Sealey SUPERSTART550E Manual

Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these instructions,
and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
Warning
Refer to
instructions
1. SAFETY
IMPORTANT: To reduce the risk of a battery explosion, follow these instructions and those published by the battery manufacturer and the
manufacturer of any equipment you intend to use in the vicinity of the battery. Remember to review warning marks on all products and on
engines. Modern vehicles contain extensive electronic systems. Check with the vehicle manufacturer for any specific instructions regarding the
use of this type of equipment on each vehicle. No liability will be accepted for damage/injury where this product is not used in accordance with all
instructions.
1.1. SAFETY INSTRUCTIONS
Read instructions carefully before using this product.
9
The product is only to be used to start 12V and 24V vehicles. It may lead to damage or be dangerous if used for other different
9
voltage rated machines.
This product is not intended to be used as a replacement vehicle battery.
9
Ensure the vehicle's battery terminals are clean and battery clamps are connected properly before jump starting the vehicle. Dirty or
9
corroded on battery terminals may effect the starting performance.
DO NOT crank the engine for more than 3 seconds at a time. The jump start feature is designed for short term operation only.
8
Operating the jump start feature for more than 3 seconds may cause damage to the unit. Allow the jump starter to cool down for
at least 2 minutes after each cranking.
Remove the battery clamps from the vehicle battery immediately after the engine has started.
9
Wear safety eye protection and protective clothing. Avoid touching eyes while working with a battery.
9
Wash immediately with soap and water if battery acid contacts skin or clothing. If acid enters eye, flush eye immediately with cool,
9
clean running water for at least 15 minutes and seek immediate medical attention.
If the internal battery is leaking do not use and have battery replaced immediately. Isolate the spillage and clean appropriately.
9
WARNING!: Battery acid can cause skin damage/burns, respiratory issues, eye damage and throat irritation so please ensure all
‰
precautions have taken place.
Remove personal metallic items such as rings, bracelets, necklaces and watches.
9
Keep the unit in good working order and condition. Replace damaged parts immediately.
9
Use only recommended parts. To use unapproved parts may be dangerous and will invalidate your warranty.
9
The unit must only be opened and checked by qualified service personnel. DO NOT disassemble the unit for any reason.
9
DO NOT modify the product.
8
Keep children and unauthorised persons away from the work area.
9
Keep work area clean and tidy and free from unrelated materials. Ensure that there is adequate lighting.
9
If the unit receives a sharp knock or blow, it must be checked by a qualified service agent before being used.
9
Children from age 8 years and above, persons with reduced physical, sensory, or mental capabilities those with lack of experience
9
and knowledge can use the appliance, if they have been given supervision or instruction concerning use of the appliance in a safe
way to understand the hazards involved.
Children shall NOT play with the appliance
8
Cleaning and user maintenance on the appliance shall not be made by children without supervision.
9
The appliance shall be disconnected from its power source during service and when replacing parts and, if that the removal of the
9
plug is foreseen, it shall be clearly indicated that the removal of the plug has to be such that an operator can check from any of the
points to which he has access that the plug remains removed.
DO NOT smoke or allow a spark, or flame in the vicinity of the battery or engine.
8
DO NOT drop any metal item onto the battery as it may spark or short circuit the battery, which could cause an explosion.
8
DO NOT use unit to recharge dry cell batteries that are commonly used with home appliances.
8
DO NOT charge or boost a frozen battery.
8
DO NOT use attachments other than those recommended.
8
DO NOT pull or carry the unit by its cable
8
DO NOT pull the Superstart by negative or positive clamps.
8
DO NOT operate in vicinity of flammable liquids, dusts or gases.
8
DO NOT recharge the unit with a charger/cables that are damaged. Replace immediately. Only use the correct, supplied charger to
8
recharge the unit.
DO NOT use this product to perform a task for which it is not designed.
8
DO NOT store the unit in damp or wet locations or where the temperature may exceed 50°C.
8
© Jack Sealey Limited
6/12/24V BATTERY STARTER/CHARGER
SUPERSTART550E, SUPERSTART750E,
MODEL NO:
SUPERSTART950E
Warning
Wear eye
protection
corrosive
substance
Original Language Version
Wear Electrical
protective shock
gloves hazard
SUPERMIG 550E,750E,950E
Keep in dry Use in well
area protect ventilated
from rain areas
Issue 1
Keep away
from sources
of ignition
08/07/24