Napoleon BIG44 Owner's Manual
Hide thumbs
Also See for BIG44:
- Owner's manual (85 pages) ,
- Assembly manual (48 pages) ,
- Owner's manual (8 pages)
Subscribe to Our Youtube Channel
Related Manuals for Napoleon BIG44
Summary of Contents for Napoleon BIG44
- Page 1 BUILT-IN SERIES Owner's Manual BI32 BI12 & BI10, BIG32, BIG38 & BIG44, BIB10 BIB12 & BIB18. Grills illustrated in this manual may differ from model purchased. We Want Your Feedback! Visit Napoleon.com to write a review Apply Serial Number...
- Page 2 CONGRATULATIONS ON YOUR NAPOLEON GRILL! You’ve Just Upgraded Your Grilling Game. WE WANT YOUR GRILLING EXPERIENCE TO BE MEMORABLE AND SAFE. Please read this Owner’s Manual before using the appliance to avoid property damage, personal injury, or death. Remove all packaging material, promotional labels and cards from the grill before use.
- Page 3 How to use the Rear Burner & Rotisserie Only use the pressure regulator and hose assembly supplied with this The Grilling Experience Checklist grill or replacement parts specifically recommended by Napoleon. How to season cast iron cooking grids WARNING! Operation Infrared Grilling Guide Read this entire Owner’s Manual before operating this grill.
- Page 4 Easy access to drip pan with for more stainless steel roller bearings convenience for efficient maintenance The grills illustrated in this Owner’s Manual may differ from the model you purchased. Featured model: BIG 44 Napoleon.com | BUILT-IN Series | Features...
- Page 5 CAUTION! The hook-up and installation of the gas and hose connection must be performed by a licensed gas fitter, and leak tested before operating the grill. CAUTION! Ensure the hoses do not contact any high temperature surfaces of the grill. WARNING! Accessible parts may be very hot. Keep young children away. Napoleon.com | BUILT-IN Series Getting Started |...
- Page 6 C = 5.7" (14.5 CM) MIN. MAX. For use with the installation of a Napoleon BI door. WARNING! The cabinet frame and the cabinet MUST be made from a non-combustible material when the appliance is not installed with the Zero Clearance Liner corresponding to your unit. Refer to the parts list in your Assembly Guide for specific information.
- Page 7 If the gas supply is lower than the requirements, the unit will be under fired and will not reach the maximum temperatures. Use a gas pressure regulator and hose supplied by Napoleon; if not included, use a regulator and hose that meet national and regional codes.
- Page 8 465 mm 5" (12.7 cm) WARNING! Check the hose for evidence of excessive abrasion, melting, cuts or cracks. If the hose is damaged, it must be replaced with an assembly specifically recommended by Napoleon. Napoleon.com | BUILT-IN Series | Getting Started...
- Page 9 WARNING! Never use an open flame to check for gas leaks. Sparks or flames will cause a fire, explosion, damage to property, serious physical injury, or death. WARNING! Only use the pressure regulator and hose assembly supplied with the grill, or one in conformity with local codes. STOP Napoleon.com | BUILT-IN Series Getting Started |...
- Page 10 WARNING! Ensure all burner controls are in the OFF position before slowly turning on gas supply valve. WARNING! Follow the lighting instructions carefully. WARNING! Make sure the lid of the grill is OPEN while igniting. WARNING! Do not adjust the cooking grids while the grill is hot, or operating. Napoleon.com | BUILT-IN Series | Operation...
- Page 11 WARNING! Do not deep fry food on the side burner. Cooking with oil can be dangerous. WARNING! Regularly clean grease out of the entire unit, including the grease tray and the sear plates, to avoid build-up and grease fires. Napoleon.com | BUILT-IN Series Operation |...
- Page 12 When a burner is operating, the corresponding knob will glow red, while the rest will remain blue. GRILLING GRILLING PRO TIP! PRO TIP! Add a Napoleon smoker Use a thermometer accessory to your grill to check the internal to flavor your meat.
- Page 13 • Follow instructions 3-4 from 'Using the Rear Burner and Rotisserie Kit' to load both spit rods. • Place a metal dish under the meat to collect the drippings. Napoleon.com | BUILT-IN Series Operation |...
- Page 14 WARNING! Disassemble rotisserie components when finished cooking, wash with warm soapy water, and store indoors. WARNING! Use heat resistant grilling gloves when handling the hot rotisserie components. WARNING! Disconnect rotisserie plug from the outlet when the grill is not in use. Napoleon.com | BUILT-IN Series | Operation...
