Page 1
PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936 PIONEER CORPORATION 2006 T-ZZK MAR.
Page 2
PIONEER Service Manual. A subscription to, or additional copies Also test with plug reversed of, PIONEER Ser vice Manual may be obtained at a (Using AC adapter Earth nominal charge from PIONEER. plug as required)
Page 3
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual. SX-SW404...
Page 4
3.4 MAIN ASSY (3/5) ............................. 18 3.5 MAIN ASSY (4/5) ............................. 20 3.6 MAIN ASSY (5/5) ............................. 22 3.7 AC INLET, CONNECT and FL ASSYS (SX-SW404, SX-SW606) ............24 3.8 AC INLET, CONNECT and FL ASSYS (SX-X360)................... 26 3.9 JACK TX ASSY ............................28 3.10 POWER SUPPLY UNIT..........................
Page 5
TV CONTROL RDS DISP MAIN AXD7442 SX-SW404, SX-SW606 only Optical cable Remote control (ADE7116) (SX-SW404, SX-SW606 : AXD7442) Remote control (SX-X360/WYXCN5, WVXCN5 : AXD7450) Remote control (SX-X360/KUCXCN : AXD7445) AM loop antenna Display cable (ADE7113) (ATB7013) Power cord (WYXCN5 : ADG1154)
Page 6
2.1 PACKING SECTION SX-X360 only SX-X360 only ×2 13 (WVXCN5 only), 14 (KUCXCN only), 15 to 17 (WYXCN5 only) WYXCN5, KUCXCN For WVXCN5 WYXCN5 only SX-SW404, SX-SW606 only 24 (1/2) 24 (2/2) 25 (1/2) 20 (WYXCN5, WVXCN5 only) 25 (2/2) SX-SW404...
Page 7
See Contrast table (2) (French) Top Cover See Contrast table (2) Operating Instructions See Contrast table (2) (German) (2) CONTRAST TABLE SX-SW404/WYXCN5, SX-SW606/WYXCN5, SX-X360/WYXCN5, WVXCN5 and KUCXCN are constructed the same except for the following: SX-X360/ SX-X360/ SX-X360/ SX-SW404/ SX-SW606/ Mark...
Page 9
Paper Tube 60 AMR7512 NSP 24 Acoustic Absorbent AMV7002 NSP 25 Mesh ANC8354 (2) CONTRAST TABLE SX-SW404/WYXCN5, SX-SW606/WYXCN5, SX-X360/WYXCN5, WVXCN5 and KUCXCN are constructed the same except for the following: SX-X360/ SX-X360/ SX-X360/ SX-SW404/ SX-SW606/ Mark Symbol and Description WYXCN5...
Page 10
2.3 DISPLAY UNIT (SX-SW404/SX-SW606 : AXX7204) 8 (1/2) 8 (2/2) DISPLAY UNIT (AXX7204) PARTS LIST Mark No. Description Part No. FL Assy AWU8271 CONNECT Assy AWU8272 AEB7368 Window AAK8285 FL Filter AEC7535 Display Panel AMB7899 Display Cover AMC7059 PWR Button Assy...
Page 11
DISPLAY UNIT (AXX7212) PARTS LIST Mark No. Description Part No. FL Assy AWU8277 CONNECT Assy AWU8278 AEB7368 Window AAK8335 Lens AAK8336 Side Panel AAK8337 Display Panel AMB7929 Display Cover AMC7063 VOL Button Assy AXG7305 AEB7368 Stand AMD7017 Screw BPZ20P080FTC Screw PSZ30P060FNI SX-SW404...
Page 12
(KUCXCN : AWU8274) MCACC MIC IN WYXCN5, WVXCN5 : XKP3084 (SR IN) KUCXCN : XKP3085 11pin FFC JACK TX ASSY ADD7538 (WYXCN5, WVXCN5: AWX8707) AC CORD (KUCXCN : AWX8708) FM/AM TUNER UNIT (WYXCN5, WVXCN5 : AXX7170) (KUCXCN : AXX7172) SX-SW404...
Page 13
Therefore, when replacing, be sure to use parts of identical designation. ÷ : The power supply is shown with the marked box. MAIN ASSY (SX-SW404, SX-SW606/WYXCN5, WVXCN5 : AWK7924) (SX-X360/WYXCN5, WVXCN5 : AWK7938) (SX-X360/KUCXCN : AWK7940) IC5501 TX&RDS...
