditions Affecting Operation
Propeller Selection
Choosing a propeller to achieve recommended engine RPM range at wide-open throttle.
How Elevation And Climate Affect Performance
Effect of air density (elevation, heat, humidity) on engine power and boat speed.
Important Information
Sterndrive Unit 10-Hour Break-In Period
Procedure for proper seating of drive unit gears and components for reduced problems.
Operation
Remote Controls
Description of panel and console-mounted remote control features and operation.
Power Trim
Adjusting drive angle for optimal boat angle and trailering/shallow water operation.
Shifting
Procedure for shifting the drive unit into forward, reverse, and neutral gears.
Maintenance
General Maintenance Information & Aids
General advice, safety, and required lubricants/fluids for maintenance.
Routine & Scheduled Maintenance
Daily, weekly, and periodic checks and tasks for upkeep.
Changing Drive Unit Oil
Step-by-step procedure for draining and refilling drive unit gear lube.
Lubrication
Lubrication points for steering system, shift cable, drive unit, and engine coupler.
Propeller Installation & Removal
Instructions for removing and installing propellers for Bravo One, Two, and Three.
Corrosion Protection
Explanation of galvanic corrosion and methods for protection using anodes and paint.
Cold Weather Storage & Recommissioning
Procedures for preparing unit for storage and bringing it back into service.
Troubleshooting
Common problems and their possible causes and remedies for controls and power trim.
Owner Service Assistance
Guidance on obtaining service, including local dealers and problem resolution.
Owner's Logbook
A log for recording maintenance and repair dates and operating hours.

Table of Contents

Save PDF