- Page 15 7. Grids are now seasoned. sides. NOTE: If rust has formed on the cast iron grids, 4. Preheat appliance to remove the rust with scouring pad or brass brush and 350°F - 400°F (176°C - 204°C). repeat the seasoning process. Napoleon.com | BUILT-IN Series Operation |...
- Page 16 5 minutes then Medium 15 minutes each side tender meat. Trim off excess until finished Lamb Chops Select larger wieners and slit MEDIUM to LOW 4 – 6 minutes lengthwise before grilling Hot dogs Napoleon.com | BUILT-IN Series | Grilling Guide...
- Page 17 WARNING! Always wear protective gloves and safety glasses when cleaning your grill. WARNING! Accumulated grease is a fire hazard. WARNING! Cleaning should only be done when the grill is cool to avoid the possibility of burns. Napoleon.com | BUILT-IN Series Cleaning |...
- Page 18 (if applicable). • Only use Napoleon approved liners on the drip pan. Never use aluminum foil, sand or any other unapproved material. This can prevent grease from flowing properly.
- Page 19 Insect Screen and Burner Ports Spiders and insects are attracted to small enclosed spaces. Napoleon has equipped the burner with an insect screen on the air shutter. This reduces the likelihood of insects building nests inside the burner, but doesn’t eliminate the problem.
- Page 20 Adjustments might be required under extreme field conditions. Note: Infrared burners have no air adjustment. Burner Port WE WANT TO HELP! Contact the Napoleon Customer Solutions Department for recommended replacement parts. +31 345 588655. Napoleon.com | BUILT-IN Series | Maintenance...
- Page 21 IE, IT, LT, NL, DE, SK IE, IS, IT, LV, LU, MT, NL, PT, SI, SK, PL PT, RO, LT, NO, PT, NO, RO, SE, SI, SK, TR RO, SE, SI, SI, SK, TR SK, TR Napoleon.com | BUILT-IN Series Maintenance |...
- Page 22 WARNING! Maintenance should only be done when the grill is cool to avoid the possibility of burns. WARNING! A leak test must be performed annually and when any component of the gas train is replaced, or when the smell of gas is present. Napoleon.com | BUILT-IN Series | Maintenance...
- Page 23 Preheat grill with all main burners on high for 10 to 15 minutes. Excessive grease and ash build on sear plates and in drip Clean sear plates and drip pan regularly. Do not line pan with pan. aluminum foil. Refer to "Cleaning Instructions". Napoleon.com | BUILT-IN Series Troubleshooting |...
- Page 24 Pipe must be sized according to installation code. Allow burner to cool and inspect very closely for cracks. Contact Leaking gasket surrounding the ceramic tile, or a weld your authorized Napoleon dealer to order replacement burner failure in the burner housing. assembly if any cracks are found.
- Page 25 2 minutes. Reignite. Allow burner to cool and inspect very closely for cracks. Contact Leaking gasket surrounding the ceramic tile, or a weld your authorized Napoleon dealer to order replacement burner failure in the burner housing. assembly if any cracks are found.
- Page 26 - 12VDC, 0.3~0.8W, 22~66mA - 12VDC, 0.3~0.8W, 22~66mA BIB18, BIB12, BIB10 KNOB LIGHT BLACK BIB18 x2, BIB12 x2, BIB10 x1 BLACK - 12VDC, 0.3~8W, 34~95mA RED / ROUGE / ROJO SWITCH - LIGHTS - 12VDC, 0.3~0.8W, 22~66mA Napoleon.com | BUILT-IN Series | Troubleshooting...
- Page 27 This grill has been thoroughly inspected by a qualified technician before packaging and shipping to ensure that you, the customer, receive the quality product you expect from NAPOLEON. NAPOLEON warrants that components in your new NAPOLEON product will be free from defects in material and workmanship from the date of purchase, for the following period: Aluminum castings / stainless steel base ........
- Page 28 U.S. and Canadian and/or foreign patents or patents pending. De Riemsdijk 22, 4004 LC, Tiel, The Netherlands 10-12 Home Farm, Meriden Road, Berkswell, CV7 7SL, United Kingdom 24 Napoleon Road, Barrie, Ontario, L4M 0G8, Canada PHONE: +31 345 588655 www.napoleon.com eu.info@napoleon.com N415-0601CE-GB...
Need help?
Do you have a question about the BIG44 and is the answer not in the manual?
Questions and answers