Page 20
3.5 MAIN ASSY (4/5) MAIN ASSY (SX-SW404, SX-SW606/WYXCN5 : AWK7924) (SX-X360/WYXCN5,WVXCN5 : AWK7938) (SX-X360/KUCXCN : AWK7940) NOTES All Capacitors are in p-pF or uF unless otherwise specified Ratings : Capacity(uF)/Voltage(V) Rated Voltage : 50V unless otherwise specified SQ : CKSQ**(2125size)
Page 21
(FR) : AUDIO SIGNAL ROUTE(PWM)(Front R ch) (SL) : AUDIO SIGNAL ROUTE(PWM)(Surround L ch) (SR) : AUDIO SIGNAL ROUTE(PWM)(Surround R ch) : AUDIO SIGNAL ROUTE(PWM)(Center ch) (SW) : AUDIO SIGNAL ROUTE(Sub Woofer ch) (AD) : AUDIO DATA SIGNAL ROUTE SX-SW404...
Page 23
MAIN ASSY (SX-SW404, SX-SW606/WYXCN5 : AWK7924) NOTES All Capacitors are in p-pF or uF (SX-X360/WYXCN5,WVXCN5 : AWK7938) TL : CFTLA unless otherwise specified (SX-X360/KUCXCN : AWK7940) : CEAT Ratings : Capacity(uF)/Voltage(V) CN3211 Rated Voltage : 50V unless All Resistors are in k-kΩ, M-MΩ or Ω...
Page 24
3.7 AC INLET, CONNECT and FL ASSYS (SX-SW404, SX-SW606) All Resistors are in k-kΩ, M-MΩor Ω All Capacitors are in p-pF or uF NOTES unless otherwise specified RS1/16S***J(1608size) Ratings : Capacity(uF)/Voltage(V) Rated Voltage : 50V unless All Inductors are in uH...
Page 28
GNDD All Resistors are in k-kΩ, M-MΩ or Ω All Capacitors are in p-pF or uF NOTES unless otherwise specified RS1/16S***J(1608size) Ratings : Capacity(uF)/Voltage(V) Rated Voltage : 50V unless otherwise specified : CEAT CH : CCSRCH(1608size) (others : CKSRYB(1608size)) SX-SW404...
Page 31
POWER SUPPLY UNIT (WYXCN5, WVXCN5 : AWR7043) (KUCXCN : AWR7044) SX-SW404...
Page 32
3.11 WAVEFORMS MAIN ASSY IC3201, IC3301, IC3401 [PWM_A, B, C, D] IC3201, IC3301, IC3401 [OUT_A, B, C, D] V: 1.0V/div. H: 2µsec/div. V: 5.0V/div. H: 2µsec/div. * Reference waveform 30.5 Vp-p (in case of this unit) SX-SW404...
Page 33
Symbol In PCB Symbol In Schematic Part Name Diagrams Diagrams C E B Capacitor Connector Transistor B C E SIDE A Transistor with resistor B C E Field effect SIDE B Chip Part P.C.Board transistor Resistor array 3-terminal regulator SX-SW404...
Page 38
4.2 AC INLET and CONNECT ASSYS (SX-SW404, SX-SW606) SIDE A SIDE B CONNECT ASSY (SX-SW404, SX-SW606) W109 VFDP 1.KEY2 VFDP GNDS GNDS 1.KEY2 REMOCON GNDS 5.VFDP GNDS KEY1 REMOCON GNDD 5.VFDP FLDC+ KEY1 FLDC- GNDD 10.FLDATA FLDC+ FLCK FLDC- XFLCS 10.FLDATA...
Page 39
1.GNDD XLED KEY1 5.FLDC- VFDP FLDC+ XLED VE+5 5.FLDC- FLCK FLDC+ XFLCS VE+5 10.KEY2 FLCK FLDATA XFLCS REMOCON 10.KEY2 GNDD FLDATA (ANP7574-A) (ANP7574-A) REMOCON GNDD SIDE A SIDE B AC INLET ASSY (SX-X360) (ANP7574-A) (ANP7574-A) SIDE A SIDE B SX-SW404...
Page 44
4.7 POWER SUPPLY UNIT SIDE A SIDE A POWER SUPPLY UNIT SX-SW404...
Page 45
SIDE B SIDE B POWER SUPPLY UNIT SX-SW404...
Page 46
Meaning of the figures and others in the parentheses in the parts list. Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding PC board. IC 301 (A, 91, 111) IC NJM2068V LIST OF HOLE PCB ASSEMBLIES SX-SW404 SX-SW606 SX-X360 SX-X360 SX-X360...
