CONFIDENTIAL Turn-off the system ※ Turn off power before disassembling. (Turn Off : Press the power button for 8 seconds.) Mobile Biz. Division...
Page 3
CONFIDENTIAL Remove CASE-REAR (1) 1. Check uSD card - If there is uSD Card, Remove Micro SD card 2. 1)Remove 4 rubbers on CASE-REAR Mobile Biz. Division...
Page 4
CONFIDENTIAL Remove CASE-REAR (2) 2)Remove 4 Screws on Case-Rear 3) Disassemble both side of hinge with tool. Caution : Use glove. May cut and cause injury Mobile Biz. Division...
Page 5
CONFIDENTIAL Remove CASE-REAR (2) 3)Disassemble center part near the hinge 3) Disassemble and pick up the rear slowly. Mobile Biz. Division...
CONFIDENTIAL Remove Battery 3. 1)Remove battery SUS bracket - Remove 2 screws 3. 2)Disconnect battery connector and remove 7 screws - Use caution! It can be easily broken. - All service should be performed after disconnecting battery connector Mobile Biz. Division...
CONFIDENTIAL LCD Disassembly 4. 1)Remove 4 screws and disconnect LCD connector, LTE module connector 4. 2)Open with Hinge and separate system and LCD part Mobile Biz. Division...
Page 8
CONFIDENTIAL System part Disassembly (1) 5. 1)Disconnect all Cables - 2 spk Cables, Main2Sub FPC, TP FFC, 2Antenna Cables, KBD FFC, - We can replace Antennas and SPK, TP FFC, Main2Sub FPC without further disassembly. ※ Bracket(5. 1)) don’t need to be removed for these materials ※...
Page 9
CONFIDENTIAL System part Disassembly (2) 5. 4)Touchpad should be pulled to upper side Mobile Biz. Division...
Page 10
CONFIDENTIAL ▶ Disassemble Upper & Lower Direction of disassemble ※ Tool Direction of Direction of disassemble disassemble Direction of Direction of Direction of disassemble disassemble disassemble Direction of disassemble Mobile Biz. Division...
Page 11
CONFIDENTIAL Disassemble upper side Disassemble left side Disassemble right side Disassemble bottom-left side(about 1/3) Disassemble bottom-right side(about 1/3) Disassemble HINGE with JIG Disassemble bottom-center Finish Mobile Biz. Division...
Page 12
CONFIDENTIAL Re-Assembly Follow disassembly in reverse order ※ Caution! - PL risk might be happened if battery got damaged by loose screw. Must tighten all of screw. - Please take care a LVDS cable and LTE module cable when you assemble rear case.
Need help?
Do you have a question about the Saturn 14 and is the answer not in the manual?
Questions and answers