Advertisement
Advertisement
Table of Contents
Related Manuals for Rayzist 2648VX
Summary of Contents for Rayzist 2648VX
- Page 2 Table of Contents Section 1 - Safety Information Section 2 - Setup Guide Section 3 - Operation Manual Section 4 - Maintenance Manual...
-
Page 3: Reference Drawing
Reference Drawing Air Pressure Regulator Knob Air Flow Valve Air Inlet Valve Abrasive Flow Valve Foot Switch Valve Heavy Duty Footpedal Water Seperator Air Pressure Regulator Gauge Union Nut Blast Hose Pressure Pot Closure Lever Air Inlet Valve Quick Disconnect Blast Nozzle... - Page 4 2648VX Super Grit Pit Safety Information...
-
Page 5: Safety Information
Do not blast materials that and supply with your cabinet, 150 grit Brown may produce combustible dusts. Never use Aluminum Oxide, MSDS information is provided in flammable solvents inside the cabinet. your information package. 1/20/2015 (3:52 PM) 2648VX - 1 - Safety v2.doc... -
Page 6: Dust Collector
SET incoming air pressure from air compressor to 90psi. Set blasting pressure regulator on the pot to desired blasting pressure, normally between 25 psi - 35 psi. 1/20/2015 (3:52 PM) 2648VX - 1 - Safety v2.doc... - Page 7 2648VX Super Grit Pit Setup Guide...
-
Page 8: Set-Up Instruction
If there are any external or internal damages to the ! WARNING equipment it must be noted on the carrier’s bill of lading. Contact Rayzist customer service at 1-800- This equipment can weigh in excess of 950 lbs. 729-9478 immediately to process a damage claim. - Page 9 (E). Connect the long hose to the quick disconnect fitting located between water separator (G) and the air inlet valve (C). 2.8 Dust Bag Installation 1/20/2015 (3:52 PM) 2648VX - 2 - Setup v2.doc...
- Page 10 Exhausting through a long vent pipe may require an additional exhaust fan installed at the point the vent exits the building. 1/20/2015 (3:52 PM) 2648VX - 2 - Setup v2.doc...
- Page 11 2.14 Cabinet Operation Free Air CFM @ 135 PSI: 4.9 Volts 60 Hz: 115/230 Locate the Operation Manual to continue. Amps: 15/7.5 Tank Capacity (Gal): 26 2. Water Trap 3. Air hose 1/20/2015 (3:52 PM) 2648VX - 2 - Setup v2.doc...
- Page 12 2648VX Super Grit Pit Operation Manual...
- Page 13 Air Inlet Valve (C) is in the “OFF” position (horizontal) and the air compressor has been set up according to instructions found in the Rayzist setup guide. Connect the compressor air hose to the Air 3.2.2...
- Page 14 (C) and try again. If for some reason you cannot get the pressure pot closure cap ! NOTICE to seal, call Rayzist and ask for technical help. 3.4 Adjusting Blasting Pressure. The air pressure regulator (A) sets the blasting...
- Page 15 ! NOTICE through the arm holes of the cabinet creating a hazardous condition of dust in the air. 1/20/2015 (3:52 PM) 2648VX - 3 - Operation v2.doc...
- Page 16 2648VX Super Grit Pit Maintenance Manual...
-
Page 17: Periodic Maintenance
Only use 4 or 6 mil poly bags that are 18 Inches by 36 to 40 Inches long. Bags are available through maintenance. Rayzist or your local plastic bag company. ALWAYS unplug the cabinet from power before doing maintenance. ! NOTICE... - Page 18 Repeat ! NOTICE as necessary until abrasive is completely emptied. 20" x 40" x 3/16" thick single strength window glass can be purchased from a local glass retailer. 1/20/2015 (3:52 PM) 2648VX - 4 - Maintenance v2.doc...
- Page 19 NZ32 Aluminum Oxide Abrasive 150 Grit AO150 FSV Sleeve Foot Switch Valve Repair Kit (R) FSVKIT Std Foot Pedal w/ hoses (F) FPRS Footswitch Valve Assembly Illustration HD Valve Actuator HDACT 1/20/2015 (3:52 PM) 2648VX - 4 - Maintenance v2.doc...
-
Page 20: Switch Wiring Diagram
Electrical Connection Box Black Black Motor Leads 22mm Ground Lever Action Black Double Pole 10A Switch Contact Black Black Green w/ Yellow White Copper Enclosed Halogen Light Fixture 100w Lamp 220 VAC 1/20/2015 (3:52 PM) 2648VX - 4 - Maintenance v2.doc...
Need help?
Do you have a question about the 2648VX and is the answer not in the manual?
Questions and answers