Page 47
C5716 CCSRCH561J50 Not used C5719 CEAT100M50 Not used C5720 CEAT470M16 Not used 7 7 7 7 PCB PARTS LIST FOR SX-SW404/WYXCN5 UNLESS OTHER WISE NOTED Mark No. Description Part No. Mark No. Description Part No. D 5602(A,211,136) DIODE UDZS8R2(B) D 5603(A,208,148) DIODE...
Page 48
R 901 (A,121,6) RS1/16S4701F R 3107(A,106,74) RAB4C470J R 902 (A,118,9) RS1/16S2701F R 3108(A,111,74) RAB4C470J R 963 (A,92,56) RS1/16S101J R 3109(A,115,74) RS1/16S1R0J R 964 (A,90,56) RS1/16S101J R 3110(A,116,84) RS1/16S0R0J R 965 (A,91,38) RAB4C101J R 3111(A,104,104) RS1/16S220J R 1203(A,92,135) RS1/16S0R0J R 3112(A,99,101) RS1/16S470J SX-SW404...
Page 49
R 5538(A,17,109) RS1/16S221J R 3403(A,125,118) RS1/16S223J R 5539(A,17,107) RS1/16S221J R 3404(A,120,121) RS1/16S221J R 5540(A,17,106) RS1/16S221J R 3421(A,126,110) RS1/16S100J R 5542(A,35,67) RS1/16S103J R 3422(A,126,125) RS1/16S100J R 5543(A,36,64) RS1/16S103J R 3429(A,151,106) RS1/16S100J R 5544(A,40,64) RS1/16S103J R 3430(A,151,128) RS1/16S100J R 5547(A,42,68) RS1/16S221J SX-SW404...
Page 50
CKSRYB105K6R3 C 3116(A,114,82) CKSRYB104K16 C 824 (A,62,23) CKSRYB105K6R3 C 3117(A,114,70) CEAL100M16 C 825 (A,67,22) CKSRYB103K50 C 3118(A,112,95) CKSRYB104K16 C 826 (A,69,24) CKSRYB105K6R3 C 3119(A,108,97) CKSRYB104K16 C 827 (A,69,23) CKSRYB105K6R3 C 3120(A,109,101) CEAL100M16 C 828 (A,79,30) CCSRCH471J50 C 3191(A,198,140) CEAT100M50 SX-SW404...
Page 51
C 5518(A,55,94) CKSRYB103K50 C 3334(B,219,89) CKSRYB104K50 C 5519(A,13,87) CKSRYB103K50 C 3335(B,207,92) CKSRYB104K50 C 5521(A,11,87) CKSRYB103K50 C 3336(B,220,105) CKSRYB104K50 C 5523(A,7,83) CCSRCH101J50 C 3337(B,201,99) CKSRYB103K50 C 5526(A,12,82) CCSRCH101J50 C 3338(B,226,94) CKSRYB103K50 C 5539(A,34,73) CKSRYB104K16 C 3339(B,203,92) CKSRYB103K50 C 5549(A,60,80) CCSRCH470J50 SX-SW404...
Page 52
CKSRYB102K50 C 5609(A,211,141) CCSRCH101J50 C 5610(A,50,124) CEAT100M50 C 5612(B,57,128) CKSRYB104K16 FL ASSY (SX-SW404, SX-SW606) C 5613(B,52,128) CKSRYB104K16 MISCELLANEOUS IC 5901(B,184 ,47 ) FL DRIVER IC PT6315 IC 5902(A,267 ,49 ) REMOTE RECEIVER UNIT GP1UM27XK0VF L 5901(A,152 ,44 ) INDUCTOR LFEA220J...
Page 53
R 5719(B,55,160) RS1/16S0R0J D 3947(B,65,151) DIODE UDZS2R0(B) R 5720(B,31,144) RS1/16S101J D 3950(B,75,149) DIODE UDZS5R1(B) R 5721(B,53,160) RS1/16S0R0J D 5401(B,75,196) DIODE 1SS355 R 5751(B,49,193) RS1/16S473J D 5402(B,76,204) DIODE 1SS355 R 5752(B,56,193) RS1/16S473J D 5403(B,83,189) DIODE 1SS355 D 5701(B,28,172) DIODE UDZS10(B) CAPACITORS SX-SW404...
Page 54
C 5714(B,39,139) CCSRCH270J50 C 5715(B,51,139) CKSRYB103K50 C 5716(B,48,163) CCSRCH561J50 C 5719(A,33,163) CEAT100M50 C 5720(A,48,142) CEAT470M16 C 5751(A,47,196) CEAT100M50 C 5752(A,54,196) CEAT100M50 POWER SUPPLY UNIT This unit has no service part. FM/AM TUNER UNIT This unit has no service part. SX-SW404...
