Subscribe to Our Youtube Channel
Related Manuals for Whirlpool AVM571/BL
Summary of Contents for Whirlpool AVM571/BL
- Page 1 WHIRLPOOL PRODUCTS DEVELOPMENT LTD. SERVICE MANUAL WHIRLPOOL MICROWAVE PRODUCTS DEVELOPMENT LIMITED SERVICE INFO MANUAL MODEL: AVM571/BL SKU#: 853857158491 DATE: October 7, 2005 Revision: Ref no: 57158491a PAGE 1 OF 19...
-
Page 2: Table Of Contents
WHIRLPOOL PRODUCTS DEVELOPMENT LTD. SERVICE MANUAL CONTENTS SPECIFICATIONS SAFETY PRECAUTIONS INSTALLATION REQUIREMENTS GENERAL GROUNDING INSTRUCTIONS SCHEMATIC DIAGRAM MICROWAVE AND LEAKAGE TEST MICROWAVE TEST MICROWAVE LEAKAGE TEST TROUBLE SHOOTING GUIDE CAUTION AND IMPORTANT MICROWAVE LEAKAGE QUICK REFERENCE MAJOR COMPONENT TESTS HV TRANSFORMER... -
Page 3: Specifications
WHIRLPOOL PRODUCTS DEVELOPMENT LTD. SERVICE MANUAL SPECIFICATION Oven Model AVM571/BL Items Technical Data Outside dimensions (H) x (W) x (D) 332mm x 424mm x 548mm Dimensions of Cavity (H) x (W) x (D) 225mm x 339.4 x 345mm Volume of Cavity... -
Page 4: Safety Precautions
WHIRLPOOL PRODUCTS DEVELOPMENT LTD. SERVICE MANUAL SAFETY PRECAUTIONS This manual is intended for use by personnel with adequate background in electrical, electronic and mechanical engineering. Any improper attempt to repair this oven may result in personal injury and property damage. The manufacturer or seller cannot be hold responsible for the interpretation of this manual nor can they assume any liability in connection with its use. -
Page 5: Installation Requirements
WHIRLPOOL PRODUCTS DEVELOPMENT LTD. SERVICE MANUAL INSTALLATION REQUIREMENTS GENERAL 1. The oven should be placed on a flat and stable surface 2. Place the oven away from high temperature and steam sources. 3. Clearance of at least 5cm (2”) on each side must be provided to allow adequate ventilation. -
Page 6: Schematic Diagram
WHIRLPOOL PRODUCTS DEVELOPMENT LTD. SERVICE MANUAL SCHEMATIC DIAGRAM Ref no: 57158491a PAGE 6 OF 19... -
Page 7: Microwave Test
WHIRLPOOL PRODUCTS DEVELOPMENT LTD. SERVICE MANUAL MICROWAVE AND LEAKAGE TESTS MICROWAVE TEST The following is a simple test to check if the appliance is generating microwave energy. This test is not intended to be an accurate test. An accurate measurement of output power must be performed under strict control following the IEC standard. - Page 8 WHIRLPOOL PRODUCTS DEVELOPMENT LTD. SERVICE MANUAL • Bottom plate • Oven foot 5. Pull the door to the position at which the oven is just about to turn off due to the interlock switch action, scan the door perimeter for microwave leakage.
-
Page 9: Trouble Shooting Guide
WHIRLPOOL PRODUCTS DEVELOPMENT LTD. SERVICE MANUAL TROUBLE SHOOTING GUIDE CAUTION AND IMPORTANT 1. Before disassembling the oven, the oven power must be turned off. Remove the power plug of the oven from the outlet and wait for at least 3 minutes. - Page 10 WHIRLPOOL PRODUCTS DEVELOPMENT LTD. SERVICE MANUAL 5. Short circuit within electrical circuit. Lamp filament short, HV transformer short, all causing fuse blown. 6. Bad contact in contacts or terminals of timer switch, primary and secondary interlock switch. 7. HV diode break down.
-
Page 11: Major Component Tests
WHIRLPOOL PRODUCTS DEVELOPMENT LTD. SERVICE MANUAL MAJOR COMPONENT TESTS HV TRANSFORMER 1. Remove lead wire. 2. Measure the resistance of the winding using an ohm meter 3. Primary winding 3 ohm (approx.) 4. Secondary winding 100 ohm (approx.) 5. Filament winding 0 ohm (approx.) - Page 12 WHIRLPOOL PRODUCTS DEVELOPMENT LTD. SERVICE MANUAL Oven door Primary switch Secondary Monitor status switch switch Open Open Open Close Close Close Close Open 1. The interlock and monitor switches positions are not service adjustable. If the screws on the hinges of the oven door are loosen, the door may not be in a correct position.
-
Page 13: Part List & Exploded Diagram
WHIRLPOOL PRODUCTS DEVELOPMENT LTD. SERVICE MANUAL PART LIST & EXPLODED DIAGRAM The following pages contain the part list for this model. Ref no: 57158491a PAGE 13 OF 19... - Page 14 WHIRLPOOL PRODUCTS DEVELOPMENT LTD. SERVICE MANUAL Item no. Description Service parts no. Oven outer cover 4619 64022083 Thermostat 4619 64874951 Thermostat support 4619 64419251 Upper hinge assy 4619 64420911 Lower hinge assy 4619 64420891 Air guide 4619 64411021 Upper wave guide cover...
- Page 15 WHIRLPOOL PRODUCTS DEVELOPMENT LTD. SERVICE MANUAL Item no. Description Service parts no. Glass tray 4619 65690701 Turntable bearing assy 4619 64189271 Interlock support Lock spring 4619 64043881 Cam plate Micro switch 4619 64832301 Micro switch 4619 64832201 Micro switch 4619 64832401...
- Page 16 WHIRLPOOL PRODUCTS DEVELOPMENT LTD. SERVICE MANUAL Item no. Description Service parts no. Thermostat 4619 64874941 Magnetron 4619 64833341 Magnetron terminal cover 4619 64149701 Air guide 4619 64419261 Fan blade (Six) 4231 07752491 Air guide 1 4619 64184521 Fan motor 4619 64781511...
- Page 17 WHIRLPOOL PRODUCTS DEVELOPMENT LTD. SERVICE MANUAL Item no. Description Service parts no. Door body assy 4619 64018975 Plastic door cover 4619 64194171 Door latch 4619 64183443 Outer glass 4619 65696111 Inner frame 4619 64191191 PE plate 4619 64183501 Ref no: 57158491a...
- Page 18 WHIRLPOOL PRODUCTS DEVELOPMENT LTD. SERVICE MANUAL Item no. Description Service parts no. Mechanical panel 4619 64197331 Display lens 4619 64191101 Display Cover 4619 64192341 Knob 4619 64187821 Panel PC plate 4619 64197341 Spring 4619 64162901 Knob 4619 64197311 Start button...
- Page 19 WHIRLPOOL PRODUCTS DEVELOPMENT LTD. SERVICE MANUAL Revision Log Revision Description Revised by Revision Date Original Revision Wang, wei guo 28 Oct. 2003 Revising PN in the service part list Liang min yi October 7, 2005 Ref no: 57158491a PAGE 19 OF 19...
Need help?
Do you have a question about the AVM571/BL and is the answer not in the manual?
Questions and answers