Page 55
• Basically, operations in Test mode are the same as in Normal mode. However, to indicate that the unit is in Test mode, the following are displayed when the functions are changed: [Functions] • SX-SW404, SX-SW606 • SX-X360 (All Destination) [FL display]...
Page 56
However, it is not counted during Standby mode. • The maximum countable power-on time is 255H59M (255 hours 59 minutes.) The indication will not advance beyond that. • The accumulated power-on time basically cannot be cleared. Test Mode connecting point MAIN ASSY SIDE B Connecting point SX-SW404...
Page 57
STANDBY/ON key Not used : Flashing Note: Be sure to select the setting corresponding to the model number of the speaker. (See the table below.) Destination Model Number Speaker setting Europe SX-SW404/WYXCN5 REGULAR (Continent) SX-SW606/WYXCN5 TALL-1 Europe (UK) SX-SW505HX/WVXCN5 REGULAR...
Page 58
Press the "SOUND" key in test mode, to select the mode that DSP error messages are displayed. Press the "SOUND" key again to return to the normal test mode display. For this reason, the usual function of "SOUND" does not work in the test mode. SX-SW404...
Page 59
Do not short-circuit between the plus speaker terminal and ground, such as the chassis, too. UNBAL75Ω LOOP ANTENNA AUDIO INPUT DIGITAL SYSTEM CONTROL SPEAKERS DVD/DVR 1 DVD/DVR 2 DIGITAL ANALOG CONNECTOR SURROUND OUTSUB WOOFER (COAXIAL) (OPTICAL) (OPTICAL) USE ONLY WITH DISPLAY UNIT CENTER FRONT Negative Speaker Terminal Do not short-circuit Ground (Chassis) SX-SW404...
Page 60
Conditions: The above prerequisite is upheld, and the conditions for an overcurrent detection are met. 5. Process when the protection circuits are activated The unit is shut down within 30 ms after abnormality detection then the volume level is set to 0. The unit can be turned on immediately after the shutdown. SX-SW404...
Page 61
High speed, with VOL 20 or more VSF+12 14.2 10/50 VSFAN 11.3 Note: The above voltage values are references. Zener diode for output They differ from product to product. voltage stability (7 V) Transistor for switching the drive voltage between 7 V and 12 V SX-SW404...
Page 62
I) to be used for servicing. The SX-X360 is not provided for servicing. As for the SX-SW404 series (SW receiver II,) the successor model of SX-SW77 series, the display is the same as that for the SX-SW77 series. So, there is a full compatibility between them.
Page 63
Remove the three screws. Unhook the two hooks. Remove the six screws. Remove the FL and CONNECT Assys. Remove the one screw. Remove the display cover. Rear view Rear view Display cover FL Assy FL Assy CONNECT Assy CONNECT Assy SX-SW404...
Page 64
Note: To avoid damage, alternately pry at two points, as Speaker shown in the photo below, little by little, not in a single motion. Thin slot screwdriver Rear view Bottom view Disconnect the connection cord. Remove the cosmetic baffle. Connection cord Cosmetic baffle Speaker SX-SW404...
Page 65
Remove the seven screws. Remove the chassis T with rear panel SW by unhooking the two hooks. Disconnect the connection cord. Remove the two screws. Pull out the Main Section. Main Section Chassis T ×2 ×2 ×3 Rear panel SW Rear view SX-SW404...
Page 66
Connect the DISPLAY Unit. FM/AM TUNER Unit JACK TX Assy MAIN Assy DISPLAY Unit AC INLET Assy POWER SUPPLY Unit Diagnosis SX-SW404...
Page 67
Power-down mode & Reset Pin "H" : Power up, "L" : Power down & Reset The AK5358 must be reset once upon power-up. Audio Interface Format Pin "H" : 24bit S Compatible, "L" : 24bit MSB justified. CKS2 Mode Select 2 Pin CKS0 Mode Select 0 Pin SX-SW404...
Page 69
Emph late PWM_L Line Out MUTE .14 Soft Soft Loud Intarpo 58,57. PWM_P&M6 R Surround Comp DRC SRC NS PWM Blquads Tone Block Emph late HP_SEL .12 PWM_R Line Out BKND_ERR .37 39. VALID Volume Control PSVC 32. PSVC SX-SW404...
Page 70
PWM_M_4 PWM 4 output (differential –) PWM_P_4 PWM 4 output (differential +) VR_PWM Voltage reference for digital PWM core supply 1.8V PWM_M_7 PWM 7 (Line out L) output (differential –) PWM_P_7 PWM 7 (Line out L) output (differential +) SX-SW404...
Page 71
PWM right channel headphone (differential +) MCLK MCLK is a 3.3V clock master clock input − RESERVED Connect to digital ground Note of types : A = analog, D = 3.3V digital, P = power/ground/decoupling, I = input, O = output SX-SW404...
Page 73
Power supply input for half-bridge A requires close decoupling of 0.1-µF capacitor to GND_A − No connect.Pins may be grounded. BST_A HS bootstrap supply (BST), external capacitor to OUT_A required GVDD_A Gate-drive voltage supply requires 0.1-µF capacitor to AGND SX-SW404...
Page 74
ADMD XADPDN POWER DOWN for A/D DSPMUTE MUTE request to PWM processor IC (LED) Control of LED (SX-X360 only) XDEC MUTE Detection of DSP boot success from DSP DSPHREQ Error detection from DSP − VSS4 VSS4 − VDD4 VDD4 SX-SW404...
Page 75
DIGITAL INPUT SELECT P32/UTX1 SR+TX UART Tx of SR+ function P33/URX1 SR+RX UART Rx of SR+ function P34/UTX2 SHUTDWN SHUTDOWN detection from Power Stage IC P35/URX2 (XREADY) no use XOTW Over Temperature Warning from Power Stage IC PB7/D7 (XDVDRST) no use SX-SW404...
Page 76
• PortE and PortF can be selected for input or output by each 2 bits. • In case of without RDS, it is best that RDSDATA and RDSCLK are assigned as I/O port which can be set output and output low level. SX-SW404...
Page 77
Interrupt 1 Pin INT0 Interrupt 0 Pin Power-Down & Reset Pin When "L", the AK4117 is powered-down and reset, and all output pins go to "L" and the control registers are reset to default state. − AVSS Analog Ground Pin SX-SW404...
Page 78
Pin Name Pin Function Chip select input Serial clock input Start bit, OP code, address and serial data inputs Serial data output and READY/BUSY internal state display output − Ground − Non connection − Non connection − Power supply SX-SW404...
Page 79
Port F3 Port F4 Port F5 − IO_VDD I/O power supply (3.3V) Port F1 Port F0 − IO_GND GPIO I/O Ground Port F9 SCAN SCAN-Manufacturing test pin. This pin should be pulled low. PF10 Port F10 − IO_GND I/O ground SX-SW404...
Page 80
I/O power supply (3.3V) 76 SCKR/PC0 Receiver Serial Clock/Port C0 77 SCKT/PC3 Transmitter Serial Clock/Port C3 78 FSR/PC1 Frame Sync for Receiver/Port C1 79 FST/PC4 Frame Sync for Transmitter/Port C4 80 SDO5/SDI0/PC6 Serial Data Output 5/Serial Data Input 0/Port C6 SX-SW404...
Page 83
5) Solder composition is Sn-3Ag-0.5Cu. 2) NP....No pin 6) DL....Datum Line 3) NX....No extend pin 7) 1G to 10G..Grid 4) Cut lead is side A. • Anode Connection REC MODE PRGSVE SOUND –1 SURR. PLII SX-SW404...
Page 84
8. PANEL FACILITIES Display unit (SX-SW404) (SX-SW606) - VOLUME + AUDIO INPUT STANDBY/ON STANDBY/ON 4 AUDIO INPUT Press to switch the system on/into standby. Press repeatedly to select one of the external audio inputs (DVD/DVR1, DVD/DVR2, DIGITAL or ANALOG). 2 Front panel display See below for details.
Page 85
Remote control (SX-SW404, SX-SW606) SOUND RETRIEVER RECORDER RECEIVER Press to restore CD quality sound to compressed audio sources. SOUND HDD/DVD FM/AM AUDIO IN RETRIEVER Playback controls PAUSE PLAY STOP PAUSE STOP REC HELP INFO Press to pause playback or recording.
Page 86
Changes RDS displays 21 ONE TOUCH COPY Press to start One Touch Copy of the currently playing 29 MAIN/SUB title to DVD or the HDD. Change from MAIN to SUB to access the green functions/ commands on the remote. SX-SW404...
Page 88
For checking audio at the SP terminal SDS1175 (FR/RED), SDS1176 (SL/BLUE) SDS1177 (SR/GRAY), SDS1178 (C/GREEN) CLEANING Before shipping out the product, be sure to clean the following positions by using the prescribed cleaning tools: Position to be cleaned Cleaning tools Fans Cleaning paper : GED-008 SX-SW404...
Need help?
Do you have a question about the SX-SW404 and is the answer not in the manual?
Questions and answers